Product Selector Guide Low Power Adapter/Charger Products

Transcription

1 Product elector Guide Low Power Adapter/Charger Products November 207

2 Product elector Guide R Innowitch -CP Innowitch-CE Low Pwr Adpt/Chrg Chart 57 Linkwitch -HP Linkwitch-4 PR Linkwitch- Linkwitch-CV W W 5 W 7 W 8 W 9 W 0 W 4 W 6 W 8 W 20 W 65 W Package esign/pin Layout Improves Reliability Wide package RAIN OURCE creepage reduces probability of arcing Important for high pollution degree environments and forced air cooling Optimal pin arrangement allows compliance with safety agency adjacent pin short-circuit test Packages below are RoH compliant Package O-8 P Package PIP-8 E Package eip-7c eip-7g K Package eop-6b K Package eop -2 V Package eip-2 C Package InOP-24 PI PI PI PI PI PI-49a PI O-8C PIP-8C PI PI

3 IC Product Tables Linkwitch-CV Adapters up to 0.5 W Product 2 Continuous Output Power (W) Continuous Output Power (W) Adapter Adapter 20 ± 5% LNK62P/ LNK624P/ LNK625P/ LNK626P/ Additional Features: 7 internal MOFET rating elf-powered ON/OFF control Hysteretic over-temperature protection Power limiting Frequency jitter reduces EMI Ecomart low standby/no-load power consumption Notes:. Minimum continuous power in a typical non-ventilated enclosed adapter measured at +50 C ambient. 2. Packages: P: IP-8C, : O-8C. Linkwitch- Charger/Adapters up to 0 W,2,,4 Product (O-8C) Package Adapter (W) LNK6404 / LNK LNK6405 / LNK645 / LNK6425 LNK6406 / LNK646 / LNK6426 / LNK646 / LNK6446 LNK6407 / LNK647 / LNK Additional Features: Compensates for transformer inductance tolerances Compensates for input line voltage variations Compensates for cable voltage drop Compensates for external component temperature variations Very accurate IC parameter tolerances using proprietary trimming technology Frequency jittering greatly reduces EMI filter cost Even tolerances achievable with external resistor selection/ trimming Programmable switching frequency up to 85 khz to reduce transformer size Minimum operation frequency fixed to improve transient load response Product 5 LNK6407K / LNK647K / LNK6427K LNK6408K / LNK648K / LNK6428K / LNK6448K LNK6408E / LNK648E / LNK6428E / LNK6448E E (eip-7c) and K (eop-2b) Packages Adapter (W) Notes:. Assumes minimum input C voltage >90 VC, K P (Recommend K P.5 for accurate CC regulation), η >78%, MAX <55%. 2. Output power capability is reduced if a lower input voltage is used.. Minimum continuous power with adequate heat sink measured at 50 C ambient with device junction below 0 C. 4. Assumes bias winding is used to supply BYPA pin. 5. Package: : O-8C, E: eip-7c, K: eop-2b.

4 IC Product Tables Linkwitch-4 Charger/Adapter BJT rivers up to 5 W Product 2, Adapter (W) LNK40x2 6.5 LNK40x 8 LNK40x 0 LNK40x4 5 Notes:. Minimum continuous power in a typical non-ventilated enclosed adapter measured at +50 C ambient, device T J 00 C. 2. Cable compensation factor. x = 0 (no cable compensation), x = (% cable compensation) x = 2 (6% cable compensation). Package: : O-8, : OT-2-6. Additional Features: ynamic base drive technology provides flexibility in choice of BJT transistor by dynamically optimizing BJT switching characteristics Extends RBOA of BJT ramatically reduces sensitivity to BJTgain Compensates for transformer inductance tolerances Compensates for input line voltage variations Compensates for cable voltage drop Compensates for external component temperature variations Very accurate IC parameter tolerances using proprietary trimming technology Frequency up to 65 khz to reduce transformer size The minimum peak current is fixed to improve transient load response Linkwitch-HP Adapters up to 25 W Product 2 Heat ink Adapter (W) LNK6xxK/V PCB-W 9 LNK6xx4K/V PCB-W LNK6xx5K/V PCB-W LNK6xx6K/V PCB-W 5 LNK6xx7K/V PCB-W 9 LNK6xx8K/V PCB-W 2 LNK6xx9K/V PCB-W 25 Additional Features: Ecomart energy efficient Multi-mode control maximizes efficiency No-load consumption below 0 mw at 20 (LNK67xx) >75% efficiency with W input at 20 >50% efficiency with 0. W input at 20 High design flexibility for low system cost ramatically simplifies power supply designs Eliminates optocoupler and all secondary control circuitry ±5% or better output voltage tolerance 2 khz operation reduces transformer and power supply size Accurate programmable current limit Compensation over line limits overload power Frequency jittering reduces EMI filter cost Notes:. PCB heat sink with wave soldering. 2. Packages: E: eip-7c, K: eop-2b, V: eip-2b. 4

