FM TRANSCEIVER YAESU EUROPE B.V. FT-1802M

Transcription

1 VERTEX STNDRD CO., LTD Nakameguro, Meguro-Ku, Tokyo , Japan VERTEX STNDRD US Headquarters Walker Street, Cypress, C 90630, U.S.. FM TRNSCEIVER YESU EUROPE.V. FT-1802M P.O. ox 75525, 1118 ZN Schiphol, The Netherlands YESU UK LTD. Unit 12, Sun Valley usiness Park, Winnall Close Winchester, Hampshire, SO23 0L, U.K. Technical Supplement 2005 VERTEX STNDRD CO., LTD. VERTEX STNDRD HK LTD. Unit 5, 20/F., Seaview Centre, Hoi un Road, Kwun Tong, Kowloon, Hong Kong EH023N90 Introduction This manual provides technical information necessary for servicing the FT-1802M FM Transceiver. Servicing this equipment requires expertise in handling surface-mount chip components. ttempts by nonqualified persons to service this equipment may result in permanent damage not covered by the warranty, and may be illegal in some countries. Two PC layout diagrams are provided for each double-sided circuit board in the Transceiver. Each side of is referred to by the type of the majority of components installed on that side ( leaded or chip-only ). In most cases one side has only chip components, and the other has either a mixture of both chip and leaded components (trimmers, coils, electrolytic capacitors, s, etc.), or leaded components only. While we believe the technical information in this manual to be correct, VERTEX STNDRD assumes no liability for damage that may occur as a result of typographical or other errors that may be present. Your cooperation in pointing out any inconsistencies in the technical information would be appreciated. Contents Specifications... Exploded View & Miscellaneous Parts... lock Diagram... Connection Diagram... Circuit Description... lignment oard Unit (Schematics, Layouts & Parts) MIN Unit Circuit Diagram MIN Unit Parts Layout MIN Unit Parts List CNTL Unit Circuit Diagram CNTL Parts Layout CNTL Parts List

2 Specifications General Frequency Range: Channel Step: Standard Repeater Shift: Frequency Stability: Modes of Emission: ntenna Impedance: Supply voltage: Current Consumption (typical): Operating Temperature Range: Case Size (WxHxD): Weight (pprox.): Tx MHz or MHz Rx MHz or MHz 5/10/12.5/15/20/25/50/ khz ±600 khz etter than ±10 ppm [ 4 F to +140 F ( 20 C to +60 C)] F2/F3 50 Ohms, unbalanced 13.8 V DC ±1, negative ground Rx: less than 0.7, less than 0.3 (squelched) Tx: 10 (50 W) /7 (25 W) /5 (10 W) /4 (5 W) 4 F to +140 F ( 20 C to +60 C) 5.5 x 1.6 x 5.7 (140 x 40 x 146 mm) (w/o knobs) 2.6 lb (1.2 kg) Transmitter Output Power: Modulation Type: Maximum Deviation: Spurious Radiation: Microphone Impedance: 50 W/25 W/10 W/5 W Variable Reactance ±5 khz/±2.5 khz etter than 60 d 2000 Ohms Receiver Circuit Type: Ifs: Sensitivity (for 12d SIND): Selectivity ( 6/ 60d): IF Rejection: Image Rejection: Maximum F Output: Double Conversion Superheterodyne 21.7 MHz & 450 khz etter than 0.2 µv 12 khz/28 khz etter than 70 d etter than 70 d 3 W into 4 % THD Specifications subject to change without notice or obligation. Specifications guaranteed only within mateur band. Frequency ranges and functions will vary according to transceiver version; check with your dealer. 2

3 Exploded View & Miscellaneous Parts CP CSE SSY w/sp NET: S M SPEKER S (2 pcs) CUSHION T WIRE SSY S CP-SP VXSTD P/N 43X001 T T Q Q C CCESSORIES DESCRIPTION MROPHONE (MH-486J) DC CLE (FT-1802M) DC CLE (FT-1802E) SPRE FUSE (15 : FT-1802M) SPRE FUSE (15 : FT-1802E) RCKET (MM-36) SCREW SET REF. VXSTD P/N U03302 U U U U T (FT-1802M) T (FT-1802E) WIRE SSY DESCRIPTION QTY. SEMS SCREW SM3X10NI 4 TPTITE SCREW M2X12NI 4 TPTITE SCREW M3X8NI 11 TPTITE SCREW M2.6X6 9 HEX SOCKET OLT M3X20 3 G R60H1317M1 Non-designated parts are available only as part of a designated assembly. MIN UNIT T WIRE SSY CNTL UNIT R INTER CONNECTOR P CONNECTOR LCD R RUER KNO R SSIS R0754 KNO (VOL/CQL) R REFLECTOR R GROUND PLTE R DIFFUSER R FRONT PNEL R ENCODER KNO 3

4 Note 4

5 lock Diagram 5

6 Connection Diagram 6

7 Circuit Description Receive Signal Path Incoming RF signal is from the antenna jack is delivered to the Main Unit and passed through the lowpass filter network consisting capacitors C1213, C1236, C1239, & C1241 and coils L1017, L1018, & L1019, antenna switching diode D1020 and D1028 (both RLS135), and varactor-tuned band-pass filter consisting of capacitors C1248, C1249, C1250, C1251, C1252, & C1268, coils L1020, L1021, & L1024, and diodes D1024 and D1025 (both HVC350), before delivery to the RF amplifier Q1045 (3SK296ZQ). The amplified RF signal is passed through the another varactor-tuned band-pass filter consisting of capacitors C1198, 1199, 1200, & 1218, coils L1012 and L1015, and diodes D1017 and D1021 (both HVC350), then applied to the 1st mixer Q1037 (3SK296ZQ) along with the first local signal from the PLL circuit. The first local signal is generated between MHz and MHz by the VCO, which consists of Q9 (2SC5231) and varactor diode D2 (HVC350) according to the receiving frequency. IF and udio Circuits The 21.7 MHz first IF signal is applied to the monolithic crystal filters XF1 and XF2 which strip away unwanted mixer products, and the IF signal is applied to the first IF amplifier Q1032 (2S400). The amplified first IF signal is then delivered to the FM IF subsystem Q1028 (NJM2591V), which contains the second mixer, limiter amplifier, noise amplifier, and FM detector. The second local signal is generated by MHz crystal X1, produces the 450 khz second IF signal when mixed with first IF signal within Q1028 (NJM2591V). The 450 khz second IF signal is applied to the ceramic filter CF1 (for Narrow FM) or CF2 (for Wide FM) which strip away unwanted mixer products to the ceramic discriminator CD1 which removes any amplitude variations in the 450 khz IF signal before detection of speech. The detected audio from the Q1028 (NJM2591V) passes through the de-emphasis circuit consisting of resistors R1082 & R1113, and capacitors C1120 & C1122, to the audio mute gate Q1034 (2SJ364) The audio signal passes through a band-pass filter consisting of Q1046 and Q1047 (both 2S154), and the audio mute gate Q1039 (2SJ347), to the audio VR which adjusts the audio sensitivity to compensate for audio level variations. The adjusted audio signal is delivered to the audio amplifier Q1035 (L4425) which provides up to 3 Watts, to the external speaker jack or a 4-Ohm loudspeaker. Squelch Control When no carrier received, the noise signal from Q1028 (NJM2591V) is amplified by Q1051 (2S617), and is detected by D1011 and D1013 (both D221). The resulting DC voltage passes through the SQL knob to main CPU Q2002 (H4F2266TF13). While no carrier is received, main CPU Q2002 (H4F2266TF13) control Q1048 (CD4094PWR), thus, audio mute gate Q1034 (2SJ364) and Q1039 (2SJ347) turns OFF to disable the audio output from the speaker. Transmit Signal Path The speech signal from the microphone is amplified by Q1049 (L2902PWR). The amplified speech signal is subjected to the low-pass filter network Q1049 (L2902PWR) to deviation controlled by Q1043 (M62364FP). The adjusted speech signal from Q1043 (M62364FP) is delivered to VCO Q9 (2SC5231) which frequency modulates the transmitting VCO made up of D4 (HSC277). The modulated transmit signal passes through buffer amplifier Q1010 and Q1023 (both 2SC5374). The transmit signal applied to the drive amplifier Q1026 (2SC5226), then finally amplified by power amplifier module Q1030 (R60H1317M) up to 50 Watts. The PC circuit controls the Q1030 (R60H1317M) power amplifier s gain. The 50 Watts RF signal passes through low-pass filter network consisting of Capacitors C1210 and C1211 and coil L1013, antenna switch D1018 and D1019 (both X15709), and another low-pass filter network consisting capacitors C1213, C1236, C1239, & C1241 and coils L1017, L1018, & L1019, and then deliver to the NT jack. 7

