176 S. New Holland Road Gordonville, PA Tel: Fax: Castle Loft

Size: px
Start display at page:

Download "176 S. New Holland Road Gordonville, PA Tel: Fax: Castle Loft"

Transcription

1 176 S. New Holland Road Gordonville, PA Tel: Fax: A S S E M B LY M A N U A L Castle Loft

2 Castle Loft Assembly Manual revised 08/31/05 Dear Customer, Thank you for your purchase of our Castle Loft. The craftsmanship and detail in this product is unmatched. This manual is designed to simplify the assembly process, however we strongly recommend having a carpenter involved in the project. Please read through the entire manual before starting!! It took 2 men 2 hours, using the tools listed below, to assemble this unit. However, it will probably take you a little longer since it will be a new project for you. Take a deep breath and get at it, the satisfaction and enjoyment of this play set is only a few hours away. Have Fun!!!!! Remember, it is very important that you have a level site for your play set. You have purchased a product that consists of heavy, bulky pieces. With your purchase, you assume full responsibility to have the necessary manpower and/or equipment available to unload the items. You also agree that any damage that happens to the equipment, product, or individuals during the unloading process, or during the entire construction process, is your responsibility, and neither the seller, nor the manufacturer, will be held liable for any such damage. TOOLS NEEDED: -7/16,1/2,9/16, and 3/4 deep sockets with 1/2 drive -3/4 wrench -Hammer -Medium vise grip pliers -#2 phillips and square drive screwdrivers or bits -Screw gun -Paint brushes (for touch-up) -utility knife -eight foot step ladder -2ft level -square HELPFUL TOOLS: -Impact wrench with 1/2 drive -Air compressor

3 Step 1: Unwrap Castle Loft and separate parts keeping similar parts together. Open hardware box and separate hardware keeping similar parts together. Step 2: On the bottom of your kit there will be a 6'x 10' floor. The front of the floor will have at least six 5/8" holes and a Pinnacle nameplate. On top of the floor will be a 6'x 10' base constructed of four 2 x 6's the front of the base will have six 5/8" holes. The two center holes on the floor and base should be closer to the left side of the Castle Loft. Place Castle Loft base at level site turning the front towards the front of your leveled site. Allow at least 7 6 of space for a slide or ramp, and either 14 or 16 feet for a swing beam with an additional recommended 6 feet of safety clearance. Step 3: Place Castle Loft floor on either the left or right side (shown on right side). Step 4: Insert four 107" posts through four back holes in floor keeping the recessed side of the holes towards the center of the set. Insert three 90 ½" posts through front three holes in floor keeping the recessed side of the holes towards the back of the set. The end of the post with two holes is the bottom of the post and is placed towards the bottom side of the floor. The holes in the floor will line up with the holes in the posts. Step 5: Insert ½"x 4 ¾" carriage bolts through the 2 x 6's in the floor and through the second set of holes in the post. Step 6: Place ½" washers, lock washers, and nuts onto the threads of the carriage bolts in recessed portion of the holes in the post. Need Help?? Call Page 1

4 Step 7: Build the base of the play set around the bottom of the posts. Secure 2 x 6 s of the base to the outside of posts with ½"x 4 ¾" carriage bolts. Install carriage bolts through 5/8" holes in 2x6's and into posts. Step 8: Place ½" washers, lock washers, and nuts into recessed portion of post and onto threads of the carriage bolt. Step 9: Lift up the top of the two corner posts that are lying on the ground to set structure upright. Step 10: Make sure the floor is squared up with posts then tighten nuts with ¾" socket wrench. Step 11: Install eight 16" corner braces (4 x 4's with 45 degree angles at both ends) underneath floor on the inside surfaces of the corner posts. Place two braces at each corner with ½" recessed hole against post, and place the other end of corner brace under poly decking making sure that brace fits tightly against post and the outside perimeter 2 x 6's of the floor. Secure the bottom of the corner brace with 3/8"x 4" lag bolts with 3/8" washers to the post. Step 12: Secure top of 16" corner brace with two 3" deck screws through 2 x 6's on the outside of the floor to secure the top of the brace. This completes floor and the base of the Castle Loft. Need Help?? Call Page 2 Step 13: Install the four walls of the Castle. The front wall has the arched door opening and should be set on the floor first to ensure it will fit later. Lean front castle walls against the back of the 107" post in the middle of the play set. Step 14: The back wall of the castle will have the 2x4 studding in 5 ¾" from both ends and will fit between the back posts on top of the floor. Make sure the back wall fits tightly and secure with four 3" screws though 2 x 4 bottom plate of the wall into the decking and outside perimeter 2x6 of the floor.

5 Step 15: Install the sidewalls of the castle; the back of the sidewalls will have 2x4 studding in 5" from one end of the wall. Set sidewalls in place keeping them tight up against rear wall flush at the back corners. Secure sidewalls with four 3" deck screws through the bottom plates into 2x6's of the floor. Step 16: Secure back corners with three 3" deck screws through each wall stud that meets the back posts. Step 17: Install front wall of castle by placing it securely between the front of the sidewalls making sure corners are flush. Secure front wall corners with three 3" deck screws through each 2x4 stud at the corners. Step 18: Secure front wall with three 3" deck screws in the bottom plate. Place screws at 18', 36", and 54" from the inside paneling of the sidewall this will hit the 2x6 floor joist. Step 19: On each side of the floor there will be a 33" opening between the posts towards the front of the Castle Loft. Step 20: Secure two 32-7/8" wide railings into two 33" openings between posts with three 2" deck screws through each end cap. Need Help?? Call Page 3 Step 21: Install two 2x4's 106" in length by securing one against the top front of the two 107" 4x4 posts in the middle of the floor and the other against the top back of the 107" posts at the rear of the Castle Loft. Step 22: Center the two predrilled holes that are 20 ¼" from each end of the 106" 2x4 to the center of the 107" posts. Align the 106" 2x4's horizontally with the bottom edge of the chipped top of each 107" post and secure with two 3" deck screws at each post.

