8 ensors ø 8. mm OL UTOD, TP, G & PDF Photoelectrics ensors ensors pecial Purpose ensors Measurement & nspection ensors Vision Wireless 85. mm Opposed, on-polarized Retroreflective and ls uffix, R, L and D 86. mm Polarized Retroreflective and Fixed-field Models uffix LP and FF 8, -5V ac nfrared LD Visible Red LD ensing Mode/LD Range onnection OPPOD m Models LO m 8 mitter -pin Micro QD 8Q mitter Models DO m 8WR 8RWR -pin Micro QD 8WRQ 8RWRQ xcess Gain G- (p. ) Beam Pattern BP- (p. ) ndicators afety Light creens afety Laser canners afety ystems afety ontrollers & Modules afety Two-Hand ontrol Modules afety nterlock witches mergency top Devices OR RTRO RTRO POLR RTRO m m 8WL 8RWL -pin Micro QD 8WLQ 8RWLQ P m m 8WLP 8RWLP FD-FLD DFFU - utoff - utoff - mm utoff mm mm onnection options: model with a QD requires a mating cordset (see ). -pin Micro QD 8WLPQ 8RWLPQ G- (p. ) G- (p. ) m 8WFF5 8RWFF5 G-6 -pin Micro QD 8WFF5Q 8RWFF5Q (p. ) m 8WFF5 8RWFF5 G-7 -pin Micro QD 8WFF5Q 8RWFF5Q (p. ) m 8WFF 8RWFF G-8 -pin Micro QD 8WFFQ 8RWFFQ (p. ) m 8WD 8RWD G- -pin Micro QD 8WDQ 8RWDQ (p. ) m 8WDL 8RWDL G-5 -pin Micro QD 8WDLQ 8RWDLQ (p. ) BP- (p. ) BP- (p.) BP- (p. ) BP-5 (p. ) MTUR OMPT WORLD-BM Q8 WORLD-BM Q M-BM 8/M8 T8 Q5 MDZ FULLZ For 9 m cable, add suffix W/ to the m model number (example, 8WD W/). Retroreflective range is specified using one model BRT- retroreflector, unless otherwise noted. ctual sensing range may differ, depending on the efficiency and reflective area of the retroreflector used. ee ccessories section for more information. 8 pecifications upply Voltage and urrent upply Protection ircuitry Output onfiguration Output Rating to 5V ac (5/6 Hz). verage current: m. Peak current: m at V ac, 5 m at V ac, 75 m at 5V ac Protected against transient voltages olid-state ac switch; three-wire hookup; Light Operate (LO) or Dark Operate (DO), depending on model. Light operate: Output conducts when the sensor sees its own (or the emitter s) modulated light Dark operate: Output conducts when sensor sees dark m max. (continuous) Fixed-field: derate 5 m/ above +5 nrush capability: amp for milliseconds, non-repetitive OFF-state leakage current: less than µ O-state voltage drop: V at m ac; V at 5 m ac ourtesy of teven ngineering, nc.- Ryan Way, outh an Francisco, 98-67-Main Office: (65) 588-9-Outside Local rea: (8) 58-9-www.stevenengineering.com More on next More information online at bannerengineering.com 9
MTUR OMPT MDZ FULLZ OR 8 pecifications Output Protection ircuitry Output Response Time Delay at Power-up Repeatability ndicators onstruction Protected against false pulse on power-up Opposed: 6 milliseconds O, 8 milliseconds OFF Polarized Retroreflective, on-polarized Retroreflective, Fixed-field and Diffuse: 6 milliseconds O/OFF milliseconds (cont d) Opposed: milliseconds Polarized Retroreflective, on-polarized Retroreflective, Fixed-field and Diffuse: milliseconds Repeatability and response are independent of signal strength. Two LDs: Green: Power O Yellow: Light sensed Housings are thermoplastic polyester. Lenses are polycarbonate or acrylic; two jam nuts included. nvironmental Rating Leakproof design rated M 6P, P67. QD models rated P69K per D 5-9. onnections m or 9 m attached cable, or -pin Micro-style quick-disconnect fi tting. QD cordsets are ordered separately. ee. Operating onditions Temperature: - to +7 Relative humidity: 9% at 5 (non-condensing) Vibration and Mechanical hock ertifications ll models meet Mil. td. F requirements. Method (Vibration; frequency to 6 Hz, max, double amplitude.6-inch acceleration G). Method B conditions H& (hock: 75G with unit operating; G for non-operation) Hookup Diagrams abled mitters: (p. 7) Other abled Models: 5 (p. 7) QD mitters: 7 (p. 7) Other QD Models: 6 (p. 7) ordsets Length uro QD ee 658 Threaded -Pin traight Right-ngle m MQD-6 MQD-6R 5 m MQD-5 MQD-5R 9 m MQD- MQD-R Length Micro QD ee 67 Threaded -Pin traight Right-ngle m MQ-6 MQ-6R 5 m MQ-5 MQ-5R 9 m MQ- MQ-R dditional cordset information available. ee 655. Brackets M8 & 8 RFLTOR RFLTOR PRTUR PRTUR pg. 67 pg. 67 pg. 69 pg. 66 MB8F.. MB8 MB8 MBM8P dditional brackets and information available. ee 6. PG 68 PG 79 ourtesy of teven ngineering, nc.- Ryan Way, outh an Francisco, 98-67-Main Office: (65) 588-9-Outside Local rea: (8) 58-9-www.stevenengineering.com More information online at bannerengineering.com
