Richard T Crane Medical Preparatory HS

Transcription

1 Facility Assessment Summary This report summarizes the findings of a facility assessment completed on the date noted in the document footer below. Assessors rate each facility feature and system by visual observation only; they do not test operability or perform destructive testing inside walls, ceilings or floors. The rankings below reflect the assessors visual evaluations of the property condition as of that date. For additional information, you may review the detailed assessment report linked on this school s profile page and visit the Facilities Standards webpage under CPS Policies and Guidelines at Condition ings and Descriptions 7: The item/system is new or in good condition and no work is required. 6: The item/system requires general cleaning and/or routine maintenance. : The item/system requires repairs and has not reached the end of its serviceable life. : The item/system has reached its expected useful life, but is still fully operational. CPS will maintain until replacement occurs. : The item/system has surpassed its expected useful life and has limited operability. CPS will maintain until replacement occurs. : The item/system has surpassed its expected useful life and has low operability. CPS will maintain until replacement occurs. 1: The item s/system s failure leads to an immediate life safety condition for occupants or to the potential of an uninhabitable facility.¹ Definitions means, for each item, the total number (or amount) of that item that exists and was evaluated. Within that, different portions may have different rankings. means the generally accepted standard unit of measure for each item. Some items, like doors, are measured individually and use the unit of measurement EA for each. Other items, like chimneys, are measured in terms of linear feet ( LF ). Still other items, like flooring, are generally measured in square feet ( SF ). means a basic estimate for each item needing some level of repair or replacement. does not include all expenses that would be necessary to complete a repair or replacement project. This is because, depending on the item and on the overall scope of a construction project, repair/replacement projects can include additional costs such as destructive testing, environmental needs, discovered conditions, and additional work triggered by building codes. For the same reason, the Campus Need listed at the end of this report reflects only a portion of what it would actually cost to repair/replace all of the listed features. Campus Need also does not reflect features that do not yet exist at a particular facility, such as: programmatic improvements, school-wide ADA compliance, air conditioning, space reconfiguration, or construction to alleviate overcrowding; these are viewed as separate capital needs. EXTERIOR CHIMNEY Brick Chimney - Concrete/ Mortar Liner LF $50,408 $50,408 CORNICE Cornice - Masonry Projecting/Limestone GRE 7 1,500 1,500 LF Assessment Date: 1/8/2013 Page 1 of 20

2 DOORS Exterior Steel Door Overhead Rolling / Garage Door Side Lite Transom Lite 1 6 GRE GRE GRE 6 6 GRE EA $22,132 7 EA $6,161 6 EA $1, EA $17,555 $47,207 ENTRANCE Concrete Exterior Stairs Concrete Ramp Entrance Controls - Audio and Video Power Door Operator and Controls Ramp Handrails Stone Stairs GRE 7 48 GRE 7 13 GRE 7 3 GRE 7 1 GRE LF 13 LF 3 EA 1 EA 26 LF 677 LF $5,577 $5,577 FOUNDATION Concrete Foundation GRE 7 1,544 1,544 LF LIGHTING Exterior Lights - Wall Mounted LINTELS 1 6 GRE EA $7,508 $7,508 Lintels - Steel Lintels - Stone GRE 7 1,560 GRE 7 1,152 1,560 LF 1,152 LF Assessment Date: 1/8/2013 Page 2 of 20

3 PARAPET Coping - Metal Coping - Stone Parapet < 16" Height Parapet > 30" Height Parapet 16" to 30" Height GRE 7 1,154 GRE 7 2,377 GRE 7 55 GRE 7 1,005 GRE 7 1,340 1,154 LF 2,377 LF 55 LF 1,005 LF 1,340 LF ROOF SYSTEM Exterior Downspouts Interior Downspouts Metal Roof Modified Bitumen Roof Roof Structure: Steel with Clay Tile Arch Roof Structure: Steel/Metal Deck/Concrete Topping GRE ,156 GRE 6 3, ,500 GRE 7 85,900 GRE 7 30, LF 1,306 LF $74,003 3,300 SF $24, ,100 SF $8,258 85,900 SF 30,000 SF $107,177 SUPERSTRUCTURE Metal Deck/Concrete Topping Steel with Clay Tile Arch GRE 7 47,900 GRE ,700 47,900 SF 371,900 SF $7,550 $7,550 WALLS Brick Prefabricated Metal Panel Wall Stone - Cut GRE 7 48,900 GRE 7 4,300 GRE 7 37,700 48,900 SF 4,300 SF 37,700 SF Assessment Date: 1/8/2013 Page 3 of 20

