SERVICE MANUAL Ver.0 2004.05 US Model Canadian Model ICF-C763 AEP Model ICF-C763/C763L UK Model ICF-C763L SPECIFICATIONS Time display UK, North and South America Other countries/regions 2-hour system 24-hour system Power requirements North and South American model Other model : 20 V AC, 60 Hz : 230 V AC, 50 Hz Frequency range Model for North and South America Band ICF-C763 Channel step FM 87.5-08 MHz 0. MHz AM 530-70 khz 0 khz Model for other countries/regions Band ICF-C763 ICF-C763L Channel step FM 87.5-08 MHz 87.5-08 MHz 0.05 MHz AM (MW) 53-602 khz 53-602 khz 9 khz LW 53-279 khz 3 khz Speaker Approx. 5.7 cm (2 / 4 inches) dia. 4 Ω Dimensions Approx. 5.5 x 05 x 0.6 mm (w/h/d) (4 5 / 8 x 4 / 4 x 4 3 / 8 inches) including projecting parts and controls Mass Approx. 665 g ( lb 7.5 oz) Approx. 675 g ( lb 7.8 oz): ICF-C763L (UK model) Approx. 600 g ( lb 5.2 oz): ICF-C763 (North and South America model) Design and specifications are subject to change without notice. Power output 200 mw (at 0 % harmonic distortion) ICF-763 FM/AM PLL SYNTHESIZED CLOCK RADIO ICF-763L FM/MW/LM PLL SYNTHESIZED CLOCK RADIO 9-877-783-0 2004E02-2004.05 Sony Corporation Personal Audio Company Published by Sony Engineering Corporation
TABLE OF CONTENTS Specifications.... GENERAL Location and Function of Controls... 3 2. ELECTRICAL ADJUSTMENTS... 4 3. DIAGRAMS 3-.IC Block Diagrams... 6 3-2. IC Pin Function Descriptions... 7 3-3. Printed Wiring Board Main section... 8 3-4. Schematic Diagram Main section... 9 3-5. Printed Wiring Board Contrd section... 0 3-6. Schematic Diagram Contrd section... 3-7. Printed Wiring Board Power section... 2 3-8. Schematic Diagram Power section... 2 4. EXPLODED VIEW 4-.Cabinet (Upper) Section... 3 5. ELECTRICAL PARTS LIST... 4 SAFETY CHECK-OUT After correcting the original service problem, perform the following safety checks before releasing the set to the customer: Check the antenna terminals, metal trim, metallized knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. LEAKAGE The AC leakage from any exposed metal part to earth Ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 ma (500 microampers). Leakage current can be measured by any one of three methods.. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers instructions to use these instruments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The limit indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A) HOW TO CHANGE THE CERAMIC FILTER This model is used two ceramic filters of CF2 and CF3. You must use same type of color marked ceramic filters in order to meet same specifications. Therefore, the ceramic filter must change two pieces together since it's supply two pieces in package as a spare parts. mark Mark Center mark frequency CF2 CF3 no mark blue orange black white 0.70MHz 0.67MHz 0.73MHz 0.64MHz 0.76MHz 0.5µF To Exposed Metal Parts on Set.5kΩ AC voltmeter (0.75V) Earth Ground Fig. A. Using an AC voltmeter to check AC leakage. SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY. ATTENTION AU COMPOSANT AYANT RAPPORT À LA SÉCURITÉ!! LES COMPOSANTS IDENTIFIÉS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHÉMATIQUES ET LA LISTE DES PIÈCES SONT CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY. 2
LOCATION AND FUNCTION OF CONTROLS SECTION GENERAL ICF-C763/C763L This section is extracted from instruction manual. The PRESET 3 button and VOLUME have a tactile dot. BRIGHTNESS TUNE/TIME SET PUSH OPEN NAP D.S.T./ CLOCK ALARM A B PRESET SELECT ENTER 2 3 4 ALARM MODE 5 SNOOZE/ SLEEP OFF SNOOZE/SLEEP OFF NIGHT LIGHT MODE OFF ON STANDBY AC power cord FM2 MW AM LW PM SLEEPRADIO A RADIO B SOUND 2345 WAKE UP PRESET MHz khz RADIO ON OFF SLEEP PRESET BAND VOLUME 3
