TNC / TNC 18 GHz series R143 / R144

Transcription

1 11 TNC / TNC 18 GHz series R143 / R144

2

3 CONTENT TNC Pages TNC Introduction Interface Characteristics TNC Ω Plugs to 11-9 Jacks to Receptacles to Caps Adapters TNC 75Ω Plugs Jacks TNC 18 GHz Interface Characteristics Plugs Jacks to Receptacles Adapters Panel drilling

4 TNC INTROUCTION Ω 75Ω C - 11 GHz (standard) C - 18 GHz (TNC 18 GHz) C GHz C - 1 GHz (recommended) and 75Ω C GHz (commercial) GENERAL crew-on equivalent to BNC bayonet series Good RF performance uitable for high power levels Long life and high strength 3 ranges: - tandard TNC series ( and 75Ω fully intermateable) - Commercial TNC series ( and 75Ω) - 18 GHz TNC series (Ω) APPLICABLE TANAR MIL-C / MIL T 348A/313 IEC CECC APPLICATION Avionics Aeronautics Countermeasures Telecommunications INTerface TNC PLUG JACK

5 Letter min. mm max. min. inch max. A B E F G INTerface TNC Letter min. mm max. min. inch max. A B C E F H TNC/TNC 18 GHz PLUG JACK INTerface TNC 18 GHz Letter min. mm max. min. inch max. A B C E F G Letter min. mm max. min. inch max. A B C E F G H

6 TNC CHARACTERITIC TNC 11-6 ELECTRICAL CHARACTERITIC Impedance Ω 75Ω Frequency range C - 11 GHz C GHz V..W.R max Insertion loss db max at 9 GHz RF leakage db min from 2 to 3 GHz Insulation resistance MΩ min Contact resistance center contact (mω) outer contact (mω) 3-16 Initial After proof 2 - Working voltage At sea level: 0 V rms at ft (21000 m): 125 V rms ielectric withstanding voltage 3-17 At sea level: 10 V rms at ft (21000 m): 375 V rms RF withstanding voltage 3-23 At sea level: 1000 V rms (5 MHz sine wave) MECHANICAL CHARACTERITIC urability matings Mating / unmating axial force: not applicable torque: 1.96 inch pounds (22.6 N.cm) Recommended mating torque 3.99 to 5.98 inch pounds (46 to 69 N.cm) Proof torque inch pounds (170 N.cm) Coupling mechanism retention force Lbf (44.5 dan) cable clamp: 40.6 Lbf (181 N min) (all cables) Cabling retention force 3-24 crimped: 51 Lbf (227 N min) (cable dia..189 (4.8) to.228 (5.8)) 76.4 Lbf (340 N min) (cable dia..2 (6.35) and above) Center contact retention Axial: 6.06 Lbf (27 N) ENVIRONMENTAL CHARACTERITIC Temperature range standard models hermetic sealed models models for semi-rigid cables -65 C / C -65 C / +100 C -65 C / +105 C Thermal shock 3-20 MIL-T-202, method 107, condition B High temperature endurance MIL-T-202, method 108 Corrosion (salt spray) 3-13 MIL-T-202, method 101, condition B Vibrations 3-18 MIL-T-202, method 204, condition B hocks 3-19 MIL-T-202, method 213, condition G Moisture resistance 3-21 MIL-T-202, method 106 Low pressure 3-22 Not applicable Hermetic seal Applied vacuum 10-6 mm of Hg (Torrs) leakage rate < 10-6 atm/cm 3 /s Leakage Pressure 3.5 bars; duration 2 mn; temperature 15 C to 25 C MATERIAL and plating Body and center pin contact Brass as per QQ-B-626 Nickel plated Center socket contact Beryllium copper as per QQ-C-530 Gold plated Ferrules Brass Insulators PTFE teflon Gaskets ilicone elastomer All dimensions are given in mm ELECTRICAL and ENVIRONMENTAL CHARACTERITIC Impedance Frequency range Ω or 75Ω C GHz Test voltage 10 V rms Operating voltage 0 V rms Insulation resistance 00 MΩ min (0 V) Contact resistance 10 mω max Temperature range -35 C / +70 C PLATING Body Center contacts Test/characteristics MIL-C A Values/remarks CHARACTERITIC commercial TNC Test/characteristics Values/remarks Nickel Gold

