3 - Zelio Time - timing relays

Transcription

1

2 /0 -

3 onens 0 - Zelio ime - iming relays Selecion guide for Zelio ime - iming relays page /2 # Modular relays, solid sae oupu, widh 17.5 mm page /6 # Indusrial relays, solid sae oupu, widh 22.5 mm page /10 # Modular relays, relay oupu, widh 17.5 mm page /14 # Indusrial single or mulifuncion relays 5 1 relay oupu, widh 22.5 mm page / relay oupus, widh 22.5 mm page /22 # Indusrial single-funcion relays, relay oupu, widh 22.5 mm page /26 # Indusrial single or mulifuncion relays, relay oupu, widh 22.5 mm.. page /28 # Indusrial, single-funcion relays, opimum, relay oupu, widh 22.5 mm, page /4 # niversal plug-in relays, 8-pin, relay oupu, widh 5 mm page /40 # niversal plug-in relays, 11-pin, relay oupu, widh 5 mm page /44 # Miniaure plug-in relays, relay oupu page /47 # Panel-mouned, plug-in, universal relays 5 1 relay oupu, 7 iming ranges page / or 2 relays oupus, 11 iming ranges page / relay oupu, 11 iming ranges page /57 /1

4 Selecion guide Zelio ime - iming relays Applicaions Oupu hese iming relays enable simple auomaion cycles o be se up using wired logic. hey can also be used o complemen he funcions of PLs. Solid sae iming relays wih solid sae oupu reduce he amoun of wiring required (wired in series). he durabiliy of hese iming relays is independen of he number of operaing cycles. elay elay oupus provide complee isolaion beween he supply and ouu circuis. I is possible o have several oupu circuis. ype Modular Indusrial Modular Indusrial iming ranges 7 ranges : 1 s, 10 s, 1 min, 10 min, 1 h, 10 h, 100 h 1 or 2 ranges, depending on model : 10 s, 0 s, 00 s, 60 min 7 ranges : 1 s, 10 s, 1 min, 10 min, 1 h, 10 h, 100 h elay ype E // E9 E // E Depending on model : 4 ranges : 0.6 s, 2.5 s, 20 s, 0 s 7 ranges : 1 s, 10 s, 1 min, 10 min, 1 h, 10 h, 100 h 7 ranges : 1 s, s, 10 s, 0 s, 100 s, 00 s, 10 min 10 ranges : 1 s, s, 10 s, 0 s, 100 s, 00 s, 0 min, 00 min, 0 h, 00 h E /// E7 Pages /6 and /7 /10 /14 and /15 /18 o /2 and /26 o /29 /2

5 hese iming relays enable simple auomaion cycles o be se up using wired logic. hey can also be used o complemen he funcions of PLs. elay elay oupus provide complee isolaion beween he supply and oupu circuis. I is possible o have several oupu circuis. Opimum Plug-in Panel-mouned niversal Miniaure Analogue Digial Elecromechanical 1 range, depending on model : 0.5 s, s, 10 s, 0 s, 00 s, 0 min 7 ranges : 1 s, 10 s, 1 min, 10 min, 1 h, 10 h, 100 h 7 ranges : 1 s, 10 s, 1 min, 10 min, 1 h, 10 h, 100 h Depending on model : 6 ranges : 1 s, 10 s, 1 min, 10 min, 1 h, 10 h 8 ranges : 1 s, 10 s, 1 min, 4 min, 10 min, 1 h, 10 h, 60 h Depending on model : 7 ranges : s, s, 99 min 59 s, min, min, 99 h 59 min, h 11 ranges : s, s, 9999 s, 99 min 59 s, min, min, 9999 min, 99 h 59 min, 99,99 h, h, 9999 h Depending on model : ranges : 6 s, 60 s, 12 min ranges : 6 min, 60 min, 12 h E8 E /// E / E /// E /// E /// E /// /4 o /7 /40 o /45 /47 (1) /51, /55 and /57 (1) (1) Please consul your egional Sales office. /

6 haracerisics Zelio ime - iming relays Modular relays, solid sae oupu, widh 17.5 mm iming characerisics epea accuracy onforming o IE ± 0.5 % (wih consan parameers) Drif emperaure ± 0.05 % / Volage ± 0.2 % / V Seing accuracy a full scale onforming o IE ± 10 % a 25 Minimum duraion of ypical ms 50 conrol impulse Maximum rese ime ypical ms 50 by de-energisaion Immuniy ime o microbreaks ypical ms > 10 characerisics Mulivolage supply Depending on version, see pages /6 and /7 Frequency Hz 50/60 Operaing range % n On-load facor 100 % Maximum power consumpion Depending on model $ 24 V W 0.6 $ 240 V W 1.5 "240 V VA 2 Oupu characerisics Oupu ype Solid sae Breaking capaciy A "/$0.7 a 20 (0.5 A L) Deraing ma 5 / Maximum permissible curren A ms Minimum breaking curren ma 10 Leakage curren ma < 5 Maximum swiching volage V "/$ 250 ypical volage drop a erminals -wire 4V - 2-wire 8V Elecrical life 10 8 operaions Mechanical life 10 8 operaions Dielecric srengh conforming o IE 664, IE kv 2.5 a 1 ma / 1 min Display characerisics Sae indicaion by 1 LED Green Operaing saus indicaion: Pulsing : relay energised, no iming in progress (excep Di-D and Li-L) Flashing : iming in progress On seady : relay energised, no iming in progress Inpu characerisics Inpu ype V Vol-free conac (no poenial) onrol possible by -wire sensor wih PNP oupu, maximum residual volage : 0.4 V whaever he supply volage of he imer eferences : pages /6 and /7 /4 page /6 page /7

7 haracerisics (coninued) Zelio ime - iming relays Modular relays, solid sae oupu, widh 17.5 mm General characerisics onforming o sandards Produc cerificaions IE , EN /2, EN /2, LV direcives (7/2/EE + 9/68/EE (& marking) + EM (89/6/EE + IE ) c L us, SA emperaure limis Operaion Sorage reepage disance and clearance Degree of proecion conforming o IE 529 onforming o IE kv 4 kv/ erminal block IP 20 Enclosure IP 40 Panel-mouned IP 50 Vibraion resisance onforming o IE f = Hz A = 0.5 mm elaive humidiy wihou condensaion Elecromagneic compaibiliy onforming o IE % Immuniy o elecrosaic discharge, conforming o IE Immuniy o elecromagneic fields, conforming o ENV 50140/204 (IE ) Immuniy o fas ransiens in burss, conforming o IE Immuniy o surges on he power supply conforming o IE Immuniy o radio frequency inerference in common mode conforming o ENV (IE ) Immuniy o volage dips and breaks conforming o IE adiaed and mains conduced disurbance conforming o EN (EN Group 1) Level III (Air 8 kv/onac 6 kv) Level III 10 V/m : (80 MHz 1 GHz) Level III (direc 2 kv / capaciive connecing clip 1 kv) Level III (common mode 2 kv / differenial mode 1 kv) Level III (10 V rms : MHz) 0 % / 10 ms 60 % / 100 ms > 95 % / 5 s lass B Mouning mehod Symmerical mouning rail mm 5 (EN 50022) lamping capaciy Wihou cable end mm 2 2 x 2.5 Wih cable end mm 2 2 x 1.5 Spring erminals, 2 erminals per connecion poin Enclosure maerial Flexible cable mm Solid cable mm Self-exinguishing eferences : pages /6 and /7 page /6 page /7 /5

