Variant FCC RF Test Report

Size: px

Start display at page:

Download "Variant FCC RF Test Report"

Maximilian Hutchinson
5 years ago
Views:

The product was received on Jun. 14, 2016 and testing was completed on Aug. 08, 2016. We, SPORTON INTERNATIONAL (KUNSHAN) INC.

1 Variant FCC RF Test Report APPLICANT EQUIPMENT BRAND NAME MODEL NAME FCC ID STANDARD CLASSIFICATION : ZTE CORPORATION : WCDMA/CDMA/LTE Multi-Mode Digital Mobile Phone : ZTE : ZTE A2017U : SRQ-ZTEA2017U : FCC 47 CFR Part 2, 22(H), 24(E), 27(L) : PCS Licensed Transmitter Held to Ear (PCE) This is a variant report which is only valid together with the original test report. The product was received on Jun. 14, 2016 and testing was completed on Aug. 08, We, SPORTON INTERNATIONAL (KUNSHAN) INC., would like to declare that the tested sample has been evaluated in accordance with the test procedures given in ANSI / TIA / EIA-603-D-2010 and has been in compliance with the applicable technical standards. The test results in this report apply exclusively to the tested model / sample. Without written approval of SPORTON INTERNATIONAL (KUNSHAN) INC., the test report shall not be reproduced except in full. Prepared by: James Huang / Manager Approved by: Jones Tsai / Manager SPORTON INTERNATIONAL (KUNSHAN) INC. No. 3-2, PingXiang Road, Kunshan, Jiangsu Province, P. R. China SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 1 of 17

2 TABLE OF CONTENTS 1 GENERAL DESCRIPTION Applicant Manufacturer Product Feature of Equipment Under Test Product Specification of Equipment Under Test Modification of EUT Testing Location Applicable Standards TEST CONFIGURATION OF EQUIPMENT UNDER TEST Test Mode Connection Diagram of Test System Support Unit used in test configuration CONDUCTED TEST RESULT Measuring Instruments Test Setup Test Result of Conducted Test Conducted Output RADIATED TEST ITEMS Measuring Instruments Test Setup Test Result of Radiated Test Field Strength of Spurious Radiation Measurement LIST OF MEASURING EQUIPMENT UNCERTAINTY OF EVALUATION APPENDIX A. TEST RESULTS OF CONDUCTED TEST APPENDIX B. TEST RESULTS OF RADIATED TEST APPENDIX C. TEST SETUP PHOTOGRAPHS APPENDIX D. PRODUCT EQUALITY DECLARATION SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 2 of 17

3 REVISION HISTORY REPORT NO. VERSION DESCRIPTION ISSUED DATE FG A Rev. 01 This is a variant report for ZTE A2017U. The product equality declaration could be referred to Appendix D. Based on the similarity between two models, only the conducted power and worst case of Spurious Emission from original test report (Sporton Report Number FG631604A) were verified for the differences. Sep. 01, 2016 SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 3 of 17

4 SUMMARY OF TEST RESULT Report Section FCC Rule Description Result Remark Conducted Output Reporting Only PASS (a) (a) 27.53(h) Field Strength of Spurious Radiation < 43+10log10(P[Watts]) PASS Under limit db at MHz SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 4 of 17

5 1 General Description 1.1 Applicant ZTE CORPORATION ZTE Plaza, Keji Road South, Hi-Tech, Industrial Park, Nanshan District,Shenzhen, Guangdong, , P.R.China 1.2 Manufacturer ZTE CORPORATION ZTE Plaza, Keji Road South, Hi-Tech, Industrial Park, Nanshan District,Shenzhen, Guangdong, , P.R.China 1.3 Product Feature of Equipment Under Test Equipment Brand Name Model Name FCC ID EUT supports Radios application IMEI Code HW Version SW Version EUT Stage Product Feature WCDMA/CDMA/LTE Multi-Mode Digital Mobile Phone ZTE ZTE A2017U SRQ-ZTEA2017U CDMA/EV-DO/ GSM/GPRS/EGPRS/WCDMA/H/DC-HSDPA/ H+(16QAM uplink is not supported)/lte/nfc WLAN 2.4GHz b/g/n HT20/HT40 WLAN 5GHz a/n HT20/HT40 WLAN 5GHz ac VHT20/VHT40/VHT80 Bluetooth v3.0 + EDR/Bluetooth v4.0 LE/Bluetooth v4.2 LE Conducted: Radiation: N/A wwdb A2017UV1.0.0B07 Production Unit Remark: The above EUT's information was declared by manufacturer. Please refer to the specifications or user's manual for more detailed description. SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 5 of 17

