TEST SUMMARY Seite 2 von 31. Prüfbericht - Nr.: Test Report No ANTENNA REQUIREMENT RESULT: Pass

Transcription

1

2 Prüfbericht - Nr.: Test Report No. Seite 2 von 31 Page 2 of 31 TEST SUMMARY ANTENNA REQUIREMENT RESULT: Pass PEAK OUTPUT POWER RESULT: Pass DB BANDWIDTH RESULT: Pass FREQUENCY STABILITY RESULT: Pass % BANDWIDTH RESULT: Pass DB BANDWIDTH RESULT: Pass POWER SPECTRAL DENSITY RESULT: Pass SPURIOUS EMISSION RESULT: Pass CONDUCTED EMISSIONS RESULT: Pass

3 Prüfbericht - Nr.: Test Report No. Seite 3 von 31 Page 3 of 31 CONTENTS 1. GENERAL REMARKS COMPLEMENTARY MATERIALS TEST SITES TEST FACILITIES LIST OF TEST AND MEASUREMENT INSTRUMENTS TRACEABILITY CALIBRATION MEASUREMENT UNCERTAINTY LOCATION OF ORIGINAL DATA STATUS OF FACILITY USED FOR TESTING GENERAL PRODUCT INFORMATION PRODUCT FUNCTION AND INTENDED USE RATINGS AND SYSTEM DETAILS INDEPENDENT OPERATION MODES NOISE GENERATING AND NOISE SUPPRESSING PARTS SUBMITTED DOCUMENTS TEST SET-UP AND OPERATION MODES PRINCIPLE OF CONFIGURATION SELECTION TEST OPERATION AND TEST SOFTWARE SPECIAL ACCESSORIES AND AUXILIARY EQUIPMENT COUNTERMEASURES TO ACHIEVE ERM COMPLIANCE TEST SETUP DIAGRAM TEST RESULTS TRANSMITTER REQUIREMENT & TEST SUITES Antenna Requirement Peak Output Power dB Bandwidth Frequency Stability % Bandwidth dB Bandwidth Power spectral density Spurious Emission Conducted emissions PHOTOGRAPHS OF THE TEST SET-UP LIST OF TABLES LIST OF PHOTOGRAPHS... 31

4 Prüfbericht - Nr.: Test Report No. Seite 4 von 31 Page 4 of General Remarks 1.1 Complementary Materials All attachments are integral parts of this test report. This applies especially to the following appendixes: Appendix A: Test data of 5G Wi-Fi. 2. Test Sites 2.1 Test Facilities EMTEK (Shenzhen) Co., Ltd. (FCC Registration No.: ) (Test site Industry Canada No.: 4480A-2) Bldg 69, Majialong Industry Zone, Nanshan District, Shenzhen, Guangdong, P.R. China The tests at the test site have been conducted under the supervision of a TÜV engineer.

5 Prüfbericht - Nr.: Test Report No. Seite 5 von 31 Page 5 of List of Test and Measurement Instruments Table 1: List of Test and Measurement Equipment Kind of Equipment Manufacturer Type S/N Calibrated until Transmitter spurious emissions EMI Test Receiver Rohde & Schwarz ESU Loop Antenna Schwarzbeck FMZB Cable H+B 3M SF / Cable H+B 6M SF / Pre-Amplifier HP 8447F 2944A Bilog Antenna Schwarzbeck VULB Cable Schwarzbeck AK9513 ACRX Cable Rosenberger N/A FP2RX Cable Schwarzbeck AK9513 CRPX Cable Schwarzbeck AK9513 CRRX Pre-Amplifier A.H. PAM Horn Antenna Schwarzbeck BBHA Pre-Amplifier A.H. PAM Horn Antenna Schwarzbeck BBHA 9170 BBHA EMI Test Receiver Rohde & Schwarz FSV K AP Pre-Amplifier Lunar EM LNA26G40-40 J Horn Antenna AHS/USA SAS Cable H+B 0.5M SF / Cable H+B 3M SF / Cable H+B 6M SF / Radio Spectrum Test EMI Test Receiver Rohde & Schwarz ESCI Vector Signal Generater Agilent N5182B My Analog Signal Generator Agilent N5171B My Signal Analyzer Agilent N9010A My Power Meter Agilent PS-X N/A Temp. / Humidity Chamber Kingson THS-M Conducted Emission Test Receiver Rohde & Schwarz ESCS / L.I.S.N. Schwarzbeck NNLK Pulse Limiter Rohde & Schwarz ESH3-Z Voltage Probe Rohde & Schwarz TK9416 N/A

