Auftrags-Nr.: Order No.: Auftragsdatum: Order date:

Transcription

1 Prüfbericht-Nr.: Auftrags-Nr.: Order No.: Seite 1 von 10 Page 1 of 10 Kunden-Referenz-Nr.: Client Reference No.: Auftragsdatum: Order date: 15 May 2018 Auftraggeber: Client: Prüfgegenstand: Test item: Bezeichnung / Typ-Nr.: Identification / Type No.: Auftrags-Inhalt: Order content: Prüfgrundlage: Test specification: Philadelphia Solar, Al Qastal Industrial Area 2, Airfreight Road, Amman, Jordan Photovoltaic (PV) modules PS P W (Aqaba), PS M72-365W (Amman), PS M (JARASH), PS P60-265W (MAFRAQ) (see also sections 1 "Product details" and "List of test samples") Determination of PV module performance characteristics according to the Guidelines for California's Solar Electric Incentive programs (CEC) Photovoltaic (PV) modules Determination of PV module performance characteristics according to the Guidelines for California's Solar Electric Incentive programs 6 th Ed., and IEC 61215:2005 / IEC 61646: CEC CMF Wareneingangsdatum: Date of receipt: Prüfmuster-Nr.: Test sample No.: Prüfzeitraum: Testing period: Ort der Prüfung: Place of testing: Prüflaboratorium: Testing laboratory: Prüfergebnis*: Test result*: geprüft von / tested by: 06 June 2018 see others 06 June September 2018 Cologne Solar Energy Assessment Center Siehe Sonstiges / See Other kontrolliert von / reviewed by: 17 October 2018 M.Sc. N. Schwarze,Project manager Datum Name / Stellung Unterschrift Date Name / Position Signature 17 October 2018 Dipl.-Ing.L.Jakisch,Business Field manager Datum Name / Stellung Unterschrift Date Name / Position Signature Sonstiges / Other: All required test results for California Solar Electric Incentive programme are listed on the following pages of this report. Test sample No.: HV , HV , HV , HV Zustand des Prüfgegenstandes bei Anlieferung: Condition of the test item at delivery: Prüfmuster vollständig und unbeschädigt Test item complete and undamaged * Legende: 1 = sehr gut 2 = gut 3 = befriedigend 4 = ausreichend 5 = mangelhaft P(ass) = entspricht o.g. Prüfgrundlage(n) F(ail) = entspricht nicht o.g. Prüfgrundlage(n) N/A = nicht anwendbar N/T = nicht getestet Legend: 1 = very good 2 = good 3 = satisfactory 4 = sufficient 5 = poor P(ass) = passed a.m. test specification(s) F(ail) = failed a.m. test specification(s) N/A = not applicable N/T = not tested Dieser Prüfbericht bezieht sich nur auf das o.g. Prüfmuster und darf ohne Genehmigung der Prüfstelle nicht auszugsweise vervielfältigt werden. Dieser Bericht berechtigt nicht zur Verwendung eines Prüfzeichens. This test report only relates to the a. m. test sample. Without permission of the test center this test report is not permitted to be duplicated in extracts. This test report does not entitle to carry any test mark. TÜV Rheinland Energy GmbH Am Grauen Stein Köln Germany Tel.: Fax: Mail: solarenergy@de.tuv.com Web:

2 Prüfbericht-Nr.: Seite 2 von 10 Page 2 of 10 Liste der verwendeten Prüfmittel List of used test equipment Prüfmittel Test equipment Prüfmittel-Nr. / ID-Nr. Equipment No. / ID-No. Nächste Kalibrierung Next calibration All equipment used for tests, including equipment for subsidiary measurements having a significant effect on the accuracy or validity of the result of the test is calibrated before being put into service. The laboratory has an established programme and procedure for the calibration of its equipment according to EN ISO/IEC (Reg. no.: D-PL ). Rev.:01

3 Prüfbericht-Nr.: Seite 3 von 10 Page 3 of 10 Produktbeschreibung Product description 1 Produktdetails Product details For the tested modules, please see List of test samples on page 4. Modules in current IEC 61215:2016/61730:2016 and UL certification are the follows: with 6 poly cells PS P72-xxx W (Aqaba) (xxx= in steps of 5) PS P60-xxxW (MAFRAQ) (xxx= in steps of 5 with 6 mono cells PS M72-xxxW (Amman) (xxx= in steps of 5) PS M60-xxxW (JARASH) (xxx= in steps of 5) xxx represent output power in Wp These are the current power classes stated by the manufacturer. 2 Verwendete Materialien Used materials see Constructional Data Form (CDF) No (still under preparation, as IEC 61215:2016 / 61730:2016 and UL61730 project is still ongoing). 3 Adresse(n) der Fertigungsstätte(n) Address(es) of the manufacturing site(s) Philadelphia Solar, Al Qastal Industrial Area 2, Airfreight Road, Amman, Jordan, Inspection report no.: (October 2017) Next factory inspection is scheduled for 24 th of October Zusammenfassung der Prüfergebnisse Summary of test results According to the inquiry of the customer the performance characteristics of 4 PV module types were determined according to the Guidelines for California's Solar Electric Incentive programs 6 th Ed., and IEC 61215:2005 / IEC 61646: CEC CMF. This test report includes a history of certification in appendix Zusatzdokumentation/Additional Documentation and appendix Foto-Dokumentation/Photo Documentation. Rev.:01

