WM-FX193/FX195 SERVICE MANUAL Ver 1.0 2000.01 US Model WM-FX193 Canadian Model AEP Model E Model Chinese Model WM-FX193/FX195 Photo : WM-FX195 Model Name Using Similar Mechanism Tape Transport Mechanism Type NEW MF-WMFX195-114 SPECIFICATIONS Frequency range FM: 87.5-108 MHz (Italy, Saudi Arabia) 87.6-107.9 MHz (Other countries) AM: 526.5-1606.5 khz (Italy, Saudi Arabia)) 531-1602 khz (Other countries) Power requirement 3 V DC batteries R6 (AA) x 2 Dimensions 89.1 x 117.7 x 35.5 mm (w/h/d) incl. projecting parts and controls Mass Approx. 140 g/approx. 220 g incl. batteries and a cassette Supplied accessories Stereo headphones or Stereo earphones (1)/Belt clip (1) Design and specifications are subject to change without notice. Battery life (approximate hours) (EIAJ*) Sony alkaline LR6 (SG) Sony R6P (SR) playback 25 7.5 radio 55 18 * Measured value by the standard of EIAJ (Electronic Industries Association of Japan). (Using a Sony HF series cassette tape) Note The battery life may shorten depending on the operation of the unit. RADIO CASSETTE PLAYER MICROFILM
TABLE OF CONTENTS Specifications... 1 1. GENERAL Location and Function of Controls... 2 2. DISASSEMBLY 2-1. Cabinet (Rear) Sub ASSY... 3 2-2. Main Board... 3 2-3. Mechanism Deck... 4 2-4. Belt, Capstan/Reel Motor (M901)... 4 2-5. Holder Sub ASSY, Cassette... 5 3. ADJUSTMENTS 3-1. Mechanical Adjustments... 6 3-2. Electrical Adjustments... 6 Flexible Circuit Board Repairing Keep the temperature of the soldering iron around 270 C during repairing. Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). Be careful not to apply force on the conductor when soldering or unsoldering. Notes on chip component replacement Never reuse a disconnected chip component. Notice that the minus side of a tantalum capacitor may be damaged by heat. 4. DIAGRAMS 4-1. Block Diagram... 9 4-2. Printed Wiring Boards...11 4-3. Schematic Diagram... 13 5. EXPLODED VIEWS 5-1. Cabinet Section... 17 5-2. Mechanism Section -1... 19 5-3. Mechanism Section -2... 20 6. ELECTRICAL PARTS LIST... 21 SECTION 1 GENERAL This section is extracted from instruction manual. LOCATION AND FUNCTION OF CONTROLS FM MODE i AVLS NORM/ LIMIT TUNING VOLUME FM/AM/TAPE (RADIO OFF) BATT x m nplay M MEGA BASS/ OFF (FX195 only) 2
z The equipment can be removed using the following procedure. SECTION 2 DISASSEMBLY Set Cabinet (rear) sub ASSY Main board Mechanism deck Belt, Capstan/reel moter (M901) Holder sub ASSY, Cassette Note : Follow the disassembly procedure in the numerical order given. 2-1. CABINET (REAR) SUB ASSY Claws Holder sub ASSY, Cassette 4 Cabinet (front) 2 5 Claw 6 5 Claw 3 Claws Cabinet (rear) sub ASSY 5 Claw 4 Claw 4 Claws 3 Claws 3 Claws 1 Screws B1.7x9 2-2. MAIN BOARD White Red Orange Black 2 Remove solder 1 Screw WH1.4 Main board 3 Claws 4 Head flexible board Cabinet (front) 3
2-3. MECHANISM DECK Mechanism deck 1 Insert the precision screwdriver (1.4 mm flat-blabe) in to the slit and release two claws. 2 Cabinet (front) 2-4. BELT, CAPSTAN/REEL MOTOR (M901) 2 Screws (M1.4) Mechanism deck 3 Capstan/reel motor (M901) 1 Belt 4
2-5. HOLDER SUB ASSY, CASSETTE Cabinet (front) 3 Move it away from projection Holder sub ASSY, Cassette 4 Spring (torsion) Cabinet (front) 5 1 Cabinet (front) Holder sub ASSY, Cassette 2 Move it away from projection Holder sub ASSY, Cassette z CAUTIONS DURING ASSEMBLY 1 Insert the dial indicator to the square hole of the cabinet (front) and align to the pointer. 2 Insert the spring (torsion) in to the L shape slot as shown in the figure. 3, 4 Insert the hinge of the Holder sub ASSY, Cassette. 5 Close the Holder sub ASSY, Cassette then press in. Hinge Holder sub ASSY, Cassette Spring (torsion) 5 2 3 Dial indicator 1 Hinge 4 Cabinet (front) 5