8 eferences, dimensions, schemes Zelio ime - iming relays Modular relays, solid sae oupu, widh 17.5 mm Solid sae oupu # Mulifuncion or single funcion # Muli-range (7 swichable ranges) # Mulivolage # Solid sae oupu: 0.7 A V (0.5 A L) # Screw erminals # Sae indicaion by 1 LED Funcion diagrams Funcion A Funcion H Funcion Li Delay on energisaion iming on energisaion Pulse-on energisaion Asymmerical recycler Pulse sar 1 2 Funcion B Funcion L Funcion Di iming on impulse, one sho Asymmerical recycler Sar afer pause Symmerical flasher, sar wih oupu in operaing posiion 1 2 eferences onnecion Screw erminals / / Funcions Mulifuncion Single funcion A - A - B - - H - H - Di - D - Ac - Bw A iming ranges 7 ranges 1 s - 10 s - 1 min - 10 min - 1 h - 10 h h aed curren 0.7 A 0.7 A Volages V "50/60 Hz E V "/$50/60 Hz E Weigh (kg) Dimensions and connecion schemes Dimensions, , ,5 haracerisics : pages /4 and /5 page /7 /6

9 Funcion Funcion A Funcion H Funcion D Funcion Bw Off-delay, wih conrol iming on energisaion Delay on energisaion Symmerical flasher, sar Pulse oupu (adjusable) conac wih memory wih memory wih oupu in res posiion 1 2 = = 1+2 Funcion Ac iming afer closing/opening of conrol conac / / Single funcion Dual funcion H Li - L 1 s - 10 s - 1 min - 10 min - 1 h - 10 h h 0.7 A 0.7 A E E onnecion schemes Funcions A, H Funcion Funcions L, Li ± Y1 Y1 MLI 18 Y1 18 (1) ± (1) Link -Y1 for funcion L only. haracerisics : pages /4 and /5 page /6 /7

10 haracerisics Zelio ime - iming relays Indusrial relays, solid sae oupu, widh 22.5 mm Presenaion he E9 range of relays is designed for simple, repeiive applicaions wih shor and inensive cycles because heir solid sae oupu provides very high elecrical durabiliy. Each relay has a single iming range. Each relay has a wide volage range from 24 o 240 V. he range comprises 9 references wih model ypes: # E9-A: funcion A, # E9-A: funcion, # E9-MS: mulifuncion A, H, L, Li. hese producs have a ransparen, hinged flap on heir fron face o avoid any accidenal aleraion of he seings. his flap can be direcly sealed. Environmen onforming o sandards IE , EN Produc cerificaions SA, GL pending. L &marking Zelio ime iming relays conform o European regulaions relaing o & marking Ambien air emperaure around he device Permissible relaive humidiy range Sorage Operaion onforming o IE % Environmenal class K Vibraion resisance onforming o IE , a = 0.5 ms 10 o 55 Hz Shock resisance onforming o IE gn - 11 ms Degree of proecion asing IP 50 erminals IP 20 Degree of polluion onforming o IE Overvolage caegory onforming o IE III aed insulaion volage onforming o IE V 250 onforming o SA V 00 es volage for insulaion ess Dielecric es kv 2.5 Shock wave kv 4.8 Volage limis Power supply circui c Frequency limis Power supply circui Hz 50/60 ± 5 % Disconnecion value Power supply circui > 0.1 c Mouning posiion wihou deraing abling Maximum c.s.a. In relaion o normal Any posiion verical mouning plane Flexible cable wihou cable end mm 2 2x2.5 Flexible cable wih cable end mm 2 2 x 1.5 ighening orque N.m Immuniy o elecromagneic inerference (EM) (applicaion class 2 conforming o EN ) Elecrosaic discharge onforming o IE Level (6 kv conac, 8 kv air) Elecromagneic fields onforming o IE Level (10 V/m) Fas ransiens onforming o IE Level (2 kv) Shock waves onforming o IE Level (2 kv) adiaed and conduced emissions ISP11 ISP22 Group 1 class A lass A eferences : page /10 /8 page /10 page /11

11 haracerisics (coninued) Zelio ime - iming relays Indusrial relays, solid sae oupu, widh 22.5 mm iming relay ype characerisics E9-A On-delay E9-A Off-delay E9-MS Mulifuncion volage V " See page /10 Volage limis Of he conrol circui n Frequency Hz ± 5 % onrol conac Mechanical only In series Beween Y2 and In series Maximum lengh of connecing cable From conac o E9 m 20 onrol inpu consumpion Inpu Y2 ma 5 iming characerisics Seing accuracy < ± 20 % epea accuracy < 1 % Minimum rese ime Afer he ime delay period ms 100 Minimum swiching ime ms 40 Maximum immuniy o microbreaks emperaure drif During he ime delay period ms Afer he ime delay period ms % per degree cenigrade Swiching characerisics (solid sae ype) Maximum coninuous curren A ambien emperaure: 20 A 0.7 (minimum 10 ma) Maximum overload curren VDE 045 par. 0, A 15 for 10 ms 4.8./lass II Maximum volage drop losed sae V A 0.7 A: Leakage curren Open sae ma Maximum dissipaed power W Deraing For emperaure > 20 ma Wihou Elecrical durabiliy In millions of operaing cycles > 100 eferences : page /10 page /10 page /11 /9

12 Funcions, references, dimensions Zelio ime - iming relays Indusrial relays, solid sae oupu, widh 22.5 mm Solid sae oupu, 1 /O conac Funcion diagrams Funcion A Funcion Funcion H Delay on energisaion Off-delay iming on energisaion Pulse-on energisaion Load onrol conac K Load Load Funcion Di Symmerical flasher, sar wih oupu in operaing posiion Funcion D Symmerical flasher, sar wih oupu in res posiion onrol conac K onrol conac K Load Load = = = = eferences Funcions A A, H, D, Di Volages $or " V / /(A) " V / /(H, D, Di) iming ranges 0.1 s 10 s E9 1MW E9 1MW7 E9 MS21MW 0. s 0 s E9 MW E9 MW7 s 00 s E9 1MW E9 1MW7 E9 MS21MW 40 s 60 min E9 A51MW E9 A51MW7 Weigh (kg) Dimensions ail mouning Screw fixing ,5 82 haracerisics : pages /8 and /9 page /11 /10