6 1.4 Product Specification of Equipment Under Test Tx Rx Maximum Output to Top Antenna Standards-related Product Specification GSM/GPRS/EDGE: 850: MHz ~ MHz 1900: MHz ~ MHz WCDMA: Band V: MHz ~ MHz Band II: MHz ~ MHz Band IV: MHz ~ MHz CDMA2000: BC0: MHz ~ MHz BC1: MHz ~ MHz GSM/GPRS/EDGE: 850: MHz ~ MHz 1900: MHz ~ MHz WCDMA: Band V: MHz ~ MHz Band II: MHz ~ MHz Band IV: MHz ~ MHz CDMA2000: BC0: MHz ~ MHz BC1: MHz ~ MHz GSM/GPRS/EDGE: 850: dbm 1900: dbm WCDMA: Band V: dbm Band II: dbm Band IV: dbm CDMA2000: BC0: dbm BC1: dbm SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 6 of 17

7 Maximum Output to Bottom Antenna Antenna Type Type of Modulation Standards-related Product Specification GSM/GPRS/EDGE: 850: dbm 1900: dbm WCDMA: Band V: dbm Band II: dbm Band IV: dbm CDMA2000: BC0: dbm BC1: dbm PIFA Antenna GSM: GMSK GPRS: GMSK EDGE: GMSK / 8PSK WCDMA: QPSK (Uplink) HSDPA/DC-HSDPA: QPSK (Uplink) HSUPA: QPSK (Uplink) H+: 16QAM uplink is not supported DC-HSDPA: 64QAM CDMA2000 1xRTT: QPSK CDMA2000 1xEV-DO: QPSK/8PSK 1.5 Modification of EUT No modifications are made to the EUT during all test items. SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 7 of 17

8 1.6 Testing Location Test Site SPORTON INTERNATIONAL (KUNSHAN) INC. No. 3-2, PingXiang Road, Kunshan, Jiangsu Province, P. R. China Test Site Location TEL: FAX: Test Site No. Sporton Site No. TH01-KS Test Site SPORTON INTERNATIONAL INC. No. 52, Hwa Ya 1 st Rd., Hwa Ya Technology Park, Test Site Location Kwei-Shan District, Tao Yuan City, Taiwan, R.O.C. TEL: Test Site No. FAX: Sporton Site No. 03CH07-HY FCC Registration No. TW Applicable Standards According to the specifications of the manufacturer, the EUT must comply with the requirements of the following standards: 47 CFR Part 2, 22(H), 24(E), 27(L) ANSI / TIA / EIA-603-D-2010 FCC KDB D01 Meas. License Digital Systems v02r02 Remark: 1. All test items were verified and recorded according to the standards and without any deviation during the test. 2. This EUT has also been tested and complied with the requirements of FCC Part 15, Subpart B, recorded in a separate test report. SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 8 of 17

9 2 Test Configuration of Equipment Under Test 2.1 Test Mode Antenna port conducted and radiated test items were performed according to KDB D01 Meas. License Digital Systems v02r02 with maximum output power. Radiated measurements were performed with rotating EUT in different three orthogonal test planes to find the maximum emission. Radiated emissions were investigated as following frequency range: MHz to 10th harmonic for GSM850 and WCDMA Band V and CDMA BC MHz to 10th harmonic for WCDMA Band IV MHz to 10th harmonic for GSM1900 and WCDMA Band II and CDMA BC1. All modes and data rates and positions were investigated. Test modes are chosen to be reported as the worst case configuration below: Test Modes Band Radiated TCs Conducted TCs GSM 850 GSM 1900 GSM Link EDGE class 8 Link GSM Link EDGE class 8 Link GSM Link EDGE class 8 Link GSM Link EDGE class 8 Link WCDMA Band V RMC 12.2Kbps Link RMC 12.2Kbps Link WCDMA Band II RMC 12.2Kbps Link RMC 12.2Kbps Link WCDMA Band IV RMC 12.2Kbps Link RMC 12.2Kbps Link CDMA BC0 1xRTT Link 1xRTT Link CDMA BC1 1xRTT Link 1xRTT Link SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 9 of 17

10 2.2 Connection Diagram of Test System Top Antenna 22H/24E/27L Bottom Antenna 22H/24E/27L SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 10 of 17

11 2.3 Support Unit used in test configuration Item Equipment Trade Name Model No. FCC ID Data Cable Cord 1. System Simulator R&S CMU 200 N/A N/A Unshielded, 1.8 m 2. DC Supply GW INSTEK GPS-3030D N/A N/A Unshielded, 1.8 m 3. Earphone Apple MC690ZP/A N/A Shielded, 1.0 m N/A SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 11 of 17

3 Conducted Test Result 3.1 Measuring Instruments See list of measuring instruments of this test report. 3.2 Test Setup 3.2.1 Conducted Output 3.