4 WINDOWS Window - Guards perforated Window - Guards wire guard Windows - Casement Aluminum Double-pane Windows - Casement Lexan Windows - Sash Aluminum Double-pane EXTERIOR 1 6 GRE 6 4,044 YEL YEL GRE 6 5,000 20, ,044 SF 150 SF $11, SF $ SF $69,086 25,250 SF $346,418 $427,795 $653,221 ELECTRICAL EMERGENCY SYSTEM Automatic Transfer switch Emergency A/C power - Auditorium and aisle lighting Emergency A/C power - Corridors and Stairs Emergency A/C power - Gym and Lunch rooms Emergency A/C power - Students Toilets Emergency Battery Packs - Corridors and Stairs Emergency generator 150 KW -200 KW natural gas - Outdoor Exit Signs - Auditorium Exit Signs - Corridors and Stairs Exit Signs - Lunchroom - Gym - multipurpose rooms Independent Electrical Service for emergency power Public Announcement System Security System - Intrusion detection GRE 7 3 GRE 6 6,385 GRE 6 56,883 GRE 6 39,422 6,650 GRE 6 4 GRE 7 1 GRE 6 6 GRE BLU 5 419,600 GRE 6 419,600 3 EA 6,385 SF $8,674 56,883 SF $24,403 39,422 SF $20,858 16,650 SF $7,143 4 EA $429 1 EA 6 EA $1, EA $16, EA $3,496 1 EA $1, ,600 SF $600, ,600 SF $390,018 $1,073,955 MAIN SERVICE Main Electrical service - Live Front to 3000 A 120/208/3PH YEL EA $514,800 Assessment Date: 1/8/2013 Page 4 of 20

5 Main Electrical service - Live Front - above 3000 A 120/208/3PH YEL EA $308,880 $823,680 POWER DISTRIBUTION Lighting and power panels Main distribution panels amp Main distribution panels less than 400 amp ELECTRICAL GRE EA $51,480 3 EA $4,290 1 EA $1,216 $56,986 $1,954,621 FIRE PROTECTION FIRE ALARM Fire Alarm Strobe Lights Fire Alarm System FIRE PROTECTION MECHANICAL AIR CONDITIONING Chillers - Water Cooled - Absorber greater than 300 tons Cooling Tower - Spray Type - greater than 300 tons Window A/C AIR HANDLING SYSTEMS 1 6 GRE 6 419,600 GRE 6 371, YEL 4 1 BLU ,600 SF $150, ,700 SF $451,801 $601,808 $601,808 2 EA $167,310 1 EA $55,770 7 EA $9,224 $232, Air Handling Package - Single Zone - Steam 4,000 to 8,000 cfm BLU EA $47,190 Air Handling Package - Single Zone - Steam 12,001 to 20,000 cfm BLU EA $121,550 Assessment Date: 1/8/2013 Page 5 of 20