4 Prüfbericht-Nr.: Seite 4 von 10 Page 4 of 10 Absatz Photovoltaic (PV) modules Messergebnisse - Bemerkungen Bewertung Clause Anforderungen - Prüfungen / Requirements - Tests Measuring results - Remarks Evaluation Test specification Crystalline silicon terrestrial photovoltaic (PV) modules Design qualification and type approval IEC 61215:2005 Marking Name, monogram or symbol of manufacturer P Type or model number P Serial number P Polarity of terminals or leads P Maximum system voltage P Date and place of manufacture* P Remarks: *Serial number on type label. See photos in appendix. According to Philadelphia Solar, production order date is prefix of serial number and serial number is connected to the flasher data. List of test samples Sample No. Sample S/N Remarks/constructional characteristics (e.g. cell, backsheet, frame type) HV PS PS P72-325W (Aqaba) HV PS PS M72-365W (Amman) HV PS PS M60-300W (JARASH) HV PS PS P60-265W (MAFRAQ) Rev.:01

5 Prüfbericht-Nr.: Seite 5 von 10 Page 5 of 10 Absatz Photovoltaic (PV) modules Messergebnisse - Bemerkungen Bewertung Clause Anforderungen - Prüfungen / Requirements - Tests Measuring results - Remarks Evaluation IEC/EN Design qualification and type approval 10 Preconditioning (min. 5.5 kwh) P 10.1 Visual inspection See table 10.1 P 10.2 Maximum power determination 10.4 Measurement of temperature coefficients See table Performance at STC See table Measurement of Nominal Operating Cell Temperature (NOCT) See table Performance at NOCT See table Performance at low irradiance See table Visual inspection (Initial) Sample No. Nature and position of initial findings HV P HV P HV junction: Junction box gluing unclean, frame: Gluing unclean P HV junction: Junction box gluing unclean, frame: Gluing unclean P Supplementary information: - Rev.:01

6 Prüfbericht-Nr.: Seite 6 von 10 Page 6 of 10 Absatz Photovoltaic (PV) modules Messergebnisse - Bemerkungen Bewertung Clause Anforderungen - Prüfungen / Requirements - Tests Measuring results - Remarks Evaluation 10.4 Measurement of temperature coefficients Ambient air temperature C 25 ± 2 Irradiance W/m² 1000 ± 50 Module temperature C high/low 68.2 / 24.4 Sample No. Coefficient Calculated value ISC %/ C Impp %/ C * HV Uoc %/ C Umpp %/ C %/ C Supplementary information: Temperature coefficients were measured under a flashlight solar simulator. * Measurement results show a strong and not clear linear variation of Impp over temperature. This is attributed to the fact that the value of Pmpp can remain constant even though its operating point on the IV curve changes slightly. Therefore measurements of temperature coefficient of current at MPP always have high uncertainties. Basing yield predictions on these values is not suggested Measurement of temperature coefficients Ambient air temperature C 25 ± 2 Irradiance W/m² 1000 ± 50 Module temperature C high/low 75 / 26.5 Sample No. Coefficient Calculated value ISC %/ C Impp %/ C * HV Uoc %/ C Umpp %/ C %/ C Supplementary information: Temperature coefficients were measured under a flashlight solar simulator. * Measurement results show a strong and not clear linear variation of Impp over temperature. This is attributed to the fact that the value of Pmpp can remain constant even though its operating point on the IV curve changes slightly. Therefore measurements of temperature coefficient of current at MPP always have high uncertainties. Basing yield predictions on these values is not suggested. Rev.:01

7 Prüfbericht-Nr.: Seite 7 von 10 Page 7 of 10 Absatz Photovoltaic (PV) modules Messergebnisse - Bemerkungen Bewertung Clause Anforderungen - Prüfungen / Requirements - Tests Measuring results - Remarks Evaluation 10.5 Measurement of Nominal Operating Cell Temperature (NOCT) Wind velocity m/s high/low* 1.75 / 0.25 Ambient temperature C high/low* / Irradiance W/m² high/low* / Module temperature C high/low* / Number of NOCT Value Wind velocity m/s (average) NOCT correction factor C Calculated NOCT C Number of NOCT Value Wind velocity m/s (average) NOCT correction factor C Calculated NOCT C Sample No. Average NOCT C HV Supplementary information: Primary method was used. Number of total NOCT values: 8. *Highest/lowest values of all 8 NOCT values. Rev.:01

8 Prüfbericht-Nr.: Seite 8 von 10 Page 8 of 10 Absatz Photovoltaic (PV) modules Messergebnisse - Bemerkungen Bewertung Clause Anforderungen - Prüfungen / Requirements - Tests Measuring results - Remarks Evaluation 10.5 Measurement of Nominal Operating Cell Temperature (NOCT) Wind velocity m/s high/low 1.75 / 0.25 Ambient temperature C high/low / Irradiance W/m² high/low / Module temperature C high/low / 34.8 Number of NOCT Value Wind velocity m/s (average) NOCT correction factor C Calculated NOCT C Number of NOCT Value 4 5 Wind velocity m/s (average) NOCT correction factor C 1 0 Calculated NOCT C Sample No. Average NOCT C HV Supplementary information: Primary method was used. Number of total NOCT values: 5. *Highest/lowest values of all 5 NOCT values. Rev.:01