SECTION 2 ELECTRICAL ADJUSTMENTS TUNER SECTION 0 db = µv AM Section Setting: BAND button: AM <MW and LW> < > : ICF-C763L ICF-C763 [ ] : Italian model AM IF ADJUSTMENT Adjust for a maximum reading on level meter. T 450 khz AM RF signal generator 30% amplitude modulation by 400 Hz signal FM Section Setting: BAND button:fm FM RF signal generator 0.0 µf 22.5 khz frequency deviation by 400 Hz signal output level : as low as possible Put the lead-wire antenna close to the set. TP (ANT) set Connecting Level Meter (FM, AM<MW and LW>) SPK+ level meter (range 0.5-5V AC) 32 Ω Connecting Digital Voltmeter (FM, AM <MW and LW>) TP (VT) 00 kω digital voltmeter Repeat the procedures in each adjustment several times, and the frequency coverage and tracking adjustments should be finally done by the trimmer capacitors. Frequency Display AM FREQUENCY COVERAGE ADJUSTMENT 530 khz [53 khz],70 khz [,602 khz] Reading on Digital voltmeter 3.0 ± 0. V 0.0 ±.0V[9.0 ±.0V] Adjustment Part L4 <confirmation> AM TRACKING ADJUSTMENT Adjust for a maximum reading on level meter. L CT 530 khz [53kHz].490 khz [.404kHz] ICF-C763L MW IF ADJUSTMENT Adjust for a maximum reading on level meter. T 450 khz MW FREQUENCY COVERAGE ADJUSTMENT Frequency Display 53 khz.602 khz Reading on Digital voltmeter 2.75 ± 0. V 9.0 ±.0 V Adjustment Part L4 <confirmation> MW TRACKING ADJUSTMENT Adjust for a maximum reading on level meter. L CT 62 khz.404 khz LW FREQUENCY COVERAGE ADJUSTMENT Frequency Display 53 khz 279 khz Reading on Digital voltmeter 2.3 ± 0.3 V 9.0 ± 0. V Adjustment Part <confirmation> CT4 LW TRACKING ADJUSTMENT Adjust for a maximum reading on level meter. L ICF-C763/C763L CT2 62 khz 243 khz FM FREQUENCY COVERAGE CONFIRMATION Frequency Display 87.5 MHz 08 MHz Reading on Digital voltmeter 3.2 ± 0.3 V 0.0 ±.5 V Adjustment Part <confirmation> <confirmation> FM TRACKING ADJUSTMENT Adjust for a maximum reading on level meter. L2 CT3 87.5 MHz 08 MHz Adjustment and Connect Location: See page 5. 4
Adjustment and Connect Location MAIN BOARD (Component Side) L4 : AM (MW) Frequency coverage adjustment CT4 : LW Frequency coverage adjustment CT : AM (MW) tracking adjustment T : AM (MW) IF adjustment CT2 : LW tracking adjustment L : LW tracking adjustment L2 : FM tracking adjustment L : AM (MW) tracking adjustment CT3 : FM tracking adjustment MAIN BOARD (Conductor Side) MAIN BOARD (Conductor Side) IT,UK D03 2 D04 IT,AEP JW9 C43 Q E B C D CT C763L R3 R JW8 C763L C763 C R2 C2 R7 C3 C4 C2 US, TP(VT) D4 C C6 SPK+ C28 7 R2 C27 JW2 JC C26 R6 C29 R20 R22 IC C40 28 C C B E C36 C33 JC JW3 4 5 Q7 E C34 C32 C37 CF R9 C4 R T C3 2 SPK+ C39 JW4 C3 CT TP(ANT) CF2 TP (VT) TP (ANT) 5
SECTION 3 DIAGRAMS Circuit Boards Location Note: All capacitors are in µf unless otherwise noted. pf: µµf 50 WV or less are not indicated except for electrolytics and tantalums. All resistors are in Ω and /4 W or less unless otherwise specified. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Note: Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une piéce portant le numéro spécifié. A : B+ Line. H : adjustment for repair. Voltages are dc with respect to ground under no-signal conditions. no mark : FM ( ) : AM Voltages are taken with a VOM (Input impedance 0 MΩ). Voltage variations may be noted due to normal production tolerances. Signal path. F : FM f : AM Abbreviation CND : Canadian model IT : Itarian model Note: X : parts extracted from the component side. : Pattern from the side which enables seeing. 3-. IC Block Diagrams IC CXA09M GND GND AF OUT Vcc RIPPLE FILTER AF IN DET OUT 30 29 28 27 26 25 24 23 22 2 20 9 8 7 6 AF POWER AMP AM IF DET AGC AM FE TUNING METER FM IF FM DISCRIMINATOR FM FE 2 3 4 5 6 7 8 9 0 2 3 4 5 GND GND FM DISCRI NF VOL AM OSC AFC FM OSC REG OUT FM RF AM RF IN N. C FM RF IN FE GND MIX OUT AFC AGC AFC AGC IF GND METER N. C FM IF IN AM IF IN FM/AM BAND SELECT 6