5 IC Product Tables Innowitch-CE Best in Class Efficiency, No-Load, Fast Transient, Chargers up to 65 W 20 ± 5% Product Adapter Open Open Adapter (W) Frame 2 (W) Frame 2 INN62C INN6C INN64C INN65C INN66C INN67C INN68C Notes:. Minimum continuous power in a typical non-ventilated enclosed typical size adapter measured at 40 C ambient. Max output power is dependent on the design. With condition that package temperature must be < = 25 C. 2. Minimum peak power capability.. Package: InOP-24. Additional Features: Up to 94% efficiency across full load range Incorporates a multi-mode Quasi-Resonant (QR) / CCM flyback controller, 6 MOFET, secondary-side sensing and synchronous rectification driver Integrated FluxLink, HIPOT-isolated, feedback link Exceptional CV/CC accuracy, independent of transformer design or external components Adjustable accurate output current sense using external output sense resistor Innowitch-CP Constant Power Profile for UB P / QC Applications up to 65 W 20 ±5% Product 2, Adapter Open Adapter Open (W) Frame 2 (W) (W) Frame 2 (W) INN264C/274C INN265C/275C INN266C/276C INN277C INN267C INN268C Additional Features: Up to 94% efficiency across full load range Incorporates a Quasi-Resonant (QR) / CCM flyback controller, 6 MOFET (INN26x) or 7 MOFET (INN27x), secondary-side sensing and synchronous rectification driver Integrated FluxLink, HIPOT-isolated, feedback link upports fast charge protocols such as UB P/QC 4.0 Constant Power (CP) Profile minimizes charging time with continuous adjustment of output current and voltage Exceptional CV/CC/CP accuracy, independent of transformer design or external components External I resistor allows custom CC programming Instantaneous transient response with 0%-00%-0% load step Notes:. Lowest maximum continuous power in a typical non-ventilated enclosed adapter measured at 40 C ambient. (package temperature < 25 C). 2. Minimum peak power capability.. Package: InOP-24. 5

6 esign Examples Linkwitch-CV Constant Voltage Adapter (RR-20) 6 W, 5 V,.2 A OUTPUT, INPUT, FLYBACK POWER UPPLY RF 2 W µf kω 6.8 µf 0 Ω 5 F07 Linkwitch-CV LNK625PG kv BP EE NC 5 8 Ω 7 N Ω 28.7 kω 50V 6 N448 50V. µh 000 µf 6 V 470 µf 0V 8.2 kω 5 V,.2 A 820 Ω mh 4.42 kω PI Linkwitch- Constant Voltage, Constant Current OE v6 Compliant UB Charger 5 W, 5 V, A OUTPUT, INPUT, FLYBACK UB POWER UPPLY 2.2 nf C9 2.2 nf mh V, A L RF W B MB0M N 4.7 µf 90 kω 4.7 µf 0 Ω ML BP 2 5 Linkwitch- LNK6426 EE 7 5PH 0 kω. Ω 2 L 2 kω 470 µf 6. V 560 µf 6. V 2.2 kω 0 µh 6 V pf 00 V 8.2 kω 6 V PI

7 esign Examples Linkwitch- Constant Voltage, Constant Current UB Charger 0 W, 5 V, 2 A OUTPUT, INPUT, FLYBACK UB POWER UPPLY B B0-G 000 V kω mh 200 kω 470 pf 2 50 Ω EP7 5 F 6 F 4 B045P5-680 µf 0 V Ferrite Bead ( mm) 680 µf 0 V 2.55 kω 5 V, 2 A J- J-4 L TP F R A t O N TP2 L Ferrite Bead ( mm) 5 µf 2 ML Linkwitch- LNK6448K BP 44.2 kω 0 kω 2.4 Ω ML 2.7 kω PI

