EN RF Test Report

Transcription

1 EN RF Test Report Report No.: Test Model: RE150707C22B EYAGJN Received Date: Jul. 07, 2015 Test Date: Jul. 14, 2015 Issued Date: Apr. 14, 2017 Applicant: TAIYO YUDEN CO., LTD. Address: 8-1, Sakae-cho, Takasaki-shi, Gunma, , Japan Issued By: Lab Address: Test Location: Bureau Veritas Consumer Products Services (H.K.) Ltd., Taoyuan Branch No. 47-2, 14th Ling, Chia Pau Vil., Lin Kou Dist., New Taipei City, Taiwan, R.O.C. No. 19, Hwa Ya 2nd Rd., Wen Hwa Vil., Kwei Shan Dist., Taoyuan City 33383, TAIWAN (R.O.C.) This report is for your exclusive use. Any copying or replication of this report to or for any other person or entity, or use of our name or trademark, is permitted only with our prior written permission. This report sets forth our findings solely with respect to the test samples identified herein. The results set forth in this report are not indicative or representative of the quality or characteristics of the lot from which a test sample was taken or any similar or identical product unless specifically and expressly noted. Our report includes all of the tests requested by you and the results thereof based upon the information that you provided to us. You have 60 days from date of issuance of this report to notify us of any material error or omission caused by our negligence, provided, however, that such notice shall be in writing and shall specifically address the issue you wish to raise. A failure to raise such issue within the prescribed time shall constitute your unqualified acceptance of the completeness of this report, the tests conducted and the correctness of the report contents. Unless specific mention, the uncertainty of measurement has been explicitly taken into account to declare the compliance or non-compliance to the specification. This report should not be used by the client to claim product certification, approval, or endorsement by TAF or any government agencies. Report No.: RE150707C22B Page No. 1 / 23 Report Format Version: 6.1.2

2 Table of Contents Release Control Record Certificate of Conformity Summary of Test Results Test Instruments Measurement Uncertainty Maximum Measurement Uncertainty Modification Record General Information General Description of EUT Description of Test Modes Test Mode Applicability and Tested Channel Detail Description of Support Units Configuration of System under Test General Description of Applied Standards Test Procedure and Results Equivalent Isotropic Radiated Power Limits of Equivalent Isotropic Radiated Power Test Procedures Deviation from Test Standard Test Setup Test Results Permitted Range of Operating Frequencies Limits of Permitted Range of Operating Frequencies Test Procedures Deviation of Test Standard Test Setup Test Results Unwanted Emissions in the Spurious Domain Limit of Unwanted Emissions in the Spurious Domain Test Procedure Deviation from Test Standard Test Setup Test Results Duty Cycle Limit of Duty Cycle Test Procedures Test Setup Test Results Receiver Spurious Radiation Limit of Receiver Spurious Radiation Test Procedure Deviation from Test Standard Test Setup Test Results Photographs of the Test Configuration Appendix Information on the Testing Laboratories Report No.: RE150707C22B Page No. 2 / 23 Report Format Version: 6.1.2

3 Release Control Record Issue No. Description Date Issued RE150707C22B Original release Apr. 14, 2017 Report No.: RE150707C22B Page No. 3 / 23 Report Format Version: 6.1.2

4 1 Certificate of Conformity Product: Wireless Module Brand: TAIYO YUDEN Test Model: EYAGJN Sample Status: Engineering sample Applicant: TAIYO YUDEN CO., LTD. Test Date: Jul. 14, 2015 Standards: EN V2.1.1 ( ) The above equipment has been tested by Bureau Veritas Consumer Products Services (H.K.) Ltd., Taoyuan Branch, and found compliance with the requirement of the above standards. The test record, data evaluation & Equipment Under Test (EUT) configurations represented herein are true and accurate accounts of the measurements of the sample s EMC characteristics under the conditions specified in this report. Prepared by :, Date: Apr. 14, 2017 Celine Chou / Specialist Approved by :, Date: Apr. 14, 2017 Ken Liu / Senior Manager Report No.: RE150707C22B Page No. 4 / 23 Report Format Version: 6.1.2