7 ELECTRICAL CHARACTERITIC Impedance Frequency range Test/characteristics MIL-C A Values/remarks V..W.R CHARACTERITIC Ω C - 18 GHz emi rigid cable: 1.17 max Flexible cable: 1.35 at 12.4 GHz In series adapter: 1.35 max Insertion loss db max at 9 GHz RF leakage db min from 2 to 3 GHz Insulation resistance MΩ min Contact resistance center contact (mω) outer contact (mω) 3-16 Initial After proof 2 - Working voltage At sea level: 0 V rms at ft (21000 m): 125 V rms ielectric withstanding voltage 3-17 At sea level: 10 V rms at ft (21000 m): 375 V rms RF withstanding voltage 3-23 At sea level: 1000 V rms (5 MHz sine wave) TNC 18 GHz MECHANICAL CHARACTERITIC urability matings Mating / unmating axial force: not applicable torque: 1.96 inch pounds (22.6 N.cm) Recommended mating torque inch pounds (265 N.cm) Proof torque inch pounds (339 N.cm) Coupling mechanism retention force Lbf (44.5 dan) Cabling retention force Lbf (227 N min) (cable dia..189 (4.8) to.228 (5.8)) 76.4 Lbf (340 N min) (cable dia..2 (6.35) and above) Center contact retention Axial: 6.06 Lbf (27 N) ENVIRONMENTAL CHARACTERITIC Temperature range standard models hermetic sealed models -65 C / C -65 C / +100 C -65 C / +105 C models for semi-rigid cables Combined climate tests Thermal shock 3-20 MIL-T-202, method 107, condition B High temperature endurance MIL-T-202, method 108 Corrosion (salt spray) 3-13 MIL-T-202, method 101, condition B Vibrations 3-18 MIL-T-202, method 204, condition B hocks 3-19 MIL-T-202, method 213, condition G Moisture resistance 3-21 MIL-T-202, method 106 Low pressure 3-22 Not applicable Hermetic seal Applied vacuum 10-6 mm of Hg (Torrs) Leakage rate < 10-6 atm/cm 3 /s Leakage Pressure 3.5 bars; duration 2 mn; temperature 15 C to 25 C MATERIAL Body Center socket contact male female Ferrules Insulators Gaskets PLATING Body Center contacts tandard packaging = unit tainless steel Brass Bronze Brass PTFE teflon ilicone elastomer Passivated Gold plated All dimensions are given in mm (inch)

8 TNC Ω PLUG TRAIGHT PLUG CRIMP TYPE FOR FLEXIBLE CABLE Fig. 1 Fig. 2 Fig. 3 imensions mm Cable group Cable group dia. Part number Fig Captive center contact Packaging A B C RG174/RG // R yes 100 pieces RG58/RG141 RG142/RG223/RG400 5// 5// R R yes 100 pieces R no R yes R Unit Note full crimp commercial version, full crimp TRAIGHT PLUG CLAMP TYPE FOR FLEXIBLE and semi rigid CABLE Fig. 1 Fig. 2 Fig. 3 imensions mm Cable group Cable group dia. Part number Fig Captive center contact Packaging A B C RG174/RG316/R316 RG179/R /+75 R yes Unit RG58/RG141/RG142 1 RG223/RG400 5//+ R no 100 pieces RG59/RG62 6/75+93 R R yes RG213/RG393/RG / 2 Unit R RG " R no Note conical braid clamp safety coupling nut 11-8 To download data sheets and assembly instructions, visit & enter the part number in the earch box. ee page 8 and 9 for packaging information.