8 esign Examples Linkwitch-4 Constant Voltage, Constant Current CoC v5 and OE v6 Compliant UB mart Phone Charger (RR-462) 0 W, 5 V, 2 A OUTPUT, INPUT, FLYBACK UB POWER UPPLY L B AB8 F 600 V 2 A 2 J N J2 R 5 Ω 470 µh 4 N.A. 2 µf Bead 0.82 Ω / W 2 µf Linkwitch-4 LNK Ω 0.9 Ω / W C GN 27 MΩ 27 MΩ B E VCC B 0 pf 500 V 2 00 Ω Ω kω 5 6 Q G005 C9 00 pf 2AC Ω 0U pf 00 V 2 N kω 620 Ω kω 560 µf 6. V 5 Ω 560 µf 6. V 5. kω 5 V, 2 A J- J-4 PI Linkwitch-4 Constant Voltage, Constant Current CoC v5 and OE v6 Compliant UB mart Phone Charger 2 W, 2 V, A OUTPUT, INPUT, FLYBACK UB POWER UPPLY mh 470 pf 60 V CY 00 pf 2 4 FL+ 5 Ω 470 pf 220 µf L 9 kω 2 V, A L N F 2 A NT 5 Ω B B06 5 µf 0.68 Ω 5 µf Linkwitch Ω 0.68 Ω C GN 0 MΩ 0 MΩ B E VCC B 220 Ω 00 Ω 0 Q 005 T kω 2 RM6 FL VFY Ω 60 Ω kω kω 6 BAV2W PI

9 esign Examples Linkwitch-HP Constant Voltage, Network Adapter 8 W, 2 V,.5 A OUTPUT, INPUT, FLYBACK POWER UPPLY CY 220 pf 2AC 0 2 kv 5 7 7, 8 B00 60 kω C9 000 µf 680 µf 0 kω 6 V 6 V 2 V,.5 A J L J N J F A RV 00 V 2 5 µf 20 mh 22 µf 00 Ω 5 EE6 6 2 Linkwitch-HP BP CONTROL LNK6775K kω 7.5 kω 6 B 470 pf 2 0 J4 4 5 kω P CP 50 kω 00 nf 00 pf 4.7 µf 8.2 kω 22 µf PI Linkwitch-HP High Efficiency Adapter with ynchronous Rectification (ER-46) 24 W, 2 V, 2 A OUTPUT, INPUT, FLYBACK AAPTER POWER UPPLY nf 2AC L4 0 mh B F206T-G 600 V 4 50 nf 2AC 9 0. MΩ. MΩ nf 4 µf V BZG00TR 0 V 6 µf 20 kω 0 nf 60 V 00 Ω K--F BP 9 RM8 F F BAV2W- 2 Ω 7-F kω 4. kω 680 pf 00 V V2P0-M/86A 9 20 Ω V BZX V Q I82AP Ω 47 kω 4 OPEN 2 26 kω /6 W µf 6 V L5 00 µh kω Q2 MMBT904 V Z2056M0L 5.6 V V, 2 A TP TP4 TP2 RV TP F 2 A Linkwitch-HP U LNK6775E nf 24 kω CONTROL P CP 00 nf 0 pf 00 pf kω 470 nf V GATE V U4 U60R TON EN/OFF GN VCC 4 PI

10 esign Examples Innowitch-CE Constant Voltage, Constant Current Adapter (ER-60) 0 W, 5 V, 2 A OUTPUT, INPUT, FLYBACK UB POWER UPPLY 00 pf 2AC 4.7 µh 2 6 /6 W 5 V, 2 A TP J- R2MA--F 2 R2MA--F kω 0 Ω 5 FL C9 20 Ω.5 nf 200 V µf 6. V 4 kω /6 W J J2 F.5 A t O R R2MA--F 4 R2MA--F 8.2 µf 8.2 µf 22 µf 8.2 kω 6 FL200-7 V CONTROL 4 EE MΩ 2.00 MΩ 47 Ω FW Q I770P--GE R VO BP 7* BAV9W 8* BAV9W GN 0 pf µh BPP 4.7 µf Innowitch-CE INN62C-H02 I 0.05 Ω, /2 W *Optional components PI TP4 J-4 Innowitch-CP UB P Mobile Phone Charger (ER-56) 45 W, 5 V, A, and 9 V, A and 5 V, A OUTPUT, INPUT, FLYBACK UB P POWER UPPLY F 2AC FL 90 µf 90 µf 20 V 20 V Q BC00P0N G 49.9 kω Q2 BC00P0N G 5 V, A 9 V, A 5 V, A B TB20J-TP 600 V 4 mh 600 µh J F 2 A B TB20J-TP 600 V nf R 5 Ω J2 t O 9 µf 9 µf 2.00 MΩ.8 MΩ 5.5 MΩ V Z200M0L 0 V 2.2 nf 60 V Q7 MMBTA06LG kω V MMZ5259BG 50 kω 20 Ω Ω 2 BAV2W-7-F 4 22 µf FL800-7 M400PL-TP FL4 FL6 FL5 V EQ27 CONTROL BPP µf F 47 Ω FW Q I82AP--GE 200 V R Innowitch-CP INN268C-H208 VO 0 Q6 RJ002YNTCL BP GN I 0 pf 6.6 kω 0.0 Ω * 6.8 nf 0* 4.02 kω *Not connected 7.6 kω 8* 8.0 kω kω.00 kω Q4 RJU00N kω KΩ GPIO0 GPIO5 I2C_A_P0.0 I2C_CL_P0. GPIO7 XRE CYP24 U2 V EPA 6 00 nf VCC GPIO6 C C 7 5 V pf 0 pf 6 V 6 V 6 V Q5 RJU00N Ω C9 5 V PI-8409a V OUT 0

