00 PIN HOUSING TO ELETRI STEP LE SM (LU) FROM ISOLTE STU IN RER HSSIS REKER PNEL TO LEVEL SYSTEM PUMP F LE SM (LK) GENERTOR GROUN FROM GENERTOR GROUN STU TO LEVEL SYSTEM GROUN STU TO PSSENGER SWITHES ETIL F TO PSSENGER SET 00-0-000 PIN HOUSING TO ONENSER FN WIRES ROUTE THROUGH FLOOR IN THIS RE PIN HOUSING TO STEP OVER 0 PIN HOUSING TO GENERTOR ETIL NTENN-TPMS W/ EXT LE 000090 / -0-000 SENSOR-WHEEL, TPMS 000090 / 0-0-000 () 9 M WIRE SM-/V TO EROOM TV (OIL OVE FLOOR) LE SM (YEL) FROM OH TTERY TO STU,JUMP STRT (RE) LE SM (LK) OH GROUN GENERTOR 0 0 LE SM (GRN) GENERTER FROM PSS THRU STU TO GENERTOR 09 ETIL LE SM (GRN) FROM OH T IS RELY TO PSS THRU STU LE SM (RE) JUMPER ETWEEN POSITIVE POSTS TUM FRONT XLE 0 PIN HOUSING TO WIRE SM-IP,MIN LES TO ISOLTE STUS MP,JT TO LP TNK MIS HSG TO WIRE SM-OH TO RIVER SET 00-0-000 LE SM (LK) FROM TTERY GROUN POST TO INVERTER ETIL E LE SM-TEMP SENSOR FROM TTERY GROUN POST TO INVERTER LE SM (ORG) FROM LOK TO INVERTER ISONNET PIN HSG TO WIRE SM-KWLL LE SM (LU) FROM ISOLTE STU TO LEVELING SYSTEM PUMP WIRE SM-HSSIS 0000 / -0-000 9-0-000 9 MHP TO INSTLL ON VLVE STEMS PER MNUFTURING INSTRUTIONS. LE SM (GRN) FROM OH ISONNET TO PSS THROUGH STU M TIRE MONITORING SYSTEM SOLR PNEL - 00 WTT MOVE NTENN WITH SUPPLIE RKET. ROUTE NTENN WIRE LONG /S FRME RIL N SEURE WITH OTHER LOOMS. ROUTE UP /S -PILLR N OIL EXESS WITH INFOTINMENT ORE WIRING ONNETORS. ZZ TO TTERY GROUN POST (SOLR PNEL GROUN) OES/STNRS-S/MVSS OES/STNRS US REST WIRE IN FRME RIL WHEN PPLILE. LMP 0-0-000, SREW G9-0-U LMP 09-0-000, SREW G9-0-U USE TIE-WIRE -0-000 TO SEURE WIRES TO FLOOR SUPPORT FRME T LEST ONE EVERY 00MM. PRE-HETER OR SNR: FTR: UNSPEIFIE TOLERNES: WHOLE IM (X) ONE-PLE (X.X) OPYRIGHT 0 WINNEGO INUSTRIES, IN.. LL IMENSIONS RE IN MILLIMETERS MTERIL: SEURE OR WY FROM LL MOVING PRTS N EXHUST WITH WIRE-TIE 9-0-000 S REQUIRE SEE WIRING INSTL-FRONT EN ITIONL INMTION. SEE WIRING INSTL-OY,0V ITIONL INMTION. ETIL PRE-HETER OR TO RP-ENG HTR ELETRIL SPEIFITIONS -0-000 ELETRIL LLOUTS 9-0-000 TWO-PLE (X.XX) NGLE REFER TO ES00 FSTENER TIGHTENING GUIELINES ESRIPTION: 0.0 ITEM/PRT NO: REF: WEIGHT: (LS) FIRST USE: P0 WIRING INSTL-HSSIS OF 0000 / 90000 -ec-0