6 Step 23: Install two 77 ¼" 2x4's one on each side between the ends of the 106" 2x4's. Secure 77 ¼ "2x4 by driving two 3" deck screws through the ends of the 106" 2x4's and into the 77 ¼ " 2x4 at each corner of the tarp frame. Step 24: Install the 9 ¾" 2x4 gussets with 45 degree angles on both ends, at each inside corner of the tarp frame keeping them under the top radius of the 2x4 tarp frame. Secure each gusset brace with two 3" deck screw through each end and into tarp frame. Step 25: Secure bottom end of the 90 ½" 4x4 plain post with 1-½" x 2" notch to the center of the bottom plate on the back wall with two 3" deck screws. Step 26: Secure 90 ½" 4x4 plain post to the center of the back 106" 2x4 of the tarp frame with two 3" deck screws into the center of the 4x4 plain post. Step 27:Install the 42 ¾" 4x4 with attached 2x4 gussets and is chipped on three sides at one end, to the center predrilled holes of the front 106" 2x4. Install the chipped end to the bottom placing the flat side against the 2x4. Step 28: Secure with two 3" deck screws through the 2x4 into the 4x4 making sure the bottom of the 42 ¾" 4x4 is flush with the bottom radius on the 2x4. Step 29: Check to make sure 42 ¾" 4x4 is vertical and secure 2x4 gussets with two 2" deck screws through each gusset into 106" 2x4 of the tarp frame. Need Help?? Call Page 4

7 Step 30: Install the ridge beam with two 2x4's that are screwed together, between the top of the 42 ¾" 4x4 to the top of the 90 ½" 4x4 by fitting the 70 ½" 2x4 centered inside the 4x4s and the 77 ¼" 2x4 on top of the 4x4 ridgepoles Step 31: Secure the top 2x4 with two 3" deck screws at each end driving them through the 77 ¼" 2x4 into the top of the 4x4 ridge poles. Step 32: Slide two 1 x 2 x 56" strips through the sleeves at the ends of tarp. Step 33: Install tarp over ridge beam and wrap the ends around the 77 ¼" 2x4's at the sides of the tarp frame. Step 34: Secure tarp ends with four 2" deck screws through the 1x 2 and into the 77 ¼" 2x4s making sure tarp is centered front to back. Step 35: Wrap the second 1"x 2" tightly around the 77 ¼" 2x4 at the other side, making sure the tarp is as tight as possible and secure with four 2" deck screws. Step 36: This leaves a 33" and a 25 ¾" opening at the front of the floor for your ladder and a slide. The ladder and the slide are standard accessories on each Castle Loft and this unit has the ladder and slide switched from the standard configuration. Step 37: Place ladder in 33"opening making sure the top rung of the ladder is at the same height as the top of the floor. Step 38: Secure ladder with two 3/8"x 4" lag bolts with 3/8" washers, through top holes in ladder and into the posts, tighten with 9/16" socket wrench. Need Help?? Call Page 5

8 Step 39: Install the Super Scoop Slide at the 25 ¾" opening by centering the slide in the opening and then secure slide with three 5/16" x 1 ¼" lag bolts with 5/16" washers. Drive the lag bolts through the three recessed holes with a ½" socket wrench, through the top of slide and into the decking being careful not to over tighten lag bolts. Step 40: Pinnacle accessories are interchangeable and you can configure them in different openings. Only eliminate railing when you add additional activities. It may be necessary to resize openings for different components. This can be done by adding a 41-1/4" 4x4 half post and small piece of railing. *Please check and make sure all bolts and screws are secured before finishing. Check all surfaces for sharp edges, and tighten hardware periodically to make sure fasteners are secure. ENJOY YOUR PINNACLE PLAY SYSTEMS CASTLE LOFT!

9 I n s t r u c t i o n s f o r p a i n t t o u c h u p o n a P i n n a c l e P l a y s e t A major benefit of purchasing a painted playset is that damage to the set via a pocket knife, etc. can be rectified with caulk and touch up paint. This also applies to the splitting and checking found in all outdoor wood products made from cedar, redwood, pine, etc. The splits seen in larger dimensional lumber are also known as checks and are more of a cosmetic concern than a structural concern. These generally occur in large lumber such as 4x4 s and 4x6 s. We have constructed this manual to assist you in repairing damages, general touch up associated with a painted set, and in filling checks that are less than 1/4 wide. Tools Needed - Paint scraper or putty knife - Touch-up paint - Sanding pad with 80 grit sandpaper - Paintbrush or small roller - Caulking gun with tube of acrylic latex caulk (fast drying non shrinking formulas work best)

10 Step 1: After cleaning the surface, slowly apply caulking into the check of the wood from one end to the other. The caulking should penetrate into the check and fill it up leaving little excess on the outside of the wood. Step 2: Remove excess caulking from wood with putty knife or scraper leaving a smooth surface over the check... Step 2 cont... leaving minimal excess caulk. Step 3: Allow caulking to dry according to manufacturers recommendation. If the repaired surface of the caulking seems to have shrunk into the check, apply a second coat of caulk and allow time to dry. Step 4: When caulking has dried, sand surface lightly with sanding pad to remove excess caulk. The acrylic latex paint we use tends to stay soft and pliable. Sand with light quick strokes, being careful not to remove original coat of paint. Step 5: When applying touch-up paint to wood, apply a thick coat of paint to cover area, smooth out with brush or roller and allow time to dry (generally less than 6 hours). The touch-up paint will work as a primer and a topcoat. Apply a second coat of paint after the first coat has dried. The second coat of paint is essential to provide long lasting protection and restore the repaired area to the same luster as the original paint.