6 Prüfbericht - Nr.: Test Report No. Seite 6 von 31 Page 6 of Traceability All measurement equipment calibrations are traceable to NIST or where calibration is performed outside the United States, to equivalent nationally recognized standards organizations. 2.4 Calibration Equipment requiring calibration is calibrated periodically by the manufacturer or according to manufacturer s specifications. Additionally all equipment is verified for proper performance on a regular basics using in house standards or comparisons. 2.5 Measurement Uncertainty Table 2: Measurement Uncertainty Parameter Uncertainty Radio Frequency ±1x10^-5 Maximum Peak Output Power Test ±1.0dB Conducted Emissions Test ±2.0dB Radiated Emission Test ±2.0dB Power Density ±2.0dB Occupied Bandwidth Test ±1.0dB Band Edge Test ±3dB All emission, radiated ±3dB Antenna Port Emission ±3dB Temperature ±0.5 Humidity ±3% 2.6 Location of Original Data The original copies of all test data taken during actual testing were retained in the TÜV Rheinland (Shenzhen) file for certification follow-up purposes.

7 Prüfbericht - Nr.: Test Report No. Seite 7 von 31 Page 7 of Status of Facility Used for Testing EMTEK (Shenzhen) Co., Ltd. test facility located at Bldg 69, Majialong Industry Zone, Nanshan District, Shenzhen, Guangdong, P.R. China is listed on the US Federal Communications Commission list of facilities approved to perform measurements.

8 Prüfbericht - Nr.: Test Report No. Seite 8 von 31 Page 8 of General Product Information 3.1 Product Function and Intended Use The EUTs are Window 10" tablet with Wi-Fi, Bluetooth function. All models are identical except the model name. The EUTs have two antennas, two antennas cannot transmitter simultaneously. For details refer to the User Manual and Circuit Diagram. 3.2 Ratings and System Details Table 3: Technical Specification of EUT Technical Specification Value Kind of Equipment Insignia Flex Window 10" Tablet with Keyboard Type Designation NS-P10W8100, NS-P10W8100-C, xxxxxxp10w81xxxxxx, NB1028-IJ (x=0-9, A-Z, a-z, - or blank, for market purpose only) FCC ID XMF-NB1028 IC NB1028 HVIN NS-P10W8100 Operating Frequency band MHz, MHz Extreme Temperature Range 0~+45 Operation Voltage DC 3.7V, 6800mAh via built-in lithium-ion battery DC 5V via AC/DC adapter Antenna Gain Ant1: 1.32dBi, Ant2: 1.32dBi Table 4: Technical Specification of 5GHz, a/n Operating mode(s) / WiFi IEEE a IEEE n HT20 IEEE n HT40 Test modulation OFDM (BPSK, QPSK, OFDM (BPSK, QPSK, OFDM (BPSK, QPSK, 16-QAM, 64-QAM) 16-QAM, 64-QAM) 16-QAM, 64-QAM) Transmit Frequency Range (MHz) , , , Channel Number Data Rate (Mbps) 6, 9, 12, 18, 24, 36, 48, 54 MCS0 ~ MCS7 MCS0 ~ MCS7 Output Power Setting level Remark: Reduce power setting of g/n due to power setting of SAR and retest Peak output power.

9 Prüfbericht - Nr.: Test Report No. Seite 9 von 31 Page 9 of 31 Table 5: Technical Specification of 5GHz, ac Operating mode(s) / WiFi Test modulation IEEE ac VHT20 IEEE ac VHT40 IEEE ac VHT80 OFDM (BPSK, QPSK, 16-QAM, 64-QAM, 256-QAM) , OFDM (BPSK, QPSK, 16-QAM, 64-QAM, 256-QAM) , OFDM (BPSK, QPSK, 16-QAM, 64-QAM, 256-QAM) Transmit Frequency Range (MHz) 5210, 5775 Channel Number Data Rate (Mbps) MCS0 ~ MCS8 MCS0 ~ MCS9 MCS0 ~ MCS9 Output Power Setting level Remark: Reduce power setting of g/n due to power setting of SAR and retest Peak output power. Table 6: List of WLAN Channel of 5GHz a/n a n HT n HT40 Channel Number Frequency (MHz) Channel Number Frequency (MHz) Channel Number Frequency (MHz)