3-2. IC Pin Function Descriptions IC00 SYSTEM CONTROL (MPD7072GB-573-A7) Pin No. Pin Name I/O Description, 2 BACK LIGHT, 2 O Back light LED 3, 4 ILLUMINATION, 2 O Illumination LED 5 to 9 KS0 to 4 O Key source 0 to 3 KR0 to 3 I Key return (Pull-down resistor: ON setting) 4 ILLUMINATION 2 O Illumination LED 5 MUTE O Mute output 6, 7 BAND, 2 O Band output 8 GND Ground 9 EO O Output for charge pump for PLL frequency synthesizer 20 VCOL I VCO input on AM band 2 VCOH I VCO input on FM band 22 REG0 Voltage regulator for PLL output 23 VDD Power supply (+3V) 24 XOUT O Connected to crystal oscillator for system clock (75kHz) 25 XIN I Connected to crystal oscillator for system clock (75kHz) 26 REG Voltage regulator for oscillation circuit output 27 REGLCD0 LCD drive power supply terminal 28, 29 CAPLCD0, Connected to the capacitor for doubler circuit 30 REGLCD LCD drive power supply terminal 3 to 34 COM0 to 3 O LCD common output 35 to 49 LCD0to 4 O LCD segment output 50 CE I Chip enable signal input 5 INT I Door open/close detect input 52 BEEP O BEEP output 53 MELODY ST O Melody IC starts playing 54 MELODY CK O Melody IC serial clock 55 MELODY DATA O Melody IC serial data 56 INTIAL O Initial output 7 7
3-3. PRINTED WIRING BOARD MAIN SECTION 2 3 4 5 6 A B C D B KEY BOARD (Page 0) IT,UK C8 CN2 4 3 D03 2 D04 IT,AEP JW9 C4 D00 JC04 MAIN BOARD E B C R09 R00 C2 R2 JW07 R3 C0 C37 JC03 CT C7 C5 R3 JW8 C763L C763 C R2 C2 JW02 56 C3 C4 C2 R22 C6 C5 R5 C3 CT2 8 C4 C22 C B E JC02 C C9 C763L 43 42 IC00 C7:C763 JC7:C763L R4 JW C B E R30 C44 C20 CT3 C0 C30 JW3 D0 C8 D2 E B C R8 R9 R6 C32 C33 C9 C20 R24 R8 D00-02 (BACK LIGHT) 29 C5 LCD0 E B C C23 R4 JW03 R5 C24 L3 C07 C JW0 28 C3 X0 C30 R29 US,CND 4 5 C27 R0 JW C763L C22 C26 R8 C3 C36 R3 JW6 R9 C23 R20 C6 C8 C6 R2 C42 C7 R0 R23 Q5 C763L US,CND Q6 JC2 R2 JW0 R7 CT4 C27 Q Q2 Q4 R3 C43 R TP(VT) D D4 L4 C25 D3 L2 BPF C29 C34 C28 C35 C28 R7 JW2 JC C26 R6 C29 R25 JW7 R20 4 JC05 JW05 Q02 C25 R28 C9 CF3 R22 C B E R4 IC0 C08 C09 IC C40 R7 5 8 C2 C06 R5 CF2 R0 JC8 JC9 C33 C36 C B E R05 R06 R02 JW3 4 5 TP(ANT) 28 Q7 C24 D02 E B C C34 C32 C37 CF C B E R08 R03 R04 C B E R2 R25 C B E R07 T C05 R26 R26 R27 R Q03 D06 Q3 R9 C4 Q0 C04 JC06 R Q00 C3 D05 CN3 5 4 2 SPK+ JC07 C39 C03 R32 JW4-86-853- C35 2 6 C38 CN 7 () A POWER BOARD (Page 2) C KEY BOARD (Page 0) z Semiconductor Location Ref. No. Location D D-2 D2 D-3 D3 D-3 D4 D-2 D00 B-2 D0 B-3 D02 B-5 D03 D- D04 D- D05 B-5 D06 B-5 IC D-4 IC00 B-3 IC0 B-4 Q C-2 Q2 C-3 Q3 C-5 Q4 C-3 Q5 C-3 Q6 C-3 Q7 D-5 Q00 A-5 Q0 A-5 Q02 B-4 Q03 B-5 E L LW/MW FERRITE-BAR ANTENNA C763L L AM FERRITE-BAR ANTENNA C763 C763L K L4 8 8
C27 C36 C28 C35 C29 C34 0. 2.2 22p 22p 0p 8p MUTE BAND BAND2 GND EO VCOL VCOH REG0 VDD XOUT XIN REG RLCD0 CLCD0 INITIAL MELODY DATE MELODY CK MELODY ST BEEP INT CE LCD4 LCD3 LCD2 LCD LCD0 LCD9 LCD8 LCD3 LCD2 LCD LCD0 JW0 JW02 JW03 LCD9 LCD8 D3 HVU202ATRU LCD3 LCD LCD2 LCD9 LCD0 LCD7 LCD8 LCD5 LCD6 LCD3 LCD4 LCD LCD2 LCD0 COM3 COM COM2 COM0 ICF-C763/C763L 3-4. SCHEMATIC DIAGRAM MAIN SECTION C763 L AM FERRITE-BAR ANTENNA CT,L AM TRACKING JW8 D4 KV60S R00 R0 R02 2.2 2.2 2.2 JC05 D00 D0 D02 SLP-WH8A-5-SW SLP-WH8A-5-SW SLP-WH8A-5-SW LCD0 LIQUID CRYSTAL DISPLAY C763L CT,L MW TRACKING L MW/LW FERRITE-BAR ANTENNA CT2,L LW TRACKING CT C2 00p CT2 TP (ANT) C 470p R2 2.2M L2 D KV563M R3 0k Q 2SC393-C BAND SELECT SWITCH C8 000p CT3,L2 FM TRACKING R8 BPF 0k R 2.2k C763 C3 C6 0.047 220p C4 000p R4 R5 00k 2.2M CT3 D2 HVU202ATRU C5 220p C7 2200p JC7 C763L C25 000p JW R5 TP (VT) C30 22 25V R6 00k C24 0p C0 5p