176 S. New Holland Road Gordonville, PA Tel: Fax: Eagles Nest

176 S. New Holland Road Gordonville, PA Tel: Fax: Eagles Nest 176 S. New Holland Road Gordonville, PA 17529 Tel: 717-768-0066 Fax: 717-768-8569 A S S E M B LY M A N U A L Eagles Nest Eagles Nest Assembly Manual revised 9/2/05 Dear Customer, Thank you for your purchase

More information

176 S. New Holland Road Gordonville, PA Tel: Fax: Playhouse Loft

176 S. New Holland Road Gordonville, PA Tel: Fax: Playhouse Loft 176 S. New Holland Road Gordonville, PA 17529 Tel: 717-768-0066 Fax: 717-768-8569 A S S E M B LY M A N U A L Playhouse Loft Playhouse Loft revised 9/6/05 Assembly Manual Dear Customer, Thank you for your

More information

176 S. New Holland Road Gordonville, PA Tel: Fax: Summit Tower

176 S. New Holland Road Gordonville, PA Tel: Fax: Summit Tower 176 S. New Holland Road Gordonville, PA 17529 Tel: 717-768-0066 Fax: 717-768-8569 A S S E M B LY M A N U A L Summit Tower Summit Tower Assembly Manual revised 9/07/05 Dear Customer, Thank you for your

More information

Oval Vinyl Gazebo. Assembly Manual

Oval Vinyl Gazebo. Assembly Manual Oval Vinyl Gazebo Assembly Manual Gazebo Assembly Thank you for your purchase of this Gazebo. This manual is designed to simplify the assembly process, however we strongly recommend having an experienced

More information

Wooden Rectangle Pergola Assembly Manual

Wooden Rectangle Pergola Assembly Manual Wooden Rectangle Pergola Assembly Manual Pergola Assembly Manual Thank you for your purchase of this Pergola This manual is designed to simplify the assembly process, however we recommend having an experienced

More information

Country Cabin. Assembly Manual. HomePlace Structures

Country Cabin. Assembly Manual. HomePlace Structures Country Cabin Assembly Manual Country Cabin Assembly Manual revised 3/20/10 Dear Customer, Thank you for your purchase of our Country Cabin. The craftsmanship and detail in this building is unmatched.

More information

Dodecagon Gazebo. Assembly Manual. If you are in the middle of your project and you need assistance Call (717)

Dodecagon Gazebo. Assembly Manual. If you are in the middle of your project and you need assistance Call (717) Dodecagon Gazebo Assembly Manual If you are in the middle of your project and you need assistance Call (717) 351-9250 Gazebo Assembly Manual Thank you for your purchase of this Gazebo. This manual is designed

More information

Renaissance Pavilion. Assembly Manual

Renaissance Pavilion. Assembly Manual Renaissance Pavilion Assembly Manual Thank you for your purchase of this pavilion. Renaissance Pavilion Assembly Manual This manual is designed to simplify the assembly process, however we recommend having

More information

Heartland Pergola. Assembly Manual

Heartland Pergola. Assembly Manual Heartland Pergola Assembly Manual Pergola Assembly Manual Thank you for your purchase of this Pergola This manual is designed to simplify the assembly process, however we recommend having an experienced

More information

The Festival Assembly Instructions

The Festival Assembly Instructions The Festival Assembly Instructions Toll Free: 866.768.8465 Hours: 9-5 Monday-Friday EST www.homeplacestructures.com Package ships as shown CONTACT INFORMATION: HomePlace Structures 301 Commerce Drive New

More information

12x12 Pavilion. Assembly Manual

12x12 Pavilion. Assembly Manual 12x12 Pavilion Assembly Manual 12x12 Pavilion Assembly Manual Congratulations on purchasing your new Pavilion. Thank You for your purchase and Welcome to the YardCraft Famiy. This manual is designed to

More information

Artisan Vinyl Pergola

Artisan Vinyl Pergola Artisan Vinyl Pergola Assembly Manual Thank you for your purchase of this Pergola. Beefy Vinyl Pergola Assembly Manual This manual is designed to simplify the assembly process, however we recommend having

More information

Sunhouse. Assembly Manual

Sunhouse. Assembly Manual Sunhouse Assembly Manual Thank you for your purchase of this sunhouse. Sunhouse Assembly Manual This manual is designed to simplify the assembly process, however we recommend having an experienced carpenter

More information

Pine Log Cabin and Cape Cod Playhouse

Pine Log Cabin and Cape Cod Playhouse Pine Log Cabin and Cape Cod Playhouse Assembly Manual Pine Log Cabin Assembly Manual revised 7/15/02 Dear Customer, Thank you for your purchase of our Pine Log Cabin Playhouse. The craftsmanship and detail

More information

SINCE 1922 P UBLICATION N O

SINCE 1922 P UBLICATION N O SINCE 1922 GARED SPORTS MICRO-Z SET-UP INSTRUCTIONS VERY IMPORTANT! READ INSTRUCTIONS CAREFULLY AND FOLLOW STEP BY STEP SET-UP PROCEDURE P UBLICATION N O. 5 5 1 7 5 2 9 1 6 Recommended tools and accessories.