12 3 Conducted Test Result 3.1 Measuring Instruments See list of measuring instruments of this test report. 3.2 Test Setup Conducted Output 3.3 Test Result of Conducted Test Please refer to Appendix A. SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 12 of 17

13 3.4 Conducted Output Description of the Conducted Output A system simulator was used to establish communication with the EUT. Its parameters were set to enforce EUT transmitting at the maximum power. The measured power in the radio frequency on the transmitter output terminals shall be reported Test Procedures 1. The transmitter output port was connected to the system simulator. 2. Set EUT at maximum power through system simulator. 3. Select lowest, middle, and highest channels for each band and different modulation. 4. Measure the maximum burst average power for GSM and maximum average power for other modulation signal. SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 13 of 17

14 4 Radiated Test Items 4.1 Measuring Instruments See list of measuring instruments of this test report. 4.2 Test Setup For radiated test from 30MHz to 1GHz For radiated test above 1GHz 4.3 Test Result of Radiated Test Please refer to Appendix B. SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 14 of 17

15 4.4 Field Strength of Spurious Radiation Measurement Description of Field Strength of Spurious Radiated Measurement The power of any emission outside of the authorized operating frequency ranges must be attenuated below the transmitter power (P) by a factor of at least log (P) db. The spectrum is scanned from 30 MHz up to a frequency including its 10th harmonic Test Procedures 1. The testing follows FCC KDB D01 v02r02 Section 5.8 and ANSI / TIA-603-D-2010 Section The EUT was placed on a rotatable wooden table 0.8 meters for frequency below 1GHz and 1.5 meter for frequency above 1GHz above the ground. 3. The EUT was set 3 meters from the receiving antenna, which was mounted on the antenna tower. 4. The table was rotated 360 degrees to determine the position of the highest spurious emission. 5. The height of the receiving antenna is varied between one meter and four meters to search for the maximum spurious emission for both horizontal and vertical polarizations. 6. Make the measurement with the spectrum analyzer's RBW = 1MHz, VBW = 3MHz, taking record of maximum spurious emission. 7. A horn antenna was substituted in place of the EUT and was driven by a signal generator. 8. Tune the output power of signal generator to the same emission level with EUT maximum spurious emission. 9. Taking the record of output power at antenna port. 10. Repeat step 7 to step 8 for another polarization. 11. EIRP = Tx Cable Loss + Tx Antenna 12. ERP = EIRP The RF fundamental frequency should be excluded against the limit line in the operating frequency band. 14. The limit line is derived from log(P) db below the transmitter power P(Watts) = P(W) - [ log(P)] (db) = [ log(P)] - [ log(P)] (db) = -13dBm. SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 15 of 17