SECTION 3 ADJUSTMENTS 3-1. MECHANICAL ADJUSTMENTS PRECAUTION 1. Clean the following parts with a denatured-alcohol-moistened swab : playback head pinch roller capstan rubber belt 2. Demagnetize the playback head with a head demagnetizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. These measurement and adjustment should be performed with the rated power supply voltage (2.5 V) unless otherwise noted. Torque Measurement Mode Torque Meter Meter Reading FWD FWD back tension FF, REW CQ-102C CQ-201B 20 30 g cm (0.28 0.41 oz inch) 0.4 2 g cm (0.006 0.027 oz inch) more than 40 g cm (more than 0.56 oz inch) 3-2. ELECTRICAL ADJUSTMENTS PRECAUTION Supplied voltage : 2.5V. Switch and control position MEGA BASS switch : OFF (FX195) VOLUME control : maximum AVLS switch : NORM Test Tape Type Signal Used for WS-48A 3kHz, 0dB Tape Speed Adjustment Tape Speed Adjustment Procedure : test tape WS-48A (3kHz, 0dB) *1 frequency counter set phones jack (J302) 1. Playback WS-48A (tape center part) and adjust RV601 so that the frequency counter reading becomes 3,000Hz. Standard value : 2,985 3,015Hz 2. Playback WS-48A (tape top and end). Check that frequency counter reading is within 1.5% of the reading of step 1. *1 FX193 E, Chines, Saudi Arabia, 16Ω E, Chines, Saudi Arabia, AEP, French, Italian, FX195 CEV FX193 US, Canadian, AEP, French, Italian, CEV 32Ω FX195 Canadian Abbreviation CEV : Ukraine, Hungary, Czech Adjustment Location : [MAIN BOARD] (Conductor side) RV601 : Tape Speed Adjustment 6
FB201 JR5 JR3 JR1 TUNER SECTION AM Section BAND : AM AM RF signal generator 0 db = 1µV Repeat the procedures in each adjustment several times, and the frequency coverage and tracking adjustments should be finally done by the trimmer capacitors. Put the lead-wire antenna close to the set. T1 < > : US, Canadian, E5, E6 model [ ] : Italian, Saudi Arabia model AM IF ADJUSTMENT Adjust for a maximum reading on level meter. 455kHz FM Section BAND : FM 30% amplitude modulation by 400Hz signal. Output level : as low as possible [MAIN BOARD] (Conductor side) -1-2 TP1 TP339 FB101 FB301C12 S1 TP338 TP9 TP8 TP1 0.01µF US, CND, E5, E6 MODEL JR2 L4 FM RF signal generator 22.5kHz frequency deviation by 400Hz signal. Output level : as low as possible EXCEPT US, CND, E5, E6 MODEL JR4 BATT CP1 US, CN T1 AM FREQUENCY COVERAGE ADJUSTMENT Adjust for a maximum reading on level meter. L4 505kHz [516.5kHz] CT4 1,690kHz < 1,770kHz> [1,631.5kHz] AM TRACKING ADJUSTMENT Adjust for a maximum reading on level meter. L1 620kHz CT1 1,400kHz FM FREQUENCY COVERAGE ADJUSTMENT Adjust for a maximum reading on level meter. L3 86MHz [87.35MHz] CT3 109.5MHz [108.25MHz] FM TRACKING ADJUSTMENT Adjust for a maximum reading on level meter. L2 86MHz [87.35MHz] CT2 109.5MHz [108.25MHz] Adjustment Location : Main board (See page 8) *1 level meter set phones jack (J302) *1 FX193 E, Chines, Saudi Arabia, 16Ω E, Chines, Saudi Arabia, AEP, French, Italian, FX195 CEV FX193 US, Canadian, AEP, French, Italian, CEV 32Ω FX195 Canadian Abbreviation CND : Canadian E5, E6 : South America CEV : Ukraine, Hungary, Czech 7
Adjustment Location : [MAIN BOARD] (Conductor side) CT1 : AM Tracking Adjustment CT4 : AM Frequency Coverage Adjustment CT2 : FM Tracking Adjustment CT3 : FM Frequency Coverage Adjustment L4 : AM Frequency Coverage Adjustment [MAIN BOARD] (Component side) T1 : AM IF Adjustment L2 : FM Tracking Adjustment L1 : AM Tracking Adjustment L3: FM Frequency Coverage Adjustment 8
SECTION 4 DIAGRAMS WM-FX193/FX195 4-1. BLOCK DIAGRAM Abbreviation CND : Canadian EA : Saudi Arabia CH : Chinese E : Indication of country of origin E9 : No Indication of country of origin CEV : Ukrine, Hungary, Czech E5, E6 : South America FR : French Signal path. F : FM f : AM E : PB 9 10