6 Air Handling Package - Single Zone - Steam 8,001 to 12,000 cfm Air Handling Package - Single Zone - Steam less than 4,000 cfm Air Intake - Built Up Air Handling Air intake for all Air Handling s except built up AHU Fan Coil - Hot Water-Heating Multi Zone Built Up Air Handling - Steam 25,001 to 35,000 cfm Multi Zone Built Up Air Handling Auxiliaries - Steam 25,001 to 35,000 cfm Reheat Boxes With Hot Water Coils Reheat Boxes With Steam Coils Return Duct Work - Masonry and Ducts - Existing or Missing Exterior Shaft Return Fans - Indoor 10,001 to 20,000 CFM Return Fans - Indoor 5,000 to 10,000 CFM Return Fans - Indoor less than 5,000 CFM Return Fans - Outdoor greater than 20,000 CFM Single Zone Built Up Air Handling - Steam 25,001 to 35,000 cfm Single Zone Built Up Air Handling Auxiliaries- Steam 25,001 to 35,000 cfm BLU 5 1 BLU 5 1 GRE GRE 6 5 BLU 5 4 YEL 4 4 YEL 4 73 YEL 4 79 GRE GRE BLU 5 1 GRE 6 4 BLU 5 1 YEL EA $21,450 1 EA $10,010 3 EA $4, EA $14,300 5 EA $6,721 4 EA $171,600 4 EA $160, EA $720, EA $824, LF $18,876 6 EA $43,758 3 EA $9,152 1 EA $2,860 4 EA $17,160 1 EA $42,900 1 EA $24,310 $2,261,259 BOILER SYSTEMS Boiler Assembly - Steam - Low Pressure Scotch Marine Boiler greater than 200 HP Boiler Auxiliary - Steam Boiler greater than 200 HP Chemical Feed System (Steam Boilers) Chemical Pot Feeder - Hot Water Combustion Dampers Feed Water Pumps and Tank - Steam Boilers HEAT EXCHANGERS 1 6 GRE 6 3 BLU 5 3 GRE 6 4 GRE 6 3 GRE EA $89,661 3 EA $49,335 1 EA $2,145 4 EA $1,201 3 EA $858 2 EA $16,874 $160, Heat Exchanger - Steam to Hot Water Shell Type YEL EA $63,492 $63,492 Assessment Date: 1/8/2013 Page 6 of 20

7 HEATING DEVICES Cabinet Heaters With Steam Coils Fin Tube Hot Water Radiators - Steam Heater - Electric Heater - Hot Water 1 6 YEL YEL BLU 5 14 BLU EA $31, LF $18, EA $9,209 1 EA $1, EA $72,930 $133,147 MECHANICAL PLUMBING Condensate Assembly - Pumps and Tank Piping - Condensate - Steel or Galvanized Piping - Hydronic Supply and Return - Steel or Galvanized Piping - Steam - Steel or Galvanized Pumps - Chilled Water HP Pumps - Condenser Water HP Pumps - Hot Water 11 to 20 HP Pumps - Hot Water 5 to 10 HP TEMPERATURE CONTROL Direct Digital Control (DDC) System Thermostats - Direct Digital Control (DDC) VENTILATION Exhaust Fan - Indoor Exhaust Fans - Roof Mounted 1,501 to 8,000 cfm Exhaust Fans - Roof Mounted 500 to 1,500 cfm 1 6 GRE BLU 5 2,800 BLU 5 5, BLU 5 2, GRE 6 2 YEL 4 2 YEL BLU 5 419, BLU GRE 6 4 GRE EA $21,736 2,800 LF $91,091 5,500 LF $251,823 2,800 LF $126,355 2 EA $21,808 2 EA $11,440 2 EA $53,625 1 EA $17,160 $595, ,600 SF $2,100, EA $23,452 $2,123,550 3 EA $11,655 4 EA $1,716 5 EA $1,144 Assessment Date: 1/8/2013 Page 7 of 20

8 Exhaust Fans - Roof Mounted above 8,000 cfm Exhaust Fans - Roof mounted less than 500 CFM Lab Exhaust Hood Type I Exhaust Hood - Kitchen or Culinary Arts Type II Exhaust Hood - Warming Kitchen MECHANICAL GRE 6 9 GRE 6 2 BLU GRE EA $19,305 2 EA $315 3 EA $69,069 1 EA $1,716 2 EA $1,859 $106,778 $5,675,641 PLUMBING HOT WATER Hot Water Heater - Gas more than 300,000 BTU/HR Hot Water Heater - Steam Heat Exchanger PIPING Domestic Piping - Cold Water from Risers to Fixtures Domestic Piping - Cold Water Risers Domestic Piping - Hot Water from Riser to fixtures Domestic Piping - Hot Water Return Risers Domestic Piping - Hot Water Risers Domestic Piping Cold Water Horizontal lines Domestic Piping Hot Water Horizontal lines Domestic Piping Hot Water Return Lines Sanitary Piping Storm Piping Vent Piping EA $6,721 1 EA $2,288 $9, ,600 SF $69, ,600 SF $129, ,600 SF $432, ,600 SF $87, ,600 SF $103, ,600 SF $340, ,600 SF $206, ,600 SF $209, ,600 SF $247, ,600 SF $185, ,600 SF $140,417 $2,152,400 Assessment Date: 1/8/2013 Page 8 of 20