10 Prüfbericht - Nr.: Test Report No. Seite 10 von 31 Page 10 of 31 Table 7: List of WLAN Channel of 5GHz ac ac VHT ac VHT ac VHT80 Channel Number Frequency (MHz) Channel Number Frequency (MHz) Channel Number Frequency (MHz) Independent Operation Modes The basic operation modes are: A. On, Wi-Fi mode 1. Transmitting a a b n HT20 c n HT40 d ac VHT20 e ac VHT40 f ac VHT80 B. Standby C. Off 3.4 Noise Generating and Noise Suppressing Parts Refer to the Circuit Diagram. 3.5 Submitted Documents - Bill of Material - Circuit Diagram - Constructional Drawing - Instruction Manual - PCB Layout - Rating Label - Photo Document

11 Prüfbericht - Nr.: Test Report No. Seite 11 von 31 Page 11 of Test Set-up and Operation Modes 4.1 Principle of Configuration Selection The equipment under test (EUT) was configured to measure its maximum power level. The test modes were adapted accordingly in reference to the instructions for use. 4.2 Test Operation and Test Software Test operation refers to test setup in chapter 5. All testing were performed according to the procedures in ANSI C63.10: Special Accessories and Auxiliary Equipment The EUT was tested together with the following accessories: Description Manufacturer Part No. Rating SHENZHEN AC/DC Adapter TEKA TEKA024- Input: AC V, 50/60Hz, 0.7A; TECHNOLOGY UK Output: DC 5V, 3.0A CO., LTD. 4.4 Countermeasures to Achieve ERM Compliance The test sample which has been tested contained the noise suppression parts as described in the Technical Construction File (TCF). No additional measures were employed to achieve compliance.

12 Prüfbericht - Nr.: Test Report No. Seite 12 von 31 Page 12 of Test Setup Diagram Diagram of Measurement Configuration for Radiation Test of below 1GHz Diagram of Measurement Configuration for Radiation Test of above 1GHz

13 Prüfbericht - Nr.: Test Report No. Seite 13 von 31 Page 13 of 31 Diagram of Measurement Equipment Configuration for Conduction Measurement Diagram of Measurement Equipment Configuration for Transmitter Measurement

14 Prüfbericht - Nr.: Test Report No. Seite 14 von 31 Page 14 of Test Results 5.1 Transmitter Requirement & Test Suites Antenna Requirement RESULT: Pass Test standard : FCC Part (b)(4) & FCC Part RSS-Gen Clause 8.3 Limit The use of antennas with directional gains that do not exceed 6dBi According to the manufacturer declared, the EUT has an internal antenna, the directional gain of antenna is 1.32dBi, and the antenna connector is designed with permanent attachment and no consideration of replacement. Therefore the EUT is considered sufficient to comply with the provision.

15 Prüfbericht - Nr.: Test Report No. Seite 15 von 31 Page 15 of Peak Output Power RESULT: Pass Test date : Test standard : FCC Part (a)(1)(iv) FCC Part (a)(3) RSS-247 clause 6.2.1(1) RSS-247 clause 6.2.4(1) Basic standard : ANSI C63.10: 2013 Limit : 23dBm for FCC, * Max e.i.r.p.<200mw (23dBm) ( MHz) *200 mw (23dBm) or 10 dbm + 10 logb, where B is the 99% emission bandwidth in MHz, where is lesser. Max conducted output power <1W (30dBm) ( MHz) Kind of test site : Shielded room Test setup Test Channel : Low/ Middle/ High Operation Mode : A.1 Ambient temperature : 25 Relative humidity : 50% Atmospheric pressure : 101kPa Table 8: Test result of Peak Output Power of Band U-NII-1 Mode Channel Frequency Peak Output Power (dbm) (MHz) ANT1 ANT2 Limit (dbm) a n HT n HT ac VHT ac VHT ac VHT

