EC centrifugal fan. forward curved, dual inlet with housing (flange)

Transcription

1 D3G133-BF3-6 ebm-papst Mulfingen GmbH & Co. KG Bachmühle 2 D Mulfingen Phone Fax info1@de.ebmpapst.com Limited partnership Headquarters Mulfingen County court Stuttgart HRA General partner Elektrobau Mulfingen GmbH Headquarters Mulfingen County court Stuttgart HRB Nominal data Type Motor D3G133-BF3-6 M3G55-CF Phase 1~ Nominal voltage VAC Nominal voltage range VAC Frequency Hz /6 Type of data definition Speed min Power input W 86 Current draw A.64 Min. ambient temperature C -25 Max. ambient temperature C +4 ml = Max. load me = Max. efficiency fa = Running at free air cs = Customer specs cu = Customer unit Subject to alterations fa Item no Revision Release Page 1 / 5 ebm-papst Mulfingen GmbH & Co. KG Bachmühle 2 D Mulfingen Phone +49 () Fax +49 () info1@de.ebmpapst.com

2 D3G133-BF3-6 Technical features Mass Size Surface of rotor Material of impeller Housing material Motor suspension Direction of rotation 3 kg 133 mm Uncoated Type of protection IP 42 Insulation class Sheet steel, galvanised Sheet steel, galvanised Motor mounted via brackets on one side Clockwise, seen on rotor "B" Humidity class F3-1 Max. permissible ambient motor temp. (transp./ storage) Min. permissible ambient motor temp. (transp./storage) Mounting position Condensate discharge holes Operation mode Motor bearing Technical features EMC interference immunity + 8 C - 4 C Shaft horizontal None S1 Ball bearing - Output 1 VDC, max. 1.1 ma - Tach output - Motor current limit - Soft start - Control input -1 VDC / PWM - Control interface with SELV potential safely disconnected from the mains - Over-temperature protected motor Acc. to EN (industrial environment) EMC harmonics Acc. to EN /3 EMC interference emission Touch current acc. IEC 699 (measuring network Fig. 4, TN system) Electrical leads Motor protection Cable exit Protection class Acc. to EN (household environment) <= 3.5 ma With plug Thermal overload protector (TOP) wired internally Lateral Product conforming to standard EN I (if protective earth is connected by customer) Item no Revision Release Page 2 / 5 ebm-papst Mulfingen GmbH & Co. KG Bachmühle 2 D Mulfingen Phone +49 () Fax +49 () info1@de.ebmpapst.com

3 D3G133-BF3-6 Product drawing 1 Connection line PVC 4 x.25 mm² with plug: AMP Mate-N-Lok red 1.2 yellow 1.3 Light blue 1.4 white 2 Connection line PVC 3G x.5 mm² with plug: AMP Mate-N-Lok brown 2.2 blue 2.3 green/yellow Item no Revision Release Page 3 / 5 ebm-papst Mulfingen GmbH & Co. KG Bachmühle 2 D Mulfingen Phone +49 () Fax +49 () info1@de.ebmpapst.com

4 D3G133-BF3-6 Connection screen Line No. Signal Colour Function / assignment 2 L brown Power supply VAC, -6 Hz, see type plate for voltage range 3 N blue Neutral conductor 1 PE green/yellow Protective earth 7-1 V PWM yellow Control input - 1 V or PWM, electrically isolated 5 Tach white Tach output: Open Collector, 1 pulse per revolution, electrically isolated 6 1V / max. 1.1 ma red Voltage output 1V / 1.1mA, electrically isolated, not short-circuit-proof 4 GND blue GND - Connection for control interface Item no Revision Release Page 4 / 5 ebm-papst Mulfingen GmbH & Co. KG Bachmühle 2 D Mulfingen Phone +49 () Fax +49 () info1@de.ebmpapst.com

5 D3G133-BF3-6 Charts: Air flow Hz Druck p f s[pa]für Rho=1,2kg/m^ qv[cfm] ,2 1, 1,1 1,5 1,95,9,85,8,75,7,65,6,55 pfs_e[in H2O],5,45,4,35,3,25,2 Measurement: LU Measurement: LU Measurement: LU Measurement: LU Air performance measured as per ISO 581 Installation category A. For detailed information on the measuring set-up, please contact ebm-papst. Suction-side noise levels: LwA measured as per ISO / LpA measured with 1m distance to fan axis. The values given are valid under the measuring conditions mentioned above and may vary according to the actual installation situation. With any deviation from the standard set-up, the specific values have to be checked and reviewed with the unit installed qv[m^3/h] ,,1, Measured values U V f Hz n min P ed W I A qv m 3 /h p fs Pa U = Supply voltage f = Frequency n = Speed P ed = Power input I = Current draw qv = Air flow p fs = Pressure increase Item no Revision Release Page 5 / 5 ebm-papst Mulfingen GmbH & Co. KG Bachmühle 2 D Mulfingen Phone +49 () Fax +49 () info1@de.ebmpapst.com