LE SM (YEL) FROM OH TTERY TO OH STU,JUMP STRT 0--09 LE SM (YEL) FROM STU,JUMP STRT TO OH SIE OF UX STRT SOLENOI 0--00 LE SM (LK) FROM STU,JUMP STRT "GROUN" TO FRME RIL GROUN -0-00 LE SM (ORG) FROM OH TTERY TO INVERTER 0--00 LE SM (ORG) FROM INVERTER TO INVERTER ISONNET SWITH 0--0 LE SM (ORG) FROM INVERTER ISONNET TO POSITIVE TERMINL ON INVERTER 0--00 LE SM (LK) FROM TTERY TO INVERTER NEGTIVE TERMINL -0-0 LE SM (LK) FROM OH TTERY TO FRME RIL GROUN -0-0 LE SM (PUR) FROM HSSIS TTERY ISONNET TO HSSIS ISOLTE STU 0--00 LE SM (LU) FROM HSSIS ISONNET TO LEVELING SYSTEM PUMP --0 LE SM (LK) FROM LEVELING SYSTEM TO FRME RIL GROUN --00 LE SM (GRN) FROM OH T IS RELY TO PSS THRU STU IN FRONT LEFT OMPT 0-- LE SM (GRN) FROM PSS THRU STU IN FRONT LEFT OMPT TO GENERTOR 0--0 LE SM (LK) FROM GENERTOR TO FRME RIL GROUN OLT -0-00 LE SM (YEL) JUMPER ETWEEN POSITIVE POSTS ON OH TTERY LE SM (LK) JUMPER ETWEEN NEGTIVE POSTS ON OH TTERY --00 --00 () --00 --00 () LE SM (RE) JUMPER ETWEEN POSITIVE POSTS IN LEFT FRONT OMPT --00 LE SM-TEMPERTURE,TTERY -0-000 LE SM (RE) FROM HSSIS TTERY TO HSSIS SIE OF UX STRT SOLENOI 0--00 LE SM (RE) FROM HSSIS TTERY TO HSSIS TTERY 0--00 LE SM (YEL) FROM OH TTERY TO OH TTERY 0--00 LE SM (YEL) FROM OH ISONNET TO MULTIPLEX PNEL 90-0-0 LE SM (YEL) FROM MULTIPLEX PNEL TO MULTIPLEX PNEL 90-0-0 OES/STNRS-S/MVSS SEE WIRING INSTL-FRONT EN ITIONL INMTION. OES/STNRS US SEE WIRING INSTL-HSSIS ITIONL INMTION. SEE LEVELING SYSTEM INSTL ITIONL INMTION. ELETRIL SPEIFITIONS -0-000 ELETRIL LLOUTS 9-0-000 ESRIPTION: OF WIRING INSTL-HSSIS ITEM/PRT NO: 0000 / 90000 -ec-0
LE SM (ORG) TO INVERTER TTERY-V 9-0-000 () OLT -0-000 () NUT-HEX 9-0-00U () WSHER-RUER -0-HT () STRP-TTERY TIE OWN 9-0-HT () TO GROUN STU EHIN HSSIS TTERIES LE SM (YEL) LE SM (LK) TO INVERTER LE SM- TEMPERTURE,TTERY HOLER- -0-000 -00 MP -0-000 SREW G9-0-U () LE SM (YEL) OH TTERY JUMPER LE SM (LK) OH TTERY JUMPER TRY SM-TTERY -0-HT () NUT 9-0-00U () WSHER E--00U () HOLER- 0-0-000-00 MP -0-000 SREW G9-0-U () 9W ONNET SOLR PNEL GROUN HERE IRUIT ZZ TPE IRUIT ZZ K TO HRNESS VIEW 9W SOLR PNEL/TTERY HRG W/O SOLR PNEL - 00 WTT OES/STNRS-S/MVSS OES/STNRS US ELETRIL SPEIFITIONS -0-000 ELETRIL LLOUTS 9-0-000 ESRIPTION: OF WIRING INSTL-HSSIS ITEM/PRT NO: 0000 / 90000 -ec-0
LE SM FROM FREIGHTLINER HSSIS (ISONNETE ) TO ISOLTE STU LE SM FROM FREIGHTLINER HSSIS (ISONNETE ) TO ISOLTE STU STU-ISOLTE -0-000 NUT 9-0-00U SREW G9-0-0U () ETIL STU-JUMP STRT,RE -0-000 LE SM (PUR) FROM HSSIS ISONNET TO ISOLTE STU PNEL-LOSEOUT -0-HT SREW G-0-U () E IRUIT REKERS ETIL E E HOLER- 0-0-000-00 MP -0-000 SREW G9-0-U () ETIL PNEL-LOSEOUT, ELETRIL -0-HT () SREW G9-0-U () STU-JUMP STRT,LK -0-000 LEL-JUMP STRT,OH -0-HT 9-0-000 () RELY 09-0-000 9-0-000 () LEL 99-0-000 HSSIS SUPPLIE GROUN LE UX STRT SOLENOI TTERY-V () (HSSIS SUPPLIE) TIEOWN-TTERY (HSSIS SUPPLIE) LOK (HSSIS SUPPLIE) FREIGHTLINER STRTER LE HSSIS TTERIES OLT -0-000 () NUT-HEX 9-0-00U () WSHER-RUER -0-HT () TTERY HOLOWN (HSSIS SUPPLIE) OES/STNRS-S/MVSS OES/STNRS US VIEW ELETRIL SPEIFITIONS -0-000 ELETRIL LLOUTS 9-0-000 ESRIPTION: OF WIRING INSTL-HSSIS ITEM/PRT NO: 0000 / 90000 -ec-0
IRUIT REKER-0 MP 9-0-000 () SREW G-0-0U () SPER-IRUIT REKER 9-0-000 () IRUIT REKER- MP 9-0-000 () SREW G-0-0U () SPER-IRUIT REKER 9-0-000 () HSSIS MNUFTURER'S ELETRIL OMPONENTS & RER PNEL EHIN LEFT RER VLNE OOR. TTERY MOE SOLENOI N ISONNET RELYS LOTE EHIN THIS PNEL. SLIEOUT LOK SLIEOUT RM SLIEOUT RM SLIEOUT RM SLIEOUT RM SLIEOUT RM OH MIN IRUIT REKER-0 MP 9-0-000 () SREW G9-0-0U () LEL-IRIUT REKER 09--000 LE SM (RE) FROM HSSIS TTERY TO HSSIS SIE OF UX STRT SOLENOI LE SM (PUR) FROM HSSIS TTERY ISONNET TO HSSIS ISOLTE STU LE SM (LU) TO LEVELING SYSTEM PUMP HOLER LE SM (YEL) FROM STU,JUMP STRT TO OH SIE OF UX STRT SOLENOI LE SM (GRN) FROM OH TTERY ISONNET RELY TO PSS THRU STU IN FRONT LEFT OMPT IRUIT REKER- MP 09-0-000 () SREW G-0-0U () SPER-IRUIT REKER 9-0-000 () 0 HYRONI HET 0 OH TTERY 0 0 HYRONI HET SOLR PNEL 0 HSSIS ISONNET ONTROL 0 ENTRNE STEP 0 0 IRUIT REKER-0 MP 90-0-000 SREW G9-0-U () 00 HOLER ONNET FEE N OH REKER FEE HERE ETIL E IRUIT REKER-0 MP 09-0-000 SREW G-0-0U SPER-IRUIT REKER 9-0-000 FEE- (HSSIS) VIEW E FEE- (OH) OH TTERY ISONNET 0-0-000 TO ISOLTE STU ON OMPT WLL WIRE SM-REKERS -0-00 FEE- (OH) ONNETOR WITH YELLOW TPE FROM WIRE SM-HSSIS WIRE SM-OH REKER FEE ONNETS HERE HSSIS TTERY ISONNET 0-0-000 RELY 9-0-000 TO MULTIPLEX PNEL NNZ PP XXV LLP LLM LLK USS R IRUIT REKER 000 / -0-HT () HOLER- 0-0-000-00 MP -0-000 SREW G9-0-U () FEE- (HSSIS) HOLER- 0-0-000 - MP, TIME-ELY -0-000 SREW G9-0-U () SJ UUG LJ 0 JJZ LP MG LR FEE- USS R IRUIT REKER 000 / -0-HT PLTE-SM- SOLENOI,MOUNTING -0-HT SREW G9-0-0U () VIEW E SOLENOI-SELE 9-0-000 SREW G0-0-0U () FEE- FROM WIRE SM-HSSIS MRKE WITH YEL TPE. FROM WIRE SM-HSSIS MRKE WITH LU TPE. REPLE EXISTING SREW TO PROPERLY TTH REKER TO USS R. FROM WIRE SM-SLIEOUT. RELY ONNETS TO WIRE SM-HSSIS. (HSSIS ISONNET LOKOUT RELY) TO T SIE OF OH TTERY ISONNET ETIL E (K VIEW-OMPONENTS) GJ FEE- 9 TO ISONNET SIE OF OH TTERY ISONNET LE SM-G --00 OES/STNRS-S/MVSS OES/STNRS US WIRE TO E MRKE Y WRP OF GRN TPE 9 MM WIE WITHIN 0 MM OF EN. IRUITS RNH FROM WIRE SM-HSSIS. 