13 Schemes Zelio ime - iming relays Indusrial relays, solid sae oupu, widh 22.5 mm erminal blocks E9 A E9 A E9 MS L L X4 L Y2 X1 X2 X ecommended applicaion schemes E9 A K E9-A L Load he iming relay is placed in series, wih he load whose de-energisaion is o be delayed on one side and swich K on he oher side. he mains supply may be a.c. or d.c. and he volage may be beween 24 V and 240 V. See funcion diagram on page opposie. " or $ E9 A E9-A L Load he iming relay is placed in series wih he load whose de-energisaion is o be delayed. Swich K is conneced o erminals Y2 and of he iming relay, and erminal is conneced o he mains supply, as indicaed in he diagram opposie. he device is operaed from an a.c. mains supply whose volage is beween 24 V and 240 V. See funcion diagram on page opposie. Y2 K " or $ E9 MS Delay on energisaion Funcion A Pulse-on energisaion Funcion H Selecion of he iming range K X X4 L E9-MS Load K X1 X X4 E9-MS L Load X-X4 no linked : range s 00 s (facory configuraion) X-X4 linked : range 0.1 s 10 s " or $ " Link o be made beween erminals X1 and X4 Symmerical flasher Sar wih oupu in he res posiion Funcion D Symmerical flasher Sar wih oupu in he operaing posiion Funcion Di K X1 X2 X X4 L Load K X2 X X4 L Load E9-MS E9-MS " " Link o be made beween erminals X2 and X4 on one side and Link o be made beween erminals X1 and X4 beween X1 and X2 on he oher side Noe : For supply volages greaer han 0 V, he raed volage of he load is equal o he supply volage. For a supply volage of 24 V, he volage drop wihin he E9 relay mus be aken ino accoun (abou V); a coil wih a nominal volage of 21 V mus herefore be seleced for he load. haracerisics : pages /8 and /9 page /10 /11

14 haracerisics Zelio ime - iming relays Modular relays, relay oupu, widh 17.5 mm iming characerisics epea accuracy onforming o IE ± 0.5 % (wih consan parameers) Drif emperaure ± 0.05 % / Volage ± 0.2 % / V Seing accuracy a full scale onforming o IE ± 10 % a 25 Minimum duraion of conrol impulse Maximum rese ime by de-energisaion Immuniy ime o microbreaks ypical ms 0 ypical under load ms 100 ypical ms 100 ypical ms > 10 characerisics Mulivolage supply Depending on version, see pages /10 Frequency Hz 50/60 Operaing range % of n On-load facor 100 % Maximum power consumpion Depending on model $ 24 V W 0.6 $ 240 V W 1.5 "240 V VA 2 Oupu characerisics Oupu ype elay, 1 /O conac, AgNi (cadmium-free) Breaking capaciy "2000 VA, $80 W Maximum breaking curren A "8, $8 Minimum breaking curren ma 10 /$ 5 V Maximum swiching volage V "/$ 250 Elecrical life 10 5 operaions 8 A 250 V resisive Mechanical life 5 x 10 6 operaions Dielecric srengh onforming o IE kv 2.5/1min/1 ma/50 Hz Impulse volage onforming o IE 664-1, IE kv 5, wave 1.2/50 µs Display characerisics Sae indicaion by 1 LED Green Operaing saus indicaion Pulsing : relay energised, no iming in progress (excep Di-D and Li-L) Flashing : iming in progress On seady : relay energised, no iming in progress Inpu characerisics Inpu ype V Vol-free conac (no poenial) onrol possible by -wire sensor wih PNP oupu, maximum residual volage : 0.4 V whaever he supply volage of he relay eferences : pages /1 and /14 /12 page /14 page /15

15 haracerisics (coninued) Zelio ime - iming relays Modular relays, relay oupu, widh 17.5 mm General characerisics onforming o sandards IE , EN /2, EN /2, LV direcives (7/2/EE + 9/68/EE (& marking) + EM (89/6/EE + IE ) Produc cerificaions c L us, SA, GL excep E emperaure limis Operaion Sorage reepage disance and clearance Degree of proecion conforming o IE 529 onforming o IE kv 4 kv/ erminal block IP 20 Enclosure IP 40 Panel-mouned IP 50 Vibraion resisance onforming o IE f = Hz A = 0.5 mm elaive humidiy wihou condensaion Elecromagneic compaibiliy onforming o IE % Immuniy o elecrosaic discharge, conforming o IE Immuniy o elecromagneic fields, conforming o ENV 50140/204 (IE ) Immuniy o fas ransiens in burss, conforming o IE Immuniy o surges on he power supply, conforming o IE Immuniy o radio frequency inerference in common mode conforming o ENV (IE ) Immuniy o volage dips and breaks conforming o IE adiaed and mains conduced disurbance conforming o EN (EN Group 1) Level III (Air 8 kv/onac 6 kv) Level III 10 V/m : (80 MHz 1 GHz) Level III (direc 2 kv / capaciive connecing clip 1 kv) Level III (common mode 2 kv / differenial mode 1 kv) Level III (10 V rms : MHz) 0 % / 10 ms 60 % / 100 ms > 95 % / 5 s lass B Mouning mehod Symmerical mouning rail mm 5 (EN 50022) lamping capaciy Wihou cable end mm 2 2 x 2.5 Wih cable end mm 2 2 x 1.5 Spring erminals, 2 erminals per connecion poin Enclosure maerial Flexible cable mm Solid cable mm Self-exinguishing eferences : pages /1 and /14 page /14 page /15 /1

16 eferences, dimensions, schemes Zelio ime - iming relays Modular relays, relay oupu, widh 17.5 mm elay oupu, 1 /O conac # Mulifuncion or single funcion # Muli-range (7 swichable ranges) # Mulivolage # 1 relay oupu: 8 A V (10 A L) # Screw or spring erminals # Sae indicaion by 1 LED # Opion of supplying a load in parallel # -wire sensor conrol opion Funcion diagrams Funcion A Funcion H Funcion Li Delay on energisaion iming on energisaion Pulse-on energisaion Asymmerical recycler Pulse sar 1 2 Funcion B Funcion L Funcion Di iming on impulse, one sho Asymmerical recycler Sar afer pause Symmerical flasher, sar wih oupu in operaing posiion 1 2 eferences onnecion Screw erminals / / / Spring erminals Funcions Mulifuncion Dual funcion Single funcion A - A - B - - H - H - Di - D Ac - Bw A - A B iming ranges 7 ranges 1 s - 10 s - 1 min - 10 min - 1 h - 10 h h aed curren 8 A 8 A 8 A Volages $24 V / " V E E E "/$ V Weigh (kg) Dimensions and connecion schemes Dimensions, , ,5 haracerisics : pages /12 and /1 page /15 /14

17 Funcion Funcion A Funcion H Funcion D Funcion Bw Off-delay, wih conrol iming on energisaion wih Delay on energisaion wih Symmerical flasher, sar Pulse oupu (adjusable) conac memory memory wih oupu in res posiion 1 2 = = 1+2 Funcion Ac iming afer closing/opening of conrol conac / / / / / Single funcion Dual funcion Dual funcion Mulifuncion Mulifuncion H - H Li - L A - A - B - - H - H - Di - D - Ac - Bw A - A - B - - H - H - Di - D - Ac - Bw 1 s - 10 s - 1 min - 10 min - 1 h - 10 h h 8 A 8 A 8 A 8 A 8 A E E E E E onnecion scheme All funcions excep L and Li Funcions L and Li + + (1) Y1 15 Y (1) Link -Y1 for funcion L only. haracerisics : pages /12 and /1 page /14 /15

