6400V-350, 4, V all ontrol Valve arbon Steel ody, Hardened hrome Plated, Stainless Steel all and Stem Product eatures ast quarter turn open or closed operation, Stainless steel ball and stem, Positive shut-off, Two piece body construction pplication Water-side control of air handling apparatus in ventilation and air-conditioning system. Water/Steam control in heating systems. 300: rangeability. The dimensions and drilling of end flanges conform to the merican cast iron flange standard, lass 50 (NSI 6.). Suitable ctuators Non-Spring lectronic ail-safe 6400V-350 SY2, GM(X) GK(X) ate created, 0/2/206 - Subject to change. elimo ircontrols (US), Inc. Technical ata 49 Service chilled or hot water, up to 60% glycol, steam low haracteristic equal percentage ontrollable low Range 5 Size [mm] 4 [00] nd itting NPT female ends ( to 2 ); ISO flange (3 to 6 ) ody W Grade arbon steel all stainless steel Stem stainless steel Stem Packing spring loaded Teflon V-ring all Seat Teflon ody Pressure Rating [psi] SM/NSI lass 50 Max Inlet Pressure (Steam) 200 psi Media Temperature Range -22 to 380 [-30 to 93 ] (Water) Media Temperature Range -22 to 380 [-30 to 93 ] (Steam) Maximum ifferential Pressure 00 psi (Steam) Max ifferential Pressure (Water) 50 psi Maximum ifferential Pressure 00 psi Steam (Rotary ctuator) lose-off Pressure 50 psi lose-off Pressure (Steam) 200 psi Rangeability 300: v 350 Weight 5.3 lb [26 kg] Leakage NSI lass IV Servicing Repack/Rebuild kits available low Pattern H GM, GMX H2 H H2 2.6 [320] 9 [229] 8.23 [463] 3.3 [334] 4.5 [4] 0.5 [20] 0.5 [5] 800-543-9038 US 866-805-089 N 203-9-8396 LTIN MRI / RIN
6400V-350, 4, V all ontrol Valve arbon Steel ody, Hardened hrome Plated, Stainless Steel all and Stem J SY2 J 4.3 9 [229] 24. 9.6 5.5 4.5 [4] 32.2 [365] [628] [498] [3] [88] H2 H GK, GKX H H2 3.6 9 [229] 8.23 3.3 4.5 4.5.8 0.5 [5] [334] [463] [334] [4] [4] [30] ate created, 0/2/206 - Subject to change. elimo ircontrols (US), Inc. 800-543-9038 US 866-805-089 N 203-9-8396 LTIN MRI / RIN
GKX24-MT-X Modulating, lectronic ail-safe, 24 V, for 2 to 0 V or 4 to 20 m ontrol Signal ate created, 0/2/206 - Subject to change. elimo ircontrols (US), Inc. Technical ata 294 Power Supply 24 V ± 20%, 50/60 Hz, 24 V ± 0% Power onsumption Running 2 W Power onsumption Holding 3 W Transformer Sizing 2 V (class 2 power source) lectrical onnection 8 G plenum rated cable with /2 conduit connector protected NM 2 (IP54) 3ft [m] 0 ft [3m] and 6 ft [5m] Overload Protection electronic throughout 0 to 95 rotation Operating Range Y 2 to 0 V, 4 to 20 m w/ ZG-R0 (500, /4 W resistor), variable (V, floating point, on/off) Impedance 00 k for 2 to 0 V (0. m), 500 for 4 to 20 m, 500 for PWM, floating point and On/Off eedback Output U 2 to 0 V, 0.5 m max, V variable ngle of Rotation max. 95, adjustable with mechanical stop irection of Rotation (Motor) reversible with built-in switch irection of Rotation (ail-safe) reversible with switch Position Indication reflective visual indicator (snap on) Manual Override external push button Running Time (Motor) 50 sec (default), variable (95 to 50 sec) Running Time (ail-safe) 35 sec ridge Time programmable 0 to 0 sec (2 sec default) delay before fail-safe activates Pre-charging Time 5 to 20 seconds Humidity 5 to 95% RH non condensing (N 6030-) mbient Temperature Range -22 to 22 [-30 to 50 ] Storage Temperature Range -40 to 6 [-40 to 80 ] Housing NM 2, IP54, UL enclosure type 2 Housing Material UL94-5V gency Listings culus acc. to UL6030-/-2-4, N/S 6030-:02, acc. to 2004/08/ and 2006/95/ Noise Level (Motor) <45 d () Noise Level (ail-safe) <45 d () Servicing maintenance free Quality Standard ISO 900 Weight 4 lb [.8 kg] Rated Impulse Voltage 800V, Type of action., ontrol Pollution egree 3 800-543-9038 US 866-805-089 N 203-9-8396 LTIN MRI / RIN
GKX24-MT-X Modulating, lectronic ail-safe, 24 V, for 2 to 0 V or 4 to 20 m ontrol Signal Wiring iagrams INSTLLTION NOTS 24 V Transformer 3 46 4 ctuators with appliance cables are numbered. Provide overload protection and disconnect as required. lk () ommon ctuators may also be powered by 24 V. Only connect common to negative (-) leg of control circuits. 500 resistor (ZG-R0) converts the 4 to 20 m control signal to 2 to 0 V. ontrol signal may be pulsed from either the Hot (Source) or ommon (Sink) 24 V line. or triac sink the ommon connection from the actuator must be connected to the Hot connection of the controller. Position feedback cannot be used with a triac sink controller; the actuator internal common reference is not compatible. eedback V (+) On/Off 24 V Transformer ( Only) Pnk (4) Y Y 2 0 46 4 lk () ommon IN4004 or IN400 diode. (IN400 supplied, elimo part number 4055). Y 46 4 ctuators may be controlled in parallel. urrent draw and input impedance must be observed. Master-Slave wiring required for piggy-back applications. eedback from Master to conrol input(s) of Slave(s). Meets culus requirements without the need of an electrical ground connection.! WRNING! LIV LTRIL OMPONNTS! uring installation, testing, servicing and troubleshooting of this product, it may be necessary to work with live electrical components. Have a qualified licensed electrician or other individual who has been properly trained in handling live electrical components perform these tasks. ailure to follow all electrical safety precautions when exposed to live electrical components could result in death or serious injury. eedback V (+) loating Point 24 V Transformer ontrol Signal ( ) V / m (+) V/m ontrol 500 /4 watt 24 V Transformer ( only) eedback V (+) PWM ontrol Pnk (4) Y 2 3 5 46 4 lk () ommon Y Pnk (4) Y2 8 46 4 lk () ommon Y Pnk (4) Y 2 ate created, 0/2/206 - Subject to change. elimo ircontrols (US), Inc. 800-543-9038 US 866-805-089 N 203-9-8396 LTIN MRI / RIN
GKX24-MT-X Modulating, lectronic ail-safe, 24 V, for 2 to 0 V or 4 to 20 m ontrol Signal 24 V Transformer ( Only) 5 ontrol Signal ( ) V / m (+) unctions Min 0% Mid 50% Max 00% Normal ontrol mode acc. to Y Override ontrol lk () 2 Pnk (4) a b c Org (5) ommon Y Y 2 24 V Transformer ( ) ontrol Signal (+) Master lk () Org (5) 5 46 4 ommon Y Slave lk () ommon Org (5) Y Master - Slave ate created, 0/2/206 - Subject to change. elimo ircontrols (US), Inc. 800-543-9038 US 866-805-089 N 203-9-8396 LTIN MRI / RIN