JR363 JR361 JR362 R302 C21 C20 JR218 JR364 R21 C207 C107 C306 JR365 JR366 TP13 JR351 R110 C308 Q301 C208 JR215 JR345 JR346 C203 R203 C206 C106 C313 R104 C103 R103 R206 R106 R601 R607 C330 JR331 R22 C602 C604 C605 R209 R109 C325 JR326 JR328 JR325 JR323 JR336 R108 JR321 JR340 JR311 JR369 C8 L5 R6 C4 JR372 R320 C309 JR329 FB201 JR5 R10 R121 R120 JR367 R210 R8 TP212 C329 JR371 R307 C11 C1 JR212 JR211 JR304 JR322 C315 L301 R208 JR301 JR3 JR1 Vref L R G C607 WM-FX193/FX195 z Semiconductor Location Ref. No. Location D120 G-4 IC1 E-4 IC301 E-8 4-2. PRINTED WIRING BOARDS A 1 2 3 4 5 6 7 8 9 10 11 S305 AVLS [MAIN BOARD] NORM -1-2 Q1 E-6 Q2 F-4 Q301 E-6 Q302 D-6 B LIMIT EXCEPT US, CND, E5, E6 MODEL DRY BATTERY SIZE "AA" (IEC DESIGNATION R6) 2PCS, 3V C D E F J302 S1 i FM MODE MONO LOCAL ST EXCEPT US, CND, E5, E6 MODEL DX US, CND, E5, E6 MODEL CV1-4 TUNING TP339 FB101 S1 CT4 CT1 TP338 TP223 CV1 CV4 CV2 CV3 FB301C12 JR2 JR213 CT2 CT3 TP1 US, CND, E5, E6 MODEL RV301 VOLUME TP221 TP9 TP8 L1 TP7 AM FERRITE ROD ANTENNA C24 C16 C2 C28 JR214 C22 JR4 C26 TP3 R1 C3 TP11 JR370 C13 C18 C10 TP12 R7 C9 TP10 C19 R2 FX193:US,CND TP224 JR368 Q2 L3 L4 L2 CF2 BATT( ) CP1 US, CND, E5, E6 MODEL C B E T1 X2 CF1 12 10 TP4 TP5 R9 C15 C6 IC1 C7 JR217 JR334 C14 13 15 20 24 5 TP6 C5 JR332 JR324 JR333 JR335 TP2 1 C23 JR327 JR330 C40 JR216 R321 JR344 R5 C331 Q302 C B E TP228 TP227 Q1 R3 R4 C334 C B E C B E JR342 JR343 R107 JR348 C17 TP226 JR337 JR338 JR339 R603 JR341 C105 C205 TP207 R207 JR349 JR350 C204 C104 TP647 TP648 R602 C603 TP205 JR303 TP643 TP642 U V 1 5 10 12 C606 48 45 IC301 TP641 TP640 R204 TP209 JR347 TP211 C101 R201 TP213 JR307 R101 C201 C310 TP315 TP319 C301 C303 JR312 TP217 TP214 TP210 C302 C304 4 3 2 1 40 37 1315 20 24 W 36 35 C333 TP639 C608 COM R610 TP635 C609 RV601 R609 TH601 TP231 L302 C307 C108 R308 JR306 JR309 TP229 TP230 TP232 30 25 C311 JR308 TP321 EXCEPT E, E9, CH, EA MODEL TP333 TP634TP636 JR310 JR201 JR401 C305 JR302 BT2 JR305 C314 TP334 BATT(+) TP335 E, E9, CH, EA MODEL J301 DC IN 3V U V W COM M901 CAPSTAN/REEL MOTOR G TP222 TP316 TP317 TP225-1 -2 TP330 D120 BATT TP337 TP336 TP320 TP341 TP331 TP332 S302 (POWER) TP233 WM-FX193 JR402 1-675-134-11 (11) 02 S301 FM AM TAPE (RADIO OFF) HP901 PLAYBACK HEAD WM-FX195 S304 MEGA BASS OFF H L-CH R-CH 4 3 2 1 Note: X : parts extracted from the component side. f : internal component. b : Pattern of the rear side. Abbreviation CND : Canadian EA : Saudi Arabia CH : Chinese E : Indication of country of origin E9 : No Indication of country of origin CEV : Ukraine, Hungary, Czech E5, E6 : South America 11 12
WM-FX193/FX195 4-3. SCHEMATIC DIAGRAM 13 14 15 Note: All capacitors are in µf unless otherwise noted. pf: µµf 50 WV or less are not indicated except for electrolytics and tantalums. All resistors are in Ω and 1 /4 W or less unless otherwise specified. f : internal component. U : B+ Line. Power voltage is dc 3V and fed with regulated dc power supply from external power voltage jack (J301). no mark : FM ( ) : AM < > : TAPE PLAY Voltages are taken with a VOM (Input impedance 10 MΩ). Voltage variations may be noted due to normal production tolerances. Signal path. F : FM E : PB Abbreviation CND : Canadian EA : Saudi Arabia CH : Chinese E : Indication of country of origin E9 : No Indication of country of origin CEV : Ukraine, Hungary, Czech E5, E6 : South America FR : French
z IC Block Diagrams. IC1 TA2111F-(EL) 1 2 3 4 FM RF IN AM RF IN 24 FM RF RF GND IC301 LB8115W-NA-TLM COM RI S/S PRE GND PRE OUT (L) PRE NF (L) PRE OUT (R) PRE NF (R) PRE FWD IN (L) PRE REV IN (L) PRE FWD IN (R) AM LOW CUT 1 48 47 46 45 44 43 42 41 40 39 38 37 2 CURRENT DET SPEED 36 35 REF VOLTAGE 34 FOR SPEED CONTROL 33 3 4 5 6 7 8 9 10 11 PRE REV IN (R) 12 FM RF OUT 23 BIAS REF RF VCC REF VOLTAGE 22 21 20 19 18 AM MIX FM OSC FM OSC FM MIX MIX OUT MVCC OSC UB OSC AM OSC AM OSC 5 6 AGC VB WB VCC SYS CONT AFC AGC DR FWD/ REV OPERATION DET MP-GND 7 8 9 AM IF IN DET OUT AM DET WOUT MPX IN AF BUFFER AM IF 17 FM MUTE FM DET FM IF IN AF AMP VOUT PRE DRIVER DET FM IF UOUT OPERATION LOGIC PLUSE DET LPF2 16 LEVEL DET GND + TUN LED LPF1 VCO DIVIDE ST/MONO FM/AM TUN LED 10 15 L-OUT 14 32 31 DET OUT 30 29 28 27 VSP IN+ MVREF M-GND LOW BOOST SW MIX IN (L) MIX IN (R) H.P IN (L) H.P IN (R) 26 LP.2 25 MIX OUT (R) 13 14 15 16 17 18 19 20 21 22 23 24 VREF R.REF SYSTEM POWER OUT (L) POWER GND POWER OUT (COM) VCC POWER OUT (R) POWER MUTE POWER IN (L) POWER IN (R) MIX OUT (L) ST LED FC R-OUT DECODE ST LED 13 11 12 OUT FREQ CARC. QUAD LOW BOOST NOTE : -XX, -X mean standardized parts, so they may have some difference from the original one. Color indication of Appearance Parts Example : KNOB, BALANCE (WHITE) (RED) Parts color Cabinet's color Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. 