18 haracerisics Zelio ime - iming relays Indusrial single or mulifuncion relays, relay oupu, widh 22.5 mm iming characerisics epea accuracy onforming o IE ± 0.5 % (wih consan parameers) Drif emperaure ± 0.05 % / Volage ± 0.2 % / V Full scale seing accuracy onforming o IE ± 10 % a 25 Minimum duraion of conrol impulse Maximum rese ime by de-energisaion Immuniy ime o microbreaks ypical ms 0 ypical under load ms 100 ypical ms 100 ypical ms > 10 characerisics Muivolage supply Depending on version, see pages /18 and /19 Frequency Hz 50/60 Operaing range % n ( n for "/$12 V ) On-load facor 100 % Maximum power consumpion Depending on model $ 24 V W 0.6 $ 240 V W 1.5 " 240 V VA 2 Oupu characerisics Oupu ype elay, /O conac AgNi (cadmium free) Breaking capaciy " 2000 VA, $80 W Maximum breaking curren A "8, $ 8 Minimum breaking curren ma 10 / $ 5 V Maximum swiching volage V "/$250 Elecrical life 10 5 operaions 8 A 250 V resisive Mechanical life 5 x 10 6 operaions Dielecric srengh onforming o IE kv 2.5/1min/1 ma/50 Hz Impulse volage onforming o IE 664-1, IE kv 5, wave 1.2/50 µs Display characerisics Sae indicaion by 2 LEDs Green Operaing sae indicaion green LED Pulsing: relay energised, no iming in progress (excep Di-D and Li-L) Flashing: iming in progress On seady: relay energised, no iming in progress Yellow On-delay relay Inpu characerisics Inpu ype V Vol-free conac (no poenial) onrol possible by -wire sensor wih PNP oupu, maximum residual volage: 0.4 V whaever he supply volage of he imer eferences : pages /18 and /19 / page /18 page /19

19 haracerisics (coninued) Zelio ime - iming relays Indusrial single or mulifuncion relays, relay oupu, widh 22.5 mm General characerisics onforming o sandards Produc cerificaions IE , EN /2, EN /2, LV direcives (7/2/EE + 9/68/EE (& marking) + EM (89/6/EE + IE ) c L us, SA, GL excep E emperaure limis Operaion Sorage reepage disance and clearance Degree of proecion conforming o IE 529 onforming o IE kv 4 kv/ erminal block IP 20 Enclosure IP 40 Fron panel IP 50 Vibraion resisance onforming o IE f = Hz A = 0.5 mm elaive humidiy wihou condensaion Elecromagneic compaibiliy onforming o IE % Immuniy o elecrosaic discharge, conforming o IE Immuniy o elecromagneic fields, conforming o ENV 50140/204 (IE ) Immuniy o fas ransiens in burss conforming o IE Immuniy o surges on he power supply, conforming o IE Immuniy o radio frequency inerference in common mode conforming o ENV (IE ) Immuniy o volage dips and breaks conforming o IE adiaed and mains conduced disurbance conforming o EN (EN Group 1) Level III (Air 8 kv/onac 6 kv) Level III 10 V/m : (80 MHz 1 GHz) Level III (direc 2 kv / capaciive connecing clip 1 kv) Level III (common mode 2 kv / differenial mode 1 kv) Level III (10 V rms : MHz) 0 % / 10 ms 60 % / 100 ms 95 % / 5 s lass B Fixing Symmerical mouning rail mm 5 (EN 50022) lamping capaciy Wihou cable end mm 2 2 x 2.5 Wih cable end mm 2 2 x 1.5 Spring erminals, 2 erminals per connecion poin Enclosure maerial Flexible cable mm Solid cable mm Self-exinguishing eferences : pages /18 and /19 page /18 page /19 /17

20 eferences, dimensions, schemes Zelio ime - iming relays Indusrial single or mulifuncion relays, relay oupu, widh 22.5 mm elay oupu, 1 /O conac # Mulifuncion or single funcion # Muli-range (7 swichable ranges) # Mulivolage # 1 relay oupu: 8 A V (10 A L) # Screw or spring erminals # Sae indicaion by 1 LED # Opion of supplying a load in parallel # -wire sensor conrol opion Funcion diagrams Funcion A Funcion H Funcion Li Delay on energisaion iming on energisaion Asymmerical recycler Pulse sar 1 2 Funcion B Funcion L Funcion Di iming on impulse, one sho Asymmerical recycler Flashing relay Sar afer pause Pulse sar 1 2 eferences onnecion Screw erminals / / / Spring erminals Funcions Mulifuncion Dual funcion Single funcion A - A - B - - H - H - Di - D Ac - Bw A - A B iming ranges 7 ranges 1 s - 10 s - 1 min - 10 min - 1 h - 10 h h Selecable inerswiching ime aed curren 8 A 8 A 8 A Volages $24 V / " V E E E "/$12 V "/$ V "20 / 80 V Weigh (kg) Dimensions and connecion schemes Dimensions ,5,5 15 Y haracerisics : pages / and /17 page /19 /18

21 Funcion Funcion A Funcion H Funcion D Funcion Bw Off-delay iming on energisaion Delay on energisaion wih Flashing relay Pulse oupu (adjusable) wih memory memory Sar afer pause 1 2 = = 1+2 Funcion Ac iming afer closing/opening of conrol conac Funcion Q Sar-dela saring i / / / / / / / Single funcion Dual funcion Dual funcion Single funcion Single funcion Mulifuncion Mulifuncion H - H Li - L Q Q A - A - B - - H - H - Di - D - Ac - Bw 1 s - 10 s - 1 min - 10 min - 1 h - 10 h h ms ms A - A - B - - H - H - Di - D - Ac - Bw 8 A 8 A 8 A 8 A 8 A 8 A 8 A E E E E E E E onnecion schemes All funcions excep L and Li Funcions L and Li Funcion Q (1) Y1 15 Y (1) Link -Y1 for funcion L only. haracerisics : pages / and /17 page /18 /19

22 haracerisics Zelio ime - iming relays Indusrial single or mulifuncion relays, relay oupu, widh 22.5 mm iming characerisics epea accuracy onforming o IE ± 0.5 % (wih consan parameers) Drif emperaure ± 0.05 % / Volage ± 0.2 % / V Full scale seing accuracy onforming o IE ± 10 % a 25 Minimum duraion of conrol impulse Maximum rese ime by de-energisaion Immuniy ime o microbreaks ypical ms 0 ypical under load ms 100 ypical ms 100 ypical ms > 10 characerisics Mulivolage supply Depending on version, see pages /22 and /2 Frequency Hz 50/60 Operaing range % n ( n for "/$12 V ) On-load facor 100 % Maximum power consumpion Depending on model $ 24 V W 0.6 $ 240 V W 1.5 " 240 V VA 2 Oupu characerisics Oupu ype elay, /O conacs, AgNi (cadmium-free) Breaking capaciy " 2000 VA, $80 W Maximum breaking curren A "8, $ 8 Minimum breaking curren ma 10 / $ 5 V Maximum swiching volage V "/$250 Elecrical life 10 5 operaions 8 A 250 V resisive Mechanical life 5 x 10 6 operaions Dielecric srengh onforming o IE kv 2.5/1min/1 ma/50 Hz Impulse volage onforming o IE 664-1, IE kv 5, wave 1.2/50 µs Display characerisics Sae indicaion by 2 LEDs Green Operaing sae indicaion green LED Pulsing: relay energised, no iming in progress (excep Di-D and Li-L) Flashing: iming in progress On seady: relay energised, no iming in progress Yellow On-delay relay Inpu characerisics Inpu ype V Vol-free conac (no poenial) onrol possible by -wire sensor wih PNP oupu, maximum residual volage: 0.4 V whaever he supply volage of he imer eferences : pages /22 and /2 /20 page /22 page /2

