MARK V XCEL & Mark V-00 XCEL ELECTRIC convection oven REPLACEMENT PARTS LIST Effective october, 0 Superseding All Previous Parts Lists. The Company reserves the right to make substitution in the event that items specified are not available. ERRORS: Descriptive and/or typographic errors are subject to correction. BLODGETT OVEN COMPANY Lakeside Avenue, Burlington, Vermont 00 USA Telephone: (0) -00 Fax: (0) 0- www.blodgett.com P/N 0 Rev C
serial number location / KEY: IMPORTANT: When ordering parts, please provide the model, voltage, phase and serial number of the oven. The identification plate is located above the right hand door under the ledge. serial number identification code: PG = Mark v XCEL ck = Mark v-00 XCEL Serial NUmber Examples 000Pg00T (New style) 0/0/0 = DATE Pg = LETTER CODE FOR Mark V xcel 00 = factory sequence T = top oven TO OBTAIN LITERATURE: Email: literature@blodgett.com or visit www.blodgett.com october, 0 MARK V XCEL & mark V-00 xcel
table of contents Doors Are Not Returnable infinite control... page digital control, Key... page ch-pro control, key... page iq control, key... page 0 SMARTOUCH CONTROL... page digital controls with humidaire, key... page humidaire components...page interior components w/exterior view... page Door Components... page Lower door support components... page accessories... page october, 0 MARK V XCEL & mark V-00 xcel
infinite CONTROL 0 VOLT FOR OVENS BUILT before 0//00 0 Controller, Temperature, Solid State Modular 0 Probe, Temperature, Solid State Timer, 0 Minute, 0V, 0 HZ 0 Mode Selector Switch, pos Knob, Replacement, all functions Qty 0 Indicator Light, Round, Red 0V Buzzer, 0V Circuit Breaker 00 Terminal Block 0 Momentary Light Switch Kit 0 Plug, for Light Switch R Contactor, amp, 0V coil, single phase only 0 Contactor MOV assy. For units without lights only, use this plug piece 0 Axial Fan, Low Velocity, 0V, 0 HZ Control Panel & Decal Assy, Infinite Harness, Rear Connecting Contactor Upgrade Kit, V Mechanical, Qty 0 Contactor, 0amp V Mechanical october, 0 MARK V XCEL & mark V-00 xcel
infinite CONTROL VOLT FOR OVENS BUILT AFTER 0//00 Controller, Temperature, Solid State Modular, Before //0 Controller, Temperature 0º TDC, After //0 0 Probe, Temperature, Solid State, Before //0 0 Probe, Temperature, After //0 0 Mode Selector Switch, pos Circuit Breaker 0 Momentary Light Switch Kit Transformer, 0/0 to V Timer, 0 Min V 0Hz Light, Indicator V Red Round Buzzer, V Harness, Module, Inf 0 Relay, DPST V A Relay, DPST V Coil Harness, Infinite, add in 0 Module Assy, Infinite SP 0 Contactor, 0 amp, VAC coil R Contactor, amp, 0 VAC coil, single phase only 0 Contactor, MOV assy october, 0 MARK V XCEL & mark V-00 xcel
digital time & temperature CONTROL, key 0 0 Controller, Temperature, Solid State Digital 0 Probe, Temperature, Solid State 0 Mode Selector Switch, pos Knob, Replacement, Mode Knob, Replacement, Adjust Temperature Circuit Breaker 0 Momentary Light Switch Kit Plug, for Light Switch For units without lights only, use this plug piece. 00 Terminal Block, interconnecting, at rear of unit 0 Axial Fan, Low Velocity, 0V, 0 HZ Control Panel & Decal Assy, SSD 0 Module Assy, SSD SP, w/o lights Harness, Rear Connecting Modules include everything pictured above, except probe. Contactor Upgrade Kit, V Mechanical, Qty 0 Contactor, 0amp V Mechanical R Contactor, amp, 0V coil, single phase only 0 Contactor, MOV assy. october, 0 MARK V XCEL & mark V-00 xcel
