TS mA/180kHz Dc to Dc Converter Controller

Transcription

1 SOP-8 MSOP-8 Pin Definition: 1. SC 5. Comp 2. SE 6. Vcc Ipk 4. Gnd 8. Vdriver General Description The TS3063 is a monolithic switching regulator and subsystem intended for use as DC to DC converter. It contains an internal temperature compensated reference, comparator, controlled duty cycle oscillator with an active peak current limit circuit, drive and a high current output switch. The TS3063 is specifically designed to be incorporated in step-up, step-down and voltage inverting converter applications. The TS3063 is offered in SOP-8 and MSOP-8 package Features Power forward control circuit Operating voltage from 3V to 40V ow standby current Current limit adjustable Output switch current up to 800mA Variable oscillator frequency up to 180kHz (max.) Output voltage adjustable Applications Charger xd-rom, xds products DC to DC converter Schematic Diagram Pin Description Name SC SE GND COMP. V CC I PK V DRIVER Ordering Information Description Switch Collector Switch Emitter Timing Capacitor Ground Comparator Inverting Input V CC Collector IPK Sense Driver Part No. Package Packing TS3063CS R SOP-8 2.5Kpcs / 13 Reel TS3063CB R MSOP-8 2.5Kpcs / 13 Reel 1/9 Version: A07

2 Absolute Maximum Rating Parameter Symbol Maximum Unit Supply Voltage V CC 40 V Comparator Input Voltage Range V FB ~ 40 V Switch Collector Output Voltage V C(SW) 40 V Switch Emitter Voltage V E(SW) 40 V Switch Collector to Emitter Voltage V CE(SW) 40 V Driver Collector Voltage V C(DRIVER) 40 V Driver Collector Current (note 1) I C(DRIVER) 100 ma Output Switching Current I SW 800 ma Power Dissipation SOP MSOP-8 Junction Temperature Range T J +150 Storage Temperature Range T STG -65 ~ +150 Note: Maximum package power dissipation limits must be observed Electrical Characteristics (V CC =5V, Ta =25 o C; unless otherwise noted.) Parameter Symbol Test Conditions Min Typ Max Unit Oscillator (OSC) Frequency F OSC C T = 100pF, Vpin5= 0V KHz Charge Current I CHARGE V CC = 5V ~ 40V ua Discharge Current I DISCHARGE V CC = 5V ~ 40V ua Discharge to Charge current ratio I DISCHARGE / I CHARGE Pin7 to V CC Current imit Sense Voltage V IPK(SENSE) I DISCHARGE = I CHARGE mv Output switch (note1) Saturation Voltage Saturation Voltage V CE(SAT) V CE(SAT) I SW = 0.8A, pin1, 8 connected P D I SW = 0.8A, Rpin8= 82ohm to Vcc, force beta = W o C o C V V DC current gain H FE I SW = 0.8A, V CE = 5V Collector off-state current I C(OFF) V CE = 40V ua Comparator Threshold Voltage V REF V ine regulation REG INE V CC = 3V ~ 40V mv Total device Supply Current I CC V CC = 5V ~ 40V, C T = 1nF, pin7= V CC, pin5> V TH, pin2=gnd, remaining pins open ma 2/9 Version: A07

3 Notes1: ow duty cycle pulse techniques are used during test to maintain junction temperature as close to ambient temperature as possible Note 2: If the output switch is driven into hard saturation (non-darlington configuration) at low switch currents ( 300mA) and high driver currents (>=30mA), it may take up to 2uS for it to come out of saturation. This condition will shorten the off time at frequencies >= 30KHz, and is magnified at high temperature. This condition does not occur with a Darlington configuration, since the output switch cannot saturate. If a non- Darlington configuration is used, the following output drive condition is recommended: Forced Bata of output switch: Ic output / (Ic driver 7mA*) >= 10 * The 100ohm resistor in the emitter of the driver divide requires about 7mA before the output switch conducts. Electrical Characteristics Curve Figure 1. Output Switch On-Off Time vs. Oscillator Timing Capacitor Figure 2. Current imit Sense Voltage vs. Temperature Figure 3. Standby Supply Current vs. Supply Voltage 3/9 Version: A07

4 Typical Application Circuit Step-Down Converter Quick Design Component Selection Table for 5V output version (uh) Cout (uf) (pf) Vin Iin (ma) Pin Vout Iout (A) Pout Frequency (KHz) η (%) 4/9 Version: A07

5 Typical Application Circuit (Continue) Step-Up Converter Quick Design Component Selection Table for 5V output version (uh) Cout (uf) (pf) Vin Iin (ma) Pin Vout Iout (A) Pout Frequency (KHz) η (%) 5/9 Version: A07

6 Typical Application Circuit (Continue) Voltage Inverting Converter Quick Design Component Selection Table for -5V & -12V Version -5V Version: R1=1KΩ, R2=3KΩ (uh) Cout (uf) (pf) Vin Iin (ma) Pin Vout Iout (A) Pout Frequency (KHz) η (%) -12V Version: R1=953Ω, R2=8.2KΩ (uh) Cout (uf) (pf) Vin Iin (ma) Pin Vout Iout (A) Pout Frequency (KHz) η (%) 6/9 Version: A07

7 SOP-8 Mechanical Drawing SOP-8 DIMENSION DIM MIIMETERS INCHES MIN MAX MIN MAX. A B C D F G 1.27BSC 0.05BSC K M 0º 7º 0º 7º P R Marking Diagram Y M = Year Code = Month Code (A=Jan, B=Feb, C=Mar, D=Apl, E=May, F=Jun, G=Jul, H=Aug, I=Sep, J=Oct, K=Nov, =Dec) = ot Code 7/9 Version: A07

8 MSOP-8 Mechanical Drawing MSOP-8 DIMENSION DIM MIIMETERS INCHES MIN MAX MIN MAX. A A A b C D E E e 0.65 (Typ.) (Typ.) Marking Diagram Y M = Year Code = Month Code (A=Jan, B=Feb, C=Mar, D=Apl, E=May, F=Jun, G=Jul, H=Aug, I=Sep, J=Oct, K=Nov, =Dec) = ot Code 8/9 Version: A07

9 Notice Specifications of the products displayed herein are subject to change without notice. TSC or anyone on its behalf, assumes no responsibility or liability for any errors or inaccuracies. Information contained herein is intended to provide a product description only. No license, express or implied, to any intellectual property rights is granted by this document. Except as provided in TSC s terms and conditions of sale for such products, TSC assumes no liability whatsoever, and disclaims any express or implied warranty, relating to sale and/or use of TSC products including liability or warranties relating to fitness for a particular purpose, merchantability, or infringement of any patent, copyright, or other intellectual property right. The products shown herein are not designed for use in medical, life-saving, or life-sustaining applications. Customers using or selling these products for use in such applications do so at their own risk and agree to fully indemnify TSC for any damages resulting from such improper use or sale. 9/9 Version: A07