More information

10X12 Arched Breeze Pergola Assembly Manual Outdoor Living Today

10X12 Arched Breeze Pergola Assembly Manual Outdoor Living Today 10X12 Arched Breeze Pergola Assembly Manual Outdoor Living Today ITEM# BZ1012ARCH Revision 2 March 25th/2015 Note: Post Mounting Hardware is NOT included in this kit. Please confirm with your local building

More information

KIT ASSEMBLY INSTRUCTIONS

KIT ASSEMBLY INSTRUCTIONS KIT ASSEMBLY INSTRUCTIONS We have designed these instructions as a stepby step procedure to simplify the assembly process. Nevertheless, we do recommend including someone with carpentry expertise on your

More information

8 Ft Wide Enclosure Assembly Guide

8 Ft Wide Enclosure Assembly Guide www.rmfiberglass.com 8 Ft Wide Enclosure Assembly Guide RM Products Ltd 1-800-363-0867 www.rmfiberglass.com Table of Contents 1. Parts and Tools List page 3 2. Hardware page 4 3. Maintenance page 5 4.

More information

1531 Fort Add On **!!IMPORTANT-PLEASE READ!!**

1531 Fort Add On **!!IMPORTANT-PLEASE READ!!** 1531 Fort Add On **!!IMPORTANT-PLEASE READ!!** This Add-On kit will require you to deviate from the main instruction manual. Please follow the outline below so that you will know what steps to be aware

More information

FOR PROFESSIONAL GARAGE DOOR INSTALLERS

FOR PROFESSIONAL GARAGE DOOR INSTALLERS Composite Garage Doors Installation Instructions FOR PROFESSIONAL GARAGE DOOR INSTALLERS Tools required Screwdriver Claw Hammer Locking Pliers Power Drill Level with a 3/32" Drill Bit Utility Knife 9/16",

More information

Showpiece Cabinet Integrated Stand For 32" - 52" LCD HDTV

Showpiece Cabinet Integrated Stand For 32 - 52 LCD HDTV Showpiece Cabinet Integrated Stand For 32" - 52" LCD HDTV Installation and Assembly Instructions 2009 Incredible Technologies Inc. Version 0109 Showpiece Cabinet Integrated Stand for 32" - 52" LCD HDTV

More information

12ft X 12ft Attached Breeze Pergola Assembly Manual. Outdoor Living Today. (For Both 9 and 12 High Posts) June 1st/2012 Version #4

12ft X 12ft Attached Breeze Pergola Assembly Manual. Outdoor Living Today. (For Both 9 and 12 High Posts) June 1st/2012 Version #4 12ft X 12ft Attached Breeze Pergola Assembly Manual (For Both 9 and 12 High Posts) Outdoor Living Today June 1st/2012 Version #4 Note: Installation of Wall Side Girders (P) and Wall Mount Brackets (M)

More information

12, 14 & 16 Wide Enclosure Assembly Guide

12, 14 & 16 Wide Enclosure Assembly Guide www.rmfiberglass.com 12, 14 & 16 Wide Enclosure Assembly Guide RM Products Ltd 1-800-363-0867 www.rmfiberglass.com Table of Contents 1. Handling and Storage page 3 to 5 2. Parts and Tools List page 7 3.

More information

Horizontal Cable Systems

Horizontal Cable Systems ALUMINUM RAILING INSTALLATION INSTRUCTIONS v2012 orizontal Cable Systems 1) Check Contents Of Packages: Verify that all parts have arrived and that they match the packing list. 1A) Coastal applications:

More information

Installation Guidelines

Installation Guidelines Page 1 Tools You ll Need 4 ft. Carpenter s level Chalk line (to mark U channel locations) Cordless drill/nut driver Caulking gun Chop saw with a metal cutting blade on it (required to make accurate and

More information

Assembly Instructions

Assembly Instructions 10' and 12' Octagon Cedar Gazebo Assembly Instructions Toll Free: 866.768.8465 Hours: 9-5 Monday-Friday EST www.homeplacestructures.com Package ships as shown revised 06/20/09 Cedar Gazebo Assembly Instructions

More information

Octagon Vinyl Gazebo Assembly Instructions For 10 & 12 Models

Octagon Vinyl Gazebo Assembly Instructions For 10 & 12 Models Octagon Vinyl Gazebo Assembly Instructions For 10 & 12 Models Toll Free: 866.768.8465 Hours: 9-5 Monday-Friday EST www.homeplacestructures.com Package ships as shown revised 04/29/09 Vinyl Gazebo Assembly

More information

Octagon Vinyl Gazebo Assembly Instructions

Octagon Vinyl Gazebo Assembly Instructions Octagon Vinyl Gazebo Assembly Instructions For 10 & 12 Models Toll Free: 866.768.8465 Hours: 9-5 Monday-Friday EST www.homeplacestructures.com Package ships as shown revised 04/29/09 Vinyl Gazebo Assembly

More information

MPA-9000 Universal Ceiling Projector Mount Kit

MPA-9000 Universal Ceiling Projector Mount Kit I N S T R U C T I O N M A N U A L Universal Ceiling Projector Mount Kit The Universal Ceiling Projector Mount provides a unique, simplified method of ceiling mounting your inverted projector. This low

More information

TREX PERGOLA INSTALLATION INSTRUCTIONS

TREX PERGOLA INSTALLATION INSTRUCTIONS RECOMMENDED TOOLS/SUPPLIES: Pencil 4' Level Measuring Tape Framing Square/Speed Square 8' High Step Ladder (Two recommended) Hacksaw or Bolt Cutters Socket Wrench with 9/16" Socket and 3/4" Deep Socket