16 5 List of Measuring Equipment Instrument Manufacturer Model No. Serial No. Characteristics Calibration Date Test Date Due Date Remark Bilog Antenna TESEQ CBL 6111D MHz to 1GHz Jan. 13, 2016 Double Ridge Horn Antenna ESCO GHz ~ 18GHz Aug. 21, 2015 BBHA Horn Antenna SCHWARZBECK 9120D GHz ~ 18GHz Nov. 02, D SHF-EHF Horn SCHWARZBECK BBHA 9170 BBHA GHz- 40GHz Nov. 02, 2015 Antenna EMI Test N9038A(MX Keysight MY Hz ~ 8.4GHz Nov. 04, 2015 Receiver E) Spectrum Analyzer Agilent N9010A MY Hz~44GHz Feb. 27, 2016 Preamplifier COM-POWER PA-103A MHz-1GHz Mar. 18, 2016 AMF-7D-00 Preamplifier MITEQ GHz ~ 18GHz Apr. 15, JS Preamplifier MITEQ GHz ~ 40GHz Jun. 02, P Controller Max-Full MF7802 MF Control Ant Mast NCR Antenna Mast Max-Full MFA520BS N/A 1m~4m NCR Chaintek Turn Table ChainTek N/A 0~360 Degree NCR 3000 NCR: No Calibration Required Aug. 02, 2016~ Aug. 08, 2016 Aug. 02, 2016~ Aug. 08, 2016 Aug. 02, 2016~ Aug. 08, 2016 Aug. 02, 2016~ Aug. 08, 2016 Aug. 02, 2016~ Aug. 08, 2016 Aug. 02, 2016~ Aug. 08, 2016 Aug. 02, 2016~ Aug. 08, 2016 Aug. 02, 2016~ Aug. 08, 2016 Aug. 02, 2016~ Aug. 08, 2016 Aug. 02, 2016~ Aug. 08, 2016 Aug. 02, 2016~ Aug. 08, 2016 Aug. 02, 2016~ Aug. 08, 2016 Radiation Jan. 12, 2017 (03CH07-HY) Radiation Aug. 20, 2016 (03CH07-HY) Radiation Nov. 01, 2017 (03CH07-HY) Radiation Nov. 01, 2016 (03CH07-HY) Radiation Nov. 03, 2016 (03CH07-HY) Radiation Feb. 26, 2017 (03CH07-HY) Radiation Mar. 17, 2017 (03CH07-HY) Radiation Apr. 14, 2017 (03CH07-HY) Radiation Jun. 01, 2017 (03CH07-HY) NCR Radiation (03CH07-HY) NCR Radiation (03CH07-HY) NCR Radiation (03CH07-HY) SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 16 of 17

17 6 Uncertainty of Evaluation Uncertainty of Radiated Emission Measurement (30 MHz ~ 1000 MHz) Measuring Uncertainty for a Level of Confidence of 95% (U = 2Uc(y)) 3.1 db Uncertainty of Radiated Emission Measurement (1GHz ~ 18GHz) Measuring Uncertainty for a Level of Confidence of 95% (U = 2Uc(y)) 3.4 db Uncertainty of Radiated Emission Measurement (18GHz ~ 40GHz) Measuring Uncertainty for a Level of Confidence of 95% (U = 2Uc(y)) 4.0 db SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : 17 of 17

18 Appendix A. Test Results of Conducted Test Conducted Output (Average power) Top Antenna Conducted (*Unit: dbm) Band GSM850 GSM GSM GPRS class GPRS class GPRS class GPRS class EGPRS class EGPRS class EGPRS class EGPRS class SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : A1 of A4

19 Conducted (*Unit: dbm) Band WCDMA Band V WCDMA Band II WCDMA Band IV AMR 12.2K RMC 12.2K HSDPA Subtest HSDPA Subtest HSDPA Subtest HSDPA Subtest DC-HSDPA Subtest DC-HSDPA Subtest DC-HSDPA Subtest DC-HSDPA Subtest HSUPA Subtest HSUPA Subtest HSUPA Subtest HSUPA Subtest HSUPA Subtest Conducted (*Unit: dbm) Band CDMA 2000 BC0 CDMA 2000 BC xRTT RC1 SO xRTT RC3 SO xRTT RC3 SO32 (+ F-SCH) 1xRTT RC3 SO32 (+SCH) 1xEVDO RTAP 153.6Kbps 1xEVDO RETAP 4096Bits SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : A2 of A4

20 Bottom Antenna Conducted (*Unit: dbm) Band GSM850 GSM GSM GPRS class GPRS class GPRS class GPRS class EGPRS class EGPRS class EGPRS class EGPRS class Conducted (*Unit: dbm) Band WCDMA Band V WCDMA Band II WCDMA Band IV AMR 12.2K RMC 12.2K HSDPA Subtest HSDPA Subtest HSDPA Subtest HSDPA Subtest DC-HSDPA Subtest DC-HSDPA Subtest DC-HSDPA Subtest DC-HSDPA Subtest HSUPA Subtest HSUPA Subtest HSUPA Subtest HSUPA Subtest HSUPA Subtest SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : A3 of A4

21 Conducted (*Unit: dbm) Band CDMA 2000 BC0 CDMA 2000 BC xRTT RC1 SO xRTT RC3 SO xRTT RC3 SO32 (+ F-SCH) 1xRTT RC3 SO32 (+SCH) 1xEVDO RTAP 153.6Kbps 1xEVDO RETAP 4096Bits SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : A4 of A4

