Digital Modules AS-i in IP20, 22,5 mm

Transcription

1 Digital Modules AS-i in 22,5 mm Cost efficient solution in IP20 (Figure similar) Figure Type Housing s digital digital voltage (sensor supply) 1 Output voltage (actuator supply) 2 AS-i connection 3 AS-i address Article No. 22,5mm x 50mm, x out of AS-i out of AS-i clamps 1 AB Slave x x x x 22,5mm x 11mm, 6 x 22,5mm x 11mm, 6 x 6x 6x out of clamps 1 AB Slave BWU2723 out of out of clamps 1 AB Slave BWU1938 out of out of clamps 1 Single Slave BWU out of clamps 2 AB Slaves BWU x 8x out of out of clamps 2 AB Slaves BWU290 out of out of clamps 2 Single Slaves BWU voltage (sensor supply): inputs are supplied by AS-i or by (auxiliary 2V power). If supplied by AS-i, inputs can neither be connected to earth nor to external potential. 2 Output voltage (actuator supply): the supply of the outputs is made by AS-i or by (auxiliary 2V power). By supply out of AS-i there is no connection to earth or external potential allowed. 3 : the connection to AS-i as well to (auxiliary 2V power) is either made via yellow AS-i profile cable with piercing technology or via M12 socket (in IP20 via clamps). AS-i address: AB Slave (max. 62 AB Slaves/AS-i network), 2 AB Slaves (max. 31 modules with 2 AB Slaves), Single Slaves (max. 31 Single Slaves/AS-i network), mixed use allowed (upon request, slaves are available with specific AS- Slave profiles). We reserve the right to change any data Mannheim, page 1

2 Digital Modules AS-i in 22,5 mm Article no. BWU1938 BWU2759 BWU2723 BWU2721 BWU290 BWU2800 Connection Periphery connection Length of connector cable AS-i Profile I/O: max. 15m (fixed) ID1=F AS-i address 1 AB Slave 1 single slave plug plug unlimited ID1=6 (fixed), ID1=6 ID1=F ID1=E 1 AB Slave 2 AB Slaves 2 single slaves Operating voltage V Required Master profile M M0 M3 M M0 Since AS-i specification Max. current consumption 165mA 35mA 60mA Voltage V Max. current consumption - A 1,2A 8A Number 8 Power supply out of AS-i out of Power supply of attached sensors 120mA max. 1,2A permanent operation 3 ( in- and outputs = max. 120mA) 1 Switching threshold U<5V (low) U>15V (high) Output Number x x 8 x, short circuit protected Power supply out ofas-i out of out of Max. output current 120mA ( in- and 1A ( 3A max.) 1A ( 3A max. O1-O, 3A max. O5-O8) outputs = max. 120mA) 1 Display LED (green) on: AS-i voltage on, flashing: AS-i voltage on, but peripheral fault 2 or address 0 off: no AS-i voltage LED /FAULT (red) on: slave address 0 or slave offline flashing: peripheral fault 2 off: slave online LED / 1 (red/green) green: slave online red: slave offline yellow/red flashing: address 0 red/green flashing: peripheral fault 2 page 2 Mannheim, We reserve the right to change any data

3 Digital Modules AS-i in 22,5 mm Article no. BWU1938 BWU2759 BWU2723 BWU2721 BWU290 BWU2800 LED / 2 (red/green) green: slave online red: slave offline yellow/red flashing: address 0 red/green flashing: peripheral fault 2 red flashing: slave 2 is switched off, because slave 1 is offline LEDs In (yellow) state of inputs State of inputs I8 LEDs O1 On (yellow) state of outputs O1-O state of outputs O1-O8 LED (green) on: 2V DC off: no 2V DC Environment Applied standards EN EN Operating temperature -25 C -25 C +70 C +55 C Storage temperature -25 C +85 C Protection category DIN EN IP20 Voltage of insulation 500V Dimensions (W / H / D) in mm 22, / 99,6 / 50,5 22,5 / 99 / 11 1 Derating current ma see Installation instruction/manual C operating temperature Derating BWU1938, BWU290, BWU2721, BWU2723, BWU2759, BWU2800 current A C operating temperature at operating temperature >60 C: Σ 1A max. We reserve the right to change any data Mannheim, page 3

4 Digital Modules AS-i in 22,5 mm connections I- I+ O- O- O1 O O2 O3 BWU1938 / BWU2759 +, - s O1 O O1 O2 O3 O + + I I + O 2 O 1 I I 3 I 2 I 1 I 2 I 3 I 1 I O 2 O 3 O 1 O FAULT ADDR I I + O 2 O 1 I I 3 I 2 I 1 I 2 I 3 I 1 I O 2 O 3 O 1 O FAULT ADDR s O1 O O 2 O 3 O 1 O + NC NC I I+ O O I 8 I 7 I 6 I 5 I I 2 I 1 D1 I6 D2 I7 I5 I8 / D1 / D2 ADDR D1 ADDR D2 O1 O O2 D1 O3 O5 O8 O6 D2 O7 O1 O2 O3 O O5 O6 O7 O8 + + O 1 O 2 O 3 O + NC NC + BWU290 / BWU2800 +, - I8 s O1 O8 I- I+ I- I+ BWU2723 +, - PWR INT nc nc nc nc + + I- I+ I- I+ I5 I8 I6 I7 BWU2721 +, - I8 PWR INT ADDR page Mannheim, We reserve the right to change any data

5 Digital Modules AS-i in 22,5 mm module BWU1938 / BWU290 / BWU2721 / BWU2723 / BWU2759 / / BWU2800 Output module BWU1938 / BWU290 / BWU2759 / / BWU2800 I+ Ix O- O1 O2 Ox Separate power supply 2V (s) 0V 2V () I+ Ix + - Programming BWU1938 / BWU2723 / BWU2759 / Bit setting D0 D1 D2 D3 BWU290 / BWU2721 / BWU2800 I5 I6 I7 I8 Output BWU1938 / BWU2759 / O1 O2 O3 O BWU290 / BWU2800 O1 O2 O3 O O5 O6 O7 O8 Parameter bit P0 P1 P2 P3 BWU290 / BWU2800 not used, watchdog always on not used not used BWU2723 / BWU2721 BWU1938 / BWU2759 0= off / 1= on (peripheral fault, if no voltage) 0= off / 1= on (watchdog) 0= on / 1= off (data input filter 128μs) 0: on / 1: off (synchronous I/O mode) We reserve the right to change any data Mannheim, page 5