8 Circuit Description TX PC Circuit portion of the power amplifier module output is rectified by D1022 (1SS321), then delivered to PC Q1038 (LM2904PWR), as a DC voltage which is proportional to the output level of the power amplifier module. The PC Q1038 (LM2904PWR) is compared the rectified DC voltage from the power amplifier module and the reference voltage from the main CPU Q2002 (H4F2266TF13), to produce a control voltage, which regulates supply voltage to the power amplifier module Q1030 (R60H1317M), so as to maintain stable output power under varying antenna loading condition. PLL portion of the output from the VCO Q9 (2SC5231) passes through the buffer amplifier Q1010 and Q1017 (both 2SC5374), then delivered to the programmable divider section of the PLL Q1011 (M1501PFV1), which divided according 8 to the frequency dividing data that is associated with the setting frequency input from the main CPU Q2002 (H4F2266TF13). It is then sent to the phase comparator section of the PLL Q1011 (M1501PFV1). The MHz frequency of the reference oscillator circuit made up of X1 is divided by the reference frequency divider section of Q1011 (M1501PFV1) into 4250 or 3400 parts to become 5 khz or 6.25 khz comparative reference frequencies, which are utilized by the phase comparator section of Q1011 (M1501PFV1). The phase comparator section of Q1011 (M1501PFV1) compares the phase between the frequency-divided oscillation frequency of the VCO circuit and comparative frequency and its output is a pulse corresponding to the phase difference. This pulse is integrated by the charge pump and loop filter into a control voltage (VCV) to control the oscillation frequency of the VCO Q9 (2SC5231).

9 lignment Introduction Required Test Equipment The FT-1802M is carefully aligned at the factory for the specified performance across the amateur band. Realignment should therefore not be necessary except in the event of a component failure. Only an authorized Vertex Standard representative should perform all component replacement and service, or the warranty policy may be void. The following test equipment (and familiarity with its use) is necessary for complete realignment. Correction of problems caused by misalignment resulting from use of improper test equipment is not covered under the warranty policy. While most steps do not require all of the equipment listed, the interactions of some adjustments may require that more complex adjustments be performed afterwards. Do not attempt to perform only a single step unless it is clearly isolated electrically from all other steps. Have all test equipment ready before beginning and, follow all of the steps in a section in the order presented. RF Signal Generator with calibrated output level at 200 MHz Deviation Meter (linear detector) In-line Wattmeter with accuracy at 200 MHz 50-Ohm 50-W RF Dummy Load 8-Ohm F Dummy Load Regulated DC Power Supply adjustable from 6 to 15 VDC, 10 Frequency Counter: 0.2-ppm accuracy at 200 MHz F Signal Generator C Voltmeter DC Voltmeter: high impedance VHF Sampling Coupler SIND Meter The following procedures cover the adjustments that are not normally required once the transceiver has left the factory. However, if damage occurs and some parts subsequently are replaced, realignment may be required. If a sudden problem occurs during normal operation, it is likely due to component failure; realignment should not be done until after the faulty component has been replaced. We recommend that servicing be performed only by authorized Vertex Standard service technicians who are experienced with the circuitry and fully equipped for repair and alignment. If a fault is suspected, contact the dealer from whom the transceiver was purchased for instructions regarding repair. uthorized Vertex Standard service technicians realign all circuits and make complete performance checks to ensure compliance with factory specifications after replacing any faulty components. Those who do undertake any of the following alignments are cautioned to proceed at their own risk. Problems caused by unauthorized attempts at realignment are not covered by the warranty policy. lso, Vertex Standard reserves the right to change circuits and alignment procedures in the interest of improved performance, without notifying owners. Under no circumstances should any alignment be attempted unless the normal function and operation of the transceiver are clearly understood, the cause of the malfunction has been clearly pinpointed and any faulty components replaced, and realignment determined to be absolutely necessary. 9

10 lignment lignment Preparation & Precautions Entering the lignment Mode 50-Ohm RF load and in-line wattmeter must be connected to the antenna jack in all procedures that call for transmission; alignment is not possible with an antenna. fter completing one step, read the next step to see if the same test equipment is required. If not, remove the test equipment (except dummy load and wattmeter, if connected) before proceeding. lignment of the FT-1802M is performed using a front panel software-based procedure. To perform alignment of the transceiver, it must first be placed in the lignment Mode, in which the adjustments will be made and then stored into memory. To enter the lignment mode, press and hold in the [REV(DW)] and [D/MR(MW)] keys while turning the radio on. Once the radio is on, release these two key. The transceiver is now in the lignment Mode. Correct alignment requires that the ambient temperature be the same as that of the transceiver and test equipment, and that this temperature be held constant between 68 F ~ 86 F (20 C ~ 30 C). When the transceiver is brought into the shop from hot or cold air, it should be allowed some time to come to room temperature before alignment. Whenever possible, alignments should be made with oscillator shields and circuit boards firmly affixed in place. lso, the test equipment must be thoroughly warmed up before beginning. PLL Reference Frequency Rotate the DIL knob to set the alignment parameter to rf. Press the [D/MR(MW)] key to enable adjustment of the PLL Reference Frequency. Press the PTT switch to activate the transmitter, adjust the DIL knob so that the counter frequency reading is MHz (± Hz). Press the [D/MR(MW)] key. Note: Signal levels in d referred to in the alignment procedure are based on 0dµ = 0.5µV. RF Front-end Tuning Inject a 145. MHz signal at a level of 10 dµ (with 1 khz khz deviation) from the RF signal generator. Rotate the DIL knob to set the alignment parameter to 145. tn. Press the [D/MR(MW)] key to enable adjustment of the RF Front-end Tuning. djust the DIL knob so that the maximum SIND. Press the [D/MR(MW)] key. Test Setup Set up the test equipment as shown below for transceiver alignment. 50-Ohm Dummy Load Inline Wattmeter RF Signal Generator RF Sampling Coupler RF Signal Generator NT DC INPUT Deviation Meter FT-1802M Frequency Counter F Signal Generator EXT SP SIND Meter M TEST EQUIPMENT SETUP 10 GND M INPUT PTT/CLONE +8V M SW1 M SW2

11 lignment Squelch Threshold Level Inject a 145. MHz signal at a level of 14 dµ (with 1 khz khz deviation) from the RF signal generator. Rotate the SQL knob to the 10-o clocl position. Rotate the DIL knob to set the alignment parameter to 145. tl. Press the [D/MR(MW)] key to enable adjustment of the Squelch Threshold Level. Press the [D/MR(MW)] key three times. Press the [D/MR(MW)] key. S-meter Level (S-1) Inject a 145. MHz signal at a level of 5 dµ (with 1 khz khz deviation) from the RF signal generator. Rotate the DIL knob to set the alignment parameter to 145. S1. Press the [D/MR(MW)] key to enable adjustment of the S-meter Level (S-1). Press the [D/MR(MW)] key three times. Press the [D/MR(MW)] key. S-meter Level (S-9) Inject a 145. MHz signal at a level of +20 dµ (with 1 khz khz deviation) from the RF signal generator. Rotate the DIL knob to set the alignment parameter to 145. S9. Press the [D/MR(MW)] key to enable adjustment of the S-meter Level (S-9). Press the [D/MR(MW)] key three times. Press the [D/MR(MW)] key. TX Power (High) Rotate the DIL knob to set the alignment parameter to HP. Press the [D/MR(MW)] key to enable adjustment of the TX Power (High). Press the PTT switch to activate the transmitter, adjust the DIL knob so that the RF Power Meter reading is 50 W (±2.0W). Press the [D/MR(MW)] key. TX Power (Low 3) Rotate the DIL knob to set the alignment parameter to L3. Press the [D/MR(MW)] key to enable adjustment of the TX Power (Low 3). Press the PTT switch to activate the transmitter, adjust the DIL knob so that the RF Power Meter reading is 25 W (±1.5 W). Press the [D/MR(MW)] key. TX Power (Low 2) Rotate the DIL knob to set the alignment parameter to L2. Press the [D/MR(MW)] key to enable adjustment of the TX Power (Low 2). Press the PTT switch to activate the transmitter, adjust the DIL knob so that the RF Power Meter reading is 10 W (±1.0 W). Press the [D/MR(MW)] key. TX Power (Low 1) Rotate the DIL knob to set the alignment parameter to L1. Press the [D/MR(MW)] key to enable adjustment of the TX Power (Low 1). Press the PTT switch to activate the transmitter, adjust the DIL knob so that the RF Power Meter reading is 5 W (±0.5 W). Press the [D/MR(MW)] key. TX Deviation Inject a 1 khz, 50 mv signal from the udio Generator. Rotate the DIL knob to set the alignment parameter to du. Press the [D/MR(MW)] key to enable adjustment of the TX Deviation. Press the PTT switch to activate the transmitter, adjust the DIL knob so that the Deviation Meter reading is 4.2 khz (±0.1 khz) (EXP version: 4.5 khz ± 0.1 khz). Press the [D/MR(MW)] key. 11