9 RIGHT ANGLE PLUG CRIMP AN OLER TYPE PLUG and jacks TNC Ω Fig. 1 Fig. 2 Fig. 3 Cable group Cable group dia. Part number Fig Captive center contact Packaging Note RG174/RG // R pieces commercial version RG58/RG141 5// R yes 100 pieces RG142/RG223/RG400 5// R Unit RG R pieces older Type RIGHT ANGLE PLUG CLAMP TYPE FOR FLEXIBLE CABLE Fig. 4 Cable group Cable group dia. Part number Captive center contact Packaging RG58/RG141/RG142/RG223/RG400 5//+ R yes Unit TRAIGHT JACK CRIMP TYPE FOR FLEXIBLE CABLE Fig. 1 Fig. 2 Fig. 3 Cable group Cable group dia. Part number Fig Captive center contact Packaging Note RG174/RG316/R /60 + R Unit RG58/RG141 5// R yes 100 pieces commercial version, full crimp RG142/RG223/RG400 5/ R Unit To download data sheets and assembly instructions, visit & enter the part number in the earch box. ee page 8 and 9 for packaging information. 11-9

10 TNC Ω Jacks TRAIGHT BULKHEA JACK CRIMP TYPE FOR FLEXIBLE CABLE imensions mm Cable group Cable group dia. Part number A B C RG174/RG // R RG58/RG141 5// R Captive center contact yes Panel drilling P09+P11 Packaging Note 100 pieces commercial version, panel sealed commercial version, panel sealed, full crimp TRAIGHT JACK CLAMP TYPE FOR FLEXIBLE CABLE Fig. 1 Fig. 2 Cable group Cable imensions mm group dia. Part number Fig Captive center A B C contact RG174/RG316/R316/RG179/R /+75 R yes 1 RG58/RG141/RG142/RG223/RG400 5//+ R no RG58/RG141 5// R QUARE FLANGE TRAIGHT JACK OLER TYPE FOR EMI-RIGI CABLE Panel drilling Packaging P04 Unit Note quare flange Also for screws type 3-56 UNF 2A Cable group Cable group dia. Part number Captive center contact Panel drilling Packaging RG " R no P01 Unit To download data sheets and assembly instructions, visit & enter the part number in the earch box. ee page 8 and 9 for packaging information.

11 Jacks and receptacles TRAIGHT BULKHEA JACK PANEL EALE REAR MOUNT TNC Ω Cable group Cable imensions (mm) group dia. Part number Captive center contact Panel drilling Packaging A B RG178/RG196 2// R Unit RG174/RG316/R / R yes 100 pieces P09 RG58/RG141 5// R Unit RG " R no 100 pieces QUARE FLANGE TRAIGHT FEMALE RECEPTACLE Fig. 1 Fig. 2 Part number Fig imensions A (mm) Captive center contact Panel drilling Packaging Note R M2.5 x 0.45 Unit 1 yes P05 older pot R pieces 17.5 mm square flange R no P02 lotted contact 19 mm square flange BULKHEA TRAIGHT FEMALE RECEPTACLE Fig. 1 Fig. 2 Fig. 3 Part number Fig Captive center contact Panel drilling Packaging Note R P08 Front mount, solder pot contact R yes P10 Unit Panel sealed, front mount, solder pot contact R P17 Hermetic, panel sealed, rear mount To download data sheets and assembly instructions, visit & enter the part number in the earch box. ee page 8 and 9 for packaging information

12 TNC Ω receptacles RF power switching connectors Part number R R Type left right QUARE FLANGE RIGHT ANGLE FEMALE RECEPTACLE Part number Captive center contact Panel drilling Packaging Note R yes P06 Unit older pot contact QUARE FLANGE TRAIGHT MALE RECEPTACLE Part number Captive center contact Panel drilling Packaging Note R yes P03 Unit older pot contact To download data sheets and assembly instructions, visit & enter the part number in the earch box. ee page 8 and 9 for packaging information.

13 PROTECTIVE CAP caps and adapters TNC Ω Fig. 1 Fig. 2 Part number Fig Finish Packaging Note R Unit Male with chain Nickel R pieces Female with chain IN ERIE AAPTER Fig. 1 Fig. 2 Fig. 3 Fig. 4 Fig. 5 Fig. 6 Fig. 7 Fig. 8 Part number Fig Captive center contact Panel drilling Packaging Note R Male-male R Female-female Unit R quare flange female-female P01 R quare flange slide on type male-female R Bulkhead hermetic, panel sealed female-female yes P pieces R Commercial version, bulkhead female-female R Unit Female-male push-on R Right angle male-female R Unit Female female male R Female female female To download data sheets and assembly instructions, visit & enter the part number in the earch box. ee page 8 and 9 for packaging information. Fig. 9 Fig