9 Prüfbericht-Nr.: Seite 9 von 10 Page 9 of 10 Absatz Photovoltaic (PV) modules Messergebnisse - Bemerkungen Bewertung Clause Anforderungen - Prüfungen / Requirements - Tests Measuring results - Remarks Evaluation Performance at STC Test method indoor outdoor Ambient temperature C 25 ± 2 Irradiance W/m² 1000 ± 50 corrected to 1000 Module temperature C 25 ± 2 corrected to 25 Sample No. Pmax W Vmpp V Impp A Voc V Isc A FF % HV HV HV HV Supplementary information: Performance at NOCT Test method indoor outdoor Ambient temperature C 25 ± 2 Irradiance W/m² 800 Module temperature C NOCT: HV , HV : 52.2 C HV , HV : 49.9 C Sample No. Pmax W Vmpp V Impp A Voc V Isc A FF % HV HV HV HV Supplementary information: - Rev.:01

10 Prüfbericht-Nr.: Seite 10 von 10 Page 10 of 10 Absatz Photovoltaic (PV) modules Messergebnisse - Bemerkungen Bewertung Clause Anforderungen - Prüfungen / Requirements - Tests Measuring results - Remarks Evaluation 10.7 Performance at low irradiance Test method indoor outdoor Ambient temperature C 25 ± 2 Irradiance W/m² 200 ± 20 corrected to 200 Module temperature C 25 ± 2 corrected to 25 Sample No. Pmax W Vmpp V Impp A Voc V Isc A FF % HV HV HV HV Supplementary information: - Rev.:01

11 Current in [A] Produkte ANLAGE zum Prüfbericht-Nr.: APPENDIX to Seite 1 von 4 Page 1 of 4 ZUSATZ-DOKUMENTATION ADDITIONAL DOCUMENTATION Fig 1: HV P@STC, P@NOCT Voltage in [V] Fig 2: HV P@LI

12 Current in [A] Produkte ANLAGE zum Prüfbericht-Nr.: APPENDIX to Seite 2 von 4 Page 2 of 4 ZUSATZ-DOKUMENTATION ADDITIONAL DOCUMENTATION Fig 3: HV P@STC, P@NOCT Voltage in [V] Fig 4: HV P@LI

13 Current in [A] Produkte ANLAGE zum Prüfbericht-Nr.: APPENDIX to Seite 3 von 4 Page 3 of 4 ZUSATZ-DOKUMENTATION ADDITIONAL DOCUMENTATION Fig 5: HV P@STC, P@NOCT Voltage in [V] Fig 6: HV P@LI

14 ANLAGE zum Prüfbericht-Nr.: APPENDIX to Seite 4 von 4 Page 4 of 4 ZUSATZ-DOKUMENTATION ADDITIONAL DOCUMENTATION Fig 7: HV P@STC, P@NOCT Fig 8: HV P@LI

15 ANLAGE zum Prüfbericht-Nr.: APPENDIX to Seite 1 von 5 Page 1 of 5 FOTO-DOKUMENTATION PHOTO-DOCUMENTATION PS M60-300W (JARASH) PS M60-300W (JARASH) PS M60-300W (JARASH) PS M60-300W (JARASH) PS M60-300W (JARASH) PS M60-300W (JARASH)

16 ANLAGE zum Prüfbericht-Nr.: APPENDIX to Seite 2 von 5 Page 2 of 5 FOTO-DOKUMENTATION PHOTO-DOCUMENTATION PS P60-265W (MAFRAQ) PS P60-265W (MAFRAQ) PS P60-265W (MAFRAQ) PS P60-265W (MAFRAQ) PS P60-265W (MAFRAQ) PS P60-265W (MAFRAQ)

17 ANLAGE zum Prüfbericht-Nr.: APPENDIX to Seite 3 von 5 Page 3 of 5 FOTO-DOKUMENTATION PHOTO-DOCUMENTATION PS P60-265W (MAFRAQ)

18 ANLAGE zum Prüfbericht-Nr.: APPENDIX to Seite 4 von 5 Page 4 of 5 FOTO-DOKUMENTATION PHOTO-DOCUMENTATION PS M72-xxxW (Amman) PS M72-xxxW (Amman) PS M72-365W (Amman) PS M72-365W (Amman) PS M72-365W (Amman)

19 ANLAGE zum Prüfbericht-Nr.: APPENDIX to Seite 5 von 5 Page 5 of 5 FOTO-DOKUMENTATION PHOTO-DOCUMENTATION PS P72-325W (Aqaba) PS P72-325W (Aqaba) PS P72-325W (Aqaba) PS P72-325W (Aqaba) PS P72-325W (Aqaba) PS P72-325W (Aqaba)