12 lignment CTCSS TX Deviation Rotate the DIL knob to set the alignment parameter to Press the [D/MR(MW)] key to enable adjustment of the CTCSS TX Deviation. Press the PTT switch to activate the transmitter, adjust the DIL knob so that the Deviation Meter reading is 0.6 khz (±0.05 khz). Press the [D/MR(MW)] key. DCS TX Deviation Rotate the DIL knob to set the alignment parameter to dc. Press the [D/MR(MW)] key to enable adjustment of the DCS TX Deviation. Press the PTT switch to activate the transmitter, adjust the DIL knob so that the Deviation Meter reading is 0.6 khz (±0.05 khz). Press the [D/MR(MW)] key. Closing the lignment mode Press the [DW(REV)] key to save the new setting and exit to normal operation. 12

13 MIN Unit Circuit Diagram 4.3 V RX: 1.4 V TX: 1.7 V RX: 6.1 V TX: 4.2 V 4.1 V 3.2 V 2.0 V TX: RX: 0.5 V TX: 0.6 V TX: 6.9 V TX: 1.6 V TX: 0.8 V TX: 4.6 V RX: 6.9 V TX: 0.5 V 0.7 V 3.3 V TX: 2.0 V TX: 4.8 V TX: 1.4 V 1.4 V TX: 0.8 V TX: 3.1 V TX: 7.5 V TX: 3.1 V RX: TX: 4.5 V 2.3 V RX: 4.2 V TX: 0.3 V TX: 3.1 V RX: 2.9 V TX: 0.4 V 0 V TX: 4.9 V RX: 6.8 V TX: 0.5 V RX: 2.0 V TX: 0.7 V RX: 2.3 V TX: 0.1 V RX: 1.4 V TX: 1.7 V RX: 5.2 V TX: 0.6 V RX: 0.1 V TX: 0 V RX: 0.6 V TX: 0.5 V RX: 4.2 V TX: 0.5 V RX: 6.4 V TX: 0.5 V RX: 1.4 V TX: 0.1 V RX: 0.7 V TX: 0 V RX: 4.5 V TX: 0 V 3.8 V 4.8 V RX: 6.9 V TX: 0.5 V 1.9 V RX: 4.8 V TX: 0.2 V RX: 7.9 V TX: 0.5 V 2.0 V 4.8 V RX: 0.7 V TX: 0.4 V RX: 3.7 V TX: 0.3 V V RX: 1.9 V TX: 0.7 V 4.9 V RX: 1.7 V TX: 0.1 V RX: 0.8 V TX: 0 V RX: 5.4 V TX: 0 V RX: 1.4 V TX: 0.5 V 0.6 V RX: 0.9 V TX: 0 V RX: 2.5 V TX: 0.3 V RX: 1.4 V TX: 0.5 V RX: 2.5 V TX: 0.8 V RX: 2.6 V TX: 0.4 V RX: 2.5 V TX: 0 V TX: RX: 3.1 V TX: 0.5 V RX: 3.2 V TX: 0 V RX: 3.2 V TX: 0 V RX: 1.9 V TX: 0.7 V RX: 5.5 V TX: 0.5 V 2.0 V RX: 7.2 V TX: 4.5 V RX: 3.2 V TX: 0.2 V RX: 7.7 V TX: 0.5 V TX: 4.6 V RX: 1.9 V TX: 1.8 V RX: 0.6 V TX: 0.5 V RX: 2.1 V TX: 0 V RX: 3.0 V TX: 0 V RX: 2.1 V TX: 0.1 V RX: 6.8 V TX: 6.2 V RX: 2.1 V TX: 0 V RX: 2.1 V TX: 0 V 1.3 V TX: 4.3 V 1.9 V 1.9 V 1 Pin Q1028 RX V V 1.1 V 4.2 V 0.6 V V TX V 0.5 V 0.5 V V 0.1 V Q1043 Pin 2 RX: 0.7 V TX (LOW 1): 2.1 V (LOW TX 2): 2.5 V TX (LOW 3): 3.3 V TX (HIGH): 4.3 V RX: 2.2 V TX: 0 V RX: 1.9 V TX: 0 V RX: 1.9 V TX: 0 V RX: 3.4 V TX: 0 V TX: 3.8 V RX: 7.9 V TX: 0.5 V TX: 4.9 V V 0.7 V RX: 2.1 V TX: 0.7 V RX: 0.7 V TX: 0.1 V 8.0 V RX: 13.8 V TX: 12.4 V RX: 7.2 V TX: 8.0 V 0.7 V TX: 2.8 V RX: 0.1 V TX: 8.0 V RX: 7.8 V TX: 0.1 V RX: 7.8 V TX: 7.2 V TX: 8.0 V 4.6 V 4.1 V 3.0 V 13

14 MIN Unit Note 14

15 MIN Unit Parts Layout (Side ) R60H1317M1 (Q1030) KI7808PI (Q1015) L4425 (Q1035) 2S1774 (FR) (Q7) 2SJ562 (Q8) CD4094PWR (Q1048) M1501PFV1 (Q1011) NJM2591V (Q1028) 3SK296ZQ (ZQ) (Q1037, 1045) 2S154 (E) (Q1033) 2S400 (RT4) (Q1032) 2S617 (R) (Q1051, 1053) 2SC5226 (R22) (Q1026) 2SC5231 (C9) (Q9) 2SC5374 (N) (Q1010, 1017, 1023) C D E F G H I DTC124EE (25) (Q1052) DTC144EE (26) (Q3, 4, 1014) 5 D221 (26) (D1011, 1013, 1016) DN235E (M) (D1010)

16 MIN Unit Parts Layout (Side ) a 1 b c d e f g h i LM2904PWR (Q6, 1038, 1044, 1050) LM2902PWR (Q5, 1049) M62364FP (Q1043) 2S1774 (FR) (Q1024, 2027, 1029) 2SJ347 (KS) (Q1039) 2SJ364 (4M) (Q1034, 1036, 1041, 1042) 2S154 (E) (Q1, 1012, 1021, 1046, 1047) FMMTL718T (Q1025) DTC144EE (26) (Q1013, 1018, 1019, 1020, 1022, 1031, 1040) S-812C50U (Q1016) D221 (26) (D9) 1SS321 (F9) (D1022) DN222 (N) (D8, 1012, 1014, 1029, 1031)