9 POOL SYSTEMS Pool Drain Piping Pool Filtration System Pool Hot Water Heater - Steam Heat Exchanger Pool Supply and Return Piping 1 6 GRE 6 50 BLU 5 1 YEL LF $858 1 EA $122,980 1 EA $13, LF $1,573 $138,424 PUMPS Domestic Booster Pump duplex Domestic Booster Pump simplex Ejector Pump Sump Pump PLUMBING INTERIOR ADMINISTRATIVE SUITES 1 6 YEL EA $3,146 1 EA $17,160 1 EA $3,003 1 EA $1,359 $24,668 $2,324,501 Ceiling - Exposed Ceiling - Lay-In Ceiling - Plaster/Drywall Flooring - Carpet Flooring - Concrete Flooring - Tile/Sheet Lighting - Lay-In Lighting - Pendant/Surface Lighting - Wall Mounted Walls - Concrete Block Walls - Plaster/Drywall 1 6 GRE GRE ,206 8,557 10,243 GRE ,904 GRE ,858 3, GRE 6 20 GRE ,068 5,401 8, GRE GRE 6 8 GRE ,863 GRE 6 3,533 23,908 18, SF $455 20,614 SF $30,922 2,402 SF $1,410 7,486 SF $19, SF $94 15,751 SF $18, SF $ SF $24 8 EA $229 2,584 SF $2,062 45,445 SF $73,083 Assessment Date: 1/8/2013 Page 9 of 20

10 $146,843 AUDITORIUM - DEDICATED Main Floor Seating Sound System Stage Curtains Stage Lighting System CHORAL ROOM 1 BLU BLU GRE EA $81,624 1 EA $92,950 2 EA $22,651 1 EA $114,400 $311,625 Risers GRE LF $807 $807 CLINIC Health Clinic GRE 7 1,464 1,464 SF CORRIDOR Stair Handrails Stairs - Asphalt DOORS 1 6 GRE 6 63 BLU LF 48 LF $2,402 $2,402 Interior Steel Doors incl hw Interior Wood Doors incl hw Store Front Door GRE EA $15, EA $150, EA $10,146 $176,443 Assessment Date: 1/8/2013 Page 10 of 20

11 GYMNASIUM / AUDITORIUM Bleacher Seating Ceiling - Plaster/Drywall Ceiling - Splined Flooring - Wood Lighting - Metal Halide/Sodium Vapor Lighting - Pendant/Surface Scoreboards Walls - Concrete Block Walls - Plaster/Drywall Walls - Structural Glazed Tile 1 6 BLU GRE 6 4,622 0,032 11,737 7,981 11,737 9, GRE ,496 GRE 6 8,432 GRE 6 3,880 1,064 EA $54,462 4,622 SF $39,525 21,769 SF $228,165 23,610 SF $120, EA $21, EA 3 EA $2,076 12,496 SF $107,216 8,432 SF $72,347 3,880 SF $27,742 $673,386 KITCHEN Ceiling - Splined Flooring - Concrete Lighting - Pendant/Surface Wall - Plaster/Drywall Wall - Structural Glazed Tile 1 6 GRE 6 2,268 GRE GRE 7 36 GRE 6 2,129 GRE 7 1,330 2,268 SF $6, SF $3, SF 2,129 SF $5,023 1,330 SF $14,738 LIBRARY Casework Flooring Carpet Lighting - Lay-In GRE BLU 5 3,985 GRE LF 3,985 SF $14, SF $44 $14,291 Assessment Date: 1/8/2013 Page 11 of 20

12 LOCKER/SHOWER ROOM Benches Lockers Showers BLU 5 1, GRE LF $6,976 1,346 EA $198, EA $38,653 $243,693 LUNCHROOM Ceiling - Lay-In Flooring - Tile/Sheet Lighting - Lay-In Serving Line Wall - Plaster/Drywall GRE ,553 GRE , GRE GRE ,980 12,823 SF $579 12,793 SF $ SF $ LF $95,753 8,132 SF $3,844 $100,685 MDF/IDF Finishes Ventilation and Cooling 1 6 GRE GRE SF $1,031 1 EA $1,031 MECHANICAL/SERVICE ROOMS Mechanical/Service Rooms Storage Room 1 6 BLU 5 6,185 4,792 7 GRE 6 4,371 3,190 10,977 SF $92,662 7,561 SF $20,627 $113,289 STAFF RESTROOM Accessories Ceiling - Lay-In GRE 6 2,396 6,055 1,099 GRE ,550 SF $107, SF Assessment Date: 1/8/2013 Page 12 of 20