C9 0p L3 82nH R4 22k L4 L4 MW FREQUENCY COVERAGE Q2 2SC393-C IF BUFFER C23 3p C26 0. R25 k R3 470 JW2 C 0.0 JC C763L CT4 CT4 LW FREQUENCY COVERAGE C3 220p C2 C4 47p 00p Q3 2SA576A MUTE SWITCH C2 0.0 Q4 2SC408-R BAND SELECT SWITCH R2 00k R7 US/CND C44 220p C20 0.0 C22 0.0 R8 R9 0k 00k Q5 2SC408-R L.P.F Q6 2SC408-R L.P.F C5 C6 470p 0. R0 0k C7 0.22 JC2 C9 220 25V C8 000p R 2.2k R03 R04 R05 R06 0 0 220 220 R07 R08 2.2k 2.2k C03 00p Q00 Q0 2SC408-R LED DRVER C04 C05 0.022 0.022 R09 2SC408-R LED DRVER C06 0.0 R R0 D00-02 BACK LIGHT JC07 JC06 MELODY C07 000p JW08 R7 C2 0.0 C08 0.0 C09 47 0V IC0 SM25-AWV-E2 R5 0 R4 00k C C37 C0 000p 0.0 000p JW3 JC03 R3 47k R2 220k JW07 JW04 C8 000p JW09 JW05 R7 k R6 JW3 0 R2 47 C29 C27 0.0 0.0 C28 R22 00 CF3 C42 00p IT,UK D03 SS355TE-7 IT,AEP D04 SS355TE-7 JC04 LIGHT LIGHT2 LCD7 LCD6 LCD7 LCD6 ILLUMI LCD5 LCD5 ILLUMI2 LCD4 LCD4 IC CXA09M R8 R9 R20 R2 KS0 KS KS2 KS3 IC00-573-A7 SYSTEM CONTROL LCD3 LCD2 LCD LCD0 LCD3 LCD2 LCD LCD0 C4 00p R22 KS4 COM3 COM3 R20 470 KR0 COM2 COM2 C43 00p JW9 US/CND R9 2.2k T AM IF :C763 MW IF :C763L C40 0.0 CF CF2 Q7 DTC44EUA BAND SELECT SWITCH C39 4.7 50V C38 0 50V C36 0.22 C35 0 50V C32 470 6.3V C37 0.022 JW4 C33 C34 2.2 C3 220 0V JC8 JC9 R28 0k JW6 C3 C4 C5 C6 C7 470p 470p 470p 470p 470p R23 JW0 JC02 R24 0k R32 D05 D06 22 SS33T-77 SS33T-77 C9 C20 KR KR2 KR3 0.0 000p ILLUMI3 R30 0k R29 0k COM COM COM0 COM0 RLCD C33 0. CLCD C32 0.0 C3 0. C30 0. Q02,03 AC-F-CLOCK DETECT CN 7P R26 00k CN3 5P CN2 4P C24 000 6.3V JW7 C23 0.0 C763L C22 0.0 R3 47 C25 C26 0. 0. JW X0 75kHz R25 R26 470k Q02 2SA576A R27 470k Q03 DTC44EUA JW2 9 9
N ICF-C763/C763L 3-5. PRINTED WIRING BOARD CONTROL SECTION 2 3 4 5 6 7 A KEY BOARD W84 5 Semiconductor Location Ref. No. Location D84 C- D85 D-2 D86 D-5 D87 E-2 D88 E-3 D89 D-6 3 W85 VOLUME BOARD Q84 E- Q85 E- B S82 5 S95 ALARM MODE 3 W85 R7 D84 SNOOZE/ SLEEP OFF S87 4 S92 ALARM B S93 TUNE/TIMESET + S90 TUNE/TIMESET - RV VOLUME -86-857- () C D E S88 SNOOZE/ SLEEP OFF R88 R89 R90 R9 R93 R92 C89 E C B Q85 JC8 R95 R94 C88 E C B Q84 S83 3 S86 2 S85 4 D85 JW92 S9 ALARM A S94 D.S.T/CLOCK C90 C9 D87 R96 JW9 R97 D88 5 W82 S84 BRIGHTNESS C93 S89 NAP R98 C92 R99 W83 2 CN86-86-854- S8 (DOOR) () SP SPEAKER SUB KEY BOARD S99 PRESET S96 BAND D86 S97 RADIO ON/OFF S98 SLEEP D89 5 W84-86-855- () MAIN BOARD (Page8) B MAIN BOARD (Page8 ) C 0 0
3-6. SCHEMATIC DIAGRAM CONTROL SECTION W82 W83 Q84 2SC408-R LED DRIVER R88 0 R89 0 R92 2.2k D84 SLP-OH8A-5 SNOOZE/ SLEEP OFF R93 2.2k R90 220 Q85 2SC408-R LED DRIVER C88 0.022 S8 (DOOR) R9 220 R94 C89 0.022 R95 D87 SS355TE-7 D88 SS355TE-7 S82 5 R99 R98 R97 R96 C93 C92 C9 C90 0k 0k 0k 0k JW92 000p 000p 000p 000p S83 3 S84 BRIGHTNESS W85 CN86 2P W85 R7 0k RV 50k VOLUME WS SP S85 S86 S87 2 4 S96 BAND S97 RADIO ON/OFF S98 SLEEP S99 PRESET D89 SS355TE D86 DAP202U W84 W84 JC8 D85 DAP202U JW9 S88 SNOOZE/ SLEEP OFF S9 ALARM A S94 D.S.T/ CLOCK S89 NAP S92 ALARM B S95 ALARM MODE S90 TUNE/ TIME SET - S93 TUNE/ TIME SET +
3-7. PRINTED WIRING BOARD POWER SECTION 3-8. SCHEMATIC DIAGRAM POWER SECTION 2 3 4 POWER BOARD W8 JW82 A JW89 JW83 C83 C85 R82 C84 D83 BLK T80 POWER UNIT JW8 R84 0k C87 0. S80 NIGHT LIGHT MODE OFF ON STANDBY R86 00k R85 Q83 2SA576A +B SWITCH Q82 2SC408-R +B SWITCH JW85 B C D82 C86 L8 PATTERN COIL C82 L82 PATTERN COIL D8 Q8 R8 B C E C8 D80 R80 L80 Q80 B C E C80 JW8 YEL JW85 7 W8 A MAIN BOARD (Page 8) C80 0 50V L80 Q80 2SC200TP-KK2 +4.V REGULATOR D80 MTZJ-4.7C Q8 2SC200TP-KK2 +4.4V REGULATOR R80 R8 470 470 D8 C8 RD5.ESB2 C82 470 470 6.3V 6.3V C84 470 6V C83 000 0V JW83 R82 k D83 SS33T C85 0.0 C86 0. L82 PATTERN COIL PATTERN COIL L8 JW88 JW89 T80 POWER UNIT D JW88 C87 R85 Q83 B C E B C E Q82 R86 JW82 D82 N4002B E STANDBY t ON toff S80 NIGHT LIGHT MODE R84-86-856- () Semiconductor Location Ref. No. Location D80 B-3 D8 C-2 D82 B-2 D83 A-3 Q80 B-3 Q8 C-2 Q82 D-3 Q83 D-3 2 2