17 MIN Unit Parts List REF C 1 C 2 C 3 C 4 C 5 C 6 C 7 C 8 C 9 C 1011 C 1012 C 1013 C 1014 C 1015 C 1016 C 1017 C 1018 C 1019 C 1020 C 1021 C 1022 C 1024 C 1025 C 1026 C 1027 C 1029 C 1030 C 1031 C 1032 C 1033 C 1034 C 1035 C 1036 C 1037 C 1038 C 1039 C 1040 C 1041 C 1042 C 1043 C 1044 C 1045 C 1046 C 1047 C 1048 C 1049 C 1050 C 1051 C 1052 C 1053 C 1054 C 1055 C 1056 C 1057 C 1059 C 1060 C 1061 C 1062 C 1063 C 1064 C 1065 C 1066 C 1067 C 1068 C 1069 C 1070 C 1071 C 1072 C 1073 C 1074 C 1075 C 1076 DESCRIPTION PC with Components Printed Circuit oard IP T.CP. IP T.CP. L.ELECTRO.CP. IP T.CP. IP T.CP. IP T.CP. IP T.CP. IP T.CP. IP T.CP. IP T.CP. L.ELECTRO.CP. L.ELECTRO.CP. VLUE 10uF 10uF 1uF pf 3300uF 0.5pF 15pF 0.22uF 0.22uF 3.3uF 0.047uF uF uF 4.7uF uF 22uF 18pF 20pF 1uF 1.5pF 10uF 10uF 47pF 47pF 47pF 15pF 0.022uF 0.015uF 150pF 560pF 10uF 10uF 47pF 5pF 5pF 5pF 7pF 47pF pf 10pF 1uF V/W TOL. F CK F CK MFR'S DESIG H023N000 TJ106M010Y TJ106M010Y GRM39103M25PT GRM188F11105Z01D GRM1882C1H101J01D GRM18811H102K01D RE3-332M 3300UF GRM1884C1HR50CZ01D GRM1882C1H150J01D GRM18811H102K01D GRM18811H102K01D GRM18811H102K01D GRM18811H102K01D TMCP1D224MTRF TMCP1D224MTRF TESVSP0J335M-8R GRM15511H102K01D GRM39473K16PT GRM15511H102K01D GRM39822M25PT GRM39822M25PT TJ475M016Y GRM39103M25PT GRM18811H272K01D TJ226M006Y GRM39103K25PT GRM18811H102K01D GRM18811H102K01D GRM18811H102K01D GRM18811H102K01D GRM18811H102K01D GRM18811H102K01D GRM1882C1H180J01D GRM1882C1H200JZ01D GRM18811H102K01D GRM188F11105Z01D GRM1884C1H1R5CZ01D GRM18811H102K01D TJ106M010Y GRM18811C104K01D GRM18811H102K01D GRM18811H102K01D TJ106M010Y GRM1882C1H470J01D GRM1882C1H470J01D GRM1882C1H470J01D GRM1882C1H150J01D GRM18811H102K01D GRM39223K25PT GRM39153K25PT GRM1882C1H151J01D GRM18811H561K01D RE2-MM GRM18811C104K01D GRM18811H102K01D GRM18811H102K01D RE2-MM GRM18811H102K01D GRM1882C1H470J01D GRM18811H102K01D GRM1882C1H5R0CZ01D GRM1882C1H5R0CZ01D GRM1882C1H5R0CZ01D GRM1882C1H7R0DZ01D GRM1882C1H470J01D GRM1882C1H101J01D GRM18811H102K01D GRM1882C1HJ01D GRM18810J105K01D GRM18811H102K01D GRM39103M25PT GRM18811H102K01D VXSTD P/N C C FR K78072 K78072 K K K K K K K K K K K K K K K K K K K K78072 K78072 K K K K K K K K K K K K K K K K K K K VERS. FT-1802M FT-1802E LOT SIDE LY DR g5 g5 g C7 D7 D7 D7 g2 C3 3 C3 C5 C5 C5 C5 D5 D5 D7 D7 D7 e5 e5 d6 d6 5 4 g5 g5 5 g5 C5 C5 C5 E7 17

18 MIN Unit Parts List REF C 1077 C 1078 C 1079 C 1080 C 1081 C 1082 C 1083 C 1084 C 1085 C 1086 C 1089 C 1090 C 1091 C 1092 C 1093 C 1094 C 1096 C 1098 C 1099 C 1101 C 1102 C 1103 C 1104 C 1105 C 1106 C 1107 C 1108 C 1109 C 1110 C 1111 C 1112 C 1113 C 1114 C 1115 C 1116 C 1117 C 1118 C 1119 C 1120 C 1121 C 1122 C 1123 C 1124 C 1125 C 1126 C 1127 C 1128 C 1129 C 1130 C 1131 C 1132 C 1133 C 1134 C 1135 C 1136 C 1137 C 1138 C 1139 C 1140 C 1141 C 1142 C 1143 C 1144 C 1145 C 1146 C 1147 C 1148 C 1149 C 1150 C 1151 C 1152 C 1153 C 1154 C 1155 C DESCRIPTION L.ELECTRO.CP. IP T.CP. L.ELECTRO.CP. L.ELECTRO.CP. L.ELECTRO.CP. VLUE 0.022uF 0.015uF 150pF 560pF uf 22pF 120pF 120pF 0.047uF 0.047uF uF 0.047uF 15pF 15pF 47pF 10uF 47pF 0.033uF 0.047uF 0.022uF 10uF 47pF 33pF 33pF 39pF 43pF 0.047uF 470uF uf 47pF V/W 1 TOL. R MFR'S DESIG GRM39223K25PT GRM39153K25PT GRM1882C1H151J01D GRM39561J25PT GRM18811H102K01D RC2-101M GRM18811H102K01D GRM18811H102K01D GRM1882C1H220J01D GRM39103M25PT GRM18811C104K01D GRM39103M25PT GRM1882C1H121J01D GRM39103M25PT GRM1882C1H121J01D GRM39473K16PT GRM39473K16PT GRM18811H472K01D GRM39473K16PT GRM18811H102K01D GRM18811H102K01D GRM18811H102K01D GRM18811H102K01D GRM1882C1H150J01D GRM18811H102K01D GRM18811H102K01D GRM1882C1H150J01D GRM18811H102K01D GRM18811H102K01D GRM18811C104K01D GRM39103M25PT GRM18811H102K01D GRM1882C1H470J01D TJ106M010Y GRM1882C1H470J01D GRM18811C104K01D GRM18811C104K01D GRM39103M25PT GRM188R11C333K01D GRM39473K16PT GRM39223K25PT GRM18811C104K01D RE2-MM GRM18811H102K01D GRM18811H102K01D GRM18811H102K01D GRM18811H102K01D GRM18811H102K01D GRM1882C1H470J01D GRM1882C1H330J01D GRM1882C1H330J01D GRM18811H102K01D GRM18811H102K01D GRM18811H102K01D GRM18811H102K01D GRM1882C1H390J01D GRM1882C1H430JZ01D GRM39473K16PT GRM18811H102K01D GRM18811H102K01D GRM18811C104K01D GRM18811H102K01D RE3-471M 470UF GRM18811C104K01D GRM18811H102K01D RC2-101M GRM1552C1H470JZ01D GRM18811H102K01D GRM18811H102K01D GRM15511H102K01D GRM18811H102K01D GRM15511H102K01D GRM18811H102K01D GRM15511H102K01D GRM18811H102K01D VXSTD P/N K K K K K K K K K K K K K K K K78072 K K K K K K K K K K K K K K VERS. LOT SIDE LY DR e6 e6 e6 e6 g4 f5 f4 a6 H5 e6 g4 g4 f5 f4 D4 f4 H6 a6 H6 H6 a4 a4 a4 2 F7 F6 F7 F6 F7 6 C3 C3 C3 E3 D3 h1 h1 h3 g6 4 g6 h6 7 F7 F6 F6 F7 c6 F7 F6 F7 F6