14 TNC 18 GHz PLUG AN JACK TRAIGHT PLUG CRIMP TYPE FOR FLEXIBLE CABLE Fig. 1 Fig. 2 Cable group Cable group dia. Part number Fig imensions mm (inch) A B C RG142/RG223/RG400 5// R (1.181) 3.2 (.126) 5.5 (.218) R (1.713) 3 (.118) 5.5 (.218) 3.85// R (1.85) 3 (.118) 4.2 (.165) 4.13/ R (1.71) 2.7 (.106) 4.5 (.177) 8.07// R (1.957) 6.3 (.248) 8.4 (.331) RG214/RG225 11// R (1.38) 7.5 (.295) 11 (.433) TRAIGHT PLUG OLER TYPE FOR EMI-RIGI CABLE Note Incl. heatshrink tube Cable group Cable group dia. Part number imensions mm (inch) A B C RG " R (.039) 3.65 (.144) 5 (.197) RG401.2" R (.067) 6.45 (.254) 8 (.315) RIGHT ANGLE PLUG CRIMP TYPE FOR FLEXIBLE CABLE Cable group Cable group dia. Part number imensions mm (inch) A B C Note 3.85// R (2.13) 3 (.118) 4.2 (.165) 4.13/ R (1.97) 2.7 (.106) 4.5 (.177) Incl. heatshrink tube TRAIGHT JACK OLER TYPE FOR EMI-RIGI CABLE imensions mm (inch) Cable group Cable group dia. Part number A B C RG " R (.039) 3.65 (.143) 5 (.197) To download data sheets and assembly instructions, visit & enter the part number in the earch box. ee page 8 and 9 for packaging information.

15 JACK TRAIGHT QUARE FLANGE JACK CRIMP TYPE FOR FLEXIBLE CABLE TNC 18 GHz Fig. 1 Fig. 2 Cable group Cable group dia. Part number Fig C Panel drilling Note 4.13/ R (.173) RG142/RG223/RG400 5// R P01 Ind. heatshrink tube 5.6(.219) R TRAIGHT QUARE FLANGE JACK OLER TYPE FOR EMI-RIGI CABLE Cable group Cable group dia. Part number imensions mm (inch) A B C RG " R (.157) 0.6 (.024) 2.25 (.089) RG " R (.197) 1 (.039) 3.65 (.144) RG401.2" R (.315) 6.45 (.254) Panel drilling P12 TRAIGHT BULKHEA JACK Panel sealed Fig. 1 Fig. 2 Cable group Cable group dia. Part number Fig imensions mm (inch) B C Panel drilling Type RG " R (.144) 5 (.197) 1 RG401.2" R P09 older 4.13/ R Crimp To download data sheets and assembly instructions, visit & enter the part number in the earch box. ee page 8 and 9 for packaging information

16 TNC 18 GHz receptacles, AAPTER and CAPs QUARE FLANGE TRAIGHT FEMALE RECEPTACLE (extended dielectric) Part number Captive center contact Panel drilling R yes P13 IN ERIE AAPTER Fig. 1 Fig. 2 Fig. 3 Fig. 4 Fig. 5 CAP Part number Fig Captive center contact Panel drilling Note R Male - male R Female - female R yes Male - female R P16 quare flange female - female R P09 Bulkhead panel sealed female - female Part number R Note Male short circuit To download data sheets and assembly instructions, visit & enter the part number in the earch box. ee page 8 and 9 for packaging information.

17 TRAIGHT PLUG CRIMP TYPE FOR FLEXIBLE CABLE plugs and jacks TNC 75Ω Cable group Cable group dia. Part number Captive center contact Note R no Full crimp RG59/RG62 6/ R yes Commercial version - full crimp TRAIGHT BULKHEA JACK CRIMP TYPE FOR FLEXIBLE CABLE Cable group Cable group dia. Part number Captive center contact Panel drilling Packaging Note RG59/RG62 6/ R yes P09 or P pieces Commercial version Panel sealed To download data sheets and assembly instructions, visit & enter the part number in the earch box. ee page 8 and 9 for packaging information

18 TNC panel RILLING PO1 PO2 PO3 PO4 PO5 PO6 PO7 PO8 PO9 P10 P11 P12 P13 P14 P15 P To download data sheets and assembly instructions, visit & enter the part number in the earch box. ee page 8 and 9 for packaging information.