More information

6x6 Maximizer Storage Shed Assembly Manual Version #9 Feb 26th, 2015

6x6 Maximizer Storage Shed Assembly Manual Version #9 Feb 26th, 2015 6x6 Maximizer Storage Shed Assembly Manual Version #9 Feb 26th, 2015 Thank you for purchasing a 6x6 Maximizer Storage Shed. Please take the time to identify all the parts prior to assembly. Please Note-

More information

12X20 Breeze Pergola Assembly Manual Outdoor Living Today

12X20 Breeze Pergola Assembly Manual Outdoor Living Today 12X20 Breeze Pergola Assembly Manual Outdoor Living Today Revision #10 July 21th, 2015 Note: Post Mounting Hardware is NOT included in this kit. Please confirm with your local building permit office to

More information

Assembly Instructions Music Library System

Assembly Instructions Music Library System Assembly Instructions Music Library System 7-Shelf Unit is shown. 6-Shelf Unit assembly is the same except where noted. Contents Important User Information...........................2 General...2 Manufacturer...2

More information

Chapter 17 - Porch Trim

Chapter 17 - Porch Trim Chapter 17 - Porch Trim Contents Chapter 17 - Porch Trim... 17-1 Timing & Prerequisites... 17-2 Trim on Porch Beams (Volunteer)... 17-4 Smart Trim on the Bottom of the Beam... 17-4 Smart Trim on the Inside

More information

Hoops Installation Instructions for Standard (Non-Adjustable) Basketball Goals

Hoops Installation Instructions for Standard (Non-Adjustable) Basketball Goals WARNING! Before beginning any excavation, call your local Underground Service Locator company to make sure there are NO electrical power, natural gas, telephone, cable television, irrigation systems or

More information

Oxford Stalls Installation Instructions

Oxford Stalls Installation Instructions Oxford Stalls Installation Instructions RAMM Horse Fencing and Stalls 13150 Airport Hwy. Swanton, OH 43558-9615 1-800-434-8456 Rev. 8/15/17 Before You Start Typical stall sizes are 10 x 10, 12 x 12 or

More information

Best Barns USA Assembly Book

Best Barns USA Assembly Book Best Barns USA Assembly Book Revised August 17, 2017 the Roanoke 16'x32' Building w/ full loft Manufactured by Reynolds Building Systems, Inc 205 Arlington Drive Greenville, PA 16125 This manual is copyrighted

More information

Independent Containment System (ICS)

Independent Containment System (ICS) Installing the Independent Containment System (ICS) Complete these instructions to install the Independent Containment System (ICS). Prerequisites This installation requires a team of at least two people.

More information

10x10 Trellis Pergola

10x10 Trellis Pergola 0x0 Trellis Pergola ASSEMBLY GUIDE Ver.-007 Table of Contents PAGE 0x0 Trellis Pergola Introduction & Overview...................................................... Pergola Materials Overview..............................................................

More information

Model #SH & CH SH Pine CH Naturaline

Model #SH & CH SH Pine CH Naturaline Model #SH304-101 & CH304-101 Assembly Manual SH304-101 Pine CH304-101 Naturaline Component Parts A 2 ea. Angled Rail - 2 x 4 x 107-1/8" B 1 ea. Center Angled Rail - 2 x 4 x 107-1/8" C 9 ea. Rock Board

More information

12-16 Ft Wide Enclosure Assembly Guide

12-16 Ft Wide Enclosure Assembly Guide www.rmfiberglass.com 12-16 Ft Wide Enclosure Assembly Guide RM Products Ltd 1-800-363-0867 www.rmfiberglass.com Handling and Storage 2 P a g e Handling and Storage: 3 P a g e Before You Begin Contact RM

More information

Installation Instructions

Installation Instructions Installation Instructions Follow these simple instructions to install your OneDayCab! IMPORTANT: Unpack and check shipment for damage. Verify color, size and parts before demolition. Installation of interiors

More information

Shed Assembly Instructions

Shed Assembly Instructions Shed Kit Contents The shed kit includes all the parts needed to assemble your shed except for tools and fasteners such as screws and nails. The various pieces are pre-cut and many are marked to indicate

More information

6X3 Patio Garden Shed Assembly Manual

6X3 Patio Garden Shed Assembly Manual Thank you for purchasing a 6x3 Patio Garden Shed. Please take the time to identify all the parts prior to assembly. Revision #4 July 6th, 2016 6X3 Patio Garden Shed Assembly Manual Please use Safety Eyewear

More information

ASSEMBLY INSTRUCTIONS DIY WALL BED KIT QUEEN BI FOLD DOOR CABINET & MECHANISM. Tools Required For Assembly. 6.5mm Masonry Drill Bit

ASSEMBLY INSTRUCTIONS DIY WALL BED KIT QUEEN BI FOLD DOOR CABINET & MECHANISM. Tools Required For Assembly. 6.5mm Masonry Drill Bit ASSEMBLY INSTRUCTIONS DIY WALL BED KIT QUEEN BI FOLD DOOR CABINET & MECHANISM Tools Required For Assembly No 2 & No 4 Phillips Head Screwdrivers No 2 Slot Head Screwdriver Hammer Electric Drill (Hammer

More information

LOFT DOOR HANGER BARN DOORS & HARDWARE. Hardware Installation Instructions. Page

LOFT DOOR HANGER BARN DOORS & HARDWARE. Hardware Installation Instructions. Page LOFT DOOR HANGER Page 1 Specifications 2 7/16" 3/8" 1-1/2 1-3/4 Ø3 3 7/8" 11-1/16 Page 2 Parts and Tools Tools Needed Tape Measure Pencil Drill with 1/8, 1/4 and 3/8 bits, 1 spade bit and Phillips bit