23 haracerisics (coninued) Zelio ime - iming relays Indusrial single or mulifuncion relays, relay oupu, widh 22.5 mm General characerisics onforming o sandards IE , EN /2, EN /2, LV direcives (7/2/EE + 9/68/EE (& marking) + EM (89/6/EE + IE ) Produc cerificaions c L us, SA GL excep E emperaure limis Operaion Sorage reepage disance and clearance Degree of proecion conforming o IE 529 onforming o IE kv 4 kv/ erminal block IP 20 Enclosure IP 40 Fron panel IP 50 excep E Vibraion resisance onforming o IE f = Hz A = 0.5 mm elaive humidiy wihou condensaion Elecromagneic compaibiliy onforming o IE % Immuniy o elecrosaic discharge, conforming o IE Immuniy o elecromagneic fields, conforming o ENV 50140/204 (IE ) Immuniy o fas ransiens in burss conforming o IE Immuniy o surges on he power supply, conforming o IE Immuniy o radio frequency inerference in common mode conforming o ENV (IE ) Immuniy o volage dips and breaks, conforming o IE adiaed and mains conduced disurbance conforming o EN (EN Group 1) Level III (Air 8 kv/onac 6 kv) Level III 10 V/m : (80 MHz 1 GHz) Level III (direc 2 kv / capaciive connecing clip 1 kv) Level III (common mode 2 kv / differenial mode 1 kv) Level III (10 V rms : MHz) 0 % / 10 ms 60 % / 100 ms > 95 % / 5 s lass B Fixing Symmerical mouning rail mm 5 (EN 50022) lamping capaciy Wihou cable end mm 2 2 x 2.5 Wih cable end mm 2 2 x 1.5 Enclosure maerial Self-exinguishing Weigh : 22.5 mm enclosure g 90 eferences : pages /22 and /2 page /22 page /2 /21

24 eferences, dimensions, schemes Zelio ime - iming relays Indusrial single or mulifuncion relays, relay oupus, widh 22.5 mm elay oupu, 2 /O conacs # Mulifuncion or single funcion # Muli-range (7 swichable ranges) # Mulivolage # 2 relay oupus: 8 A V (10 A L) of which 1 insananeous # Screw erminals # Sae indicaion by 1 LED # Opion of supplying a load in parallel # -wire sensor conrol opion Funcion diagrams Funcion A Funcion Funcion Ac Delay on energisaion, 2 imed conacs or 2 imed conacs, 1 of which converible o insananeous 1/2 2 INS Off-delay 2 imed conacs or 2 imed conacs, 1 of which converible o insananeous 1/2 2 ins. iming afer closing/opening of conrol conac 2 imed conacs or 2 imed conacs, 1 of which converible o insananeous 1/2 2 Ins. Funcion B Funcion H Funcion Di iming on impulse, one sho 2 imed conacs or 2 imed conacs, 1 of which converible o insananeous Delay on energisaion wih memory 2 imed conacs or 2 imed conacs, 1 of which converible o insananeous Flashing relay Pulse sar 2 imed conacs or 2 imed conacs, 1 of which converible o insananeous 1/2 2 Ins. 1/2 2 Ins. 1 2 = 1+2 1/2 2 Ins. eferences onnecion Screw erminals / / Funcions Mulifuncion Dual funcion A - A - B - - H - H - Di - D - Ac - Bw A - A iming ranges 7 ranges 1 s - 10 s - 1 min - 10 min - 1 h - 10 h h 4 ranges elay oupu 2 imed conacs, 1 converible o insananeous 2 imed conacs aed curren 8 A 8 A Volages $24 V / " V E E "/$12 V Weigh (kg) Dimensions and connecion schemes Dimensions, ,5 15 Y haracerisics : pages /20 and /21 page /2 /22

25 Funcion K Funcion A Funcion H Funcion D Funcion Bw Delay on de-energisaion rue off-delay (wihou auxiliary supply) 2 imed conacs iming on energisaion wih memory 2 imed conacs or 2 imed conacs, 1 of which converible o insananeous iming on energisaion 2 imed conacs or 2 imed conacs, 1 of which converible o insananeous Flashing relay Sar afer pause 2 imed conacs or 2 imed conacs, 1 of which converible o insananeous Pulse oupu (adjusable) 2 imed conacs or 2 imed conacs, 1 of which converible o insananeous 1/2 1/2 2 Ins. 1 2 = 1+2 1/2 2 Ins. 1/2 2 Ins. 1/2 2 Ins / / Single funcion Mulifuncion K A - A - B - - H - H - Di - D - Ac - Bw 1 s - 10 s - 1 min - 10 min - 1 h - 10 h h 0.6 s s - 20 s - 0 s 2 imed conacs 2 imed conacs, 1 converible o insananeous 8 A 8 A E E onnecion schemes All funcions excep K Funcion K + + Y / /22 28/ haracerisics : pages /20 and /21 page /22 /2

26 haracerisics Zelio ime - iming relays Indusrial single or mulifuncion relays, relay oupu, widh 22.5 mm Presenaion he E7 range of relays, wih only 2 references, covers all iming applicaions. hese relays offer muli-range iming from 50 ms o 00 h. hey are mulivolage. hree models combine several differen funcions: mulifuncion relays. hese producs have a ransparen, hinged flap on heir fron face o avoid any accidenal aleraion of he seings. his flap can be direcly sealed. Environmen onforming o sandards IE , EN Produc cerificaions SA, GL pending, L & marking Zelio ime iming relays conform o European regulaions relaing o & marking Ambien air emperaure around he device Permissible relaive humidiy range Sorage Operaion onforming o IE % Environmenal class K Vibraion resisance onforming o IE , a = 0.5 ms 10 o 55 Hz Shock resisance onforming o IE gn - 11 ms Degree of proecion asing IP 50 erminals IP 20 Degree of polluion onforming o IE Overvolage caegory onforming o IE III aed insulaion volage onforming o IE V 250 Beween conac circui and onforming o SA power supply or beween conac V 00 circui and conrol inpus es volage for insulaion ess Dielecric es kv 2.5 Shock wave kv 4.8 Volage limis Power supply circui c Frequency limis Power supply circui Hz 50/60 ± 5 % Disconnecion value Power supply circui > 0.1 c Mouning posiion wihou deraing abling Maximum c.s.a. In relaion o normal Any posiion verical mouning plane Flexible cable wihou cable end mm 2 2x 2.5 Flexible cable wih cable end mm 2 2 x 1.5 ighening orque N.m Immuniy o elecromagneic inerference (EM) (applicaion class 2 conforming o EN ) Elecrosaic discharge onforming o IE Level (6 kv conac, 8 kv air) Elecromagneic fields onforming o IE Level (10 V/m) Fas ransiens onforming o IE Level (2 kv) Shock waves onforming o IE Level (2 kv) adiaed and ISP11 Group 1 class A conduced emissions ISP22 lass A onsumpion " 50/60 Hz $ Average consumpion 24 V 48 V 110 V 240 V 24 V 48 V 110 V 240 V E7-//11B VA W E7-//12B and E7-//1B VA W E7-////MW (1) VA W (1) E7-B//MW: curren peak on energisaion = 1 A / 0 ms. eferences : pages /26 o /29 /24