NOTE : -XX, -X mean standardized parts, so they may have some difference from the original one. Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. 4-. CABINET (UPPER) SECTION SECTION 4 EXPLODED VIEW The mechanical parts with no reference number in the exploded views are not supplied. Accessories are given in the last of this parts list. Abbreviation CND : Canadian model IT : Itarian model 32 30 35 3 34 ICF-C763/C763L The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié. When indicating parts by reference number, please include the board. 6 26 33 27 2 29 # 4 3 SP 0 25 6 7 8 9 8 28 4 27 7 27 5 27 3 24 9 20 2 #2 #2 22 20 23 2 27 24 T80 Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks 3-252-827-0 SCREW (B2.6), (+) BV TAPPING 2 A-4547-466-A POWER BOARD, COMPLETE (C763) 2 A-4547-48-A POWER BOARD, COMPLETE 3 3-265-388-0 KNOB (LIGHTMODE) 4 3-265-38-0 CHASSIS (LOWER) 5 A-4547-454-A MAIN PC BOARD ASSY (IT) 5 A-4547-472-A MAIN PC BOARD ASSY (US, CND) 5 A-4547-476-A MAIN PC BOARD ASSY (UK) 5 A-4547-484-A MAIN PC BOARD ASSY (AEP) 6 X-2023-066- CABINET (FRONT) SUB ASSY 7 A-4547-463-A SUB, KEY BOARD, COMPLETE 8 3-265-382-0 CHASSIS (UPPER) 9 A-4547-470-A VOLUME (HAND) BOARD, COMPLETE 0 3-265-387-0 KNOB (VOL) A-4547-459-A KEY BOARD, COMPLETE 2 3-265-396-0 SPRING (SHAFT) 3 3-265-376-0 HOLDER (SHAFT) 4 X-2023-067- CABINET (UPPER) SUB ASSY 6 3-265-379-0 BUTTON (POWER) 7 3-265-370-0 CABINET (REAR) 8 3-265-385-0 GUIDE (STAND) 9 3-265-384-0 COVER (STAND) 20 3-265-398-0 SPRING (STAND) 2 3-265-386-0 PLATE (STAND), CLICK 22 3-252-830-0 SCREW (B3), (+) PWH TAPPING 23 3-265-383-0 STAND 24 3-265-40-0 FOOT 25 3-252-828-0 SCREW (B2.6), (+) PWH TAPPING 26 3-254-058-0 SCREW 27 3-254-08-0 SCREW 28 3-265-372-0 WINDOW (LCD) 29 3-265-375-0 SHAFT 30 3-265-377-0 LID 3 3-265-378-0 PLATE, CLICK 32 3-265-393-0 PANEL (C763) 32 3-265-393- PANEL 33 3-265-394-0 CUSHION (SNOOZE) 34 3-265-397-0 SPRING (CLICK) 35 3-265-402-0 RING, O SP -544-57-5 SPEAKER 0T80-468-672-2 POWER UNIT (US, CND) 0T80-468-673-2 POWER UNIT (UK) 0T80-468-674-2 POWER UNIT (IT, AEP) # 7-626-34- SPRING PIN 2X8 #2 7-67-3-0 STEEL, BALL 3 3
KEY MAIN SECTION 5 ELECTRICAL PARTS LIST NOTE : Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. -XX, -X mean standardized parts, so they may have some difference from the original one. RESISTORS All resistors are in ohms METAL : Metal-film resistor METAL OXIDE :Metal oxide-film resistor F : nonflammable Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. SEMICONDUCTORS In each case, u : µ, for example : ua... : µ A..., upa... : µ PA... upb... : µ PB..., upc... : µ PC... upd... : µ PD... CAPACITORS uf : µ F COILS uh : µ H Abbreviation CND : Canadian model IT : Itarian model When indicating parts by reference number, please include the board. Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark A-4547-459-A KEY BOARD, COMPLETE S83-77-550- SWITCH, TACTILE (3) ****************** S84-77-550- SWITCH, TACTILE (BRIGHTNESS) S85-77-550- SWITCH, TACTILE () < CAPACITOR > C88-64-227- CERAMIC CHIP 0.022uF 0% 25V C89-64-227- CERAMIC CHIP 0.022uF 0% 25V C90-62-964- CERAMIC CHIP 0.00uF 0% 50V C9-62-964- CERAMIC CHIP 0.00uF 0% 50V C92-62-964- CERAMIC CHIP 0.00uF 0% 50V C93-62-964- CERAMIC CHIP 0.00uF 0% 50V < CONNECTOR > CN86-580-8- SOCKET, CONNECTOR 2P < DIODE > D84 6-500-92-0 DIODE SLP-OH8A-5 (SNOOZE/SLEEP OFF) D85 8-79-94-09 DIODE DAP202U D87 8-79-988-6 DIODE SS355TE-7 D88 8-79-988-6 DIODE SS355TE-7 The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifié. S86-77-550- SWITCH, TACTILE (2) S87-77-550- SWITCH, TACTILE (4) S88-554-937- SWITCH, TACTILE (SNOOZE/SLEEP OFF) S89-77-550- SWITCH, TACTILE (NAP) S90-77-550- SWITCH, TACTILE (TUNE/TIME SET -) S9-77-550- SWITCH, TACTILE (ALARM A) S92-77-550- SWITCH, TACTILE (ALARM B) S93-77-550- SWITCH, TACTILE (TUNE/TIME SET +) S94-77-550- SWITCH, TACTILE (D.S.T/CLOCK) S95-77-550- SWITCH, TACTILE (ALRM MODE) < FLAT CABLE > W82-829-28- CABLE, FLEXIBLE FLAT (4 CORE) W83-829-30- CABLE, FLEXIBLE FLAT (5 CORE) W84-829-27- CABLE, FLEXIBLE FLAT (5 CORE) W85-829-26- CABLE, FLEXIBLE FLAT (3 CORE) ************************************************************* < SHORT > JC8-26-864- SHORT CHIP 0 < TRANSISTOR > A-4547-454-A A-4547-472-A A-4547-476-A A-4547-484-A MAIN PC BOARD ASSY (IT) MAIN PC BOARD ASSY (US, CND) MAIN PC BOARD ASSY (UK) MAIN PC BOARD ASSY (AEP) ********************* Q84 8-729-905-35 TRANSISTOR 2SC408-R Q85 8-729-905-35 TRANSISTOR 2SC408-R < RESISTOR > R88-26-797- METAL CHIP 0 5% /0W R89-26-797- METAL CHIP 0 5% /0W R90-26-83- METAL CHIP 220 5% /0W R9-26-83- METAL CHIP 220 5% /0W R92-26-825- METAL CHIP 2.2K 5% /0W R93-26-825- METAL CHIP 2.2K 5% /0W R94-26-829- METAL CHIP 4.7K 5% /0W R95-26-829- METAL CHIP 4.7K 5% /0W R96-26-833- METAL CHIP 0K 5% /0W R97-26-833- METAL CHIP 0K 5% /0W R98-26-833- METAL CHIP 0K 5% /0W R99-26-833- METAL CHIP 0K 5% /0W < SWITCH > S8-570-953- SWITCH, PUSH ( KEY) (DOOR) S82-77-550- SWITCH, TACTILE (5) 3-265-380-0 HOLDER (LCD) 3-265-39-0 HOLDER (ANT) < BAND PASS FILTER > BPF -236-022- FILTER, BAND PASS < CAPACITOR > C -64-35- CERAMIC CHIP 470PF 5% 50V C2-62-927- CERAMIC CHIP 00PF 5% 50V C3-65-76- CERAMIC CHIP 0.047uF 0% 6V C4-62-964- CERAMIC CHIP 0.00uF 0% 50V C5-64-230- CERAMIC CHIP 220PF 5% 50V C6-64-230- CERAMIC CHIP 220PF 5% 50V C7-62-966- CERAMIC CHIP 0.0022uF 0% 50V (C763) C8-62-964- CERAMIC CHIP 0.00uF 0% 50V C9-62-95- CERAMIC CHIP 0PF 0.5PF 50V C0-62-90- CERAMIC CHIP 5PF 0.25PF 50V 4
MAIN Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark C -62-970- CERAMIC CHIP 0.0uF 0% 25V C2-62-923- CERAMIC CHIP 47PF 5% 50V C3-64-230- CERAMIC CHIP 220PF 5% 50V C4-62-927- CERAMIC CHIP 00PF 5% 50V C5-64-35- CERAMIC CHIP 470PF 5% 50V C6-07-826- CERAMIC CHIP 0.uF 0% 6V C7-5-467- CERAMIC CHIP 0.22uF 0% 0V C8-62-964- CERAMIC CHIP 0.00uF 0% 50V C9-04-666- ELECT 220uF 20% 25V C20-62-970- CERAMIC CHIP 0.0uF 0% 25V C25-07-826- CERAMIC CHIP 0.uF 0% 6V C26-64-56- CERAMIC CHIP 0.uF 25V C27-07-826- CERAMIC CHIP 0.uF 0% 6V C28-62-99- CERAMIC CHIP 22PF 5% 50V C29-62-95- CERAMIC CHIP 0PF 0.5PF 50V C30-64-56- CERAMIC CHIP 0.uF 25V C3-64-56- CERAMIC CHIP 0.uF 25V C32-62-970- CERAMIC CHIP 0.0uF 0% 25V C33-64-56- CERAMIC CHIP 0.uF 25V C34-62-93- CERAMIC CHIP 8PF 0.5PF 50V C35-62-99- CERAMIC CHIP 22PF 5% 50V C36-35-834-9 CERAMIC CHIP 2.2 6PF 6.3V C37-62-970- CERAMIC CHIP 0.0uF 0% 25V C2-62-970- CERAMIC CHIP 0.0uF 0% 25V C22-62-970- CERAMIC CHIP 0.0uF 0% 25V C23-62-908- CERAMIC CHIP 3PF 0.25PF 50V C24-62-95- CERAMIC CHIP 0PF 0.5PF 50V C25-62-964- CERAMIC CHIP 0.00uF 0% 50V C26-07-826- CERAMIC CHIP 0.uF 0% 6V C27-62-970- CERAMIC CHIP 0.0uF 0% 25V C28-25-837-9 CERAMIC CHIP uf 0% 6.3V C29-62-970- CERAMIC CHIP 0.0uF 0% 25V C30-28-55- ELECT 22uF 20% 63V C3-26-934- ELECT 220uF 20% 6V C32-04-655-9 ELECT 470uF 20% 6.3V C33-25-837-9 CERAMIC CHIP uf 0% 6.3V C34-35-834-9 CERAMIC CHIP 2.2 6PF 6.3V C35-26-964- ELECT 0uF 20% 50V C36-5-467- CERAMIC CHIP 0.22uF 0% 0V C37-64-227- CERAMIC CHIP 0.022uF 0% 25V C38-26-964- ELECT 0uF 20% 50V C39-26-963- ELECT 4.7uF 20% 50V C40-62-970- CERAMIC CHIP 0.0uF 0% 25V C4-62-927- CERAMIC CHIP 00PF 5% 50V C42-62-927- CERAMIC CHIP 00PF 5% 50V C43-62-927- CERAMIC CHIP 00PF 5% 50V (US, CND) C44-64-230- CERAMIC CHIP 220PF 5% 50V (US, CND) C03-62-927- CERAMIC CHIP 00PF 5% 50V