16 Prüfbericht - Nr.: Test Report No. Seite 16 von 31 Page 16 of 31 Table 9: Test result of Peak Output Power of Band U-NII-3 Mode Channel Frequency Peak Output Power (dbm) (MHz) ANT1 ANT2 Limit (dbm) a n HT n HT ac VHT ac VHT ac VHT

17 Prüfbericht - Nr.: Test Report No. Seite 17 von 31 Page 17 of dB Bandwidth RESULT: Pass Date of testing : Test standard : FCC Part (a)(5) Basic standard : ANSI C63.10: 2013 Kind of test site : Shielded room Test setup Test Channel : Low/ Middle/ High Operation Mode : A.1 Ambient temperature : 25 Relative humidity : 50% Atmospheric pressure : 101kPa Table 10: Test result of 26dB Bandwidth Band U-NII-1 Mode Channel Frequency 26dB Bandwidth (MHz) (MHz) ANT1 ANT2 Limit (MHz) N/A a N/A N/A N/A n HT N/A N/A n HT N/A N/A N/A ac VHT N/A N/A ac VHT N/A N/A ac VHT N/A

18 Prüfbericht - Nr.: Test Report No. Seite 18 von 31 Page 18 of 31 Table 11: Test result of 26dB Bandwidth of Band U-NII-3 Mode Channel Frequency 26dB Bandwidth (MHz) (MHz) ANT1 ANT2 Limit (MHz) N/A a N/A N/A N/A n HT N/A N/A n HT N/A N/A N/A ac VHT N/A N/A ac VHT N/A N/A ac VHT N/A

19 Prüfbericht - Nr.: Test Report No. Seite 19 von 31 Page 19 of Frequency Stability RESULT: Date of testing : Test standard : FCC Part (g) RSS-Gen Clause 6.11 Basic standard : ANSI C63.10:2013 Limits : Within assigned bands Kind of test site : Shielded room Pass Test setup Test Channel : Low/ Middle/ High Operation Mode : A.1 Ambient temperature : 25 Relative humidity : 50% Atmospheric pressure : 101kPa Table 12: Test result of Frequency Stability Band U-NII-1 Frequency 5180MHz Voltage (Vac) Temperature ( C) Measured Frequency(MHz) Frequency deviation(khz) ANT ANT ANT1 ANT2 ANT1 ANT ppm Frequency 5240MHz Voltage (Vac) Temperature ( C) Measured Frequency(MHz) Frequency deviation(khz) ANT ANT ANT1 ANT2 ANT1 ANT ppm

20 Prüfbericht - Nr.: Test Report No. Seite 20 von 31 Page 20 of 31 Table 13: Test result of Frequency Stability Band U-NII-3 Frequency 5745MHz Voltage (Vac) Temperature ( C) Measured Frequency(MHz) Frequency deviation(khz) ANT ANT ANT1 ANT2 ANT1 ANT ppm Frequency 5825MHz Voltage (Vac) Temperature ( C) Measured Frequency(MHz) Frequency deviation(khz) ANT ANT ANT1 ANT2 ANT1 ANT ppm

21 Prüfbericht - Nr.: Test Report No. Seite 21 von 31 Page 21 of % Bandwidth RESULT: Pass Date of testing : Test standard : RSS-Gen clause 6.6 Basic standard : ANSI C63.10: 2013 Kind of test site : Shielded room Test setup Test Channel : Low/ Middle/ High Operation Mode : A.1 Ambient temperature : 25 Relative humidity : 50% Atmospheric pressure : 101kPa Table 14: Test result of 99% Bandwidth Band U-NII-1 Mode Channel Frequency 99% Bandwidth (MHz) (MHz) ANT1 ANT2 Limit (MHz) N/A a N/A N/A N/A n HT N/A N/A n HT N/A N/A N/A ac VHT N/A N/A ac VHT N/A N/A ac VHT N/A

22 Prüfbericht - Nr.: Test Report No. Seite 22 von 31 Page 22 of 31 Table 15: Test result of 99% Bandwidth of Band U-NII-3 Mode Channel Frequency 99% Bandwidth (MHz) (MHz) ANT1 ANT2 Limit (MHz) N/A a N/A N/A N/A n HT N/A N/A n HT N/A N/A N/A ac VHT N/A N/A ac VHT N/A N/A ac VHT N/A