27 haracerisics (coninued) Zelio ime - iming relays Indusrial single or mulifuncion relays, relay oupu, widh 22.5 mm iming characerisics Seing accuracy As % of he full-scale value ±10% epea accuracy ±0.2% Influence of volage In he volage range, n <0.2% Influence of emperaure < 0.07 %/ Immuniy o microbreaks ms Minimum conrol pulse ms 20 (excep E7-/MW: 1 s) ese ime ms 50 Oupu circui characerisics Maximum swiching volage V Mechanical durabiliy In millions of operaing cycles 20 urren limi Ih A 8 (excep E7-B//MW: 5 A) aed operaional limis a V 115 V 250 V onforming o IE /1991 A-15 A and VDE 0660 D-1 A Minimum swiching capaciy 12 V/10 ma onac maerial 90/10 nickel silver (excep E7-B//M: gold flashed silver alloy) emoe conrol inpu characerisics Maximum volage Signal delivered by conrol inpus Y1Z2, X1Z2, X2Z2 No galvanic insulaion beween hese inpus and he supply Poeniomeer for connecion beween erminals Z1Z2, ZZ2 Applicable o inpus Y1Z2, X1Z2, X2Z2 V 60 Swiching curren ma < 1 Maximum disance m 50 ompaibiliy /4-wire PNP and NPN elemecanique sensors or oher sensors wihou an inernal load ype Linear a ± 20 % esisance kω 47 ± 20 % Power W 0.2 Maximum disance m 25 by shielded cable: shielding linked o erminal Z2 a.c. load d.c. load urve 1 urve 2 Load limi curve Elecrical durabiliy of conacs on resisive load in millions of operaing cycles educion facor k for inducive loads (applies o values aken from durabiliy curve 1) Millions of operaing cycles ,1 A 0, urren broken in A educion facor k 1 0,9 0,8 0,7 0,6 0,5 0,4 0, 1 0,8 0,6 0,5 0,4 0, 0,2 Power facor on breaking (cos ϕ) Volage in V A 10 0,1 0,2 0, urren in A A E7-B//MW A E7-B//MW 1 L/ = 20 ms 2 L/ wih load proecion diode esisive load Example: An L1-F185 conacor supplied wih 115 V/50 Hz for a consumpion of 55 VA or a curren consumpion equal o 0.1 A and cos ϕ = For 0.1 A, curve 1 indicaes a durabiliy of approximaely 1.5 million operaing cycles. E7 As he load is inducive, i is necessary o apply a reducion coefficien k o his number of cycles as indicaed by curve 2. For cos ϕ = 0.: k = 0.6 he elecrical durabiliy herefore becomes: operaing cycles x 0.6 = operaing cycles. K eferences : pages /26 o /29 /25

28 Funcions, references, schemes Zelio ime - iming relays Indusrial single-funcion relays, relay oupu, widh 22.5 mm elay oupu, 1 /O conac Muliple iming ranges Funcion diagrams Funcion A Funcion W Funcion A Delay on energisaion Exernal conrol for sar of ime delay Exernal conrol for parial sop of ime delay (wih memory) /O 15/18 (25/28) 15/ (25/26) Parial sop /O (Y1Z2) 15/18 Parial sop (X1Z2) / /O 15/18 15/ = Funcion H Funcion Hi Funcion H Pulse-on energisaion Sar on energisaion Sar on opening of exernal conrol conac Exernal conrol for parial sop of ime delay (wih memory) /O 15/18 (25/28) 15/ (25/26) Sar /O Y1Z2 15/18 Parial sop X1Z / /O 15/18 15/ = eferences Funcions A A, W, A Ac Ae, Af iming ranges 0.05 s...00 h 10 ranges 0.05 s...00 h 10 ranges 0.05 s...00 h 10 ranges 0.05 s...00 h 10 ranges Volages $or " 24 V / / / / " V / / / / " or $ V / / / $or " V eferences E7 L11B E7 M11B E7 M1B E7 MV11B Weigh (kg) Dimensions and connecion schemes Dimensions ail mouning 80 Screw fixing 89, , Ø4 haracerisics : pages /24 and /25 pages /0 and /1 /26

29 Funcion Ac Funcion Ae Funcion Af Funcion K Funcion Hf emoe conrol for parial sop of ime delay Exernal conrol for sar of ime delay Asymmerical On-delay and Off-delay wih exernal conrol Off-delay emoe conrol for sop of ime delay > 1 s (1) Sar Y1Z2 Y1 /O 15/18 15/ X1Z2 Parial sop ime delay 1 s 2 s 4 Sar Y1Z2 /O /18 (25/28) 15/ (25/26) a r Exernal conrol /O = a + 4 = r /O 15/18 (25/28) 15/ (25/26) Parial sop /O X1Z2 15/18 15/ 1 s 2 Funcion D Funcion L Funcion Li Funcion L Symmerical flasher, sar wih oupu in res posiion Sar wih oupu in res posiion (X2Z2 no linked) Asymmerical flasher. Sar wih oupu in operaing posiion (X2Z2 linked) Exernal conrol for parial sop of ime delay /O 15/18 (25/28) 15/ (25/26) /O /O 15/18 (25/28) 15/ (25/26) /O 15/18 (25/28) 15/ (25/26) r a a r Parial sop X1Z2 1 s2 s 4 (1) If he device has been sored, de-energised, for more han a monh, i mus be energised for abou 15 seconds in order o acivae i. Subsequenly, i only akes 1 second o sar he ime delay. % If his ime is no complied wih, he relay remains energised indefiniely K Hf H Hi, H D L, Li, L 0.05 s 10 min 7 ranges 0.05 s...00 h 10 ranges 0.05 s...00 h 10 ranges 0.05 s...00 h 10 ranges 0.05 s...00 h 10 ranges 0.05 s...00 h 10 ranges / / / / / / / / / / / / / / E7 1MW E7 1B E7 PE11B E7 PM11B E7 L11B E7 V11B E7 M11B low level conac onnecion schemes E7 L11B E7 1MW E7 PE11B E7 M11B, E7 1B E7 M11B, E7 PM11B Z1 B2 E7 M1B E7 MV11B 15 Z1 B B B E7 L11B 18 E7 V11B 18 X1 Y1 Z2 18 X1 Y1 Z Z1 Z B B X1 X2 Z2 18 haracerisics : pages /24 and /25 page /26 pages /0 and /1 /27

30 Funcions, references, schemes Zelio ime - iming relays Indusrial single or mulifuncion relays, relay oupu, widh 22.5 mm elay oupu, 2 /O conacs Muliple iming ranges Funcion diagrams Funcion A Funcion Ac Funcion Sar on energisaion Exernal conrol for sar of ime delay Off-delay wih exernal conrol for sar of ime delay /O 15/18 (25/28) Sar Y1Z2 Sar 15/ (25/26) /O 15/18 (25/28) 15/ (25/26) a r /O 15/18 15/ Funcion K Off-delay > 1 s (1) /O 15/18 (25/28) 15/ (25/26) (1) If he device has been sored, de-energised, for more han a monh, i mus be energised for abou 15 seconds in order o acivae i. Subsequenly, i only akes 1 second o sar he ime delay. % If his ime is no complied wih, he relay remains energised indefiniely. eferences Funcions A Ac K iming ranges 0.05 s...00 h 10 ranges 0.05 s...00 h 10 ranges 0.05 s...00 h 10 ranges 0.05 s 10 min 7 ranges Volages $or " 24 V / / / " V / / / " or $ V / / / $or " V / eferences E7 P1B E7 MB symmerical E7 L1B low level conac Weigh (kg) Dimensions and connecion schemes Dimensions ail mouning 80 Screw fixing E7 MW 89, , Ø4 haracerisics : pages /24 and /25 pages /0 and /1 /28