C04-64-227- CERAMIC CHIP 0.022uF 0% 25V C05-64-227- CERAMIC CHIP 0.022uF 0% 25V C06-62-970- CERAMIC CHIP 0.0uF 0% 25V C07-62-964- CERAMIC CHIP 0.00uF 0% 50V C08-62-970- CERAMIC CHIP 0.0uF 0% 25V C09-26-947- ELECT 47uF 20% 35V C0-62-964- CERAMIC CHIP 0.00uF 0% 50V C -62-964- CERAMIC CHIP 0.00uF 0% 50V C2-62-970- CERAMIC CHIP 0.0uF 0% 25V C3-64-35- CERAMIC CHIP 470PF 5% 50V C4-64-35- CERAMIC CHIP 470PF 5% 50V C5-64-35- CERAMIC CHIP 470PF 5% 50V C6-64-35- CERAMIC CHIP 470PF 5% 50V C7-64-35- CERAMIC CHIP 470PF 5% 50V C8-62-964- CERAMIC CHIP 0.00uF 0% 50V C9-62-970- CERAMIC CHIP 0.0uF 0% 25V C20-62-964- CERAMIC CHIP 0.00uF 0% 50V C22-62-970- CERAMIC CHIP 0.0uF 0% 25V C23-62-970- CERAMIC CHIP 0.0uF 0% 25V C24-26-96- ELECT 000uF 20% 6.3V < FILTER > * CF -577-39- FILTER, CERAMIC (C763) CF -578-677-2 FILTER, CRYSTAL CF2-577-324- FILTER, CERAMIC CF3-577-324- FILTER, CERAMIC < CONNECTOR > CN -770-638- CONNECTOR, FFC/FPC 7P CN2-770-644- CONNECTOR, FFC/FPC 4P CN3-770-636- CONNECTOR, FFC/FPC 5P < TRIMMER > CT -4-304-2 CAP, CERAMIC TRIMMER 0PF (AM TRACKING) CT2-4-459- CAP, TRIMMER (SEAL TYPE) 45PF (LW TRACKING) CT3-4-304-2 CAP, CERAMIC TRIMMER 0PF (FM TRACKING) CT4-4-459- CAP, TRIMMER (SEAL TYPE) 45PF (LW FREQUENCY COVERAGE) < DIODE > D 8-79-023-99 DIODE KV563M-3 D2 8-79-084-67 DIODE HVU202ATRU D3 8-79-084-67 DIODE HVU202ATRU D4 6-500-69-0 DIODE KV60STL-2 (C763) D00 6-500-95-0 DIODE SLP-WH8A-5-SW D0 6-500-95-0 DIODE SLP-WH8A-5-SW D02 6-500-95-0 DIODE SLP-WH8A-5-SW D03 8-79-988-6 DIODE SS355TE-7 (IT, UK) D04 8-79-988-6 DIODE SS355TE-7 (IT, AEP) D05 8-79-99-33 DIODE SS33T-77 D06 8-79-99-33 DIODE SS33T-77 < IC > IC 8-752-050-6 IC CXA09M IC00 6-804-29-0 IC upd7072gb-573-a7 IC0 6-70-907-0 IC SM25-AWV-E2 < SHORT > JC -26-864- SHORT CHIP 0 JC2-26-864- SHORT CHIP 0 JC7-26-864- SHORT CHIP 0 JC8-26-864- SHORT CHIP 0 JC9-26-864- SHORT CHIP 0 JC02-26-864- SHORT CHIP 0 JC03-26-864- SHORT CHIP 0 JC04-26-864- SHORT CHIP 0 5
MAIN POWER Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark JC05-26-864- SHORT CHIP 0 JC06-26-864- SHORT CHIP 0 R04-26-797- METAL CHIP 0 5% /0W R05-26-83- METAL CHIP 220 5% /0W JC07-26-864- SHORT CHIP 0 < COIL > L -428-95- COIL, FERRITE-ROD ANTENNA (MW) (AM TRACKING) (C763) L -428-952- COIL, FERRITE-ROD ANTENNA (LW/MW TRACKING) L2-406-922- COIL, AIR-CORE (FM TRACKING) L3-44-690-2 INDUCTOR 82nH L4-406-485- COIL (OSC) R06-26-83- METAL CHIP 220 5% /0W R07-26-825- METAL CHIP 2.2K 5% /0W R08-26-825- METAL CHIP 2.2K 5% /0W R09-26-829- METAL CHIP 4.7K 5% /0W R0-26-829- METAL CHIP 4.7K 5% /0W R -26-829- METAL CHIP 4.7K 5% /0W R2-26-849- METAL CHIP 220K 5% /0W R3-26-84- METAL CHIP 47K 5% /0W R4-26-845- METAL CHIP 00K 5% /0W R5-26-797- METAL CHIP 0 5% /0W LCD0-805-589- < LIQUID CRYSTAL DISPLAY > DISPLAY PANEL, LIQUID CRYSTAL < TRANSISTOR > R7-26-829- METAL CHIP 4.7K 5% /0W R8-26-829- METAL CHIP 4.7K 5% /0W R9-26-829- METAL CHIP 4.7K 5% /0W R20-26-829- METAL CHIP 4.7K 5% /0W R2-26-829- METAL CHIP 4.7K 5% /0W Q 8-729-423-52 TRANSISTOR 2SC393-C Q2 8-729-423-52 TRANSISTOR 2SC393-C Q3 8-729-026-53 TRANSISTOR 2SA576A-T06-QR Q4 8-729-905-35 TRANSISTOR 2SC408-R Q5 8-729-905-35 TRANSISTOR 2SC408-R Q6 8-729-905-35 TRANSISTOR 2SC408-R Q7 8-729-029-4 TRANSISTOR DTC44EUA-T06 Q00 8-729-905-35 TRANSISTOR 2SC408-R Q0 8-729-905-35 TRANSISTOR 2SC408-R Q02 8-729-026-53 TRANSISTOR 2SA576A-T06-QR Q03 8-729-029-4 TRANSISTOR DTC44EUA-T06 < RESISTOR > R -26-825- METAL CHIP 2.2K 5% /0W R2-26-86- METAL CHIP 2.2M 5% /0W R3-26-833- METAL CHIP 0K 5% /0W R4-26-845- METAL CHIP 00K 5% /0W R5-26-86- METAL CHIP 2.2M 5% /0W R6-26-845- METAL CHIP 00K 5% /0W R7-26-829- METAL CHIP 4.7K 5% /0W R8-26-833- METAL CHIP 0K 5% /0W R9-26-845- METAL CHIP 00K 5% /0W R0-26-833- METAL CHIP 0K 