5 2 Summary of Test Results The EUT has been tested according to the following specifications: EN Clause Test Parameter Result Equivalent Isotropic Radiated Power (e.i.r.p) Pass Permitted Range of Operating Frequencies Pass Unwanted Emission in the Spurious Domain Pass Duty Cycle Pass Receiver spurious radiation Pass Report No.: RE150707C22B Page No. 5 / 23 Report Format Version: 6.1.2

6 2.1 Test Instruments Description & Manufacturer Model No. Serial No. Calibrated Date Calibrated Until Spectrum Analyzer Agilent E4440A MY Mar. 09, 2015 Mar. 08, 2016 BILOG Antenna SCHWARZBECK VULB Feb. 04, 2015 Feb. 03, 2016 HORN Antenna ETS Feb. 10, 2015 Feb. 09, 2016 HORN Antenna SCHWARZBECK BBHA 9170 BBHA Feb. 05, 2015 Feb. 04, 2016 Preamplifier Agilent 8449B 3008A01976 Aug. 22, 2014 Aug. 21, 2015 Preamplifier Agilent 8447D 2944A10634 Aug. 22, 2014 Aug. 21, 2015 RF signal cable HUBER+SUHNER SUCOFLEX /4 Aug. 22, 2014 Aug. 21, 2015 RF signal cable HUBER+SUHNER SUCOFLEX Aug. 22, 2014 Aug. 21, 2015 RF signal cable HUBER+SUHNER Software ADT. Antenna Tower Max-Full 10dB Attenuation JFW Turn Table ADT Controller Max-Full Temperature & Humidity chamber TERCHY CA G.90 (3m) & CA F.90 (2m) ADT_Radiated_ V NF090(3m)*2 & TCF427S(2m)*1 Apr. 07, 2015 Apr. 06, 2016 NA NA NA MFA-440H NA NA 50HF-010-SMA NA NA NA NA SN30303 NA NA MF7802 MF NA NA MHU-225AU Jun. 18, 2015 Jun. 17, 2016 Note: 1. The calibration interval of the above test instruments is 12 months and the calibrations are traceable to NML/ROC and NIST/USA. 2. The test was performed in HwaYa RF Chamber The horn antenna and preamplifier (model: 8449B) are used only for the measurement of emission frequency above 1GHz if tested. Report No.: RE150707C22B Page No. 6 / 23 Report Format Version: 6.1.2

7 2.2 Measurement Uncertainty Where relevant, the following measurement uncertainty levels have been estimated for tests performed on the EUT: This uncertainty represents an expanded uncertainty expressed at approximately the 95% confidence level using a coverage factor of k=2. Parameter Uncertainty Radio frequency ±1.06x10-8 Radiated emission of transmitter, valid up to 26.5GHz ±3.294dB Radiated emission of receivers, valid up to 26.5GHz ±3.294dB Temperature ±0.23 C Humidity ±0.3 % Voltages(DC) ±0.1 % Voltages(AC, <10kHz) ±0.22 % 2.3 Maximum Measurement Uncertainty For the test methods, according to ETSI EN standard, the measurement uncertainty figures shall be calculated in accordance with TR [7] and shall correspond to an expansion factor (coverage factor) k = 1,96 or k = 2 (which provide confidence levels of respectively 95 % and 95,45 % in the case where the distributions characterizing the actual measurement uncertainties are normal (Gaussian)). Maximum measurement uncertainty Parameter Uncertainty Radio frequency ±1x10-7 Radiated emission of transmitter, valid to 26.5GHz ±6.0 db Radiated emission of receiver, valid 26.5GHz ±6.0 db Temperature ±1 C Humidity ±5.0 % Voltages(DC) ±1.0 % Voltages(AC, <10kHz) ±2.0 % 2.4 Modification Record There were no modifications required for compliance. Report No.: RE150707C22B Page No. 7 / 23 Report Format Version: 6.1.2