19 MIN Unit Parts List REF C 1157 C 1158 C 1161 C 1162 C 1163 C 1164 C 1165 C 1166 C 1167 C 1168 C 1170 C 1171 C 1173 C 1174 C 1175 C 1176 C 1177 C 1178 C 1179 C 1180 C 1181 C 1182 C 1183 C 1184 C 1185 C 1186 C 1187 C 1188 C 1189 C 1190 C 1191 C 1192 C 1193 C 1194 C 1196 C 1198 C 1199 C 1200 C 1201 C 1202 C 1204 C 1205 C 1206 C 1207 C 1208 C 1209 C 1210 C 1211 C 1212 C 1213 C 1214 C 1215 C 1216 C 1217 C 1218 C 1220 C 1221 C 1223 C 1225 C 1226 C 1227 C 1228 C 1230 C 1231 C 1232 C 1233 C 1236 C 1237 C 1239 C 1240 C 1241 C 1243 C 1244 C 1245 C 1248 DESCRIPTION L.ELECTRO.CP. IP T.CP. CERM CP. IP T.CP. IP T.CP. IP T.CP. VLUE 0.047uF 10uF 4.7uF 8pF 1pF 56pF 0.022uF 10uF 22pF 39pF 0.5pF 5pF 22uF 470pF 0.022uF uF 1uF 1uF 18pF 18pF 27pF 22pF 33pF 8pF uF 5pF 10uF 33pF 1pF 33pF 1pF 7pF 3pF 10pF 39pF V/W TOL. CK CK CK CK CJ MFR'S DESIG GRM39103M25PT GRM18811H102K01D GRM39473K16PT GRM18811H102K01D RE2-MM TJ475M016Y GRM18811H102K01D GRM39103M25PT GRM18811H102K01D GRM39103M25PT GRM1882C1H8R0DZ01D GRM1884C1H1R0CZ01D GRM18811C104K01D GRM1882C1H560J01D GRM39103M25PT GRM18811C104K01D GRM18811H102K01D GRM39223K25PT GRM15511H102K01D GRM18811H102K01D GRM15511H102K01D GRM18811H102K01D GRM15511H102K01D GRM18811H102K01D GRM15511H102K01D GRM18811H102K01D GRM18811H102K01D GRM39103M25PT GRM JPT TJ106M010Y GRM18811H102K01D GRM18811H102K01D GRM18811C104K01D GRM18811H102K01D GRM1882C1H220J01D GRM1882C1H390J01D GRM1884C1HR50Z01D GRM1882C1H5R0CZ01D GRM18811C104K01D GRM18811C104K01D TJ226M006Y GRM1882C1H471J01D GRM39223K25PT GRM18811H472K01D GRM18810J105K01D GRM18810J105K01D CF316180J500T CF316180J500T GRM1882C1H270J01D CF316220J500T GRM39103M25PT GRM18811H102K01D GRM39103M25PT GRM18811H102K01D GRM1882C1H330J01D GRM1882C1H8R0DZ01D GRM18811H102K01D GRM18811H102K01D GRM18811C104K01D GRM18811H562K01D GRM18811H102K01D GRM18811C104K01D GRM1882C1H5R0CZ01D TJ106M010Y GRM18811C104K01D GRM18811H102K01D CF316330J500T GRM2194C2D1R0CY21D CF316330J500T GRM2194C2D1R0CY21D CF316070D500T GRM1883C1H3R0CZ01D GRM18811H102K01D GRM1882C1HJ01D GRM1882C1H390J01D VXSTD P/N K K K K K K K K K78072 K K K K K K K K K K K K K K K K K K K78072 K K K K K K K K VERS. LOT SIDE LY DR E3 F3 d4 E3 F4 F4 F5 F5 F5 F5 g6 F7 F6 G7 G7 G7 G4 F3 G4 G4 F4 b4 F4 F5 G4 b4 g6 G3 G3 H4 G3 b4 b4 a4 a3 G4 c6 a6 a7 G2 H3 H2 H3 H2 a3 G4 H5 19

20 MIN Unit Parts List REF C 1249 C 1250 C 1251 C 1252 C 1253 C 1254 C 1255 C 1256 C 1257 C 1258 C 1259 C 1260 C 1261 C 1262 C 1263 C 1264 C 1265 C 1266 C 1267 C 1268 C 1270 C 1273 C 1274 C 1275 C 1276 C 1277 C 1278 C 1279 C 1280 C 1281 C 1282 C 1283 CD1 CF1 CF2 D 1 D 2 D 3 D 4 D 5 D 6 D 7 D 8 D 9 D 1010 D 1011 D 1012 D 1013 D 1014 D 1015 D 1016 D 1017 D 1018 D 1019 D 1020 D 1021 D 1022 D 1023 D 1024 D 1025 D 1026 D 1028 D 1029 D 1030 D 1031 F1 F2 F3 F4 F5 F6 F7 J 1 J 2 J 3 20 DESCRIPTION CERM CP. IP T.CP. CERM DISC CERM FILTER CERM FILTER SURGE SORER FERRITE EDS FERRITE EDS FERRITE EDS FERRITE EDS FERRITE EDS FERRITE EDS FERRITE EDS CONNECTOR CONNECTOR CONNECTOR VLUE 1pF 22pF 1pF 39pF uF 1uF 27pF 12pF pf 4pF 0.5pF 10uF 1uF 1uF 1uF 1uF uF uF 2.2uF V/W TOL. CK CK CK MFR'S DESIG GRM1884C1H1R0Z01D GRM1882C1H220J01D GRM1884C1H1R0Z01D GRM1882C1H390J01D GRM18811H102K01D GRM18811H102K01D GRM39103M25PT GRM18811H102K01D GRM39103M25PT GRM18811H222K01D GRM39103M25PT GRM18810J105K01D GRM18811H102K01D GRM1882C1H270J01D GRM18811H102K01D CF316120J500T GRM JPT GRM1882C1H101J01D GRM1882C1H4R0CZ01D GRM1884C1HR50Z01D TJ106M010Y GRM18810J105K01D GRM18810J105K01D GRM18810J105K01D GRM18810J105K01D GRM18811H222K01D GRM18811H562K01D GRM18811C104K01D GRM18811C104K01D GRM15511H102K01D GRM18811H102K01D GRM KE18D JT50C7 LFYM450G=K LFYM450F=K 1SS400 T1 HVC350-TRF P6K18 HSC277TRF HSC277TRF HVC350-TRF HVC350-TRF DN222 TL D221 TL DN235E TL D221 TL DN222 TL D221 TL DN222 TL EDZ TE D221 TL HVC350-TRF X157090HR X157090HR RLS135 TE-11 HVC350-TRF 1SS321 TE85R 1SS400 T1 HVC350-TRF HVC350-TRF 1SS400 T1 RLS135 TE-11 DN222 TL 1SS400 T1 DN222 TL SM SM SM SM SM K1608HS121-T K1608HS121-T SC25-02WS HSJ FLT-SM2-T(LF)(SN) VXSTD P/N K K K K K K K K K K K K K78072 K K K K K K K H H H G G Q G G G G G G G G G G G G G G G G G G G G G G G G G G G L L L L L L L P P P VERS. LOT SIDE LY DR H5 H5 H4 H5 H1 H1 H5 a3 H5 a6 a6 E7 g7 H5 H6 G7 F6 G7 H6 H5 g5 2 e6 a5 H5 a6 G3 G3 H4 a3 H5 H5 E7 H4 F h1 h1 3 1 F6