13 Ceiling - Plaster/Drywall Floor Drain Flooring - Tile Ceramic/Porcelain Flooring - Tile/Sheet Hand Dryer Lavatory Lighting - Lay-In Lighting - Pendant/ Surface Partitions Urinals Wall - Concrete Block Wall - Plaster/Drywall Wall - Structural Glazed Tile Wall - Tile Ceramic/ Porcelain Water Closet GRE 6 4,926 7,205 4,773 GRE GRE 6 8,183 3,002 GRE 6 6,108 GRE GRE GRE GRE 6 8,092 3,315 GRE , GRE 7 11,448 GRE 7 1, ,904 SF $48, EA $19,520 11,185 SF $20,829 6,108 SF $8, EA $5, EA $26, SF $ SF $ EA $27, EA $22,680 11,407 SF $23,143 4,277 SF $10,887 11,448 SF 1,488 SF 110 EA $56,514 $378,242 SWIMMING POOL Accessories Bleacher Seating/Plank seating Floor Tile Lighting - Pendant/ Surface Paint Pool Basin Pool Deck Pool deck drains Splined Ceiling including access Structural Glazed Tile Wall Tile 1 6 GRE 6 3,885 17,165 GRE GRE 7 150,440,181 GRE 6 5 GRE 6 3,885 GRE GRE 6 3,144 3,885 SF $30, EA $1,656 1,165 SF $3, SF $ SF 1,440 SF $40,772 1,181 SF $7,802 5 EA $1,859 3,885 SF $41, SF 3,144 SF $9,486 $137,236 Assessment Date: 1/8/2013 Page 13 of 20

14 THEATER Ceiling - Plaster/Drywall Flooring - Carpet Flooring - Concrete Lighting - Lay-In Lighting - Pendant/ Surface Stage Wall - Plaster/Drywall GRE 7 7,122 YEL 4 2,720 BLU 5 3,312 GRE BLU 5 1,100 GRE 7 5,038 7,122 SF 2,720 SF $28,238 3,312 SF $15, SF 12 SF $20 1,100 SF $30,831 5,038 SF $74,718 VERTICAL CONVEYANCE Elevator - Roped Holeless Hydraulic Stage Lift EA $56,628 2 EA $3,737 $60,365 VOCATIONAL SHOP Work Sink INTERIOR GRE EA $98,456 $98,456 $2,548,252 ROOM ADMIN_WALL Administrative Office Walls GRE 7 1,429 1,429 SF Assessment Date: 1/8/2013 Page 14 of 20

15 CASEWORK Casework GRE LF $37,109 $37,109 CEILING Exposed Ceiling Lay-In/Drop Plaster/Drywall GRE 6 2,183 1,714 5,052 GRE 6 23,029 40,425 GRE 7 3,848 8,949 SF $7,356 63,454 SF $49,397 3,848 SF $56,753 CHALK BOARD Chalk Board YEL LF $25,161 $25,161 CLASSROOM Eye Wash Station Science Lab Elements Science Lab Shower BLU GRE EA $29,315 3 SF $69 7 EA $46,475 $75,859 CORRIDORS Carpet Ceiling Concrete Block Concrete Epoxy/Painted Drop/Lay-In Floors 1 BLU GRE GRE 7 13,338 GRE 6 374, ,831 29,527 GRE 7 7, SF $ SF $2,039 13,338 SF 374 SF $1,765 59,713 SF $73,498 7,310 SF Assessment Date: 1/8/2013 Page 15 of 20