More information

10ft X 16ft Breeze Pergola Assembly Manual. Outdoor Living Today. Revision 6 March 20th,2012

10ft X 16ft Breeze Pergola Assembly Manual. Outdoor Living Today. Revision 6 March 20th,2012 10ft X 16ft Breeze Pergola Assembly Manual Outdoor Living Today Revision 6 March 20th,2012 Note: Post Mounting Hardware is NOT included in this kit. Please confirm with your local building permit office

More information

VACUSEAL MODEL 200. HOT TUB PRODUCTS 233 Carrington Road Bethany CT

VACUSEAL MODEL 200. HOT TUB PRODUCTS 233 Carrington Road Bethany CT VACUSEAL MODEL 200 J G F G H L HOT TUB PRODUCTS 233 Carrington Road Bethany CT 06524 860-469-2580 www.vacusealcoverlift.com www.hottubproducts.com Made in USA H K E D C I A P B 10 9 8 7 6 5 4 3 2 1 0 SPAS

More information

ROCKWELL. Two Panel Door. Half X Door. Double X Door. Z Combination Door

ROCKWELL. Two Panel Door. Half X Door. Double X Door. Z Combination Door ROCKWELL 4 in 1 DOOR Choose between four door styles with this Door Kit. Our versatile Rockwell Door Kit is very easy to assemble. All materials and hardware needed to assemble any of the four styles are

More information

3/8-16 x 3/4 cap screw. 3/8-16 hex nut for above screws. 1/4-20 x 3/4 socket cap screw. 3/16 short arm hex key (not to scale)

3/8-16 x 3/4 cap screw. 3/8-16 hex nut for above screws. 1/4-20 x 3/4 socket cap screw. 3/16 short arm hex key (not to scale) Super Slab Roller 24, 30 and 36 models Worktable Assembly Directions P.O. Box 89 Cheney, WA 99004 USA 509.235.9200/800.23.7896 Fax: 509.235.9203 www.northstarequipment.com Revised September, 2006. All

More information

8X10 Breeze Pergola Assembly Manual Outdoor Living Today

8X10 Breeze Pergola Assembly Manual Outdoor Living Today 8X10 Breeze Pergola Assembly Manual Outdoor Living Today Revision #11 Jan 18th, 2018 Note: Post Mounting Hardware is NOT included in this kit. Please confirm with your local building permit office to determine

More information

P a r k c o n s o l e s i n k a s s e m b l y i n s t r u c t i o n s

P a r k c o n s o l e s i n k a s s e m b l y i n s t r u c t i o n s P a r k c o n s o l e s i n k a s s e m b l y i n s t r u c t i o n s Before You Begin: Professional installation by two-person crew is required for this fixture. Install water supply and drain piping

More information

Gold Crown POCKET BILLIARD TABLE INSTALLATION MANUAL. SERVICE DEPARTMENT P.O. BOX 68 BRISTOL, WI 53104

Gold Crown POCKET BILLIARD TABLE INSTALLATION MANUAL.   SERVICE DEPARTMENT P.O. BOX 68 BRISTOL, WI 53104 Gold Crown TM V POCKET BILLIARD TABLE INSTALLATION MANUAL www.brunswickbilliards.com SERVICE DEPARTMENT P.O. BOX 68 BRISTOL, WI 53104 51-905708-000 OCTOBER 2007 NOTE: Please use the instructions in this

More information

Best Barns USA. the Brookhaven 10' x 16' Assembly Book. revised March 23, 2016

Best Barns USA. the Brookhaven 10' x 16' Assembly Book. revised March 23, 2016 Best Barns USA Assembly Book revised March 23, 2016 the Brookhaven 10' x 16' Manufactured by Reynolds Building Systems, Inc. 205 Arlington Drive Greenville, PA 16125 724-646-3775 This manual is copyrighted.

More information

AMISHGAZEBOSHOP.COM VINYL GAZEBO KIT CONTENTS

AMISHGAZEBOSHOP.COM VINYL GAZEBO KIT CONTENTS VINYL GAZEBO KIT CONTENTS Hardware for assembling your gazebo (provided): 2 1/2" screws Use to fasten joist together fasten posts to outside joist fasten rafters to rafter header fasten benches & cupola

More information

10x10 Trellis Pergola

10x10 Trellis Pergola 0x0 Trellis Pergola ASSEMBLY GUIDE Ver.0-7 Table of Contents PAGE Introduction & Overview...................................................... Pergola Materials Overview..............................................................

More information

Treviso POCKET BILLIARD TABLE INSTALLATION MANUAL. SERVICE DEPARTMENT P.O. BOX 68 BRISTOL, WI 53104

Treviso POCKET BILLIARD TABLE INSTALLATION MANUAL.  SERVICE DEPARTMENT P.O. BOX 68 BRISTOL, WI 53104 Treviso TM POCKET BILLIARD TABLE INSTALLATION MANUAL www.brunswickbilliards.com SERVICE DEPARTMENT P.O. BOX 68 BRISTOL, WI 53104 51-905881-000 NOVEMBER 2008 NOTE: Please use the instructions in this manual

More information

Grand Garden Chalet 6X3 Assembly Manual - Costco

Grand Garden Chalet 6X3 Assembly Manual - Costco Revision #16 March 22nd, 2013 Grand Garden Chalet 6X3 Assembly Manual - Costco Thank you for purchasing a Grand Garden Chalet. Please take the time to identify all the parts prior to assembly. Please use

More information

Parts list Instruction guide Warnings Please read carefully before assembling and using product.