8 3 General Information 3.1 General Description of EUT Product Wireless Module Brand TAIYO YUDEN Test Model EYAGJN Status of EUT Engineering sample Nominal Voltage 3Vdc (Host equipment) Voltage Operation Range V nom = 3.0 V min = 1.8 V max = 3.6 Temperature Operating Range -40~85 Modulation Type Transfer Rate Operating Frequency Number of Channel 78 EIRP Power (Measured Max. Average) Antenna Type Accessory Device Data Cable Supplied GFSK 1Mbps 2403 ~ 2480MHz 4.38dBm PCB antenna with -1.5dBi gain NA NA Note: This report is issued as a duplicate report to the original BV ADT report no.: RE150707C22-1. The difference compared with original report is updating standard to the latest version. Due to no effect on any test item, we didn t re-test. Report No.: RE150707C22B Page No. 8 / 23 Report Format Version: 6.1.2

9 3.2 Description of Test Modes 78 channels are provided to this EUT: Channel FREQ. (MHz) Channel FREQ. (MHz) Channel FREQ. (MHz) Channel FREQ. (MHz) Report No.: RE150707C22B Page No. 9 / 23 Report Format Version: 6.1.2

10 3.2.1 Test Mode Applicability and Tested Channel Detail EUT Configure Mode Applicable to EIRP PR SE<1G SE 1G - - Where EIRP: Equivalent Isotropic Radiated Power PR: Permitted Range SE<1G: Spurious Emissions below 1GHz SE 1G: Spurious Emissions above 1GHz Description Note: The EUT had been pre-tested on the positioned of each 3 axis. The worst case was found when positioned on X-plane. Equivalent Isotropic Radiated Power: Pre-Scan has been conducted to determine the worst-case mode from all possible combinations between available modulations, data rates and antenna ports (if EUT with antenna diversity architecture). Following channel(s) was (were) selected for the final test as listed below. EUT Configure Mode Available Channel Tested Channel Modulation Type - 1 to 78 1, 39, 78 GFSK Permitted Range Test: Pre-Scan has been conducted to determine the worst-case mode from all possible combinations between available modulations, data rates and antenna ports (if EUT with antenna diversity architecture). Following channel(s) was (were) selected for the final test as listed below. EUT Configure Mode Available Channel Tested Channel Modulation Type - 1 to 78 1, 39, 78 GFSK Spurious Emissions Test (Below 1 GHz): Pre-Scan has been conducted to determine the worst-case mode from all possible combinations between available modulations, data rates and antenna ports (if EUT with antenna diversity architecture). Following channel(s) was (were) selected for the final test as listed below. EUT Configure Mode Available Channel Tested Channel Modulation Type - 1 to 78 1 GFSK Spurious Emissions Test (Above 1 GHz): Pre-Scan has been conducted to determine the worst-case mode from all possible combinations between available modulations, data rates and antenna ports (if EUT with antenna diversity architecture). Following channel(s) was (were) selected for the final test as listed below. EUT Configure Mode Available Channel Tested Channel Modulation Type - 1 to 78 1, 78 GFSK Report No.: RE150707C22B Page No. 10 / 23 Report Format Version: 6.1.2

11 Test Condition: Applicable to Environmental Conditions Input Power Tested by EIRP 25deg. C, 60%RH 3Vdc Leo Chan PR 25deg. C, 60%RH 3Vdc Leo Chan SE<1G 25deg. C, 65%RH 3Vdc Cedric Wu SE 1G 25deg. C, 65%RH 3Vdc Cedric Wu Report No.: RE150707C22B Page No. 11 / 23 Report Format Version: 6.1.2

