Digital and Mixed-Signal custom, semi-custom, off-the-shelf designs with Aeroflex Gaisler IP. Guaranteed radiation performance

Transcription

1 A passio for performace. Digital ad Mixed-Sigal custom, semi-custom, off-the-shelf desigs with Aeroflex Gaisler IP Guarateed radiatio performace QML-V, QML-Q, Mil-Aero, medical, idustrial grades Category 1A Trusted Accreditatio Itegratig the Sigal Chai RadHard ad HiRel ASICS Digital ad Mixed-Sigal

2 RadHard ASICs Fabless busiess model for mask geeratio ad wafer fabricatio. - All other desig, maufacturig ad quality assurace steps occur i house. Numerous mature foudry processes available. Aeroflex proprietary ASIC libraries & IP. - Access to commercial libraries & IP as well. Idustry stadard EDA desig tools ad desig flow. Assured log term supplier of itegrated circuit products Specialized developmet ad qualificatio of RadHard ASIC techologies. Trusted, CAT1A Accredited, Desig through Qualificatio 30 YEARS AND MOVING FORWARD Aeroflex Microelectroic Solutios HiRel has a 30-year history of cost-effective RadHard ad commercial ASIC solutios for the most critical applicatios. To meet the ew demads of the digital world, Aeroflex offers prove RadHard Mixed-Sigal ASIC capabilities, expadig our products to a full rage of custom solutios - from FPGA coversios to complete Mixed-Sigal system-level solutios, from high-voltage 0.6 µm CMOS to dese 90 m CMOS. Aeroflex RadHard ASICs have flow before o Cassii, Mars Rover, GOES-R, Iridium, Milstar, P-91, the Iteratioal Space Statio, ad may classified satellites. Aeroflex's commercial Mixed-Sigal ASICs are curretly istalled i medical, security, ad idustrial applicatios. With Aeroflex's ew custom RadHard Mixed-Sigal solutios, system desigers do ot eed to settle for more costly ad power-hugry FPGA solutios. By leveragig our high-volume commercial ad RadHard product kowledge, our Aeroflex Gaisler portfolio, our proprietary advaced RadHard techiques, ad the stregth of our foudry parters, Aeroflex has the experiece, techology, ad motivatio to assure your program success. Aeroflex remais committed to assured supply from 0.6 µm to 90 m. AEROFLEX GAISLER SOC Buildig Block IP LEON3/4 SPARC V8 Processor LEON3/4 FT SPARC V8 Processor GRLIB portable IP library GRFPU IEEE-754 floatig-poit uit GRPCI Master/Target PCI bridge GRETH 10/100/1000 Mbit Etheret MAC USB host cotroller USB device cotroller SpaceWire cotroller SpaceWire router GR1553 AHB IF for 1553 Spacecraft Data Hadlig I²C - Iter-IC Bus iterfaces Serial Peripheral Iterface AES/ECC Cryptography CAN cotrollers Memory cotrollers FLEX ENGAGEMENT MODELS Aeroflex has prove experiece i covertig FPGAs ito RadHard ASICs. As FPGAs (most recetly the 1020, 1040 ad 1280) become obsolete, Aeroflex has coverted may Flex Egagemet Models to ASICs. Examples iclude Actel RH1020, RH1280, RT54SX32S/72S, RTAX250S/1000S/2000S, Xilix XC2/3/4000, ad Virtex-II/-IIPro/-4/-5. We offer these beefits. CML/SSTL/LVDS/PLL capability Chip capacitors o packages SEU of <2E-12 error/bit-day SEL of >128MeV o 0.6 µm process* SEL of >110MeV o 0.25 µm process* Actel compatible 84, 172, 208, 256, 352 CQFPs, 624 CCGA Xilix compatible CQFP, Flip Chip, CCGA, PBGA, LGA piouts * maximum rate possible with test 125 C