xcess Gain urves (Diffuse and Fixed-Field mode performance based on 9% reflectance white test card ) = nfrared LD P = Visible Red LD Polarized 8/M8 Retroreflective Mode 8/M8 Polarized Retroreflective Mode 8/M8 8/M8 Photoelectrics ensors ensors pecial Purpose ensors Measurement & nspection ensors Vision G- G. m (.') 8/M8 eries m m (.') (') DT m (') G- G. m (.') 8/M8 eries with BRT- Reflector. m m (.') (.') DT on-polarized Retro m (') G- G. m (.') 8/M8 eries with BRT- Reflector. m m (.') (.') DT Polarized Retro m (') G- G mm (.") Minimum Gain 8/M8 eries hort Range Maximum Gain mm mm (.") (") DT mm (") Wireless ndicators afety Light creens afety Laser canners afety ystems afety ontrollers & Modules Range: m LD: Range: m LD: Range: m LD: P Range: mm LD: afety Two-Hand ontrol Modules 8/M8 Fixed-Field Mode 8/M8 afety nterlock witches mergency top Devices G-5 G mm (.") Maximum Gain Range: mm LD: Minimum Gain 8/M8 eries Long Range mm mm (.") (") DT mm (") G-6 Fixed-Field Mode 8/M8 G. mm (.") utoff: LD: 8/M8 eries Fixed-field mode with far limit cutoff mm mm (.") (.") DT mm (") Ø mm spot size @ 8 mm focus Ø mm spot size @ cutoff Using 8% gray test card: utoff distance will be 95% of value shown. Using 6% black test card: utoff distance will be 9% of value shown. Fixed-Field Mode 8/M8 MTUR OMPT WORLD-BM Q8 WORLD-BM Q M-BM 8/M8 T8 Q5 MDZ FULLZ 8/M8 eries Fixed-field mode with far limit cutoff Ø mm spot size @ mm focus Ø mm spot size @ cutoff 8/M8 eries Fixed-field mode with mm far limit cutoff Ø mm spot size @ mm focus Ø mm spot size @ mm cutoff G-7 G. mm (.") mm mm (.") (.") DT mm (") Using 8% gray test card: utoff distance will be 9% of value shown. Using 6% black test card: utoff distance will be 85% of value shown. G-8 G. mm (.") mm mm (.") (.") DT mm (") Using 8% gray test card: utoff distance will be 85% of value shown. Using 6% black test card: utoff distance will be 75% of value shown. utoff: LD: utoff: mm LD: ourtesy of teven ngineering, nc.- Ryan Way, outh an Francisco, 98-67-Main Office: (65) 588-9-Outside Local rea: (8) 58-9-www.stevenengineering.com More information online at bannerengineering.com
MTUR OMPT MDZ FULLZ Beam Patterns (Diffuse mode performance based on 9% reflectance white test card) = nfrared LD P = Visible Red LD Polarized 8/M8 Retroreflective Mode 8/M8 Polarized Retroreflective Mode 8/M8 8/M8 OR ffective Beam: mm mm mm 8 eries 6" " " " " 6" mm 8 mm mm mm 8 mm mm 8 eries on-polarized Retro with BRT- Reflector.7".".6".6".".7" mm mm 8 eries Polarized Retro with BRT- Reflector 6" " " " " 6" mm mm 8 eries hort Range Diffuse.6".".".".".6" BP- 5 m (6') m 5 m (') (9') DT m (66') 5 m (8') BP-.5 m (.6'). m.5 m (.') (.8') DT. m (6.').5 m (8.') BP-.5 m (.6'). m.5 m (.') (.8') DT. m (6.').5 m (8.') BP- (") 7 mm (") (") (") (5") DT Range: m LD: Range: m LD: Range: m LD: P Range: mm LD: 8/M8 mm mm 8 eries Long Range Diffuse.6".".".".".6" BP-5 8 mm 6 mm mm mm mm (") (6") (9") (") (5") DT Range: mm LD: ourtesy of teven ngineering, nc.- Ryan Way, outh an Francisco, 98-67-Main Office: (65) 588-9-Outside Local rea: (8) 58-9-www.stevenengineering.com More information online at bannerengineering.com
HOOKUP WRG DGRM RFR HRT GLORY TRTOL RP Hookups -wire -wire with Quick-Disconnect able RFR -V ac = Brown = Blue -V ac = Green = Red/Black = Red/White ot Used OT: Wire a load in series before powering up sensor. OT: Wire a load in series before powering up sensor. -Pin Micro mitters mitters with Quick-Disconnect able ee pecifications = Brown = Blue ee pecifications = Green = Red/Black = Red/White ot Used -Pin Mini 5-Pin Mini -Pin Micro -Pin Mini 5 More on next ourtesy of teven ngineering, nc.- Ryan Way, outh an Francisco, 98-67-Main Office: (65) 588-9-Outside Local rea: (8) 58-9-www.stevenengineering.com 7 More information online at bannerengineering.com
Hookups Hookups Wiring Diagrams 5 -wire 6 -wire with Quick-Disconnect able Reference harts Glossary nternational Reps ee pecifications = Brown = Blue = Black ee pecifications = Red/Black = Red/White = Red = Green ot Used -Pin Mini -Pin Micro 7 mitters with Quick-Disconnect able 8 PDT lectromechanical Relay Output ee pecifications = Red/Black = Red/White = Red = Green ot Used 5 ee pecifications...o. = Brown = White = Blue = Black 5 = Yellow -Pin Micro 5-Pin Mini 5 More on next ourtesy of teven ngineering, nc.- Ryan Way, outh an Francisco, 98-67-Main Office: (65) 588-9-Outside Local rea: (8) 58-9-www.stevenengineering.com More information online at bannerengineering.com 7