16 Lay-In Pendant/Surface Plaster/Drywall Single Water Cooler Stair Handrails Stairs Student Lockers Terrazzo Tile Ceramic/Porcelain Tile/Sheet Flooring Walls 5,546 41,969,445 6,824 GRE 6 2,294 72,785 22, GRE ,812 GRE , ,294 16,180 GRE 6 57 GRE 6 4,754 20,609 GRE 7 1,010 57,515 EA $11,115 8,269 EA $1,033 97,149 SF $182, EA $43,043 2,751 LF 896 EA $1,344 1,846 EA $164,307 33,474 SF $97, SF $145 25,363 SF $6,798 1,010 SF $585,897 CORRIDORS CEILING Plaster/Drywall GRE ,399 7,965 SF $1,603 $1,603 FLOOR Carpet Concrete Floor Tile/Sheet 1 YEL GRE 6 7,079 7 GRE 7 1,057 GRE ,735 56,132 1,352 SF $10,578 7,079 SF $33,406 1,057 SF 66,763 SF $18,995 $62,979 GYM_FLOOR Gymnasia Floor , ,560 SF $27,950 $27,950 Assessment Date: 1/8/2013 Page 16 of 20

17 KITCHEN_FLOOR Kitchen Floor 1 6, ,584 SF $5,459 $5,459 LIBRARY_CEILING Drop/Lay-In LIBRARY_WALL 1 6 GRE 6 3, ,985 SF $8,548 $8,548 Plaster/Drywall GRE 6 2,944 2,944 $6,946 LIGHTING $6,946 Lay-In Pendant/Surface ,167 EA $31, EA $13,156 $45,045 MARKER BOARD Marker Board ,170 1,182 LF $1,459 $1,459 RESTROOM_LIGHT Restroom Lighting GRE EA Assessment Date: 1/8/2013 Page 17 of 20

18 RESTROOM_WALL Restroom Walls 1 6 7,845 1,304 3,149 SF $4,696 $4,696 STAIRS Terrazzo Tile THEATER_WALL 1 6 GRE 6 32 BLU SF $362 3 SF $57 $ Auditorium Walls BLU SF $5,221 $5,221 WALL Concrete Block Metal/Folding Panel Plaster/Drywall Wall ROOM GRE 6 9,075 8,361 GRE GRE ,067 68,551 BLU 5 4,441 17,436 SF $25, SF $1,062 90,338 SF $53,105 4,441 SF $20,957 $101,079 $1,052,181 SITE ATHLETIC Football/Soccer - Natural Running Track Asphalt ,000 BLU 5 33, ,100 SF $29,387 33,360 SF $110,198 $139,585 Assessment Date: 1/8/2013 Page 18 of 20

19 CIVIL/DRAINAGE Catch Basin Site Manhole GRE EA $1, EA $1,216 FENCING Chain Link Ornamental Iron 1 6 7, GRE ,594 LF $22, LF $14,508 $36,510 LANDSCAPE Asphalt Play Area/Hardscape Benches Grass Hardscape - Concrete Irrigation Parkway trees Walking Path - Crushed Stone 1 BLU 5 2,910 6 GRE GRE 7 31, ,737 GRE 6 51, GRE ,910 SF $8,239 6 EA $1,416 31,962 SF 9,882 SF $2,737 51,000 SF $29, EA $2, SF $44,018 PARKING LOT Asphalt Concrete Curbs Parking lot interior plantings Trash Compactor Trash Enclosure 1 6 GRE 6 30,335 7 GRE ,039 GRE 7 8 GRE 7 1 GRE ,335 SF $26,027 1,114 LF $3,681 8 LF 1 EA 216 SF $29,708 Assessment Date: 1/8/2013 Page 19 of 20

20 SIDEWALKS Perimeter Sidewalks 1 6 7,092 21,730 22,822 SF $20,613 $20,613 SIGNAGE Flag Pole Marquee - Free Standing Back Lighted SITE Campus Need ² ³ GRE 7 1 GRE EA 1 EA $271,649 $15,081,874 ¹ It is very rare for an assessor to find a feature in this condition. If they do, they are required to report it immediately to CPS, and CPS addresses it immediately. Thus, no features will be ranked 1 in summary reports; by the time the report is compiled, they have been resolved. ² As stated above, Assessed Campus Need does not include the addition of features not already in a particular facility, such as programmatic improvements, school-wide ADA compliance, air conditioning, space reconfiguration or construction to alleviate overcrowding; these items are treated as separate capital needs. The Assessed Campus Need includes current deficiencies and is based on current unit cost estimates; it does not reflect a complete project cost. ³ The overall condition of different items can change after an assessment date due to many variables, including newly occurring deficiencies, renovation or repairs and cost changes. These dollar figures in this report are estimates only and are based solely on the data that was collected as of the assessment date in the footer below. Assessment Date: 1/8/2013 Page 20 of 20