121 FCCTR_ TEST REPORT MAGNETI MARELLI S.P.A.

Transcription

1 121 FCCTR_ TEST REPORT APPLICANT: APPLICANT REFEREE: EUT DESCRIPTION EUT MODEL EUT FCC ID MAGNETI MARELLI S.P.A. - LIGHTING & BODY ELECTRONIC C/O C.F.R. STRADA TORINO ORBASSANO - TO - ITALY Phone : Mr. Cardelli REMOTE KEYLESS ENTRY TFR198 RX2TRF198 EUT TRADEMARK MANUFACTURER MAGNETI MARELLI S.P.A. REFERENCE STANDARDS 47 CFR FCC part (b) TEST REPORT NUMBER FCCTR_ TEST REPORT ISSUE DATE 22/2/216 TESTING LABORATORY TESTING LOCATION Prima Ricerca & Sviluppo Via Campagna, Faloppio (Co) Italy FCC test registration number: As Above DATE OF TEST SAMPLE RECEIPT 2/1/16 NUMBER OF TESTED SAMPLES 1 DATE OF TEST 2/1/216 TESTED BY APPROVED BY Giacomo ARMELLINI Responsabile Laboratorio EMC e RADIO/ EMC and RADIO Laboratory Manager Vincenzo LA FRAGOLA Direttore generale / Managing director The test results reported in this test report shall refer only to the sample actually tested and shall not refer or be deemed to refer to bulk from which such a sample may be said to have be obtained. Reproduction of this Test Report, should not be reproduced, except in full, without the written authorization of the Laboratory TRFCC_ Page 1 of 12 Prima Ricerca & Sviluppo. Capitale Sociale 5. i.v. Codice Fiscale e Partita IVA Uff. registro di COMO - n.rea CO27979 Sede: I-222 Faloppio (Co) Via Campagna, 92 Tel Fax

2 122 FCCTR_ CONTENTS Page. CONTENTS RELEASE CONTROL RECORD TECHNICAL INFORMATION OF EQUIPMENT UNDER TEST (EUT) Identification Technical data Ports identification Auxiliary equipment OPERATING TEST MODES AND CONDITIONS REFERENCE STANDARD / DOCUMENT FOR PERFORMED TESTS SUMMARY OF TEST RESULTS TEST RESULTS LIST OF EQUIPMENT USED RELEASE CONTROL RECORD TEST REPORT NUMBER REASON OF CHANGE DATE OF ISSUE FCCTR_ Original release 22/2/216 TRFCC_ Page 2 of 12 Prima Ricerca & Sviluppo. Capitale Sociale 5. i.v. Codice Fiscale e Partita IVA Uff. registro di COMO - n.rea CO27979 Sede: I-222 Faloppio (Co) Via Campagna, 92 Tel Fax

3 123 FCCTR_ TECHNICAL INFORMATION OF EQUIPMENT UNDER TEST (EUT) 2.1 Identification Trademark: Manufacturer: Type of Equipment : Model name: FCC ID : Country of manufacturer: MAGNETI MARELLI S.P.A. REMOTE KEYLESS ENTRY TRF198 RX2TFR198 ITALY 2.2 Technical data Product type: Radio type: Product description / application Power supply requirements : Operating Frequency: Channel spacing Radio Equipment Intentional radiators The EUT is a remote keyless entry using the 433MHz frequency for remote control of vehicle s door (i.e lock door, unlock door/trunck) 3V (CR232 type) MHz NA Number of Channel 1 Modulation Type Pulse Train Pulse width Antenna Type ASK 1ms 95.2ms Integral Antenna. TRFCC_ Page 3 of 12 Prima Ricerca & Sviluppo. Capitale Sociale 5. i.v. Codice Fiscale e Partita IVA Uff. registro di COMO - n.rea CO27979 Sede: I-222 Faloppio (Co) Via Campagna, 92 Tel Fax

4 124 FCCTR_ Ports identification This section contains descriptions of all signal ports and AC/DC power input/output ports, the length and the type of the cable provided by manufacturer needed for the tests. Moreover it is specified if the ports are ever or optionally connected. Port Description Connection 1 Enclosure Plastic / Metal Snaps & screw 2 AC Power Supply Port not present DC power supply Port not present (powered by 3Vdc internal battery) Signal lines Port not present Telecomm. Lines Port not present Antenna port Port not present --- Note: During the tests all cables must be what provided the manufacturer or the same that used in the real employment of the EUT. 2.4 Auxiliary equipment None TRFCC_ Page 4 of 12 Prima Ricerca & Sviluppo. Capitale Sociale 5. i.v. Codice Fiscale e Partita IVA Uff. registro di COMO - n.rea CO27979 Sede: I-222 Faloppio (Co) Via Campagna, 92 Tel Fax