19 AUTOMOTIVE AEROspace Cable designation Cable Group /Ω Imp. Ω Core type Cable dimensions mm (inch) Core Insulator creen RG 174 A/U RG 178 B/U RG 178 B/U RG 178 non m. RG 179 B/U RG 187 A/U RG 188 A/U RG 196 A/U RG 212 /U RG 213 /U RG 214 /U RG 215 RG 216 /U RG 217 /U RG 218 /U RG 223 /U RG 225 /U RG 303 /U RG 316 /U R 316 RG 393 RG / 2 / 2 / 2 / 2.6 / / / 2 / 8 / 10 / 11 / 10 / 11 / / 22 / 5 / 11 / 5 / 2.6 / 2.6 / 10 / 5 / / x x x x x x x x x x x x x x x x x (.019) 0.30 (.012) 0.30 (.012) 0.29 (.011) 0.30 (.012) 0.30 (.012) 0.51 (.020) 0.30 (.012) 1.41 (.056) 2.26 (.089) 2.25 (.089) 2.25 (.089) 1.21 (.048) 2.69 (.106) 4.95 (.195) 0.89 (.035) 2.38 (.094) 0.94 (.037) 0.53 (.021) 0.53 (.021) 2.39 (.094) 0.98 (.039) R 179 BT 3002 BT / / 75 5 / x x (.012) 0.31 (.012) 0.60 (.024) 1.52 (.060) 0.84 (.033) 0.84 (.033) 0.84 (.033) 1.60 (.063) 1.60 (.063) 1.52 (.060) 0.86 (.034) 4.70 (.185) 7.24 (.285) 7.24 (.285) 7.25 (.285) 7.24 (.285) 9.40 (.370) (.680) 2.95 (.116) 7.24 (.285) 2.95 (.116) 1.52 (.060) 1.52 (.060) 7.24 (.285) 2.95 (.116) Outer 2.79 (.110) 1.78 (.070) 1.83 (.072) 1.80 (.071) 2.54 (.010) 2.79 (.110) 2.79 (.110) 2.03 (.080) 8.43 (.331) (.406) (.425) (.405) (.425) (.545) (.870) 5.38 (.212) (.429) 4.32 (.170) 2.49 (.098) 2.80 (.110) 9.91 (.390) 4.95 (.195) EFENE INUTRIAL INTRUMENTATION MEICAL PACE Coaxial, rf & microwave TELECOM imply Your Best Connection Radiall cable if applicable P/N Remark C C C C C C C C na C C na C C C C C na C C C C PVC jacket FEP jacket PVC jacket non magnetic / FEP jacket FEP jacket PTFE jacket PTFE jacket PTFE jacket C C C LOH jacket FEP jacket FEP jacket s.a. 89 outh 52nd treet, uite. Technical information and sales contacts are available at : 401, Tempe, Arizona (.121) 3.55 (.140) 5.1 (.200) PVC jacket PVC jacket PVC jacket PVC jacket glass fiber jacket We offer an extensive range of solutions that supports the most demanding signal transmission applications. 4G wireless infrastructure, active array radars, IE s detection, electrical wiring in aircrafts, soldier tactical radios, in-vehicle communications networks, and magnetic resonance imaging systems are just a few of the complex applications that we support. RF coaxial connectors Multipin rectangular connectors Fiber optic connectors and transceivers Rack and panel connectors Antennas for tactical networks, aerospace Coaxial and fiber optic cable assemblies and harnesses and instrumentation High frequency microwave components Coaxial switches, including the smallest and most reliable PT relay. FEP jacket FEP jacket FEP jacket FEP jacket India - Radiall India Pvt. Ltd. Best Value-added ervices emi rigid cables MIL-C-17 standard.2".2".141".141".141".141".141".085".085".085".085".047".047" 1.63 (.064) 1.63 (.064) 0.92 (.036) 0.92 (.036) 0.92 (.036) 0.92 (.036) 0.92 (.036) 0.51 (.020) 0.51 (.020) 0.51 (.020) 0.51 (.020) 0.29 (.011) 0.29 (.011) Hand-formable Hand-formable Hand-formable Hand-formable.085".141".141".141" 0.51 (.020) 0.92 (.036) 0.92 (.036) 0.92 (.036) 5.31 (.209) 5.31 (.209) 2.98 (.117) 2.98 (.117) 2.98 (.117) 2.98 (.117) 2.98 (.117) 1.68 (.066) 1.68 (.066) 1.68 (.066) 1.68 (.066) 0.94 (.037) 0.94 (.037) (.2) 6.35 (.2) 3.58 (.141) 3.58 (.141) 3.58 (.141) 3.58 (.141) 3.58 (.141) 2.20 (.087) 2.20 (.087) 2.20 (.087) 2.20 (.087) 1.19 (.047) 1.19 (.047) C copper tubing C tinned alu tubing C copper tubing C tinned copper tubing C silvered