USER'S MANUAL TRANSPORT POWER SUPPLY P-05 SAES ADVANCED TECHNOLOGES S.p.A. - tly www.sesgetters.com
1:,. : The TRANSPORT POWER SUPPLY P05 power supply serves for operting the NEXTorr pumps. WARNNG After trnsporttion, the device hs to be left idle without mins voltge for t lest 3 hours t the lbortory Security provisions ATTENTON nside the instrument nd lso in the connector nd cble for the ion pump connection, high voltge is present which is cpble of cusing csulty even without ny direct touch. Mnipultion the high voltge cble nd lso of the grounding wire is prohibited during the course of the supply opertion. Likewise, the supply opertion without protective covers is prohibited. Protect the device ginst humidity nd ginst penetrtion of conductive objects nd liquids into the ventiltion slots. Symbols on the Product These symbols pper on the product: Lt WARNNG High voltge Ground terminl & CAUTON Refer to mnul POWER SUPPLY P-05 - USER'S MANUAL M.HST.0079.23 Rev.1 Pge 2 of 10
NDEX ~ : ::ll :::11 ==- 1. OPERATON....................... 4 1.1. Operting instructions for trnsport ion getter pump source... 4 1.2. List of commnds........... 4 2. SPECFCATON......,.............. :... 6 3. TROUBLESHOOTNG.................. 6 4. NSTRUCTON FOR NSTRUMENT DSPOSAL... 6 5. WARRANTY CONDTONS............................ 7 6. SERVCE....................... 8 6.1. Sles & Service Loctions:... 8 POWER SUPPLY P-05 - USER'S MANUAL M.HST.0079.23 Rev. 1 Pge 3 of 10
J~-5"" \$ ) 1. OPERATON 1.1. Operting instructions for trnsport ion getter pump source J s:! r : ~ ill ill ill!ti ii ~ " The trnsport source is used for pumping ny vcuum system with diode type ion getter pumps (with positive voltge supply) during trnsport. The source llows to power vcuum pumps with the working voltge of 5 kv nd the totl current up to 100 µa. The source is using the 9 piece LR14 btteries with totl nominl voltge of 13,5V. After connection of the HV output cbles t the ion pumps switch on the min switch. The opertion is indicted by the wek whistling (the height of the tone is dependent on immedite current of the vcuum pumps) nd by flshing the lights on the Pnel. The first 1 O s one red nd one green light is flshing nd then only some of the three green lights is lso flshing, tht indictes the totl current in both pumps in the fields of 0-10 µa, 10-50 µa, or 50-100 µa. f there is n excess of totl current over 100 µa (or short circuit), the source is utomticlly shut down for period of 1 min during tht the red light is flshing. Then the source tries to strt gin. f the source is in use, it is possible to press the button (by the pproprite instrument) with the BATTERY mrk to disply the bttery sttus. The red light flshing mens the criticl btteries dischrge (the voltge < 9V) nd they need to be replced s soon s possible. The source utomticlly turns off if the bttery voltge flls below 6.5 V. When using lkline btteries nd the totl current of pumps is 20 µa the source cn work of bout 16 dys. This period my lso be dversely ffected by temperture. The operting prmeters nd historicl record cn be visulized on PC vi RS-232 interfce with communiction speed of 115 200biUs. 1.2. List of commnds End of every commnd mmedite output voltge mmedite totl current mmedite bttery voltge mmedite totl current <Enter u 5990 v 430 na B 12800 mv 430 na POWER SUPPLY P-05 - USER'S MANUAL M.HST. 0079.23 Rev. 1 Pge 4of 10
'. mmedite temperture Number of records T 24 c F 07Records The record of current list of vlue is clled by commnd FOO, previous one F01 etc. The oldest record hs the highest number. The record is relized only when the source is running more thn 1 min. Commnd Displyed (typed) vlue Description History record f 07 Exmple Record# 7 Totl Time: 24600 min ' Totl time fter bttery chnge On Time: 1475770 s Totl time fter source switching on Chrge: 266490149 uc Totl curried chrge Mx. : 539864 s: 20140 na Mximum current nd Min. : 1466 s: 19490 na Minimum current nd Mx. T: 1376897 s: 26 C Mximum temperture nd Min. T: 423169 s: 18 C Minimum temperture nd Min. B: 1475738 s: 7900 mv Current: 00 na Voltge: 00 V Bttery: 3200 mv Minimum bttery voltge nd Lst vlue of current Lst vlue of pump voltge Lst vlue of bttery voltge &. Cution: After communiction cble connection the consumption from bttery is rising of bout 5mA. Therefore if it is not necessry, do not leve the communiction cble connected! POWER SUPPLY P-05 - USER'S MANUAL M.HST.0079.23 Rev.1 Pge 5 of 10