5 125 FCCTR_ OPERATING TEST MODES AND CONDITIONS In the following table there are the operating conditions adopted during tests identified by an indicator (#..) at which has been referred the item Operating condition of the equipment under test Operating condition Description #1 Sample 1: Continuous transmission, modulated carrier (see note 1) Note: 1 The timing of the continuous transmission and the usual standard operating condition is the same and it is illustrated in Test report (Edition 3) issued by TÜV SÜD SENTON GmbH on 6/2/212: Duty Cycle correction factor = -.4dB Special Test Software: Special software and hardware by the Applicant to operate the EUT at channel frequency continuously. Transmitter Test Antenna: The EUT has been tested with the antenna fitted in a manner typical of normal intended use as integral antenna equipment as described with the test results. TRFCC_ Page 5 of 12 Prima Ricerca & Sviluppo. Capitale Sociale 5. i.v. Codice Fiscale e Partita IVA Uff. registro di COMO - n.rea CO27979 Sede: I-222 Faloppio (Co) Via Campagna, 92 Tel Fax

6 126 FCCTR_ REFERENCE STANDARD / DOCUMENT FOR PERFORMED TESTS CFR 47, Part 15, Subpart C ANSI C63.4:213 Federal Communication Commission, Code of Federal Regulations, Title 47, Part 15: General Rules and Regulations, Allocation, Assignment, and Use of Radio Frequencies Methods and Measurements of Radio-Noise Emissions from Low- Voltage Electrical And Electronic Equipment in the Range of 9 khz to 4 GHz 5. SUMMARY OF TEST RESULTS Phenomena Field Strength of Fundamental and Spurious Emissions Basic standard FCC Part (b) Operating condition Result #1 Compliant Note: Preliminary measurements on all axes have been performed in order to determine the worst case emissions. 6. TEST RESULTS Field Strength of Fundamental and Spurious Emissions... 7 TRFCC_ Page 6 of 12 Prima Ricerca & Sviluppo. Capitale Sociale 5. i.v. Codice Fiscale e Partita IVA Uff. registro di COMO - n.rea CO27979 Sede: I-222 Faloppio (Co) Via Campagna, 92 Tel Fax

7 127 FCCTR_ TEST 1. REFERENCE DOCUMENT FIELD STRENGTH OF FUNDAMENTAL AND SPURIOUS EMISSIONS According to (b)in addition to the provisions of 15.25, the field strength of emissions from intentional radiators operated under this section shall not exceed the following: Fundamental frequency (MHz) Field strength of fundamental (microvolts/meter) , , ,25 to 3, to , ,75 to 12, to 1,25 Above 47 12,5 1,25 Field strength of spurious emissions (microvolts/meter) 1 Linear interpolations. TEST SETUP TEST LOCATION In according to ref std TYPE OF MEASUREMENT RADIATED Semi Anechoic Chamber TEST EQUIPMENT EMI receiver Rohde & Schwarz Mod, ESU 4 Spectrum Analyzer Rohde & Schwarz Mod, FSP4 Chase Antenna Mod, CBL 6111 C Antenna Rohde & Schwarz mod, HL5 High pass filter Wainwright WHNX 1,3/18G-1SS TEST PERFORMED BY Giacomo Armellini TESTING DATE 2/1/216 UNCERTAINTY OF MEASURE: Combined uncertainty = 1,75 db Total uncertainty = (k=2) 3,5 db TEST CONDITIONS: MEASURED Ambient temperature : 23 C 5 C 24 C Ambient humidity : %rh 45% Pressure : kpa (86 mbar - 16 mbar) 96mbar OPERATING CONDITION #1 TEST RESULT COMPLIANT TRFCC_ Page 7 of 12 Prima Ricerca & Sviluppo. Capitale Sociale 5. i.v. Codice Fiscale e Partita IVA Uff. registro di COMO - n.rea CO27979 Sede: I-222 Faloppio (Co) Via Campagna, 92 Tel Fax