12 3.3 Description of Support Units The EUT has been tested as an independent unit together with other necessary accessories or support units. The following support units or accessories were used to form a representative test configuration during the tests. ID Product Brand Model No. Serial No. FCC ID Remarks A. DC Power Supply Topward 6603D NA NA - B. Notebook DELL E5430 2RL3YW1 FCC Doc Approved - Note: 1. All power cords of the above support units are non-shielded (1.8 m). 2. Item A and B were placed under the testing table. ID Descriptions Qty. Length (m) Shielding (Yes/No) Cores (Qty.) 1. Power cable N 0-2. USB cable Y 0 - Remarks Configuration of System under Test Power Supply (A) Notebook (B) (1) (2) EUT (Power from host equipment) Test table 3.4 General Description of Applied Standards The EUT is a RF Product. According to the specifications of the manufacturer, it must comply with the requirements of the following standards: EN V2.1.1 ( ) All test items have been performed and recorded as per the above standards. Report No.: RE150707C22B Page No. 12 / 23 Report Format Version: 6.1.2

13 4 Test Procedure and Results 4.1 Equivalent Isotropic Radiated Power Limits of Equivalent Isotropic Radiated Power Condition Under all test conditions Limit (e.i.r.p) AV:10dBm Test Procedures Refer to EN V2.1.1 clause Deviation from Test Standard No deviation Test Setup The test setup has been constructed as the normal use condition. Controlling software (provided by manufacturer) has been activated to set the EUT on specific status Test Results EIRP Power (dbm) Test Condition (CH1) 2403 MHz (CH39) 2441 MHz (CH78) 2480 MHz T nom ( ) +25 V nom (v) T min ( ) -40 T max ( ) +85 V min (v) V max (v) V min (v) V max (v) Report No.: RE150707C22B Page No. 13 / 23 Report Format Version: 6.1.2

14 4.2 Permitted Range of Operating Frequencies Limits of Permitted Range of Operating Frequencies The width of the power envelope is f H f L for a give operating frequency. In equipment that allows adjustment or selection of different frequencies, the power envelope take up different positions in the allowed band. The frequency range is determined by the lowest value of f L and the highest value of f H resulting from the adjustment of the equipment to the lowest and highest operating frequency Test Procedures Refer to EN V2.1.1 clause Deviation of Test Standard No deviation Test Setup The EUT has been placed in an environment where the temperature can be controlled. The power source should be replaced by a power supply for voltage change. Before testing, the transmitter has to be able to send signal to receiver Test Results Test Condition Lowest Frequency (MHz) Highest T nom ( ) +25 V nom (v) T min ( ) -40 T max ( ) +85 V min (v) V max (v) V min (v) V max (v) Measured frequency (lowest and highest) F L = F H = Report No.: RE150707C22B Page No. 14 / 23 Report Format Version: 6.1.2

15 4.3 Unwanted Emissions in the Spurious Domain Limit of Unwanted Emissions in the Spurious Domain Frequency Range 47MHz to 74MHz 87.5MHz to 108MHz 174MHz to 230MHz 470MHz to 862MHz Other Frequencies Below 1GHz >1GHz Limit (Operating) 4nW ( 54dBm) 250nW ( 36dBm) 1μW ( 30dBm) Limit (Standby) 2nW ( 57dBm) 2nW ( 57dBm) 2nW ( 47dBm) Test Procedure Refer to EN V2.1.1 clause Deviation from Test Standard No deviation Test Setup 1. For the actual test configuration, please refer to the related Item in this test report (Photographs of the Test Configuration). 2. The test setup has been constructed as the normal use condition. Controlling software (provided by manufacturer) has been activated to set the EUT on specific status. Report No.: RE150707C22B Page No. 15 / 23 Report Format Version: 6.1.2

16 4.3.5 Test Results Worst-case Data: Frequency Range 25MHz ~ 1GHz Operating Channel 1 Operating State Operating Spurious Emission Level Frequency (MHz) Antenna Polarization Level (dbm) Limit (dbm) Margin (db) H V H V H H V H H V V V Frequency Range 1GHz ~ 25GHz Operating Channel 1, 78 Operating State Operating Channel 1 78 Spurious Emission Level Frequency Antenna Level Limit Margin (MHz) Polarization (dbm) (dbm) (db) H V H V Report No.: RE150707C22B Page No. 16 / 23 Report Format Version: 6.1.2