23 Prüfbericht - Nr.: Test Report No. Seite 23 von 31 Page 23 of dB Bandwidth RESULT: Pass Date of testing : Test standard : FCC Part (e) RSS-247 clause 6.2.4(1) Basic standard : ANSI C63.10: 2013 Limit : 500kHz for 6dB bandwidth Kind of test site : Shielded room Test setup Test Channel : Low/ Middle/ High Operation Mode : A.1 Ambient temperature : 25 Relative humidity : 50% Atmospheric pressure : 101kPa Table 16: Test result of 6dB Bandwidth Band U-NII-1 Mode Channel Frequency 6dB Bandwidth (MHz) (MHz) ANT1 ANT2 Limit (MHz) a n HT n HT ac VHT ac VHT ac VHT

24 Prüfbericht - Nr.: Test Report No. Seite 24 von 31 Page 24 of 31 Table 17: Test result of 6dB Bandwidth of Band U-NII-3 Mode Channel Frequency 6dB Bandwidth (MHz) (MHz) ANT1 ANT2 Limit (MHz) a n HT n HT ac VHT ac VHT ac VHT

25 Prüfbericht - Nr.: Test Report No. Seite 25 von 31 Page 25 of Power spectral density RESULT: Pass Date of testing : Test standard : FCC Part (a)(1)(iv) FCC Part (a)(3) RSS-247 clause 6.2.1(1) RSS-247 clause 6.2.4(1) Basic standard : ANSI C63.10: 2013 Limit : <11dBm/MHz ( MHz); <30dBm/500KHz ( MHz) e.i.r.p. spectral density <10dBm/MHz ( MHz) <30dBm/500KHz ( MHz) Kind of test site : Shield room Test setup Test Channel : Low/ Middle/ High Operation mode : A.1 Ambient temperature : 25 Relative humidity : 50% Atmospheric pressure : 101kPa Table 18: Test result of power spectral density of Band U-NII-1 Mode a n HT n HT ac VHT ac VHT ac VHT80 Channel Frequency (MHz) Result (dbm/mhz) ANT1 ANT2 Limit (dbm/mhz) for FCC Limit (dbm/mhz) for IC

26 Prüfbericht - Nr.: Test Report No. Seite 26 von 31 Page 26 of 31 Table 19: Test result of power spectral density of Band U-NII-3 Mode Channel Frequency Result (dbm/500khz) Limit (MHz) ANT1 ANT2 (dbm/500khz) a n HT n HT ac VHT ac VHT ac VHT

27 Prüfbericht - Nr.: Test Report No. Seite 27 von 31 Page 27 of Spurious Emission RESULT: Pass Date of testing : to Test standard : FCC part (b) RSS-247 clause 6.2.1(2) RSS-247 clause 6.2.4(2) KDB D02 v01 Basic standard : ANSI C63.10: 2013 Limits : FCC part (a) Kind of test site : 3m Semi-Anechoic Chamber & Anechoic Chamber Test setup Test Channel : Low/ Middle/ High Operation mode : A.1 Ambient temperature : 24 Relative humidity : 53% Atmospheric pressure : 101kPa The frequency range of testing is 30MHz to 40GHz, and no any emissions were found from 26.5GHz to 40GHz, hence the radiated emission from 26.5GHz to 40GHz were not recorded. For details refer to appendix A.

28 Prüfbericht - Nr.: Test Report No. Seite 28 von 31 Page 28 of Conducted emissions RESULT: Pass Date of testing : Test standard : FCC Part FCC part (b)(6) RSS-Gen Clause 8.8 Basic standard : ANSI C63.10: 2013 Frequency range : MHz Limits : FCC Part Kind of test site : Shield room Test setup Input Voltage : AC 120V, 60Hz Operation Mode : A.1 Earthing : Not Connected Ambient temperature : 22 Relative humidity : 55% Atmospheric pressure : 101kPa For details refer to appendix A.