. '. 2. SPECFCATON Operting voltge: Mximum lod current: Stndlone opertion required : Totl nominl voltge: Communiction protocol (History record): 6 kv 100 µa 9 bttery cells (size LR14, C, bby) 13.5 V. RS232/115200 Bd 16 Alkline bttery endurnce - lod current 20 µa ~6 l 0 0 l 6 8 10 12 14 16 18 20 Dys 3. TROUBLESHOOTNG The device conforms with CSN EN 61010-1 stndrd sfety requirements. 4. NSTRUCTON FOR NSTRUMENT DSPOSAL The instrument disposl should be crried out in complince with the user's country pplicble regultions. The instrument contins mterils which my endnger the environment. When disposing of the instrument, seprte disssembly by mteril is to be rrnged for nd the different mterils shll be collected seprtely for disposl. Neither the collection nor the trnsport of thus collected nd seprted mterils is subject to ny specil requirements. POWER SUPPLY P-05 - USER'S MANUAL M.HST.0079.23 Rev.1 Pge 6of10
f;:: i i::. ~ t: ~ c ~ t: t E ' r t t 5. WARRANTY CONDTONS SAES gurntees tht the Products delivered shll be free from opertionl nd mteril defects nd shll comply with the construction nd functionl dt nd specifictions indicted in the Contrctul Documents. This wrrnty shll hve term of TWELVE (12) MONTHS. For Products which require instlltion t BUYER's fcility by SAES personnel, the wrrnty shll hve term of TWELVE (12) MONTHS from the dte of instlltion or FOURTEEN (14) MONTHS from the dte of delivery, whichever term is shorter. Subject to the reminder of this Article 14, ny ction by BUYER for ny lleged brech of this wrrnty shll be brought in writing by BUYER within thirty (30) dys of BUYER's discovery of the brech. This wrrnty shll only pply to the BUYER nd my not be ssigned. During the term of the wrrnty set forth bove, SAES will promptly repir the Products which for their fetures cn be repired nd which do not conform to the specifictions nd which BUYER returns to SAES t the ddress provided. Unless otherwise greed nd specified, BUYER shll be responsible for ll trnsporttion chrges incurred in returning Products to SAES for repir; BUYER shll hve obtined Returned Mteril Authoriztion ("RMA") number nd specific shipping instructions from SAES prior to its shipping of the Products to SAES. SAES shll not unresonbly deny BUYER uthoriztion to ship Products to SAES. SAES shll return repired Products to BUYER, with trnsporttion chrges prepid by SAES, unless otherwise greed. Additionl informtion is vilble on the Generl conditions of sles. : POWER SUPPLY P-05 - USER'S MANUAL M.HST.0079. 23 Rev.1 Pge 7of 10
6. SERVCE For request of return of the component contct SAES Customer Service nd will receive Return Merchndise Authoriztion (RMA) number. SAES S.p.A. cn not ccept ny instrument which contins biologicl hzrds or rdioctivity. f this requirement present problem cll SAES Customer Service to discuss lterntives solutions: 6.1. Sles & Service Loctions: Europe, Middle Est nd Afric: SAES Getters S.p.A. Vile tli 77 20020 Linte (Miln) - tly Ph. +39 02 93178 1 - Fx +39 02 93178 320 Europen Customer Reltions: Ph. +39 02 9317 8402 - Fx +39 02 93178320 E-mil: CRM_SALES@ses-group.com Asi nd Oceni: SAES Getters S.p.A. -Jpn Technicl Service Brnch Office 2nd Gotnd Fujikoshi Bldg. 23-1 Higshi Gotnd 5-Chome Tokyo 141, Jpn Ph. +81 3 542 00431 - Fx +81 3 542 00438 SAES Getters (Nnjing) Co.,Ltd. 56 Xingngddo, Xinshengwei Nnjing Economic & Technicl Development Zone Nnjing 210038, Jngsu Province, P.R. of Chin Ph. +86 25 8580 2335 - Fx +86 25 8580 1639 SAES Getters Kore Corportion 7th Fl. Dongwon Bldg. 143-28 Smsung-dong, Gngnm-gu Seoul 135-877, Kore Ph. +82 2 3404 2400 - Fx +82 2 3452 4510/11 North nd South Americ: SAES Getters USA, nc. 1122 Est Cheyenne Mountin Blvd. Colordo Springs, CO 80906 - USA Ph. +1719576 3200 - Fx +1719576 5025 POWER SUPPLY P-05 - USER'S MANUAL M.HST.0079.23 Rev.1 Pge 8of10
S,7 E -/ u --~-- G,<;f--7 lo~ '1 7. 0 E~7!. 3 f --7 1<& f; ~ 7 2ot11-.,..,?o~,1 ~,Lt\:-7 '2.~~-1?. ~ e ~-, 2.( E-7 1 (:,,7 ~, 7 t-7 (, c; h ") (JJQrfl 1] tjo-.(' J.rr J, b. /:.( ~ tj ~ ( vf log lo/ro\ 1$ 1.HC.< J(l "'\c,j \ 1 Jfi\ \c cl.µ ( 1'J 1- i o "1-- /0 6 lo u re~~ l.' JO.tc~ fy.~v' th~. fves<:.v.rts ev~ lc--'e"" ~b ~.&{--~~'Dr ~ectcjwj-el.. fl.a.va' r ll~ ~'" 1. s 0v< tv <,(_(. cf{. )et fialer--- f'u~ -: 7, Sr' ( (Ve.,.i J,r. ~ v H~ ---": ~ 1 r- f;