RG56-AG7- ebm-papst Mulfingen GmbH & Co. KG Bachmühle 746 Mulfingen Phone: +49 798 - Fax: +49 798 - www.ebmpapst.com info@de.ebmpapst.com Nominal data Type Motor RG56-AG7- MG-FF Phase ~ Nominal voltage [VAC] Nominal voltage range [VAC] 8.. 48 Frequency [Hz] /6 Type of data definition ml Speed [min - ] Power input [W] Current draw [A].6 Min. ambient temperature [ C] -5 Max. ambient temperature [ C] 6 ml = max. load me = max. efficiency rfa = running at free air cs = customer specs cu = customer unit Subject to alterations Item no.: 5-5-998 Revision status: KM668 Print-out on 9.6. Created by Y. Uhlmann (VM-TDO) Page of 5 ebm-papst Mulfingen GmbH & Co. KG Bachmühle 746 Mulfingen Phone: +49 798 - Fax: +49 798 - www.ebmpapst.com info@de.ebmpapst.com
RG56-AG7- Technical features Leackage current Size Operation mode Direction of rotation Mounting position Electrical leads EMC interference emission EMC interference immunity <=,5 ma 56 mm S Humidity class F4- Insulation class Condensate discharge holes Bearing motor Mass Material of electronics housing Material of impeller Motor protection Product conforming to standard Surface of rotor Number of blades 9 Clockwise, seen on rotor Shaft horizontal or rotor on bottom; rotor on top on request Via terminal box Acc. to EN -6- (household environment) Acc. to EN -6- (industrial environment) "F" Rotor-side Ball bearing.5 kg Type of protection IP 54 Protection class Technical features Max. permissible ambient motor temp. (transp./ storage) Min. permissible ambient motor temp. (transp./storage) Approval Die-cast aluminum Aluminium sheet Reverse polarity and locked-rotor protection CE; EN 8-5- Coated in black I - PFC, passive - Control input - VDC / PWM - Over-temperature protected electronics / motor - Alarm relay - Integrated PID controller - Input for sensor - V or 4- ma - Output for slave - V - RS485 ebmbus - Motor current limit - Soft start - Line undervoltage / phase failure detection - Output VDC, max. ma - Output VDC, max. ma +8 C -4 C CSA C. Nr.77; GOST; UL ; VDE Item no.: 5-5-998 Revision status: KM668 Print-out on 9.6. Created by Y. Uhlmann (VM-TDO) Page of 5 ebm-papst Mulfingen GmbH & Co. KG Bachmühle 746 Mulfingen Phone: +49 798 - Fax: +49 798 - www.ebmpapst.com info@de.ebmpapst.com
RG56-AG7- Product drawing Cable diameter: min. 4 mm, max. mm; tightening torque: 4±.6 Nm Accessory part: Inlet nozzle 7--4 not included in delivery, other inlet nozzles on request Depth of screw max. 5 mm 4 Tightening torque, terminal box cover.5±.5 Nm Item no.: 5-5-998 Revision status: KM668 Print-out on 9.6. Created by Y. Uhlmann (VM-TDO) Page of 5 ebm-papst Mulfingen GmbH & Co. KG Bachmühle 746 Mulfingen Phone: +49 798 - Fax: +49 798 - www.ebmpapst.com info@de.ebmpapst.com
RG56-AG7- Connection screen No. Pin Signal Function / assignment PE PE Protective earth connection KL,, L, L, L Supply voltage, /6 Hz KL NC Floating status message contact, normally closed connection KL COM Floating status message contact, changeover contact, common connection ( A, max. VAC, min. ma, AC) KL NO Floating status message contact, normally open connection KL OUT Analog output, - VDC, max. ma, SELV, output of the current level control coefficient: V equates to % level control coefficient. V equate to % level control coefficient. KL, 8 GND Reference mass for control interface, SELV KL, 7 - V Use control / actual value input - VDC, impedance kω only as alternative to 4- ma input, SELV KL 4 + V Voltage output VDC (+/- %), max. ma, supply voltage for ext. devices (e.g. potentiometers), SELV KL 5 + V Voltage output VDC (+5 %/- %), max. ma, supply voltage for ext. devices (e.g. sensors), SELV KL 6 4- ma Use control / actual value input 4- ma, impedance Ω, only as alternative to - V input, SELV KL 9, RSB RS485 interface for ebmbus, RSB, SELV KL, RSA RS485 interface for ebmbus, RSA, SELV Item no.: 5-5-998 Revision status: KM668 Print-out on 9.6. Created by Y. Uhlmann (VM-TDO) Page 4 of 5 ebm-papst Mulfingen GmbH & Co. KG Bachmühle 746 Mulfingen Phone: +49 798 - Fax: +49 798 - www.ebmpapst.com info@de.ebmpapst.com
RG56-AG7- Charts: Air flow Hz Druck für Rho=,kg/m^ 8 7 7 6 6 5... 8 V [cfm] 4. 5. 4 6. 7. 8.,,,9,8,7,6,5,4,,, Measurement: LU-858 Measurement: LU-96 Measurement: LU-9 Measurement: LU-96 4 7,9,8,7,6,5,4 Pfa_E [IN HO]. 6 5 4. 4 6. 9 8. V [m^/h] 6 5.. 4.,,,,9,8,7,6,5,4,,, Measured values U [V] f [Hz] n [min - ] P [W] 49 I [A].8 LpA ss LpA ds LwA ss LwA ds 9 V p fa [m /h] [Pa] 9. 74 88 58.6 7 8 86 889 5 4 5.9 7 8 86 659 7 5 84. 7 79 85 47 6 4.77 7 8985 8 7. 749 4 8 46.9 55 8 9 9 4.74 65 78 8 9 555.9 64 7 5 4 9 64.4 7 58 44 9 66.99 6 4 7.4 6 57 645 4 7.5 59 57 55 5 7 4.58 58 56 457 48 6 7 88.55 55 55 9 Item no.: 5-5-998 Revision status: KM668 Print-out on 9.6. Created by Y. Uhlmann (VM-TDO) Page 5 of 5 ebm-papst Mulfingen GmbH & Co. KG Bachmühle 746 Mulfingen Phone: +49 798 - Fax: +49 798 - www.ebmpapst.com info@de.ebmpapst.com