digital time & temperature CONTROL, key VOLT FOR OVENS BUILT AFTER 0//00 0 Controller, Temperature, Solid State Digital 0 Probe, Temperature, Solid State 0 Mode Selector Switch, pos Circuit Breaker 0 Momentary Light Switch Kit Transformer, 0-0V/V Harness, Control 0 Relay VAC Relay, DPST V Module Assy, SSD- includes everything pictured in view A. 0 Contactor, 0 amp, VAC coil R Contactor, amp, 0 VAC coil, single phase only 0 Contactor MOV assy. october, 0 MARK V XCEL & mark V-00 xcel
CH-Pro control, key 0 0 Controller, CH Pro 0 Probe, Temperature, CH Pro 0 Mode Selector Switch, pos Knob, Replacement, Mode R00 Relay, 0V Relay, 0V 0 Momentary Light Switch Kit Plug, for Light Switch For units without lights only, use this plug piece. Circuit Breaker 00 Terminal Block, interconnecting, at rear of unit 0 Control Panel & Decal Assy, CHPro 0 Axial Fan, Low Velocity, 0V, 0 HZ Harness, Rear Connecting Contactor Upgrade Kit, V Mechanical, Qty 0 Contactor, 0amp V Mechanical R Contactor, amp, 0 VAC coil 0 Contactor, MOV assy. october, 0 MARK V XCEL & mark V-00 xcel
CH-Pro control, key VOLT FOR OVENS BUILT AFTER 0//00 0 Controller, CH Pro 0 Probe, Temperature, CH Pro 0 Mode Selector Switch, pos 0 Momentary Light Switch Kit Circuit Breaker Transformer, 0-0/V 0 Relay, VAC Relay, DPST VAC Harness, Control Module Assy, CHPRO 0 Contactor, 0 amp, VAC coil R Contactor, amp, 0 VAC coil, single phase only 0 Contactor, MOV assy. october, 0 MARK V XCEL & mark V-00 xcel
iq control, key 0 0 Controller w/decal Assy, IQ 0 Decal Only, IQ Control (Before -0-00) 0 Decal Only, IQ Control (After -0-00) Control Retainer Gasket, Rubber Gasket, Control back 0 Probe, IQ Rocker Switch, DPST, Black Relay, V Qty per oven Relay, V, Qty per oven 00 Terminal Block 0 Transformer, /0V to V Step Down 0 Circuit Breaker Decal, Circuit Breaker On/Off Plug, for Light Switch For units without lights only, use this plug piece. 0 Light Switch 0 Axial Fan, Low Velocity, 0V, 0 HZ Contactor Upgrade Kit, V Mechanical, Qty 0 Contactor, 0amp V R Contactor, amp, 0V coil, single phase only 0 Contactor, MOV assy. FOR OVENS BUILT AFTER 0//0- THE FOL- LOWING PARTS WERE ADDED/ CHANGED DUE TO A CHANGE IN VOLTAGE. Transformer, 0-0/V Module Assy, IQ october, 0 0 MARK V XCEL & mark V-00 xcel
SMARTOUCH control 0 0 Control, Programmed, Before // Control, Programmed, After // USB Cover Meat Probe Jack Meat Probe Jack Plug Meat Probe, ", Dual Sensor Meat Probe, ", Dual Sensor Circuit Breaker 0A Relay, DPST, VDC 0 Relay, DPDT, VDC Jumper USB Cable Speaker 0 I/O Board, Before // I/O Board, After // 0 Thermal Switch 0 Probe, RTD, K 00 Transformer, 0/0 to V 0 DC Power Supply, V, W Varistor Assembly, V 0 Communication Cable 0 Contactor, 0 amp, VAC coil R Contactor, amp, 0 VAC coil, single phase only 0 Contactor, MOV assy. october, 0 MARK V XCEL & mark V-00 xcel
digital CONTROL with Humidaire, key 0 Knob, Mode Knob, Adjust 0 Momentary Light Switch Kit Plug, for LIght Switch For units without lights only, use this plug piece. 0 Light, Ind. VAC Amber Circuit Breaker 0 Controller, Temperature 0 Probe, Temperature 0 Switch, Rotary Position Timer, Preset Humidaire 0 Relay, DPST VAC Harness, Control Harness, Humidaire 0 Harness, Rear Humidaire 0 Relay, VAC Transformer, 0-0/ Contactor Upgrade Kit, Mechanical V 0 Module Assy, SSD w/ Humidaire 0 Contactor, 0 amp, VAC coil R Contactor, amp, 0 VAC coil, single phase only 0 Contactor MOV assy. Modules include EVERYTHING pictured above, except probe. october, 0 MARK V XCEL & mark V-00 xcel