Parts list Instruction guide Warnings Please read carefully before assembling and using product. Parts list Instruction guide Warnings Please read carefully before assembling and using product. Jet Rail XL Part Number 27377 Tools required for assembly Hammer 9/16 Wrench 3/4 Wrench Ratchet 9/16 Socket

More information

Horizontal Cable Systems

Horizontal Cable Systems ALUMINUM RAILING INSTALLATION INSTRUCTIONS Horizontal Cable Systems 1) Check Contents Of Packages: Verify that all parts have arrived and that they match the packing list. 1A) Coastal applications: Confirm

More information

INSTALLATION INSTRUCTIONS VENETIAN 84" SLIDING SHOWER DOOR SYSTEM (180º INSTALLATION)

INSTALLATION INSTRUCTIONS VENETIAN 84 SLIDING SHOWER DOOR SYSTEM (180º INSTALLATION) INSTALLATION INSTRUCTIONS VENETIAN 84" SLIDING SHOWER DO SYSTEM (180º INSTALLATION) 28539 Industry Drive, Valencia, CA 91355 Toll Free Phone: (877) 728-3874 Toll Free Fax: (888) 440-9567 Phone: (661) 775-1675

More information

12ft Octagon Bayside Gazebo Assembly Manual

12ft Octagon Bayside Gazebo Assembly Manual We recommend reviewing this Assembly Manual thoroughly before starting this project. Become familiar with the tools required and where and when assistants are necessary. If you re planning on finishing

More information

SwingSafe Swing-Away Mailbox Support Diagram

SwingSafe Swing-Away Mailbox Support Diagram SwingSafe Swing-Away Mailbox Support Diagram Wood Mounting Plates Top Arm (B) Muffler Clamps (A) Carriage Bolts and Nuts Bottom Arm 4-Foot U-Channel Post USPS Recommended 42-44 Height Ground Slope Hex

More information

10 Octagon Cedar Gazebo Assembly Instructions

10 Octagon Cedar Gazebo Assembly Instructions 10 Octagon Cedar Gazebo Assembly Instructions Toll Free: 866.768.8465 Hours: 9-5 Monday-Friday EST www.homeplacestructures.com Package ships as shown revised 06/22/09 10 Cedar Gazebo Assembly Instructions

More information

A MULTI-PURPOSE LOFT THAT CAN BE USED FOR SLEEPING, STORAGE, AND FREEING UP SPACE (Supports 200 lbs max) DIFFICULTY: 6/10

A MULTI-PURPOSE LOFT THAT CAN BE USED FOR SLEEPING, STORAGE, AND FREEING UP SPACE (Supports 200 lbs max) DIFFICULTY: 6/10 A MULTI-PURPOSE LOFT THAT CAN BE USED FOR SLEEPING, STORAGE, AND FREEING UP SPACE (Supports 200 lbs max) DIFFICULTY: 6/10 CAUTION The instructions are only a guide, and should be followed by individuals

More information

Fortress Fe Posts must always be secured to the deck framing. Fortress Fe Posts should never be attached to only the deck boards.

Fortress Fe Posts must always be secured to the deck framing. Fortress Fe Posts should never be attached to only the deck boards. Installation Instructions for FortressCable H-Series Stair Panels with Simplified Stair Bracket SSB-05 and Fe Posts It is the responsibility of the installer to meet all code and safety requirements, and

More information

BISON GOOSENECK FOOTBALL 1 PAIR OF GOAL POSTS

BISON GOOSENECK FOOTBALL 1 PAIR OF GOAL POSTS Instruction Manual BISON GOOSENECK FOOTBALL 1 PAIR OF GOAL POSTS Customer Service (800) 247-7668 P A R T S L I S T Item Qty Description Item Qty Description A 2 GOOSENECK POLE I 4 UPRIGHTS B 2 BAND CLAMP

More information

PATRIOT DOCKS ASSEMBLY INSTRUCTIONS

PATRIOT DOCKS ASSEMBLY INSTRUCTIONS 6/1/2008 PATRIOT DOCKS ASSEMBLY INSTRUCTIONS Congratulations on your new Patriot Dock purchase. This manual contains instructions to assemble basic dock configurations for use at typical shoreline application.

More information

10ft Octagon Bayside Gazebo Assembly Manual

10ft Octagon Bayside Gazebo Assembly Manual We recommend reviewing this Assembly Manual thoroughly before starting this project. Become familiar with the tools required and where and when assistants are necessary. If you re planning on finishing

More information

THE PODIUM MUSIC STAND

THE PODIUM MUSIC STAND THE PODIUM MUSIC STAND 1 Set Assembly Instructions Wooden Parts: a. 1 Column b. 2 Long Slide Pieces c. 2 Slide Spacers (1 long & 1 short) d. 4 Feet e. 2 Fork Pieces f. 1 Fork Spacer g. 2 Long Desk Frame

More information

CCC Project Manual BUILDING MATERIALS

CCC Project Manual BUILDING MATERIALS CCC Project Manual BUILDING MATERIALS Units of Measure and Conversions In this manual, you may see some shorthand notations for units of measure... 12 means 12 inches 10 means 10 feet 12 inches equals

More information

Pacifica Pool House. Assembly Manual. Toll Free: Hours: 9-5 Monday-Friday EST. Package ships as shown. Suncast Corporation

Pacifica Pool House. Assembly Manual. Toll Free: Hours: 9-5 Monday-Friday EST. Package ships as shown. Suncast Corporation Pacifica Pool House Assembly Manual Toll Free: 866.768.8465 Hours: 9-5 Monday-Friday EST Package ships as shown Simpson Hurricane Straps Double Insulated Raised-Panel Door in back wall (71 x71 Total opening)

More information

Spiral Slide

Spiral Slide IMPORTANT Page 1 PLEASE READ THESE INSTRUCTIONS BEFORE COMMENCING ASSEMBLY. All equipment must be installed in accordance with these instructions. Check your shipment against Bill of Lading and Parts list.