copper tubing C tinned alu tubing C non magnetic / copper tubing C copper tubing C tinned copper tubing C tinned alu tubing C non magnetic / copper tubing C copper tubing C tinned copper tubing 2.21 (.087) 3. (.138) 4.05 (.159) 4. (.177) C C C C C ollaboration: We work closely with your engineers to understand your business, your technical needs, and your budgetary issues; Wide Product Range: We manage our product lines thru the entire lifecycle in order to offer you a wide selection of standard products at an affordable cost; Custom Products: We can tailor products to specific equipment and application needs; Global Presence: We re everywhere you need us, with worldwide sales, engineering support, R& in North America, Europe, and Asia, and manufacturing facilities strategically located in the United tates, Mexico, France, India, and China; Responsive upport and ervice: From the design stage, planning to post-installation support, we re with you at every step, whether you need sales support or engineering expertise; On-time elivery: We support your logistical needs so you get the products when and where you need them; Warranty: We proudly stand behind our products. 1C004XE January Edition RG 401 /U RG 401 alu RG 402 /U RG 402 tin RG 402 silver RG 402 alu RG 402 non m. RG 405 /U RG 405 tin RG 405 alu RG 405 non m..047".047" tin Hand-formable cable 1.63 (.064) 2.95 (.116) 2.98 (.117) 2.98 (.117) tin soaked braid tin soaked braid FEP jacket LZH jacket Certifications and Environmental Corrugated cables (with helical or ringed/annular copper tube) Flexible Flexible Flexible Flexible Flexible uper flexible uper flexible uper flexible uper flexible 1/4" 1/2" 7/8" 1 1/4" 1 5/8" 1/4" 3/8" 1/2" 7/8" Note: = single braid. = dual braid. tube 2.38 (.094) 4.80 (.189) 9.13 (.359) 12.7 (.0) 17.3 (.681) 1.90 (.075) 2.60 (.102) 3.60 (.142) 9.04 (.356) 6.40 (.252) 11.6 (.457) 22.5 (.866) 32.5 (1.28) 43.5 (1.71) 4.70 (.185) 6.30 (.248) 8.70 (.343) (.930) (.343) (.644) 27.7 (1.091) 39.5 (1.55).5 (1.99) 7.40 (.291) 10.8 (.425) 13.2 (.520) (1.082) na C na na na C C C C Coaxial, rf & microwave ringed/annular tube ringed/annular tube ringed/annular tube ringed/annular tube ringed/annular tube helical tube helical tube helical tube helical tube Full Line Catalog Radiall is IO 9001: 2008 certified and dedicated to continuous improvement programs that have resulted in also being A9100, T16949 and IO certified. In addition, Radiall is committed to investing in its people, future technologies and the environment, such as being RoH (Restriction of Hazardous ubstances) and REACH (Registration, Evaluation, Authorization and Restriction of Chemical substances) compliant. For more information about cables manufactured by Radiall, please consult our online catalog. Radiall is a global leader in the design, development and manufacturing of leading edge interconnect solutions. edicated to understanding its customers needs since 1952, Radiall has earned the reputation of being the best of the best in engineering ingenuity by providing a constant flow of creative system solutions serving the telecommunications, aerospace, defense, instrumentation, automotive, industrial, medical and broadcast markets. The Best End-to-End Interconnect olutions PVC jacket PVC jacket Flexible cable BT approved 1.6 (.063) 1.95 (.077) 2.5 (.098) Company Profile Coaxial, rf & microwave