0 9 WIRE TO E MRKE Y WRP OF RN TPE 9 MM WIE WITHIN 0 MM OF EN. WIRE TO E MRKE Y WRP OF WHT TPE 9 MM WIE WITHIN 0 MM OF EN. LKEN OUT THE WOR "LOK" WITH LK MRKER. ELETRIL SPEIFITIONS -0-000 ELETRIL LLOUTS 9-0-000 ESRIPTION: OF WIRING INSTL-HSSIS ITEM/PRT NO: 0000 / 90000 -ec-0
-PIN HSG TO STEP OVER TIE UP TO FRME ENTERSETION HERE -PIN HSG TO RIVERS SET LMP TO RER SIE OF GENERTOR HERE PIN HOUSING TO PSSENGERS SET MIS SWITHES & HOUSINGS WIRE SM-/V & WIRE SM-HSSIS TO PSSENGERS SWITHES LE SM (RE) 9-0-000 LE SM (GRN) (FROM OH SIE OF TTERY ISONNET) LE SM (GRN) (TO GENERTOR) 0 PIN HOUSING TO WIRE SM-IP,MIN 0-PIN HSG TO GENERTOR LE SM (LU) TO LEVELING SYSTEM PUMP LE SM (LK) GENERTOR GROUN TO STU ON FRME RIL -PIN HSG TO ELETRI STEP 000 MM LOOP EHIN GENERTOR TRY MOVEMENT LE SM (GRN)& LE SM (LK) (TO GENERTOR) OES/STNRS-S/MVSS OES/STNRS US SEE WIRING INSTL-FRONT EN ITIONL INMTION. SEE WIRE SM-HSSIS ITIONL INMTION VIEW F ELETRIL SPEIFITIONS -0-000 ELETRIL LLOUTS 9-0-000 ESRIPTION: OF WIRING INSTL-HSSIS ITEM/PRT NO: 0000 / 90000 -ec-0
RIGHT FRONT RM PIN HSG TO SLIEOUT RM MOTOR IRUITS PP,PPE PIN HSG TO SLIEOUT RM ENOER IRUITS NNT,NNV,NNU RIGHT RER RM PIN HSG TO SLIEOUT RM MOTOR IRUITS PPF,PPG PIN HSG TO SLIEOUT RM ENOER IRUITS NNW,NNY,NNX FRONT LEFT RER RM PIN HSG TO SLIEOUT RM MOTOR IRUITS LLU,LLW PIN HSG TO SLIEOUT RM ENOER IRUITS GGK,GGM,GGL OES/STNRS-S/MVSS OES/STNRS US. T MINIMUM LL WIRES TO E SUPPORTE N SEURE PER OE REQUIREMENTS. USE LMP 09 OR 09 OR WIRE TIE OR 00 N SREW G-XXX OR G-XXX S PPROPRITE INSTLLTION. ELETRIL SPEIFITIONS -0-000 ELETRIL LLOUTS 9-0-000 ESRIPTION: OF WIRING INSTL-HSSIS ITEM/PRT NO: 0000 / 90000 -ec-0
GENERTOR INVERTER LEVELING PUMP INVERTER ISONNET SWITH REMOTE-JUMP STRT STU (LOTE IN LEFT RER OMPRTMENT) GRN YEL YEL RE TO REKER PNEL TO REKER PNEL HOUSE TTERY ISONNET HSSIS TTERY ISONNET UX STRT SOLENOI REMOTE-JUMP STRT STU (LOTE IN LEFT RER OMPRTMENT) INVERTER PUR HSSIS TTERY NK HSSIS SUPPLIE STRTER GRN HOUSE TTERY NK FREIGHTLINER HSSIS SUPPLIE S & RELYS PUR REMOTE STU (LOTE IN LEFT RER OMPRTMENT) LU REMOTE STU (LOTE IN LEFT FRONT OMPRTMENT) OES/STNRS-S/MVSS OES/STNRS US SEE WIRING INSTL-FRONT EN ITIONL INMTION. TO FRONT REKER PNEL ELETRIL SPEIFITIONS -0-000 ELETRIL LLOUTS 9-0-000 ESRIPTION: OF WIRING INSTL-HSSIS ITEM/PRT NO: 0000 / 90000 -ec-0