31 Funcion H Funcion Hi Funcion Q Funcion Qg Funcion D Pulse-on energisaion Sar on energisaion Sar on opening of exernal conrol conac iming relays for sar-dela sarers iming relays for sar-dela sarers Symmerical flasher, sar wih oupu in res posiion /O 15/18 (25/28) 15/ (25/26) Sar /O Y1Z2 15/18 15/ /O1 15/18 15/ 25/28 /O2 25/26 K1 sar K dela 50 ms /O1 17/18 /O2 17/28 sar K1 dela K 50 ms /O 15/18 (25/28) 15/ (25/26) Funcion Di Symmerical flasher sar wih oupu in operaing posiion /O H Hi D Q Qg A,, H, Hi, D, Di A,, H, Hi, D, Di, Qg, Q 0.05 s...00 h 10 ranges 0.05 s...00 h 10 ranges 0.05 s...00 h 10 ranges 0.05 s...00 h 10 ranges 0.05 s...00 h 10 ranges 0.05 s...00 h 10 ranges 0.05 s...00 h 10 ranges / / / / / / / / / / / / / / / / / / / / / / E7 PP1B E7 PD1B E7 P1B E7 Y2B E7 Y12B E7 ML11B E7 MY1B E7 MY1MW onnecion schemes E7 P1B E7 MW E7 YA E7 L1B, E7 MB E7 PD1B 15 Z1 25 (21) B2 B (22) (21) 28 (24) 26 (22) Z2 18 (24) 15 Z Z B2 B Z Y1 25 (21) B2 B (22) (24) (21) 28 (24) 26 (22) Z2 18 E7 PP1B E7 P1B 15 Z1 25 (21) B2 B (22) (24) (21) 28 (24) 26 (22) Z2 18 E7 Y E7 MY1B E7 MY1MW Y1 17 B2 Z1 25 (21) Y1 Z1 25 (21) X1 B Z (22) 25 (21) 28 (24) 28 (24) 26 (22) Z (22) (24) (21) 28 (24) 26 (22) Z2 18 haracerisics : pages /24 and /25 page /29 pages /0 and /1 /29

32 Schemes Zelio ime - iming relays Indusrial single or mulifuncion relays, relay oupu, widh 22.5 mm ecommended applicaion schemes E7 L, M, P, L, P, ML, MY Sar on energisaion E7 M, MA, MV, M, L, PM, PD, ML, MY Sar by exernal conrol E7 M, PM, ML, MY Exernal conrol of parial sop E7 MA, MV, A, M Sar by exernal conrol (1) (2) () B2 (1) (2) () B2 Y1 Z2 (1) (2) () B2 X1 Z2 (1) (2) () B2 X1 Z2 E7 B Sar on de-energisaion E7 A Sar by exernal conrol + + Y1 B2 Y1 Y1 E7 PP Sar on energisaion E7 PE Sar on energisaion E7 V Selecion of saring phase (1) (2) () B2 (1) () B2 B (1) (2) () B2 X2 Z2 (6) E7 M, P, MA, A, M, PP, PM, ML, MY onnecion of poeniomeer E7 MV onnecion of poeniomeers o asymmerical iming relays E7 V onnecion of poeniomeers onnecion precauions Z1 Z2 Z Z1 (4) (5) Z2 Z Z1 (7) (8) Z2 X1 or Y1 or Z1 Z2 No galvanic isolaion beween supply erminals,,, B2 and conrol inpus X1, Y1, Z1, Z2. (1) " V excep E7 MY1MW : V (2) V () 7 24 V (4) Adjusmen of he On-delay period (5) Adjusmen of he Off-delay period (6) Sar during he On-delay period : X2, Z2 linked. Sar during he Off-delay period : X2, Z2 no linked (7) Off-delay adjusmen (r) (conac 15/ closed) (8) On-delay adjusmen (a) (conac 15/18 closed) haracerisics : pages /24 and /25 eferences : pages /26 o /29 /0

33 Schemes (coninued) Zelio ime - iming relays Indusrial single or mulifuncion relays, relay oupu, widh 22.5 mm ecommended applicaion schemes (coninued) Power scheme E7 Y2B onrol schemes Sar-dela funcion wih double On-delay iming Q L1 L2 L F2 F 95 erminal block B2 K2 F W1 V1 1 M1 K V2 2 W K S2 K1 S1 K K 14 K1 1 K1 K2 K1 K 14 K K1 Y N B Z2 18 K1 = relay E7 YA Power scheme E7 Y12B onrol schemes Sar-dela funcion wih conac for swiching o sar connecion Q K2 L1 F L2 4 4 L W1 V1 1 M1 K 1 2 V2 2 W K No galvanic isolaion beween supply erminals,,, B2 and supply erminal Z2. his erminal mus herefore never be used (facory seing). onrol of several relays wih a single exernal conrol conac onnecion of a elemecanique -wire NPN or PNP sensor + F2 F S2 S1 K K1 K1 5 K K Y K K1 K K2 N K B2 erminal block B Z2 18 K1 = relay E7 Y, or 2 Y1 or X1 Z2, or 2 Y1 or X1 Z2, or 2 Y1 or X1 Z2, or 2 Y1 or X1 Z2 BN BK B NPN PNP I is advisable o follow he recommended wiring schemes deailed above and on previous pages. However, he connecions below are possible if he resricions given are aken ino accoun. onnecion of an exernal conrol conac wihou using erminal Z2: onnecion of a elemecanique -wire NPN or PNP sensor wihou using erminal Z2: - possible on all E7 relays wih exernal conrol opion excep E7 1B, - d.c. supply only. - only possible on relay E7////B, - d.c. supply only , or 2 Y1 or X1 Z2, or 2 Y1 or X1 Z2 24 or 48 V B2 Y1 Z2 BN BK B NPN 24 or 48 V B2 Y1 Z2 BN BK B PNP haracerisics : pages /24 and /25 eferences : pages /26 o /29 /1