21 MIN Unit Parts List REF L 2 L 3 L 4 L 5 L 6 L 7 L 8 L 9 L 1010 L 1011 L 1012 L 1013 L 1014 L 1015 L 1016 L 1017 L 1018 L 1019 L 1020 L 1021 L 1022 L 1024 Q 1 Q 3 Q 4 Q 5 Q 6 Q 7 Q 8 Q 9 Q 1010 Q 1011 Q 1012 Q 1013 Q 1014 Q 1015 Q 1016 Q 1017 Q 1018 Q 1019 Q 1020 Q 1021 Q 1022 Q 1023 Q 1024 Q 1025 Q 1026 Q 1027 Q 1028 Q 1029 Q 1030 Q 1031 Q 1032 Q 1033 Q 1034 Q 1035 Q 1036 Q 1037 Q 1038 Q 1039 Q 1040 Q 1041 Q 1042 Q 1043 Q 1044 Q 1045 Q 1046 Q 1047 Q 1048 Q 1049 Q 1050 Q 1051 Q 1052 Q 1053 R 1 DESCRIPTION IP COIL IP COIL M.RFC M.RFC M.RFC M.RFC M.RFC M.RFC COIL M.RFC IP COIL COIL COIL IP COIL M.RFC COIL COIL COIL IP COIL IP COIL COIL IP COIL TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR FET TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR FET FET FET FET TRNSISTOR FET FET FET TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR VLUE 0.056uH 0.018uH 0.1uH 0.047uH 0.082uH 0.047uH 1uH 1uH 0.212uH 1uH 0.1uH 0.033uH 0.047uH 0.1uH 1uH 0.033uH 0.033uH 0.033uH 0.1uH 0.022uH 0.012uH 0.082uH 3.3k V/W TOL. MFR'S DESIG LQW2HN56NG03L LQW18N18NG00D TFL0816-N TFL TFL N TFL LK1608 1R0K-T LK1608 1R0K-T S N ELJ-ND1R0JF LQW18NR10G00D S5-33NK S NK LQW18NR10G00D ELJ-ND1R0JF S5-33NK S5-33NK S5-33NK LQW18NR10G00D LQW18N22NG00D S N LQW18N82NG00D 2S154-T11-1E DTC144EE TL DTC144EE TL LM2902PWR LM2904PWR 2S1774 TL R 2SJ562-TD 2SC5231C9-TL 2SC5374-TL M1501PFV1-G-ND-EF 2S154-T11-1E DTC144EE TL DTC144EE TL KI7808PI S-812C50U-C3E-T2 2SC5374-TL DTC144EE TL DTC144EE TL DTC144EE TL 2S154-T11-1E DTC144EE TL 2SC5374-TL 2S1774 TL R FMMTL718T 2SC TL 2S1774 TL R NJM2591V-TE1 2S1774 TL R R60H1317M1 DTC144EE TL 2S400-4-TL 2S154-T11-1E 2SJ364-Q(TX) L4425 2SJ364-Q(TX) 3SK296ZQ-TL LM2904PWR 2SJ347 TE85R DTC144EE TL 2SJ364-Q(TX) 2SJ364-Q(TX) M62364FP 600D LM2904PWR 3SK296ZQ-TL 2S154-T11-1E 2S154-T11-1E CD4094PWR LM2902PWR LM2904PWR 2S617 TL R DTC124EE TL 2S617 TL R RMC1/16S 332JTH VXSTD P/N L L L L L L L L L L L L L L L L L L L L L L G E G G G G G R G G I G G G E G G G G G G G G G E G G G R G G E G R G G R G G G D G E G Q G G Q G G G G G Q G Q G G G G E G E G G G G R G G R J VERS. LOT SIDE LY DR C5 f4 C3 F4 F5 F5 G3 H4 G4 G3 H2 H2 H5 H1 H4 g5 D7 e6 4 C5 d6 d6 5 g4 C5 d6 f5 f5 f4 f4 C2 b4 6 F5 b4 a7 g7 G4 b4 E7 h7 F6 F6 g5 21

22 MIN Unit Parts List REF R 2 R 3 R 4 R 5 R 6 R 7 R 8 R 1010 R 1011 R 1012 R 1013 R 1014 R 1015 R 1016 R 1017 R 1018 R 1019 R 1020 R 1021 R 1022 R 1023 R 1025 R 1026 R 1027 R 1028 R 1029 R 1030 R 1031 R 1032 R 1033 R 1034 R 1035 R 1036 R 1037 R 1038 R 1039 R 1040 R 1041 R 1042 R 1043 R 1044 R 1045 R 1046 R 1047 R 1048 R 1049 R 1050 R 1051 R 1052 R 1053 R 1054 R 1055 R 1056 R 1057 R 1058 R 1059 R 1060 R 1061 R 1062 R 1063 R 1064 R 1065 R 1066 R 1067 R 1068 R 1069 R 1070 R 1071 R 1072 R 1073 R 1075 R 1076 R 1077 R 1079 R DESCRIPTION VLUE k 12k k 1.8k 1.5k k 22k 220k k 15k 150k 0 68k 18k k 220k k 680 1k 22k k 390k 68k 470k 1k 470k 22k k 1M 390k 39k 220k 470k 330k 390k 390k k k k 0 390k 22k 2.2k 1k V/W TOL. MFR'S DESIG RMC1/16S 123JTH RMC1/16S 330JTH RMC1/16S 182JTH RMC1/16S 182JTH RMC1/16S 152JTH RMC1/16S 223JTH RMC1/16S 224JTH RMC1/16S 681JTH RMC1/16S 564JTH RMC1/16S 153JTH RMC1/16S 154JTH RMC1/16S JPTH RMC1/16S 683JTH RMC1/16S 183JTH RMC1/16S 224JTH RMC1/16S 471JTH RMC1/16S 332JTH RMC1/16S 681JTH RMC1/16S 102JTH RMC1/16S 223JTH RMC1/16S 681JTH RMC1/16S 220JTH RMC1/16S 220JTH RMC1/16S 394JTH RMC1/16S 394JTH RMC1/16S 683JTH RMC1/16S 474JTH RMC1/16S 102JTH RMC1/16S 474JTH RMC1/16S 223JTH RMC1/16S 105JTH RMC1/16S 394JTH RMC1/16S 393JTH RMC1/16S 224JTH RMC1/16S 474JTH RMC1/16S 334JTH RMC1/16S 394JTH RMC1/16S 394JTH RMC1/16S 471JTH RMC1/16S 222JTH RMC1/16S JPTH RMC1/16S 394JTH RMC1/16S 223JTH RMC1/16S 222JTH RMC1/16S 102JTH VXSTD P/N J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J VERS. LOT SIDE LY DR D7 d6 e5 d6 3 C5 C5 C5 C5 C5 e5 e5 e6 C5 C5 E7 E7 e6 e6 f5 f4 E7

23 MIN Unit Parts List R 1082 R 1083 R 1084 R 1085 R 1086 R 1087 R 1088 R 1089 R 1090 R 1091 R 1092 R 1093 R 1094 R 1095 R 1096 R 1097 R 1098 R 1099 R 1 R 1101 R 1102 R 1103 R 1104 R 1105 R 1106 R 1107 R 1108 R 1109 R 1110 R 1111 R 1112 R 1113 R 1114 R 1115 R 1116 R 1117 R 1118 R 1119 R 1120 R 1121 R 1122 R 1123 R 1124 R 1125 R 1126 R 1127 R 1128 R 1129 R 1130 R 1131 R 1133 R 1134 R 1135 R 1136 R 1137 R 1138 R 1139 R 1140 R 1141 R 1142 R 1143 R 1144 R 1145 R 1146 R 1147 R 1148 R 1149 R 1150 R 1152 R 1153 R 1154 R 1156 R 1157 R 1158 R 1159 DESCRIPTION VLUE 4.7k 2.2k 12k 2.2k 2.2k 2.2k 1k 2.7k k k 1k 5.6k k k k 330k k 330k k 1k 2.2k 33k 330k 4.7k 330k 4.7k 220k k 220k 82 39k 330k 330k 330k V/W 1/10W 1W 1W TOL. 10% MFR'S DESIG RMC1/16S 472JTH RMC1/16S 222JTH RMC1/16S 123JTH RMC1/16S 222JTH RMC1/16S 222JTH RMC1/16S 222JTH RMC1/16S 102JTH RMC1/16S 272JTH RMC1/16S 331JTH RMC1/16S 220JTH RMC1/16S 471JTH RMC1/16S 152JTH RMC1/16S 330JTH RMC1/16S 221JTH RMC1/16S 472JTH RMC1/16S 102JTH RMC1/16S 562JTH RMC1/16S 331JTH RMC1/16S 180JTH RMC1/16S 331JTH RMC1/16S 470JTH RMC1/16S 102JTH RMC1/16S 221JTH RMC1/16S 474JTH RMC1/16S 334JTH RMC1/16S 334JTH RMC1/10T 1R0J RMC1/16S JTH RMC1 R33KTE RMC1/16S JTH RMC1/16S 152JTH RMC1/16S 102JTH RMC1/16S 222JTH RMC1/16S 333JTH RMC1/16S 334JTH RMC1/16S 472JTH RMC1/16S 334JTH RMC1/16S 472JTH RMC1 101JTE RMC1/16S 224JTH RMC1/16S 224JTH RMC1/16S 820JTH RMC1/16S 393JTH RMC1/16S 334JTH RMC1/16S 334JTH RMC1/16S 334JTH VXSTD P/N J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J VERS. LOT SIDE LY DR d6 c6 e6 d6 e5 e6 f4 f4 f4 f4 C3 a6 a6 H6 a6 a4 C3 C3 C3 E3 b4 b4 i3 g6 6 g6 d4 F5 F5 g6 a7 G4 G4 b4 b4 F4 F4 F5 F4 F5 23