humidaire components 0 Regulator and Solenoid Assy VAC (includes everything pictured above) M0 Fitting, Compression / x / R0 Valve, Solenoid R0 Coil, Solenoid VAC Nipple, Brass Hex / x. 0 Tee, Brass / x -/ 0 Regulator, Pressure 0 Elbow, Brass / Pipe 0 DEG 0 Bushing, / x / Hex Thermal Switch, SPNO Tape, Gore-tex gasket (by the foot) Dam, Liner Bottom Cap, End 0 Grommet, Rubber / 0 Grommet, Nylon Split Tube, Flex / x " 0 Fitting, Compression, / x / Tube, Water Inject Clip, Thermostat Bulb october, 0 MARK V XCEL & mark V-00 xcel
interior components & exterior view 0 LINER NOT REPLACEABLE Interior Baffle, Porcelain, Blower Wheel cover Interior Baffle, S/S, Blower Wheel Cover 00 Blower Wheel Wheel Puller 0 Motor, 0V, / HP, SP, After //00 Motor, 0V, SP, Before //00 Motor Mount & Panel Assy, After //00 Lamp, Qty per oven 0 Watt 0-0 V Socket, for Lamp Qty per oven Housing, for Socket & Lamp Racks, Each, Qty per oven EZ Slide Rack 00 Rack Support Kit, Set of 0 Stops, Rack Each Qty per oven 0 Combustion Compartment Cover (w/o security package) Crumb Pan Set (LH & RH) 0 Element Assy, 0V (Before 0-0-00) 0 Element Assy, 0V (Before 0-0-00) 0 Element Assy, 0V (Before 0-0-00) 0 Element Assy, 0V (Before 0-0-00) Element Assy, 0V (After 0-0-00) Element Assy, 0V (After 0-0-00) 0 Element Assy, 0V (After 0-0-00) 0 Element Assy, 0V (After 0-0-00) Transformer, 0V to0v. KVA Transformer Harness Transformer Kit,. KVA Cover, Access Panel 0 Axial Fan, Qty Fan Guard Assy Bodytop, with opening for flue box 0 Bodyside, RH 0 Bodyside, LH october, 0 MARK V XCEL & mark V-00 xcel
door components 0 Right Hand Door - Attached to unit Left Hand Door 0 DOOR HINGE COMPONENTS Left Hand Door 0 Door Assy Sld, RH Door Assy, Sld LH Door Assy, Gls RH Door Assy, Gls LH 0 Window Tool, for installation and removal of window assy 0 Window Assy, Drop In (0-/" x -/") Door Handle, Porcelain 0 Top Plate, Door Handle 000 Bushings, Door Hinge (Set of ) Sleeve, Upper Door Bushing Hinge Pin, Upper Door Center Trim, Door 0 0 Pressure Lock Gasket Assy, Perimeter 0 Lower Door Support Assy Microswitch, Door 0 Nameplate Side View, Lower Door Support Assy october, 0 MARK V XCEL & mark V-00 xcel
lower door support components 0 Lower Door Support Assy Lower Door Support Assy includes the hinge pins, arms, chain & turnbuckles, sprocket assys, cam assy, and microswitch. Microswitch, Door If you need to replace the sprockets, chain & turnbuckle, or the hinge pin we strongly suggest ordering the entire lower door support. It will include all of these components and will greatly reduce your labor costs and time invested. october, 0 MARK V XCEL & mark V-00 xcel
accessories A VIEW FROM FRONT OF OVEN C B CASTER UNDER SIDE VIEW 0 Draft Diverter, Canopy Vent, S/S Mark V Xcel Sgl Flue Connector Assy, Piece Mark V Xcel Dbl Pieces A, B & C make up Kit Flue Box Single Oven Mark V Xcel 0 Clips, Stacking Double Oven 00 Legs, " w/ Bolts, S/S Set of Legs, " w/ Bolts, S/S Set of " and " Legs look the same. Seismic Legs, ", S/S Set of 000 Studs, Leg Set of Bolts, Leg Set of Casters w/ Plate Set of Dbl Oven 00 Casters Set of Sgl Oven Only Casters, Low Profile Set of Dbl Oven 0 Casters, Heavy Duty Low Profile Set of (Jarvis & Jarvis) Dbl Oven Open Stand w/ Feet, S/S Mark V Xcel Open Stand w/ Casters,S/S MarkVXCE Side Heat Shield, Right or Left october, 0 MARK V XCEL & mark V-00 xcel