17 Frequency Range 25MHz ~ 1GHz Operating Channel 1 Operating State Standby Spurious Emission Level Frequency (MHz) Antenna Polarization Level (dbm) Limit (dbm) Margin (db) H V H V V H V H V H V H Frequency Range 1GHz ~ 25GHz Operating Channel 1, 78 Operating State Standby Channel 1 78 Spurious Emission Level Frequency Antenna Level Limit Margin (MHz) Polarization (dbm) (dbm) (db) H V V H Report No.: RE150707C22B Page No. 17 / 23 Report Format Version: 6.1.2

18 4.4 Duty Cycle Limit of Duty Cycle Frequency Band Duty Cycle Application 2400 MHz to MHz No Restriction 2400 MHz to MHz No Restriction (a) 2446 MHz to 2454 MHz No Restriction (b) 2446 MHz to 2454 MHz 15% 5725 MHz to 5875 MHz No Restriction 9200 MHz to 9500 MHz No Restriction 9500 MHz to 9975 MHz No Restriction 10.5 GHz to 10.6 GHz No Restriction 13.4 GHz to 14.0 GHz No Restriction 17.1 GHz to 17.3 GHz DDA or equivalent techniques GHz to GHz No Restriction Generic use Detection, movement and alert applications RFID RFID Generic use Radiodetermination: radar, detection, movement and alert applications Radiodetermination: radar, detection, movement and alert applications Radiodetermination: radar, detection, movement and alert applications Radiodetermination: radar, detection, movement and alert applications Radiodetermination: GBSAR detecting and movement and alert applications Generic use and for Radiodetermination: radar, detection, movement and alert applications Test Procedures Refer to EN V2.1.1 clause Test Setup The EUT was operated in normal operation condition Test Results The duty cycle of this device declared by client is 100%. Report No.: RE150707C22B Page No. 18 / 23 Report Format Version: 6.1.2

19 4.5 Receiver Spurious Radiation Limit of Receiver Spurious Radiation Frequency Range Frequencies below 1GHz Frequencies above 1GHz Limit 2nW ( 57dBm) 20nW ( 47dBm) Test Procedure Refer to EN V2.1.1 clause Deviation from Test Standard No deviation Test Setup 1. For the actual test configuration, please refer to the related Item in this test report (Photographs of the Test Configuration). 2. The test setup has been constructed as the normal use condition. Controlling software (provided by manufacturer) has been activated to set the EUT on specific status. Report No.: RE150707C22B Page No. 19 / 23 Report Format Version: 6.1.2

20 4.5.5 Test Results Worst-case Data: Frequency Range 25MHz ~ 1GHz Operating Channel 1 Spurious Emission Level Frequency (MHz) Antenna Polarization Level (dbm) Limit (dbm) Margin (db) H H V H V V V H H V V V H Frequency Range 1GHz ~ 25GHz Operating Channel 1, 78 Channel 1 78 Spurious Emission Level Frequency Antenna Level Limit Margin (MHz) Polarization (dbm) (dbm) (db) V H H V Report No.: RE150707C22B Page No. 20 / 23 Report Format Version: 6.1.2

21 5 Photographs of the Test Configuration TX / RX Spurious Emission Test Report No.: RE150707C22B Page No. 21 / 23 Report Format Version: 6.1.2

22 Report No.: RE150707C22B Page No. 22 / 23 Report Format Version: 6.1.2

23 Appendix Information on the Testing Laboratories We, Bureau Veritas Consumer Products Services (H.K.) Ltd., Taoyuan Branch, were founded in 1988 to provide our best service in EMC, Radio, Telecom and Safety consultation. Our laboratories are accredited and approved according to ISO/IEC If you have any comments, please feel free to contact us at the following: Linko EMC/RF Lab Tel: Fax: Hsin Chu EMC/RF/Telecom Lab Tel: Fax: Hwa Ya EMC/RF/Safety Lab Tel: Fax: Web Site: The address and road map of all our labs can be found in our web site also. --- END --- Report No.: RE150707C22B Page No. 23 / 23 Report Format Version: 6.1.2