5-1. CABINET SECTION 20 19 16 FX195 21 SECTION 5 EXPLODED VIEWS The mechanical parts with no reference number in the exploded views are not supplied. Hardware (# mark) list and accessories and packing materials are given in the last of this parts list. 18 3 17 11 4 15 14 1312 3 8 9 10 Abbreviation CND : Canadian EA : Saudi Arabia CH : Chinese E : Indication of country of origin E9 : No Indication of country of origin CEV : Ukraine, Hungary, Czech E5, E6 : South America FR : French 7 22 23 MF-WMFX195-114 5 1 2 L1 6 24 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 1 X-3378-185-1 CABINET (REAR) SUB ASSY (EXCEPT E, E9, EA,CH) 1 X-3378-186-1 CABINET (REAR) SUB ASSY (E, E9, EA,CH) 2 3-019-503-11 SHEET(CABINET REAR) 3 3-318-203-92 SCREW(B1.7), TAPPING 4 3-022-581-01 PLATE, LIGHT GUIDE 5 3-039-265-01 LID,BATTERY CASE 6 A-3021-289-A MAINBOARD, COMPLETE (FX195:E,E9,CH) 6 A-3021-290-A MAINBOARD, COMPLETE (FX193:E,E9,CH) 6 A-3021-291-A MAINBOARD, COMPLETE (FX193:EA) 6 A-3021-292-A MAINBOARD, COMPLETE (FX193:E5,E6) 6 A-3021-293-A MAINBOARD, COMPLETE (FX193:US,CND) 6 A-3021-294-A MAINBOARD, COMPLETE (FX193:AEP,CEV) 6 A-3021-295-A MAINBOARD, COMPLETE (FX193:FR) 6 A-3021-296-A MAINBOARD, COMPLETE (FX193:Italian) 6 A-3021-297-A MAINBOARD, COMPLETE (FX195:EA) 6 A-3021-298-A MAINBOARD, COMPLETE (FX195:CND) 6 A-3021-299-A MAINBOARD, COMPLETE (FX195:AEP,CEV) 6 A-3021-300-A MAINBOARD, COMPLETE (FX195:FR) 6 A-3021-301-A MAINBOARD, COMPLETE (FX195:Italian) 6 A-3021-302-A MAINBOARD, COMPLETE (FX195:E5,E6) 7 3-029-332-01 TERMINAL (-), BATTERY 8 9-910-999-31 SCREW(M1.7X1.5) 9 3-039-262-01 KNOB(TUNING) 10 3-039-266-01 TERMINAL (+), BATTERY 11 3-921-955-01 SCREW (M1.4), TOOTH (WH) 12 3-019-859-01 BUTTON (STOP) 13 3-019-860-01 BUTTON (FF) 14 3-019-858-01 BUTTON (PLAY) 15 3-019-861-01 BUTTON (REW) 16 3-375-114-31 SCREW 17 3-039-259-01 COVER, LID 18 3-039-260-01 DIAL INDICATOR 19 3-039-267-01 HOLDER, CASSETTE (FX195:CND,E5,E6) (GOLD) 19 3-039-267-11 HOLDER, CASSETTE (FX195:CND,E5,E6) (BLUE) 19 3-039-267-21 HOLDER, CASSETTE (FX195:CND,E5) (BLACK) 19 3-039-267-31 HOLDER, CASSETTE (FX195:AEP,CEV,FR,E,E9,CH) (GOLD) 19 3-039-267-41 HOLDER, CASSETTE (FX195:AEP,CEV,FR,E,E9,CH) (BLUE) 19 3-039-267-51 HOLDER, CASSETTE (FX195:AEP,CEV,FR,E,E9,CH) (BLACK) 19 3-039-267-61 HOLDER, CASSETTE (FX195:Italian,EA)(GOLD) 19 3-039-267-71 HOLDER, CASSETTE (FX195:Italian,EA) (BLUE) 19 3-039-267-81 HOLDER, CASSETTE (FX195:Italian,EA) (BLACK) 19 X-3378-178-1 HOLDER SUB ASSY, CASSETTE (FX193:AEP,FR,CEV,E,E9,CH) (GRAY) 19 X-3378-179-1 HOLDER SUB ASSY, CASSETTE (FX193:AEP,CEV,E,E9,CH) (BLUE) 19 X-3378-180-1 HOLDER SUB ASSY, CASSETTE (FX193:EA) (GRAY) 19 X-3378-181-1 HOLDER SUB ASSY, CASSETTE (FX193:Italian,EA) (BLUE) 19 X-3378-182-1 HOLDER SUB ASSY, CASSETTE (FX193:E5,E6) (GRAY) 19 X-3378-183-1 HOLDER SUB ASSY, CASSETTE (FX193:US,CND,E5,E6) (BLUE) 19 X-3378-184-1 HOLDER SUB ASSY, CASSETTE (FX193:E5,E6) (ORANGE) 20 3-007-012-01 SPRING (TORSION) 21 3-039-268-01 KNOB(MEGABASS) (FX195) 22 3-932-037-01 SPRING (CASSETTE) 23 3-039-255-01 CABINET (FRONT) (FX193:E,E9,CH,EA) 23 3-039-255-11 CABINET (FRONT) (FX193:AEP,Italian,FR,CEV) 23 3-039-255-21 CABINET (FRONT) (FX193:US,CND,E5,E6) 23 3-039-255-31 CABINET (FRONT) (FX195:E,E9,CH,EA) 23 3-039-255-41 CABINET (FRONT) (FX195:AEP,Italian,CEV,FR) 23 3-039-255-51 CABINET (FRONT) (FX195:CND,E5,E6) 24 3-039-261-01 POINTER L1 1-754-084-11 ANTENNA, FERRITE-ROD (AM TRACKING) R.F VREF 16 17 18