29 Prüfbericht - Nr.: Test Report No. Seite 31 von 31 Page 31 of List of Tables Table 1: List of Test and Measurement Equipment... 5 Table 2: Measurement Uncertainty... 6 Table 3: Technical Specification of EUT... 8 Table 4: Technical Specification of 5GHz, a/n... 8 Table 5: Technical Specification of 5GHz, ac... 9 Table 6: List of WLAN Channel of 5GHz a/n... 9 Table 7: List of WLAN Channel of 5GHz ac Table 8: Test result of Peak Output Power of Band U-NII Table 9: Test result of Peak Output Power of Band U-NII Table 10: Test result of 26dB Bandwidth Band U-NII Table 11: Test result of 26dB Bandwidth of Band U-NII Table 12: Test result of Frequency Stability Band U-NII Table 13: Test result of Frequency Stability Band U-NII Table 14: Test result of 99% Bandwidth Band U-NII Table 15: Test result of 99% Bandwidth of Band U-NII Table 16: Test result of 6dB Bandwidth Band U-NII Table 17: Test result of 6dB Bandwidth of Band U-NII Table 18: Test result of power spectral density of Band U-NII Table 19: Test result of power spectral density of Band U-NII List of Photographs Photograph 1: Set-up for Conducted Emissions Photograph 2: Set-up for Spurious Emissions for MHz Photograph 3: Set-up for Spurious Emissions for 1-18GHz Photograph 4: Set-up for Spurious Emissions for 18-40GHz... 30

30 Page 1 of 163 Table of Contents 1. TRANSMITTER SPURIOUS EMISSIONS OF A MODE TRANSMITTER SPURIOUS EMISSIONS, 30MHZ - 1GHZ TRANSMITTER SPURIOUS EMISSIONS, 1GHZ - 18GHZ RESTRICTED BANDS TRANSMITTER SPURIOUS EMISSIONS OF N20 MODE TRANSMITTER SPURIOUS EMISSIONS, 30MHZ - 1GHZ TRANSMITTER SPURIOUS EMISSIONS, 1GHZ - 18GHZ RESTRICTED BANDS TRANSMITTER SPURIOUS EMISSIONS OF N40 MODE TRANSMITTER SPURIOUS EMISSIONS, 30MHZ - 1GHZ TRANSMITTER SPURIOUS EMISSIONS, 1GHZ - 18GHZ RESTRICTED BANDS TRANSMITTER SPURIOUS EMISSIONS OF AC20 MODE TRANSMITTER SPURIOUS EMISSIONS, 30MHZ - 1GHZ TRANSMITTER SPURIOUS EMISSIONS, 1GHZ - 18GHZ RESTRICTED BANDS TRANSMITTER SPURIOUS EMISSIONS OF AC40 MODE TRANSMITTER SPURIOUS EMISSIONS, 30MHZ - 1GHZ TRANSMITTER SPURIOUS EMISSIONS, 1GHZ - 18GHZ RESTRICTED BANDS TRANSMITTER SPURIOUS EMISSIONS OF AC80 MODE TRANSMITTER SPURIOUS EMISSIONS, 30MHZ - 1GHZ TRANSMITTER SPURIOUS EMISSIONS, 1GHZ - 18GHZ RESTRICTED BANDS CONDUCTED EMISSIONS

31 Page 2 of 163 Note 1: Testing was carried out within frequency range 9 khz to the tenth harmonics. The measurement results below 30MHz and above 18 GHz ware greater than 20dB below the limit, so only the radiated spurious emissions from 30MHz to 18 GHz were reported. Note 2: Testing was carried out on the antenna which with the higher output power. 1. Transmitter Spurious Emissions of a mode 1.1 Transmitter Spurious Emissions, 30MHz - 1GHz

32 Page 3 of 163

33 Page 4 of 163

34 Page 5 of 163

35 Page 6 of 163

36 Page 7 of 163

37 Page 8 of 163

38 Page 9 of 163

39 Page 10 of 163

40 Page 11 of 163

41 Page 12 of 163

42 Page 13 of 163

43 Page 14 of Transmitter Spurious Emissions, 1GHz - 18GHz

44 Page 15 of 163

45 Page 16 of 163

46 Page 17 of 163

47 Page 18 of 163

48 Page 19 of 163

49 Page 20 of 163

50 Page 21 of 163

51 Page 22 of 163

52 Page 23 of 163

53 Page 24 of 163

54 Page 25 of 163

55 Page 26 of Restricted Bands

56 Page 27 of 163

57 Page 28 of 163

58 Page 29 of 163

59 Page 30 of 163

60 Page 31 of 163

61 Page 32 of 163

62 Page 33 of 163