8 128 FCCTR_ FREQUENCY RANGE 3MHz 1GHz RADIATED MEASUREMENT VERTICAL POLARIZATION FCC_15_247_RADIATED_SPURIOUS_VERTICAL 9 8 FCC 1 5 _ FU N D A M E N T A L Level in dbµv/m FCC 1 5 _ S P U R IO U S FCC 1 5 _ 2 9 _ G E N E R A L _ E M IS S IO N S _ L IM IT M M G Fre quency in Hz Blue trace Peak detector, Blue Marker Peak detector Final Result Frequency (MHz) Max Peak Duty Cycle correction Average Bandwidth (khz) Height (cm) Polarization Azimuth (deg) Limit Margin 13. V V V TRFCC_ Page 8 of 12 Prima Ricerca & Sviluppo. Capitale Sociale 5. i.v. Codice Fiscale e Partita IVA Uff. registro di COMO - n.rea CO27979 Sede: I-222 Faloppio (Co) Via Campagna, 92 Tel Fax

9 129 FCCTR_ FREQUENCY RANGE 1GHz-5GHz VERTICAL POLARIZATION FCC_15_247_RADIATED_SPURIOUS_VERTICAL Level in dbµv/m FCC 1 5 _ S P U R IO U S FCC 1 5 _ 2 9 _ G E N E R A L _ E M IS S IO N S _ L IM IT G 2G 3G 4G 5G Fre quency in Hz Blue trace Peak detector, Blue Marker Peak detector Final Result Frequency (MHz) Max Peak Duty Cycle correction Average Bandwidth (khz) Height (cm) Polarization Azimuth (deg) Limit Margin V V V V V TRFCC_ Page 9 of 12 Prima Ricerca & Sviluppo. Capitale Sociale 5. i.v. Codice Fiscale e Partita IVA Uff. registro di COMO - n.rea CO27979 Sede: I-222 Faloppio (Co) Via Campagna, 92 Tel Fax

10 121 FCCTR_ FREQUENCY RANGE 3MHz 1GHz HORIZONTAL POLARIZATION FCC_15_247_RADIATED_SPURIOUS_VERTICAL 9 8 FCC 1 5 _ FU N D A M E N T A L Level in dbµv/m FCC 1 5 _ S P U R IO U S FCC 1 5 _ 2 9 _ G E N E R A L _ E M IS S IO N S _ L IM IT M M G Fre quency in Hz Blue trace Peak detector, Blue Marker Peak detector Final Result Frequency (MHz) Max Peak Duty Cycle correction Average Bandwidth (khz) Height (cm) Polarization Azimuth (deg) Limit Margin H H TRFCC_ Page 1 of 12 Prima Ricerca & Sviluppo. Capitale Sociale 5. i.v. Codice Fiscale e Partita IVA Uff. registro di COMO - n.rea CO27979 Sede: I-222 Faloppio (Co) Via Campagna, 92 Tel Fax

11 1211 FCCTR_ FREQUENCY RANGE 1GHz-5GHz HORIZONTAL POLARIZATION FCC_15_247_RADIATED_SPURIOUS_VERTICAL Level in dbµv/m FCC 1 5 _ S P U R IO U S FCC 1 5 _ 2 9 _ G E N E R A L _ E M IS S IO N S _ L IM IT G 2G 3G 4G 5G Fre quency in Hz Blue trace Peak detector, Blue Marker Peak detector Final Result Frequency (MHz) Max Peak Duty Cycle correction Average Bandwidth (khz) Height (cm) Polarization Azimuth (deg) Limit Margin H H H H H TRFCC_ Page 11 of 12 Prima Ricerca & Sviluppo. Capitale Sociale 5. i.v. Codice Fiscale e Partita IVA Uff. registro di COMO - n.rea CO27979 Sede: I-222 Faloppio (Co) Via Campagna, 92 Tel Fax

12 1212 FCCTR_ LIST OF EQUIPMENT USED EQUIPMENT MANUFACTURER MODEL SERIAL Nr. CAL. DUE EMI TEST RECEIVER 2Hz - 4GHz Rohde & Schwarz ESU /3/216 RF SEMI-ANECHOIC CHAMBER (CSSA) Siemens B83117-D619- T /94C 26/1/216 BILOG ANTENNA Chase CBL6111C /5/216 LOG PERIODIC ANTENNA BROAD BAND 1-26,5GHz Rohde & Schwarz HL /4/216 SPECTRUM ANALYZER Rohde & Schwarz FSP /1/217 SYSTEM DC POWER SUPPLY HP 6623A 3448A451 1/1/217 HIGH PASS FILTER Wainwright WHNX 1,3/18G- 1SS 1 11/11/216 TRFCC_ Page 12 of 12 Prima Ricerca & Sviluppo. Capitale Sociale 5. i.v. Codice Fiscale e Partita IVA Uff. registro di COMO - n.rea CO27979 Sede: I-222 Faloppio (Co) Via Campagna, 92 Tel Fax