5-2. MECHANISM SECTION-1 (MF-WMFX195-114) 54 52 53 HP901 55 M901 56 51 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 51 3-013-560-11 BELT 52 3-703-816-31 SCREW (M1.4), SPECIAL HEAD 53 3-921-042-01 GEAR(REEL) 54 3-703-816-73 SCREW (M1.4), SPECIAL HEAD 55 X-3369-749-1 PINCH LEVER (N) ASSY 56 3-920-996-01 SPRING (PINCH N) HP901 1-500-641-11 HEAD, MAGNETIC (PLAYBACK) M901 1-763-073-11 MOTOR (CAPSTAN/REEL) (INCLUDING PULLEY) 19
5-3. MECHANISM SECTION-2 (MF-WMFX195-114) 109 108 110 111 112 113 114 104 105 106 107 115 118 116 103 117 102 101 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark 101 3-921-797-01 WASHER 102 3-921-003-01 BEARING 103 3-938-628-02 SPRING (PLAY-CP) 104 3-920-999-01 GEAR (A) 105 X-3376-169-1 CLUTCH ASSY 111 3-921-335-01 WASHER, LEVER 112 3-920-990-01 SPRING (UD), COMPRESSION 113 3-921-050-01 GEAR (B) 114 X-3372-619-1 WHEEL ASSY (P), CAPSTAN 115 3-921-043-11 GEAR (D) 106 3-013-142-01 SPRING (FR-CP) 107 3-015-436-01 SPRING (STOP) 108 3-938-613-01 LEVER (OW), DETECTION 109 3-728-091-01 WASHER, STOPPER 110 3-923-530-01 SLEEVE (M) 116 3-036-664-11 SPRING (FR LEVER OWN) 117 X-3377-890-1 CHASSIS ASSY (GL-02C) 118 3-016-989-01 SPRING (SW-CP) 20
NOTE : Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. -XX, -X mean standardized parts, so they may have some difference from the original one. RESISTORS All resistors are in ohms METAL : Metal-film resistor METAL OXIDE :Metal oxide-film resistor F : nonflammable Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. SECTION 6 ELECTRICAL PARTS LIST SEMICONDUCTORS In each case, u : µ, for example : ua... : µ A..., upa... : µ PA... upb... : µ PB..., upc... : µ PC... upd... : µ PD... CAPACITORS uf : µ F COILS uh : µ H MAIN When indicating parts by reference number, please include the board. Abbreviation CND : Canadian EA : Saudi Arabia CH : Chinese E : Indication of country of origin E9 : No Indication of country of origin CEV : Ukraine, Hungary, Czech E5, E6 : South America FR : French Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-3021-289-A MAIN BOARD, COMPLETE (FX195:E,E9,CH) A-3021-290-A MAIN BOARD, COMPLETE (FX193:E,E9,CH) A-3021-291-A MAIN BOARD, COMPLETE (FX193:EA) A-3021-292-A MAIN BOARD, COMPLETE (FX193:E5,E6) A-3021-293-A MAIN BOARD, COMPLETE (FX193:US,CND) C13 1-163-091-00 CERAMIC CHIP 8PF 0.25PF 50V (EXCEPT Italian,EA) C13 1-163-217-11 CERAMIC CHIP 1PF 0.25PF 50V (Italian,EA) C14 1-135-151-21 TANTALUM CHIP 4.7uF 20% 4V A-3021-294-A MAIN BOARD, COMPLETE (FX193:AEP,CEV) A-3021-295-A MAIN BOARD, COMPLETE (FX193:FR) A-3021-296-A MAIN BOARD, COMPLETE (FX193:Italian) A-3021-297-A MAIN BOARD, COMPLETE (FX195:EA) A-3021-298-A MAIN BOARD, COMPLETE (FX195:CND) A-3021-299-A MAIN BOARD, COMPLETE (FX195:AEP,CEV) A-3021-300-A MAIN BOARD, COMPLETE (FX195:FR) A-3021-301-A MAIN BOARD, COMPLETE (FX195:Italian) A-3021-302-A MAIN BOARD, COMPLETE (FX195:E5,E6) ********************************* 3-029-332-02 TERMINAL (-), BATTERY < CAPACITOR > C1 1-163-083-00 CERAMIC CHIP 1PF 50V (EXCEPT Italian,EA) C1 1-163-085-00 CERAMIC CHIP 2PF 50V (Italian,EA) C2 1-163-093-00 CERAMIC CHIP 10PF 5% 50V (EXCEPT Italian,EA) C2 1-163-101-00 CERAMIC CHIP 22PF 5% 50V (Italian,EA) C3 1-163-093-00 CERAMIC CHIP 10PF 5% 50V (EXCEPT Italian,EA) C3 1-163-101-00 CERAMIC CHIP 22PF 5% 50V (Italian,EA) C4 1-163-575-11 CERAMIC CHIP 3PF 50V (EXCEPT Italian,EA) C4 1-163-088-00 CERAMIC CHIP 5PF 50V (Italian,EA) C4 1-163-089-00 CERAMIC CHIP 6PF 50V C5 1-162-937-11 CERAMIC CHIP 6PF 0.5PF 50V C6 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C7 1-165-128-11 CERAMIC CHIP 0.22uF 0% 16V C8 1-164-360-11 CERAMIC CHIP 0.1uF 16V C9 1-115-156-11 CERAMIC CHIP 1uF 0% 10V C10 1-164-360-11 CERAMIC CHIP 0.1uF 16V C11 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V C12 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C15 1-163-077-00 CERAMIC CHIP 0.1uF 10% 25V C16 1-164-227-11 CERAMIC CHIP 0.022uF 10% 25V C17 1-124-584-00 ELECT 100uF 20% 10V C18 1-163-023-00 CERAMIC CHIP 0.015uF 5% 50V (US,CND,E5,E6) C18 