24 MIN Unit Parts List REF R 1160 R 1161 R 1162 R 1163 R 1164 R 1165 R 1166 R 1167 R 1168 R 1169 R 1170 R 1171 R 1172 R 1173 R 1174 R 1175 R 1177 R 1178 R 1179 R 1180 R 1181 R 1182 R 1183 R 1184 R 1185 R 1186 R 1187 R 1188 R 1189 R 1190 R 1191 R 1192 R 1193 R 1194 R 1195 R 1196 R 1197 R 1198 R 1199 R 1200 R 1201 R 1202 R 1203 R 1204 R 1205 R 1206 R 1208 R 1209 R 1210 R 1211 R 1212 R 1213 R 1214 R 1215 R 1216 R 1217 R 1218 R 1219 R 1220 R 1221 R 1222 R 1223 R 1224 R 1225 R 1226 R 1228 R 1229 R 1230 R 1231 R 1234 R 1235 R 1236 R 1237 R 1238 R DESCRIPTION VLUE 15k k 2.2M k 15k 220k 4.7k 47 k k k 2.7k 1k 33k 33k 33k 4.7k k 470k 2.2M 68k 4.7k 4.7k 68k 220k 0 330k 220k 330k 470k 330k 56k 4.7k 0 220k 220k 150k 2.2M 2.2k 0 22k 330k 220k 330k 68k 330k 330k 5.6k 4.7k 330k 22k 0 3.3k k 2.2k k 2.2k V/W TOL. 1% 1% % 1% 1% 1% MFR'S DESIG RMC1/16S 153JTH RMC1/16S 225JTH RMC1/16 103FTP RMC1/16 104FTP RMC1/16S 153JTH RMC1/16S 224JTH RMC1/16S 472JTH RMC1/16S 470JTH MCR01MZP800 RMC1/16S 474JTH RMC1/16S 272JTH RMC1/16S 102JTH RMC1/16S 333JTH MCR01MZPD3302 MCR01MZPD3302 RMC1/16S 472JTH MCR01MZPD3 MCR01MZPD4702 MCR01MZPD4703 RMC1/16S 225JTH RMC1/16 683FTP RMC1/16 472FTP RMC1/16 472FTP RMC1/16 103FTP RMC1/16S 683JTH RMC1/16S 224JTH RMC1/16S JPTH MCR01MZPD3303 MCR01MZPD2203 MCR01MZPD3303 MCR01MZPD4703 MCR01MZPD3303 MCR01MZPD5602 RMC1/16S 472JTH RMC1/16S JPTH RMC1/16S 224JTH RMC1/16S 224JTH RMC1/16S 154JTH RMC1/16S 225JTH RMC1/16S 222JTH RMC1/16S JPTH MCR01MZPD2202 MCR01MZPD2 RMC1/16S 334JTH RMC1/16S 224JTH RMC1/16S 334JTH RMC1/16S 683JTH RMC1/16S 334JTH RMC1/16S 334JTH RMC1/16S 562JTH RMC1/16S 472JTH RMC1/16S 334JTH RMC1/16S 223JTH RMC1/16S JPTH RMC1/16S 332JTH RMC1/16S 222JTH RMC1/16S 681JTH RMC1/16S 472JTH RMC1/16S 222JTH VXSTD P/N J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J VERS. LOT SIDE LY DR a7 g7 g7 g7 b4 a4 G4 G4 G4 G4 G4 b4 b4 a7 a7 a7 g7 g7 h7 h7 h7 h7 h7 h7 a3 I4 H5 H5 E7 a3

25 MIN Unit Parts List REF R 1240 R 1241 R 1242 R 1243 R 1244 R 1245 R 1246 R 1247 R 1248 R 1249 R 1250 TH1 TH2 X 1 XF1 XF2 DESCRIPTION THERMISTOR THERMISTOR XTL S-6 XTL FILTER XTL FILTER SHIELD CSE VLUE 4.7k 22k 22k 150k k 0 470k 22k 22k 21.25MHz 21.7MHz 21.7MHz V/W TOL. MFR'S DESIG RMC1/16S 472JTH RMC1/16S 223JTH RMC1/16S 223JTH RMC1/16S 154JTH RMC1/16S JPTH RMC1/16S 474JTH RMC1/16S 223JTH RMC1/16S 223JTH ERTJ1VV473J ERTJ1VV473J MHZ 21R MHZ 21R MHZ VXSTD P/N J J J J J J J J G G H H H R VERS. LOT SIDE LY DR a6 E7 E7 F6 F6 E7 E3 F5 F5 1-25

26 MIN Unit Note 26

27 CNTL Unit Circuit Diagram 8.0 V 3.4 V 2.3 V 2.6 V 2.6 V RX: 4.8 V TX: 0.6 V RX: 4.8 V TX: 0.6 V 3.9 V 2.5 V 4.8 V 1.8 V 3.6 V 4.0 V 3.6 V 4.6 V Pin J2003 RX 4.6 V 1.9 V 3.0 V 1.1 V 3.2 V 4.9 V 8.0 V 0.6 V V V 3.1 V TX 4.6 V 1.8 V 3.0 V 0.6 V 4.9 V 8.0 V V V 3.1 V RX: 13.1 V TX: 11.9 V 4.9 V RX: 13.8 V TX: 12.6 V RX: 4.9 V TX: 4.5 V 1.2 V 5.6 V 0.6 V 27

28 CNTL Unit Parts Layout (Side ) C D E F G H I 1 CPH6202 (C) (Q2005) DTC143ZE (E23) (Q2004) 2S617 (R) (Q2007, 2008, 2013) 2SC5374 (N) (Q2003) D4830FVE (Q2011) S-812C50U (Q2010) DTC143ZE (E23) (Q2012) D221 (26) (D2001, 2025) DN222 (N) (D2023) 2 3 (Side ) C D E F G H I (Side ) H4F2266TF13 (Q2002) 28 R24L64 (Q2006)

29 CNTL Unit Parts List REF C 2001 C 2002 C 2003 C 2004 C 2005 C 2006 C 2007 C 2008 C 2009 C 2010 C 2011 C 2012 C 2013 C 2015 C 2016 C 2017 C 2018 C 2019 C 2020 C 2021 C 2022 C 2023 C 2024 C 2025 C 2026 C 2027 C 2028 C 2029 C 2030 C 2031 C 2032 C 2033 C 2034 C 2035 C 2036 C 2037 C 2038 C 2039 C 2040 C 2041 C 2042 C 2043 C 2044 C 2045 C 2046 C 2047 C 2048 C 2049 C 2050 C 2051 C 2052 C 2053 C 2054 C 2055 C 2056 C 2057 C 2058 C 2059 C 2060 C 2061 D 2001 D 2002 D 2003 D 2004 D 2005 D 2006 D 2007 D 2008 DESCRIPTION PC with Components Printed Circuit oard IP T.CP. IP T.CP. IP T.CP. IP T.CP. L.ELECTRO.CP. L.ELECTRO.CP. L.ELECTRO.CP. LED LED LED LED LED LED LED VLUE pf pf 6pF 18pF 18pF pf 0.047uF 0.022uF 1uF 1uF 0.047uF uF 10uF uF 4.7uF 1uF 10uF 22uF 10uF 47uF 1uF 1uF 1uF uf V/W TOL. F MFR'S DESIG H023N000 GRM15511H102K01D GRM15511H102K01D GRM15511H102K01D GRM15511H102K01D GRM15511H102K01D GRM1552C1H101JD01D GRM1552C1H101JD01D GRM36103K16PT GRM36103K16PT GRM36104K10PT GRM36104K10PT GRM36104K10PT GRM1552C1H6R0DZ01D GRM1552C1H180JZ01D GRM1552C1H180JZ01D GRM36103K16PT GRM36104K10PT GRM36104K10PT GRM1552C1H101JD01D GRM36473K10PT GRM36223K16PT GRM15511H102K01D GRM18810J105K01D GRM36104K10PT GRM18810J105K01D GRM36473K10PT GRM36103K16PT GRM36472K25PT GRM15511H102K01D TJ106M010Y GRM36103K16PT GRM36103K16PT GRM36103K16PT GRM36472K25PT GRM36103K16PT TESVSP0J475M-8R GRM36103K16PT GRM18810J105K01D TJ106M010Y GRM15511H102K01D GRM36103K16PT GRM36103K16PT TJ226M006Y GRM15511H102K01D RV4-MD46-RR2 GRM36103K16PT RV4-470MF46-RR2 GRM188F11105Z01D GRM18810J105K01D GRM15511H102K01D GRM15511H102K01D GRM15511H102K01D GRM18810J105K01D GRM15511H102K01D ECEV1C101WP GRM36104K10PT GRM36104K10PT GRM18811C104K01D GRM15511H102K01D GRM15511H102K01D D221 TL SML-512WWT86 SML-512WWT86 SML-512WWT86 SML-512WWT86 SML-512WWT86 SML-512WWT86 SML-512WWT86 VXSTD P/N C C C C C C FR K K K K K K K K K K K K K K K K K K K K K K K78072 K K K K K K K K K78072 K K K K K K K K K K K K G G G G G G G G VERS. LOT SIDE LY DR FT-1802M 2 FT-1802M 1 FT-1802M 3 FT-1802E 1 FT-1802E 2 FT-1802M 3 1 i2 i2 1 h2 i2 f1 f1 b1 f2 f2 f2 e2 e2 e1 2 2 e2 d1 a2 a2 a1 a1 a1 a1 h2 h2 e2 a2 a2 a2 a2 a1 a1 h2 h2 e2 d1 b1 h1 d1 d1 e2 G1 G1 f1 C1 D1 E1 F1 G1 G1 C2 29