34 haracerisics Zelio ime - iming relays Indusrial single-funcion relays, opimum, relay oupu, widh 22.5 mm Presenaion he E8 range of relays is designed for simple and repeiive applicaions, providing basic funcions. Each relay comprises: - a single iming range, - a /O oupu relay. hese producs have a ransparen, hinged flap on heir fron face o avoid any accidenal aleraion of he seings. his flap can be direcly sealed. Environmen onforming o sandards IE EN Produc cerificaions SA, GL pending. L &marking Zelio ime iming relays conform o European regulaions relaing o & marking Ambien air emperaure around he device Permissible relaive humidiy range Sorage Operaion onforming o IE % Environmenal class K Vibraion resisance onforming o IE , a = 0.5 ms 10 o 55 Hz Shock resisance onforming o IE gn - 11 ms Degree of proecion asing IP 50 erminals IP 20 Degree of polluion onforming o IE Overvolage caegory onforming o IE III aed insulaion volage onforming o IE V 250 onforming o SA V 00 es volage for insulaion ess Dielecric es kv 2.5 Shock wave kv 4.8 Volage limis Power supply circui c Frequency limis Power supply circui Hz 50/60 ± 5 % Disconnecion value Power supply circui > 0.1 c Mouning posiion wihou deraing onnecion maximum c.s.a. In relaion o normal Any posiion verical mouning plane Flexible cable wihou cable end mm 2 2 x 2.5 Flexible cable wih cable end mm 2 2 x 1.5 ighening orque N.m Immuniy o elecromagneic inerference (EM) (applicaion class 2 conforming o EN ) Elecrosaic discharge onforming o IE Level (6 kv conac, 8 kv air) Elecromagneic fields onforming o IE Level (10 V/m) Fas ransiens onforming o IE Level (2 kv) Shock waves onforming o IE Level (2 kv) adiaed and conduced ISP11 Group 1 class A emissions ISP22 lass A onsumpion onsumpion " $ 24 V 110 V 240 V 80 V 415 V 24 V E8-A, A, L, PE, P, P VA W 0.5 E8-YG, B VA W 0.5 E8-YA VA W 0.7 eferences : pages /4 o /7 /2 pages /4 and /6 page /5

35 haracerisics (coninued) Zelio ime - iming relays Indusrial single-funcion relays, opimum, relay oupu, widh 22.5 mm iming characerisics Seing accuracy As % of he full-scale value ± 20 % epea accuracy < 1 % Influence of volage In he volage range, n < 2.5 % Influence of emperaure < 0.2 %/ Immuniy o microbreaks ms Minimum conrol pulse ms 26 (excep E8-YG: 60) ese ime ms 50 Oupu circui characerisics Maximum swiching volage V Mechanical durabiliy In millions of operaing cycles 20 urren limi Ih A 8 aed operaional limis a V 115 V 250 V onforming o IE /1991 A-15 A and VDE 0660 D-1 A Minimum swiching capaciy 12 V/10 ma onac maerial 90/10 nickel silver emoe conrol inpu characerisics Signal delivered by conrol inpu Y1 No galvanic insulaion beween his inpu and he supply No-load volage volage Swiching curren ma < 10 Maximum disance m 50 ompaibiliy 2-wire sensors $ wih leakage curren < 1 ma a.c. load d.c. load urve 1 urve 2 Load limi curve Elecrical durabiliy of conacs on resisive load in millions of operaing cycles educion facor k for inducive loads (applies o values aken from durabiliy curve 1) Millions of operaing cycles ,1 A 0, urren broken in A A E8-B//BQ educion facor k 1 0,9 0,8 0,7 0,6 0,5 0,4 0, 1 0,8 0,6 0,5 0,4 0, 0,2 Power facor on breaking (cos ϕ) Volage in V A 10 0,1 0,2 0, urren in A A E8-B//BQ 1 L/ = 20 ms 2 L/ wih load proecion diode esisive load Example: An L1-F185 conacor supplied wih 115 V/50 Hz for a consumpion of 55 VA or a curren consumpion equal o 0.1 A and cos ϕ = 0.. For 0.1 A, curve 1 indicaes a durabiliy of approximaely 1.5 million operaing cycles. As he load is inducive, i is necessary o apply a reducion coefficien k o his number of cycles as indicaed by curve 2. + E8 For cos ϕ = 0.: k = 0.6 he elecrical durabiliy herefore becomes: operaing cycles x 0.6 = operaing cycles. K eferences : pages /4 o /7 pages /4 and /6 page /5 /

36 Funcions, references, schemes Zelio ime - iming relays Indusrial single-funcion relays, opimum, relay oupu, widh 22.5 mm elay oupu, 1 /O conac Single iming range Funcion diagrams Funcion A Sar on energisaion Funcion Wih conrol conac /O 15/18 15/ Sar /O 15/18 15/ eferences (sold in packs of 10) Funcions A Volages $or " 24 V / / " V / / " V iming ranges 0.05 s 0.5 s 0.1 s s E8 A61BQ 0.1 s 10 s E8 1BQ E8 1BQ E8 1FQ 0. s 0 s E8 BQ E8 BQ E8 FQ s 00 s E8 1BQ E8 1BQ E8 1FQ 20 s 0 min E8 A41BQ E8 A41FQ Weigh (kg) Dimensions Dimensions ail mouning Screw fixing 80 89,5 22, Ø4 haracerisics : pages /2 and / page /5 /4

37 Funcion K Off-delay Funcion D Symmerical /O 15/18 15/ /O 15/18 15/ > 80 ms K D / / / / E8 B51BQ E8 1BQ E8 L11BQ E8 BQ Schemes onnecion schemes ecommended applicaion schemes E8 A, L E8 A E8 B E8 A, L E8 A Y Y1 sar onrol of several relays wih a single exernal conrol conac E8 A, E8 PD onnecion of a $ 2-wire sensor + If Y1 Y1 Y1 Y1 he exernal conrol conac may be an elecronic conrol device, for example a 2-wire sensor. In his case - = $ 24 V and he conrol device can only conrol up o a maximum of 4 relays. Leakage curren (open sae) If < 1 ma. haracerisics : pages /2 and / page /4 /5

38 Funcion, references, schemes (coninued) Zelio ime - iming relays Indusrial single-funcion relays, opimum, relay oupu, widh 22.5 mm elay oupu, 1 /O conac Single iming range Funcion diagrams Funcion H Pulse-on energisaion Funcion W Sar on opening of exernal conrol conac /O 15/18 Sar Y1 15/ /O 15/18 15/ eferences (sold in packs of 10) Funcions H W Volages $or " 24 V / / " V / / " V iming ranges 0.05 s 0.5 s 0.1 s s 0.1 s 10 s E8 PE11BQ E8 PD11BQ E8 PD11FQ 0. s 0 s E8 PE1BQ E8 PD1BQ E8 PD1FQ s 00 s E8 PE21BQ E8 PD21BQ E8 PD21FQ 20 s 0 min Weigh (kg) Dimensions, schemes Dimensions ail mouning Screw fixing 80 89,5 22, Ø4 onnecion schemes (erminal blocks) E8 PE E8 PD E8 P E8 YA E8 YG Y haracerisics : pages /2 and / page /7 /6

39 Funcion He Funcion Qc Funcion Qe Pulse-on energisaion, sar on de-energisaion iming relay for sar-dela sarers iming relay for sar-dela sarers /O 15/18 15/ > 80 ms < Sar Dela 15/18 15/ 50 ms /O N/O 15/ 25/28 80 ms He Qc Qe / / / / / / / E8 P01BQ E8 YG11BQ E8 YG1BQ E8 YBQ E8 YFQ E8 YQQ E8 YG21BQ ecommended applicaion schemes Pulse-on energisaion relays E8 PE, E8 P E8 PD + Y1 sar iming relays for sar-dela sarers E8 YG, E8 YA E8 YG E8 YA L1 L2 L Q1 KM2 KM KM1 1 V1 W1 Y V2 W2 h (1) (1) L (1) K1 : E8-YG/1//Q (1) K1 : E8-Y//Q Noe : orrec operaion of he sar-dela sarer associaed wih he E8 YG is only possible if he wiring scheme is sricly complied wih. Y Y L haracerisics : pages /2 and / page /6 /7