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V (EXCEPT US,CND,E5,E6) C19 1-163-023-00 CERAMIC CHIP 0.015uF 5% 50V (US,CND,E5,E6) C19 1-163-021-91 CERAMIC CHIP 0.01uF 10% 50V (EXCEPT US,CND,E5,E6) C20 1-164-360-11 CERAMIC CHIP 0.1uF 16V C21 1-164-360-11 CERAMIC CHIP 0.1uF 16V C22 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C23 1-115-156-11 CERAMIC CHIP 1uF 0% 10V C24 1-164-360-11 CERAMIC CHIP 0.1uF 16V C26 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C28 1-163-090-00 CERAMIC CHIP 7PF 50V (EXCEPT Italian,EA) C28 1-163-217-11 CERAMIC CHIP 1PF 50V (Italian,EA) C40 1-164-360-11 CERAMIC CHIP 0.1uF 16V C101 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C103 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C104 1-126-153-11 ELECT 22uF 20% 6.3V C105 1-115-156-11 CERAMIC CHIP 1uF 0% 10V C106 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C107 1-115-156-11 CERAMIC CHIP 1uF 0% 10V C108 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C201 1-162-962-11 CERAMIC CHIP 470PF 10% 50V C203 1-162-968-11 CERAMIC CHIP 0.0047uF 10% 50V C204 1-126-153-11 ELECT 22uF 20% 6.3V C205 1-115-156-11 CERAMIC CHIP 1uF 0% 10V C206 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C207 1-115-156-11 CERAMIC CHIP 1uF 0% 10V C208 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C301 1-115-156-11 CERAMIC CHIP 1uF 0% 10V C302 1-104-847-11 TANTAL. CHIP 22uF 20% 4V C303 1-164-360-11 CERAMIC CHIP 0.1uF 16V 21
MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C304 1-164-360-11 CERAMIC CHIP 0.1uF 16V C305 1-124-584-00 ELECT 100uF 20% 10V C306 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V C307 1-164-360-11 CERAMIC CHIP 0.1uF 16V C308 1-115-156-11 CERAMIC CHIP 1uF 0% 10V C309 1-164-505-11 CERAMIC CHIP 2.2uF 0% 16V C310 1-162-964-11 CERAMIC CHIP 0.001uF 10% 50V C311 1-162-974-11 CERAMIC CHIP 0.01uF 50V C313 1-135-149-21 TANTALUM CHIP 2.2uF 20% 10V C314 1-164-360-11 CERAMIC CHIP 0.1uF 16V C315 1-115-156-11 CERAMIC CHIP 1uF 0% 10V C325 1-115-156-11 CERAMIC CHIP 1uF 0% 10V C329 1-115-156-11 CERAMIC CHIP 1uF 0% 10V C330 1-115-156-11 CERAMIC CHIP 1uF 0% 10V C331 1-135-151-21 TANTALUM CHIP 4.7uF 20% 4V C333 1-124-434-00 ELECT 220uF 20% 4V C334 1-164-004-11 CERAMIC CHIP 0.1uF 10% 25V C602 1-162-970-11 CERAMIC CHIP 0.01uF 10% 25V C603 1-115-467-11 CERAMIC CHIP 0.22uF 10% 10V C604 1-163-809-11 CERAMIC CHIP 0.047uF 10% 25V C605 1-163-809-11 CERAMIC CHIP 0.047uF 10% 25V C606 1-163-809-11 CERAMIC CHIP 0.047uF 10% 25V C607 1-107-823-11 CERAMIC CHIP 0.47uF 10% 16V C608 1-135-149-21 TANTALUM CHIP 2.2uF 20% 10V C609 1-164-360-11 CERAMIC CHIP 0.1uF 16V < JACK > J301 1-750-061-11 JACK,DC(POLARITY UNIFIED TYPE) (DC IN 3V)(E,E9,CH,EA) J302 1-565-287-11 JACK (i) < JUMPER RESISTOR > JR1 1-216-864-11 METAL CHIP 0 5% 1/16W (EXCEPT US,CND,E5,E6) JR2 1-216-864-11 METAL CHIP 0 5% 1/16W (EXCEPT US,CND,E5,E6) JR3 1-216-821-11 METAL CHIP 1K 5% 1/16W (EXCEPT US,CND,E5,E6) JR4 1-216-864-11 METAL CHIP 0 5% 1/16W (US,CND,E5,E6) JR5 1-216-864-11 METAL CHIP 0 5% 1/16W (US,CND,E5,E6) JR201 1-216-295-00 METAL CHIP 0 5% 1/10W JR211 1-216-295-00 METAL CHIP 0 5% 1/10W JR212 1-216-295-00 METAL CHIP 0 5% 1/10W JR213 1-216-295-00 METAL CHIP 0 5% 1/10W JR214 1-216-295-00 METAL CHIP 0 5% 1/10W JR215 1-216-295-00 METAL CHIP 0 5% 1/10W JR216 1-216-295-00 METAL CHIP 0 5% 1/10W JR217 1-216-295-00 METAL CHIP 0 5% 1/10W JR218 1-216-295-00 METAL CHIP 0 5% 1/10W JR301 1-216-296-00 METAL CHIP 0 5% 1/8W < FILTER > CF1 1-527-870-00 FILTER CF2 1-767-733-71 FILTER ASSY, CERAMIC < COMPOSITION CIRCUIT BLOCK > CP1 1-234-395-11 FILTER, BAND PASS (US,CND,E5,E6) CP1 1-236-711-21 FILTER, BAND PASS (EXCEPT US,CND,E5,E6) < TRIMMER > CT1 1-141-613-11 CAP, VAR (AM TRACKING) CT2 1-141-613-11 CAP, VAR (FM TRACKING) CT3 1-141-613-11 CAP, VAR (FM FREQUENCY COVERAGE) CT4 1-141-613-11 CAP, VAR (AM FREQUENCY COVERAGE) < VARIABLE CAPACITOR > CV1 1-141-613-11 CAP, VAR (TUNING) CV2 1-141-613-11 CAP, VAR (TUNING) CV3 1-141-613-11 CAP, VAR (TUNING) CV4 