11 esign Examples Innowitch-CE ual Output Industrial Power upply (ER-57) 6 W, 2 V, A OUTPUT, INPUT, FLYBACK, NETWORK POWER UPPLY 2.2 nf 2AC EQ2506 F 2 V, A 2.00 MΩ pf kv 68 Ω L Ω 000 pf 60 V 470 µf 6 V FL V 470 µf 6 V.8 kω 2 0 pf C9 22 nf 0 kω TP TP4 L TP N F 2 A R 2.5 Ω 00 nf 275 RV mh 4 2 B GBL V 2 4 µf µf.54 MΩ 2 N NC F 47 Ω Q I490AY 2 90 Ω V BZX79-V2 8.2 V 0 TP2 t O 5.6 kω 22 µf V FW R VO BP GN CONTROL 00 µh BPP 4.7 µf Innowitch-CE INN66C-H02 I Ω /2 W PI

12 Worldwide ales upport Locations World Headquarters 5245 Hellyer Avenue an Jose, CA 958, UA Main: Customer ervice: Worldwide: Americas: usasales@power.com info@power.com AMERICA WET 5245 Hellyer Avenue an Jose, CA 958 UA Tel: Fax: usasales@power.com GERMANY (AC-C/LE ales) Lindwurmstrasse München Germany Tel: Fax: eurosales@power.com INIA (Mumbai) Power Integrations India Private Limited Unit: 06-07, agar Tech Plaza-B akinaka, Andheri Kurla Road Mumbai , Maharashtra, India Tel : Tel 2: indiasales@power.com JAPAN Yusen hin-yokohama -chome Bldg. -7-9, hin-yokohama, Kohoku-ku Yokohama-shi, Kanagawa Japan Phone: japansales@power.com TAIWAN 5F, No. 8, Nei Hu. Rd., ec. Nei Hu ist. Taipei, Taiwan 4, R.O.C. Tel: Fax: taiwansales@power.com On the Web AMERICA EAT 760 McGinnis Ferry Road uite 225 uwanee, GA 0024 Tel: Fax: usasales@power.com CHINA (hanghai) Room 60-60, Charity Plaza No. 88 North Caoxi Road hanghai, PRC Tel: Fax: chinasales@power.com GERMANY (Gate river ales) HellwegForum Ense Germany Tel: gate-drivers.sales@power.com INIA (New elhi) #45, Top Floor Okhla Industrial Area, Phase III New elhi, India Pin 0020 Tel: /5 indiasales@power.com KOREA RM602, 6FL, 22 Teheran-ro 87-gil, Gangnam-gu eoul, 0664, Korea Tel: Fax: koreasales@power.com UNITE KINGOM Building 5, uite 2 The Westbrook Centre Milton Road Cambridge CB4 YG Tel: +44 (0) eurosales@power.com AMERICA CENTRAL 00 undee Road, uite 204 Northbrook, IL Tel: usasales@power.com CHINA (henzhen) 7/F, Hivac Building, No 2 Keji outh 8th Road, Nanshan istrict henzhen, China Zip Code: Tel: Fax: chinasales@power.com ITALY Via Milanese esto an Giovanni (MI) Italy Tel: eurosales@power.com INIA (Bangalore) #, 4th Main Road Vasanthanagar Bangalore India Tel : Tel 2: Fax: indiasales@power.com INGAPORE 5 Newton Road #20-0/0 Goldhill Plaza ingapore, Tel: Cust. vc: Fax: singaporesales@power.com The PI logo, TOPwitch, Tinywitch, ENZero, CALE, CALE-iriver, CALE-iFlex, Qspeed, Peakwitch, LYTwitch, LinkZero, Linkwitch, Innowitch, HiperTF, HiperPF, HiperLC, PA-witch, CAPZero, Clampless, Ecomart, E-hield, Filterfuse, FluxLink, takfet, PI Expert and PI FACT are trademarks of Power Integrations, Inc. Other trademarks are property of their respective companies. 207, Power Integrations, Inc.