30 CNTL Unit Parts List REF D 2009 D 2010 D 2011 D 2012 D 2013 D 2014 D 2015 D 2016 D 2017 D 2018 D 2019 D 2020 D 2022 D 2023 D 2025 D 2026 D 2027 DS2001 F2001 F2002 F2003 F2004 F2005 F2006 J 2001 J 2002 J 2003 J 2004 L 2001 L 2002 Q 2002 Q 2003 Q 2004 Q 2005 Q 2006 Q 2007 Q 2008 Q 2010 Q 2011 Q 2012 Q 2013 R 2003 R 2004 R 2005 R 2006 R 2007 R 2008 R 2009 R 2010 R 2011 R 2012 R 2013 R 2014 R 2015 R 2016 R 2017 R 2018 R 2019 R 2020 R 2021 R 2022 R 2023 R 2024 R 2025 R 2026 R 2027 R 2028 R 2030 R 2031 R 2032 R 2033 R 2034 R 2036 R 2037 R DESCRIPTION LED LED LED LED LED LCD FERRITE EDS FERRITE EDS FERRITE EDS FERRITE EDS FERRITE EDS FERRITE EDS CONNECTOR CONNECTOR CONNECTOR CONNECTOR M.RFC M.RFC TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR TRNSISTOR VLUE V/W TOL. 150uH 1uH 220k 220k 1k 1k 1k 22k k 1M 33k 22k k 1k 1k 68k 390k 1k k k 6.8k 1W MFR'S DESIG SML-512WWT86 SML-512WWT86 1SS400 T1 1SS400 T1 SML-512WWT86 SML-512WWT86 SML-512WWT86 1SS400 T1 1SS400 T1 1SS400 T1 1SS400 T1 1SS400 T1 1SS400 T1 DN222 TL D221 TL 1SS400 T1 015Z3.3X-TPH3 H023N 15015X K1608HS121-T K1608HS121-T K1608HS121-T K1608HS121-T K1608HS121-T K1608HS121-T MJD0606KX06L FLT-SM2-T(LF)(SN) XK6F14345YJ FLC32T-151J LK1608 1R0K-T H4F2266TF13 2SC5374-TL DTC143ZE TL CPH6202-TL R24L64F-WE2 2S617 TL R 2S617 TL R S-812C50U-C3E-T2 D4830FVE-TR DTC143ZE TL 2S617 TL R RMC1/16S 224JTH RMC1/16S 224JTH RMC1/16S 102JTH RMC1/16S 102JTH RMC1/16S 102JTH RMC1/16S 223JTH RMC1/16S 105JTH RMC1/16S 333JTH RMC1/16S 223JTH RMC1/16S 102JTH RMC1/16S 102JTH MCR01MZP802 MCR01MZPD3903 MCR01MZPD2 RMC1/16S 102JTH RMC1 JTE RMC1/16S JPTH RMC1/16S 224JTH RMC1/16S 682JTH VXSTD P/N G G G G G G G G G G G G G G G G G L L L L L L P P P P L L G G G G G R G R G G G G R J J J J J J J J J J J J J J J J24305 J J J VERS. LOT SIDE LY DR D2 E2 d1 d1 F2 G2 H2 d1 F1 F1 F1 H2 h2 h2 E1 i2 i2 i2 i2 i2 i2 2 c1 c2 g2 d1 e2 2 H2 d1 a1 a2 a2 i2 b1 b1 D1 D1 D1 f2 f2 f2 F1 G1 G1 c1 2 D1 D2 D2 c1 c1 e2 e2 2 H2 H2 H2 I2 H2 a1 a2 : Please contact VERTEX STNDRD

31 CNTL Unit Parts List REF R 2039 R 2040 R 2041 R 2042 R 2043 R 2044 R 2045 R 2046 R 2047 R 2048 R 2049 R 2050 R 2051 R 2052 R 2053 R 2054 R 2055 R 2056 R 2057 R 2058 R 2059 R 2060 R 2061 R 2062 R 2063 R 2064 R 2065 R 2066 R 2067 R 2068 R 2069 R 2070 R 2071 R 2072 R 2073 R 2074 R 2075 R 2076 R 2077 R 2078 R 2079 R 2080 R 2081 R 2082 R2001 R2002 R2003 R2004 R2005 R2006 R2007 S 2001 VR2001 VR2002 X 2001 DESCRIPTION LOCK RES. LOCK RES. LOCK RES. LOCK RES. LOCK RES. LOCK RES. LOCK RES. ROTRY ENCODER POT. POT. XTL XPFEGC VLUE 68k 220k 6.8k 68k 68k 1.5k 3.3k 3.3M 1.8M 68k 1.5k 3.3k 1M 1M 1M 27k 15k 2.2k 2.2k k 390k 470k 470k 15k 470k 15k 470 k k 220k 1k 220k 4.7k MHz V/W TOL. MFR'S DESIG RMC1/16S 683JTH RMC1/16S 224JTH RMC1/16S 682JTH RMC1/16S 683JTH RMC1/16S 683JTH RMC1/16S 152JTH RMC1/16S 332JTH RMC1/16S 335JTH RMC1/16S 185JTH RMC1/16S 683JTH RMC1/16S 152JTH RMC1/16S 332JTH RMC1/16S 105JTH RMC1/16S 105JTH RMC1/16S 105JTH RMC1/16S 273JTH RMC1/16S 153JTH RMC1/16S 222JTH RMC1/16S 222JTH RMC1/16S 221JTH RMC1/16S 220JTH RMC1/16S 223JTH RMC1/16S 394JTH RMC1/16S 474JTH RMC1/16S 474JTH RMC1/16S 153JTH RMC1/16S 474JTH RMC1/16S 153JTH RMC1/16S 471JTH RMC1/16S 224JTH RMC1/16S 102JTH RMC1/16S 224JTH RMC1/16S 472JTH MNR04M0J102 MNR04M0J102 MNR04M0J102 MNR04M0J102 MNR04M0J102 MNR04M0J102 MNR04M0J102 EC12E WH K 25/5 WH K 25/ MHZ VXSTD P/N J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J J Q J J H VERS. LOT LY DR a2 a2 a1 a1 a1 a1 a1 e2 a2 a2 a2 f2 h2 h2 h2 i2 d1 h2 h2 h1 i2 f1 b1 d1 d1 h2 i2 i2 i2 F1 F1 F1 f1 c1 a1 a1 e2 e2 e2 e2 d1 I2 1 1 e2 31