1-141-613-11 CAP, VAR (TUNING) < DIODE > D120 8-719-074-20 LED LNV210C6AOSO (BATT) < FERRITE BEAD > FB101 1-414-760-21 INDUCTOR CHIP FB201 1-414-760-21 INDUCTOR CHIP FB301 1-414-760-21 INDUCTOR CHIP < IC > IC1 8-759-493-20 IC TA2111F-(EL) IC301 8-759-574-69 IC LB8115W-TLM JR302 1-216-296-00 METAL CHIP 0 5% 1/8W JR303 1-216-296-00 METAL CHIP 0 5% 1/8W JR304 1-216-296-00 METAL CHIP 0 5% 1/8W JR305 1-216-296-00 METAL CHIP 0 5% 1/8W JR306 1-216-296-00 METAL CHIP 0 5% 1/8W JR307 1-216-296-00 METAL CHIP 0 5% 1/8W JR308 1-216-296-00 METAL CHIP 0 5% 1/8W JR309 1-216-296-00 METAL CHIP 0 5% 1/8W JR310 1-216-296-00 METAL CHIP 0 5% 1/8W JR311 1-216-296-00 METAL CHIP 0 5% 1/8W JR312 1-216-296-00 METAL CHIP 0 5% 1/8W JR321 1-216-296-00 METAL CHIP 0 5% 1/8W JR322 1-216-864-11 METAL CHIP 0 5% 1/16 JR323 1-216-296-00 METAL CHIP 0 5% 1/8W JR324 1-216-296-00 METAL CHIP 0 5% 1/8W JR325 1-216-296-00 METAL CHIP 0 5% 1/8W JR326 1-216-296-00 METAL CHIP 0 5% 1/8W JR327 1-216-296-00 METAL CHIP 0 5% 1/8W JR328 1-216-296-00 METAL CHIP 0 5% 1/8W JR329 1-216-296-00 METAL CHIP 0 5% 1/8W JR330 1-216-296-00 METAL CHIP 0 5% 1/8W JR331 1-216-296-00 METAL CHIP 0 5% 1/8W JR332 1-216-296-00 METAL CHIP 0 5% 1/8W JR333 1-216-296-00 METAL CHIP 0 5% 1/8W JR334 1-216-296-00 METAL CHIP 0 5% 1/8W JR335 1-216-296-00 METAL CHIP 0 5% 1/8W JR336 1-216-296-00 METAL CHIP 0 5% 1/8W JR337 1-216-296-00 METAL CHIP 0 5% 1/8W JR338 1-216-296-00 METAL CHIP 0 5% 1/8W JR339 1-216-296-00 METAL CHIP 0 5% 1/8W JR340 1-216-296-00 METAL CHIP 0 5% 1/8W JR341 1-216-296-00 METAL CHIP 0 5% 1/8W 22
MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark JR342 1-216-296-00 METAL CHIP 0 5% 1/8W JR343 1-216-296-00 METAL CHIP 0 5% 1/8W JR344 1-216-296-00 METAL CHIP 0 5% 1/8W JR345 1-216-296-00 METAL CHIP 0 5% 1/8W JR346 1-216-296-00 METAL CHIP 0 5% 1/8W JR347 1-216-296-00 METAL CHIP 0 5% 1/8W JR348 1-216-296-00 METAL CHIP 0 5% 1/8W JR349 1-216-296-00 METAL CHIP 0 5% 1/8W JR350 1-216-296-00 METAL CHIP 0 5% 1/8W JR351 1-216-296-00 METAL CHIP 0 5% 1/8W JR361 1-216-296-00 METAL CHIP 0 5% 1/8W JR362 1-216-296-00 METAL CHIP 0 5% 1/8W JR363 1-216-296-00 METAL CHIP 0 5% 1/8W JR364 1-216-296-00 METAL CHIP 0 5% 1/8W JR365 1-216-296-00 METAL CHIP 0 5% 1/8W JR366 1-216-296-00 METAL CHIP 0 5% 1/8W JR367 1-216-296-00 METAL CHIP 0 5% 1/8W JR368 1-216-296-00 METAL CHIP 0 5% 1/8W JR369 1-216-296-00 METAL CHIP 0 5% 1/8W JR370 1-216-296-00 METAL CHIP 0 5% 1/8W JR371 1-216-296-00 METAL CHIP 0 5% 1/8W JR372 1-216-296-00 METAL CHIP 0 5% 1/8W JR401 1-216-295-00 METAL CHIP 0 5% 1/10W (EXCEPT E,E9,CH,EA) JR402 1-216-864-11 METAL CHIP 0 5% 1/16W (FX193) R7 1-216-815-11 METAL CHIP 330 5% 1/16W R8 1-216-797-11 METAL CHIP 10 5% 1/16W R9 1-216-815-11 METAL CHIP 330 5% 1/16W R10 1-216-827-11 RES-CHIP 3.3K 5% 1/16W (FX193:US,CND) R21 1-216-829-11 METAL CHIP 4.7K 5% 1/16W R22 1-216-829-11 METAL CHIP 4.7K 5% 1/16W R101 1-216-821-11 METAL CHIP 1K 5% 1/16W R103 1-216-855-11 METAL CHIP 680K 5% 1/16W R104 1-216-839-11 METAL CHIP 33K 5% 1/16W R106 1-216-819-11 METAL CHIP 680 5% 1/16W R107 1-216-214-00 RES-CHIP 4.7K 5% 1/8W R108 1-216-138-00 METAL CHIP 3.3 5% 1/8W (US) R108 1-216-150-91 RES-CHIP 10 5% 1/8W (FX193:CND,AEP,Italian,CEV/FX195:CND) R108 1-216-166-00 RES-CHIP 47 5% 1/8W (FX193:FR) R108 1-216-154-00 RES-CHIP 15 5% 1/8W (FX193:E,E5,E6,E9,CH,EA/FX195:EXCEPT CND,FR) R108 1-216-174-00 RES-CHIP 100 5% 1/8W (FX195:FR) R109 1-216-190-00 RES-CHIP 470 5% 1/8W (FX193:US,CND,AEP,Italian,CEV/FX195:CND) R109 1-216-198-91 RES-CHIP 1K 5% 1/8W (FR) R109 1-216-182-00 RES-CHIP 220 5% 1/8W (FX193:E,E5,E6,E9,CH,EA/FX195:EXCEPT CND,FR) < COIL > L1 1-754-084-11 ANTENNA, FERRITE-ROD (AM TRACKING) L2 1-416-623-11 COIL (WITH CORE) (EXCEPT Italian,EA) (FM TRACKING) L2 1-416-624-11 COIL (WITH CORE) (Italian,EA) (FM TRACKING) L3 1-416-626-11 COIL (WITH CORE) (EXCEPT Italian,EA) (FM FREQUENCY COVERAGE) L3 1-416-627-11 COIL (WITH CORE) (Italian,EA) (FM FREQUENCY COVERAGE) L4 1-406-408-11 COIL (OSC) (EXCEPT Italian,EA) (AM FREQUENCY COVERAGE) L4 1-406-409-11 COIL (OSC) (Italian,EA) (AM FREQUENCY COVERAGE) L5 1-216-295-00 METAL CHIP 0 5% 1/10W L301 1-412-002-31 INDUCTOR CHIP 4.7uH L302 1-216-864-11 METAL CHIP 0 5% 1/16W < TRANSISTOR > Q1 8-729-216-22 TRANSISTOR 2SA1162-G Q2 8-729-216-22 TRANSISTOR 2SA1162-G Q301 8-729-230-49 TRANSISTOR 2SC2712-YG Q302 8-729-230-49 TRANSISTOR 2SC2712-YG < RESISTOR > R1 1-216-295-00 METAL CHIP 0 5% 1/10W R2 1-216-839-11 METAL CHIP 33K 5% 1/16W R3 1-216-234-00 RES-CHIP 33K 5% 1/8W R4 1-216-234-00 RES-CHIP 33K 5% 1/8W R5 1-216-831-11 METAL CHIP 6.8K 5% 1/16W R6 1-216-825-11 METAL CHIP 2.2K 5% 1/16W R110 1-216-864-11 METAL CHIP 0 5% 1/16W (EXCEPT FX195: FR) R110 1-216-807-11 METAL CHIP 68 5% 1/16W (FX195:FR) R120 1-216-819-11 METAL CHIP 680 5% 1/16W R121 1-216-825-11 METAL CHIP 2.2K 5% 1/16W R201 1-216-821-11 METAL CHIP 1K 5% 1/16W R203 1-216-855-11 METAL CHIP 680K 5% 1/16W R204 1-216-839-11 METAL CHIP 33K 5% 1/16W R206 1-216-819-11 METAL CHIP 680 5% 1/16W R207 1-216-214-00 RES-CHIP 4.7K 5% 1/8W R208 1-216-138-00 METAL CHIP 3.3 5% 1/8W (US) R208 1-216-150-91 RES-CHIP 10 5% 1/8W (FX193:CND,AEP,Italian,CEV/FX195:CND) R208 1-216-166-00 RES-CHIP 47 5% 1/8W (FX193:FR) R208 1-216-154-00 RES-CHIP 15 5% 1/8W (FX193:E,E5,E6,E9,CH,EA/FX195:EXCEPT CND,FR) R208 1-216-174-00 RES-CHIP 100 5% 1/8W (FX195:FR) R209 1-216-190-00 RES-CHIP 470 5% 1/8W (FX193:US,CND,AEP,Italian,CEV/FX195:CND) R209 1-216-198-91 RES-CHIP 1K 5% 1/8W (FR) R209 1-216-182-00 RES-CHIP 220 5% 1/8W (FX193:E,E5,E6,E9,CH,EA/FX195:EXCEPT CND,FR) R210 1-216-864-11 METAL CHIP 0 5% 1/16W (EXCEPT FR) R210 1-216-807-11 METAL CHIP 68 5% 1/16W (FX195:FR) R302 1-216-789-11 METAL CHIP 2.2 5% 1/16W R307 1-216-833-91 RES-CHIP 10K 5% 1/16W 23
WM-FX193/FX195 MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R308 1-216-845-11 METAL CHIP 100K 5% 1/16W R320 1-216-845-11 METAL CHIP 100K 5% 1/16W R321 1-216-841-11 METAL CHIP 47K 5% 1/16W R601 1-216-821-11 METAL CHIP 1K 5% 1/16W R602 1-216-835-11 METAL CHIP 15K 5% 1/16W R603 1-216-841-11 METAL CHIP 47K 5% 1/16W R607 1-216-845-11 METAL CHIP 100K 5% 1/16W R609 1-216-833-91 RES-CHIP 10K 5% 1/16W R610 1-216-821-11 METAL CHIP 1K 5% 1/16W < VARIABLE RESISTOR > RV301 1-225-362-11 RES, VAR, CARBON (VOLUME w) RV601 1-223-994-21 RES, CARBON ADJ VAR 4.7K (TAPE SPEED) < SWITCH > S1 1-692-298-11 SWITCH, SLIDE (FM MODE) S301 1-692-299-11 SWITCH, SLIDE (FM/AM/TAPE, RADIO OFF) S302 1-762-302-11 SWITCH, DETECTION (SMALL TYPE) (POWER) S304 1-692-462-31 SWITCH, SLIDE (MEGA BASS) (FX195) S305 1-692-298-11 SWITCH, SLIDE (AVLS) < TRANSFORMER > T1 1-404-949-11 TRANSFORMER, IF (AM IF) < THERMISTOR > TH601 1-803-751-21 THERMISTOR, POSITIVE < VIBRATOR > X2 1-767-733-71 FILTER ASSY, CERAMIC ************************************************************** MISCELLANEOUS ************** HP901 1-500-641-11 HEAD, MAGNETIC (PLAYBACK) L1 1-754-084-11 ANTENNA, FERRITE-ROD (AM TRACKING) M901 1-763-073-11 MOTOR (CAPSTAN/REEL) ************************************************************** ACCESSORIES & PACKING MATERIALS ******************************* 1-505-521-11 HEADPHONE (MDR-023) (FX193:US,CND,AEP, Italian,FR,CEV/FX195:CND) 3-020-998-01 CLIP, BELT 3-867-998-11 MANUAL, INSTRUCTION (AEP,Italian,FR) (ENGLISH,FRENCH,SPANISH,PORTUGUESE, GERMAN,ITALIAN,DUTCH,SWEDISH,FINNISH) 3-867-998-21 MANUAL, INSTRUCTION (US,E5,E6) (ENGLISH, SPANISH, PORTUGUESE) 3-867-998-31 MANUAL, INSTRUCTION (CND,CH) (ENGLISH,FRENCH,SIMPLIFIED,CHINESE) 3-867-998-41 MANUAL, INSTRUCTION (E,EA) (ENGLISH,TRADITIONAL CHINESE,ARABIC) 3-867-998-51 MANUAL, INSTRUCTION (E9) (ENGLISH,TRADITIONAL CHINESE,ARABIC) 3-867-998-61 MANUAL, INSTRUCTION (CEV) (ENGLISH, RUSSIAN,HUNGARIAN,SLOVAK,POLISH, CZECH,TURKISH,GREEK) 8-953-130-90 HEADPHONE MDR-E805LP (FX193:E,E5,E6, E9,CH,EA/FX195:EXCEPT CND) 9-927-646-11 Sony Corporation Personal Audio Division Company 24 2000A0278-1 Printed in Japan 2000.1 Published by General Engineering Dept.