5% /0W R -26-825- METAL CHIP 2.2K 5% /0W R2-26-845- METAL CHIP 00K 5% /0W R3-26-87- METAL CHIP 470 5% /0W R4-26-837- METAL CHIP 22K 5% /0W R5-26-829- METAL CHIP 4.7K 5% /0W R6-26-797- METAL CHIP 0 5% /0W R7-26-82- METAL CHIP K 5% /0W R8-26-833- METAL CHIP 0K 5% /0W R9-26-825- METAL CHIP 2.2K 5% /0W R20-26-87- METAL CHIP 470 5% /0W R2-26-805- METAL CHIP 47 5% /0W R22-26-809- METAL CHIP 00 5% /0W R25-26-82- METAL CHIP K 5% /0W R26-26-845- METAL CHIP 00K 5% /0W R00-26-789- METAL CHIP 2.2 5% /0W R0-26-789- METAL CHIP 2.2 5% /0W R02-26-789- METAL CHIP 2.2 5% /0W R03-26-797- METAL CHIP 0 5% /0W R22-26-829- METAL CHIP 4.7K 5% /0W R23-26-829- METAL CHIP 4.7K 5% /0W R24-26-833- METAL CHIP 0K 5% /0W R25-26-829- METAL CHIP 4.7K 5% /0W R26-26-853- METAL CHIP 470K 5% /0W R27-26-853- METAL CHIP 470K 5% /0W R28-26-833- METAL CHIP 0K 5% /0W R29-26-833- METAL CHIP 0K 5% /0W R30-26-833- METAL CHIP 0K 5% /0W R3-26-805- METAL CHIP 47 5% /0W R32-26-80- METAL CHIP 22 5% /0W < TRANSFORMER > T -404-790- TRANSFORMER, IF < VIBRATOR > X0-767-388- VIBRATOR, CRYSTAL (75kHz) ************************************************************* A-4547-466-A POWER BOARD, COMPLETE (C763) A-4547-48-A POWER BOARD, COMPLETE ************************** < CAPACITOR > C80-26-964- ELECT 0uF 20% 50V C8-26-935- ELECT 470uF 20% 6V C82-26-935- ELECT 470uF 20% 6V C83-26-926- ELECT 000uF 20% 0V C84-26-935- ELECT 470uF 20% 6V C85-62-970- CERAMIC CHIP 0.0uF 0% 25V C86-64-56- CERAMIC CHIP 0.uF 25V C87-07-826- CERAMIC CHIP 0.uF 0% 6V < DIODE > D80 8-79-92-40 DIODE MTZJ-4.7C D8 8-79-09-85 DIODE RD5.ESB2 D82 8-79-063-79 DIODE N4002B D83 8-79-99-33 DIODE SS33T-77 < COIL > L80-40-294-3 INDUCTOR 38uH < TRANSISTOR > Q80 8-729-0-92 TRANSISTOR 2SC200TP-KK2 6
Ref. No. Part No. Description Remark Q8 8-729-0-92 TRANSISTOR 2SC200TP-KK2 Q82 8-729-905-35 TRANSISTOR 2SC408-R Q83 8-729-026-53 TRANSISTOR 2SA576A-T06-QR POWER SUB KEY VOLUME < RESISTOR > R80-26-87- METAL CHIP 470 5% /0W R8-26-87- METAL CHIP 470 5% /0W R82-26-82- METAL CHIP K 5% /0W R84-26-833- METAL CHIP 0K 5% /0W R85-26-829- METAL CHIP 4.7K 5% /0W R86-26-845- METAL CHIP 00K 5% /0W < SWITCH > S80-554-06-00 SWITCH, SLIDE (NIGHT LIGHT MODE) < FLAT CABLE > W8-829-29- CABLE, FLEXIBLE FLAT (7 CORE) ************************************************************* A-4547-463-A SUB KEY BOARD, COMPLETE ********************* < DIODE > D86 8-79-94-09 DIODE DAP202U D89 8-79-988-6 DIODE SS355TE-7 < SWITCH > S96-77-550- SWITCH, TACTILE (BAND) S97-77-550- SWITCH, TACTILE (RADIO ON/OFF) S98-77-550- SWITCH, TACTILE (SLEEP) S99-77-550- SWITCH, TACTILE (PRESET) ************************************************************* A-4547-470-A VOLUME BOARD, COMPLETE ********************* < RESISTOR > R7-26-833- METAL CHIP 0K 5% /0W < VARIABLE RESISTOR > RV -227-482- RES, VAR, CARBON 50K (w VOLUME) ************************************************************ MISCELLANEOUS ************* SP -544-57-5 SPEAKER 0 T80-468-672-2 POWER UNIT (US, CND) 0 T80-468-673-2 POWER UNIT (UK) 0 T80-468-674-2 POWER UNIT (IT, AEP) ****************************************************** ACCESSORIES *********** 3-266-73- MANUAL, INSTRUCTION (ENGLISH, FRENCH, SPANISH, GERMAN) (EXCEPT US) 3-266-73-2 MANUAL, INSTRUCTION (ENGLISH) (US) 3-266-73-3 MANUAL, INSTRUCTION (ITALIAN, DUTCH, PORTUGUESE, SWEDISH, FINNISH) (IT, AEP) The components identified by Les composants identifiés par une mark 0 or dotted line with mark marque 0 sont critiques pour 0 are critical for safety. la sécurité. Replace only with part number Ne les remplacer que par une pièce specified. portant le numéro spécifié. 7
REVISION HISTORY Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. Date Description of Revision.0 2004.05 New