3 Aeroflex Process Techology TECHNOLOGY PARAMETERS 90m CMOS 130m CMOS 180m CMOS 0.25µm CMOS 0.35µm CMOS 0.6µm CMOS Metal layers 6-9 Cu 6-8 Al/Cu 5-6 Al/Cu 4-5 Al/Cu 3-4 Al/Cu 3 Al/Cu Capacitors MiM MiM MiM MiM MiM/PiP PiP High-value resistors No Yes Yes Yes Yes Yes Vertical NPN bipolar No No Yes Yes Yes Yes Substrate PNP bipolar Yes Yes Yes Yes Yes Yes HV CMOS support No No 5 V (self-aliged) Yes 10 V (self-aliged) 20 V (ext drai) Thick metal iductor No Yes Yes No Yes No Digital/aalog supply volt- 2.5, 1.8, 1.2, 3.3, 2.5, 1.8, 5.0, 3.3, , , 5.0, , 3.3, 2.5 ages (DVdd, AVdd; Vss=0) , 1.2 Alterate aalog supply ±2.5, ±1.65, ±5, ±2.5, voltages (AVdd/AVss) ±0.9 ±1.65 Maximum toggle frequecy 33 GHz 5 GHz 2.4 GHz 1 GHz 375 MHz 215 MHz Power dissipatio - W/ gate - MHz; 20% duty cycle Gate delay 25 C (ps) Usable gates M M 8 M 3 M 1.5 M 500 K (NAND2 equivalet) Typical sigal I/O ~1024 ~1024 ~1024 ~512 ~425 ~400 Flip-chip I/O available Yes Yes Yes No No No Cold sparig Yes No Yes Yes Yes Yes Full 5V compliace No No Yes No Yes Yes 5V tolerace No No Yes Yes Yes Yes Example aalog IP (full Bad-gap, Volt. reg. Bad-gap, Volt. reg. Bad-gap, Volt. reg. Bad-gap, Volt. reg. custom aalog available) SerDes Temp Comp/op-amps, Comp/op-amps, Comp/op-amps Sesor ADCs, DACs ADCs, DACs, ADCs, DACs DACs, ADCs, PLL PLL PLL, VCO PLL PLL, VCO PLL/DLL RC oscillator SRAM compiled Yes Yes Yes No No No No-volatile memory Flash* EEPROM* Flash* EEPROM* RadHard OTP RadHard OTP Metal Fuse** Metal Fuse** Special I/O SSTL, MGT, SSTL, MGT, SSTL, MGT, SSTL, MGT, SSTL, MGT, SSTL, MGT, CML, CML, LVDS, CML, LVDS, CML, LVDS, CML, LVDS CML, LVDS, LVDS, PCI PCI, PCI, PCI PCI, USB1.1 PCI PCI, RS232/ SerDes RS485 (±5V), USB1.1 Total ioizig dose Rads (Si) K K K K K K SEL (MeV-cm 2 /mg) >100 >110 >110 >110 >110 Vdd max ad 125 C Reliability (FIT rate) <50 <20 <10 <10 <10 <5 Wafer foudry quality level QML-Q&V QML-Q/Q+ QML-Q/Q+ QML-Q&V QML-Q&V QML-Q&V Trusted foudry level CAT1A CAT1A *Limited total-ioizig dose eviromets. Floatig Gate Memories such as Flash ad EEPROM must be periodically re-writte i a total ioizig dose eviromet for reliability. ** To be QML qualified

4 RadHard ASIC Desig Flow SUPPORTED DESIGN TOOLS Aeroflex Colorado Sprigs actively supports robust ad easy-to-use desig eviromets icludig VHDL ad Verilog, usig third-party desig tools. Aeroflex supports libraries for: Cadece Metor Graphics MATLAB Syopsys Full mixed-mode simulatio m ay others

5 R adhard sesor iter face solutios Aeroflex uderstads that RadHard data coversio solutios must be system orieted. That s why Aeroflex offers Aeroflex Gaisler IP ad radiatio aalysis of photoic sesors usig a Aeroflex-proprietary SEE simulator. Usig the output of our simulator, we ca take ito accout all radiatio-iduced oise sources, icludig the oise geerated i the sesor whe desigig RadHard aalog-to-digital coversio ASICs for critical cotrol loop or sesig applicatios. Rather tha have discrete ADCs for each sesig chael, Aeroflex ca itegrate multiple, idepedet ADCs o a sigle ASIC with low cross-talk betwee chaels. Usig Aeroflex s substrate-isolated, RadHard aalog library, chael-to-chael isolatio of >-108 db ca be achieved. Multiple, parallel ADCs ofte save power over highly MUXed solutios, sice each ADC ca operate at sigificatly lower frequecies. Cotact Aeroflex today to take advatage of the icreased performace, reliability ad reduced size ad power cosumptio of our RadHard Mixed-Sigal ASICs. W E C O N N E C T T H E R E A L WO R L D TO T H E D I G I TA L WO R L D E X A M P L E S O F A R a d H a r d A S I C S O LU T I O N Radiatio Temperature D L R O W L A E R SENSOR Light Acceleratio Pressure Magetism T U P N I LNA FILTER ADC DSP MAC PHY + µp NVM - ANALOG MEMORY DIGITAL

6 RadHard ASICs PACKAGING TYPE LEADS/DESCRIPTION CQFP 68, 84, 132, 172, 196, 208, 256, 304, 340, 352 CPGA 281, 299 CLGA/CCGA 472, 624, 1028, 1752 Chip-o-Flex 100µ lead pitch Aeroflex also offers custom packages icludig multi-chip modules, ed modules, ad all JEDEC packages. WEB SiTE Our passio for performace is defied by three attributes represeted by these three icos: solutio-mided, performace-drive ad customer-focused. TELEPHONE Part No. RHASIC 8/11/2015. Specificatios are subject to chage without otice.