22 Appendix B. Test Results of Radiated Test Radiated Spurious Emission Top Antenna ERP GSM850 (GSM) H H H H V V V V ERP GSM850 (EDGE class 8) H H H V V V EIRP GSM1900 (GSM) H H H V V V SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : B1 of B6

23 EIRP GSM1900 (EDGE class 8) H H H V V V ERP WCDMA Band V(RMC 12.2Kbps) H H H V V V EIRP WCDMA Band II(RMC 12.2Kbps) H H H V V V SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : B2 of B6

24 EIRP WCDMA Band IV(RMC 12.2Kbps) H H H V V V ERP CDMA BC0(1XRTT) H H H V V V EIRP CDMA BC1(1XRTT) H H H V V V SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : B3 of B6

25 Bottom Antenna ERP GSM850 (GSM) H H H V V V ERP GSM850 (EDGE class 8) H H H V V V EIRP GSM1900 (GSM) H H H H V V V V SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : B4 of B6

26 EIRP GSM1900 (EDGE class 8) H H H H V V V V ERP WCDMA Band V(RMC 12.2Kbps) H H H V V V EIRP WCDMA Band II(RMC 12.2Kbps) H H H V V V SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : B5 of B6

27 EIRP WCDMA Band IV(RMC 12.2Kbps) H H H H V V V V ERP CDMA BC0(1XRTT) H H H V V V EIRP CDMA BC1(1XRTT) H H H V V V SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : B6 of B6

28 Appendix D. Product Equality Declaration SPORTON INTERNATIONAL (KUNSHAN) INC. Page Number : D1 of D1

29 内部公开 Internal Use Only ZTE CORPORATION Product Change Description As the applicant of the below model, [ZTE Corporation] declares that the product, [ZTE A2017U] [ZTE Corporation] is the variant of the initial certified product, [ZTE A2017U] [ZTE Corporation] [Project Number:16ZTE027] SOFTWARE MODIFICATIONS: Protocol Stack changes: NO MMS/STK changes: NO JAVA changes: NO Other changes detailed: NO HARDWARE MODIFICATION: Band changes: NO Amplifier changes: NO Antenna changes: GPS/WiFi/Bluetooth 3in1 antenna is now updated. Aiming at improving GPS performance, we updated this antenna and this result to 1dB efficiency better than previous one. Meanwhile, WiFi/Bluetooth efficiency was slightly down. < 以上所有信息均为中兴通讯股份有限公司所有, 不得外传 > All Rights reserved, No Spreading abroad without Permission of ZTE 第 1 页

内部公开 Internal Use Only Before After PCB Layout changes: NO

key and touch key FPC Before After Speaker changes: NO Camera

changes: NO Other changes: NO < 以上所有信息均为中兴通讯股份有限公司所有, 不得外传 >

30 内部公开 Internal Use Only Before After PCB Layout changes: NO Components on PCB changes: NO LCD changes: Yes, Added touch key and touch key FPC Before After Speaker changes: NO Camera changes: NO Vibrator changes: NO Bluetooth changes: NO FM changes: NO Other changes: NO < 以上所有信息均为中兴通讯股份有限公司所有, 不得外传 > All Rights reserved, No Spreading abroad without Permission of ZTE 第 2 页

31 内部公开 Internal Use Only MECHANICAL MODIFICATIONS: Use new metal front/back cover or keypad: NO Mechanical shell changes: NO Other changes detailed: NO ACCESSORY MODIFICATIONS: Battery changes:no AC Adaptor changes:no Earphone changes:no APPROVED BY: Min zhang Project Manager: Li xiaofeng Date: Company: ZTE Corporation Address: B109, #889, Bibo Rd, Zhangjiang Hi-Tech Park, Shanghai,China Tel: Fax: < 以上所有信息均为中兴通讯股份有限公司所有, 不得外传 > All Rights reserved, No Spreading abroad without Permission of ZTE 第 3 页

FCC RF Test Report. : FCC 47 CFR Part 2, and 90(S) : PCS Licensed Transmitter (PCB)

FCC RF Test Report. : FCC 47 CFR Part 2, and 90(S) : PCS Licensed Transmitter (PCB) FCC RF Test Report APPLICANT EQUIPMENT BRAND NAME MODEL NAME FCC ID STANDARD CLASSIFICATION : ZTE CORPORATION : LTE Ufi : ZTE : MF920VS : SRQ-MF920VS : FCC 47 CFR Part 2, and 90(S) : PCS Licensed Transmitter