More information

Kentucky 4H Wood Science Plans Notebook. Plans Level 3

Kentucky 4H Wood Science Plans Notebook. Plans Level 3 Kentucky 4H Wood Science Plans Notebook Plans Level 3 MATERIALS: 2 pieces wood 3/4 x 10 x 4 1 piece wood 3/4 x 12 x 4 2 pieces wood 3/4 x 3 x 2 5 1/2" 2 pieces wood 3/4 x 3 x 1 8 1 piece wood 2 x 4 x

More information

Real Life Ninja Complete Starter Pack (14ft. Warped Wall) Assembly Instructions

Real Life Ninja Complete Starter Pack (14ft. Warped Wall) Assembly Instructions MATERIALS: 3 - Main Sections (Only 2 Sections for 10 ) 8 3 deck screws for joining sections inside of 2 Rock Wall Panels (with pre-installed t-nuts. Top panel comes with ladder mounting block preinstalled.)

More information

Desk/Wall-Mount Rack

Desk/Wall-Mount Rack Desk/Wall-Mount Rack Patent(s) Pending Installation Instructions Post P/N: 119-1752 119-1781 119-1782 119-4014 Frame P/N: 119-1591 119-1754 119-1755 Kit Contents (2) Frames (4) Posts Assembly Hardware

More information

Best Barns USA Assembly Book

Best Barns USA Assembly Book Best Barns USA Assembly Book Revised August 15, 2017 the Richmond 16'x32' Building w/ Full Loft Manufactured by Reynolds Building Systems, Inc 205 Arlington Drive Greenville, PA 16125 This manual is copyrighted

More information

Osprey Platform Assembly Guide. Menunkatuck Audubon Society. Rev 1.0

Osprey Platform Assembly Guide. Menunkatuck Audubon Society. Rev 1.0 Osprey Platform Assembly Guide Menunkatuck Audubon Society Rev 1.0 1 Menunkatuck Audubon Society is a local chapter of National Audubon Society. We serve the shoreline towns of West Haven, New Haven, East

More information

Installation Manual Flat Track Series

Installation Manual Flat Track Series Manual Flat Track Series Contents Safety...1 Parts...2 Hardware.......................................... 2 Tools Required..................................... 4.............................................

More information

PRO CYC PRO CYC, INC. SYSTEM SUPER 1.5QS

PRO CYC PRO CYC, INC. SYSTEM SUPER 1.5QS Assembly Instructions System Super 1.5QS Congratulations on your decision to use the world s most advanced and user-friendly cyclorama system. We have taken a great deal of care to create and ship your

More information

Dura-Lock Roof System

Dura-Lock Roof System DLR-14 Dura-Lock Roof System Assembly and Installation Instructions Read the instructions before starting the job. They explain the steps required to produce a finished product that will meet factory specifications.

More information

Please read and understand the OnBoard Timpani Cart Owner s Manual before using the Timpani Cart.

Please read and understand the OnBoard Timpani Cart Owner s Manual before using the Timpani Cart. Assembly and Owner s Manual OnBoard Timpani Cart Performance Position Towing Position CONTENTS Important User Information...........................2 General......................................2 Manufacturer.................................2

More information

EASY POOL STEP (NE113)

EASY POOL STEP (NE113) EASY POOL STEP (NE113) FOR USE WITH: EASY POOL STEP (NE113) (1 CARTON) EASY POOL STEP WITH OUTSIDE LADDER (NE126) EASY POOL STEP ENTRY SYSTEM (NE138) (With Gate) (4 CARTONS) Above are the options available

More information

Flex Fence Instruction Manual

Flex Fence Instruction Manual The Safer Stronger Smarter Choice Flex Fence Instruction Manual Table of contents 2 3 4 4 5 5 6 7 8 10 10 11 11 12 13 13 15 18 18 19 20 22 Table of contents Supplies, tools and equipment Introduction Laying

More information

Installation and Assembly - Universal Articulating Swivel Double-Arm for 42" - 60" Plasma Screens

Installation and Assembly - Universal Articulating Swivel Double-Arm for 42 - 60 Plasma Screens Installation and Assembly - Universal Articulating Swivel Double-Arm for 42" - 60" Plasma Screens Models: PLAV 70-UNL, PLAV 70-UNL-S PLAV 70-UNLP, PLAV 70-UNLP-S R This product is UL Listed. It must be

More information

KD Table Base Assembly and Top Attachment Instructions

KD Table Base Assembly and Top Attachment Instructions KD Table Base Assembly and Top Attachment Instructions 4011xx 5000xx 7014xx 8001xx 8206xx Congratulations on the purchase of your Tropitone furniture. Read through all steps before starting assembly. CAUTION:

More information

Best Barns USA Assembly Book

Best Barns USA Assembly Book Best Barns USA Assembly Book Revised August 15, 2017 the Richmond 16'x20' Building w/ Full Loft Manufactured by Reynolds Building Systems, Inc 205 Arlington Drive Greenville, PA 16125 This manual is copyrighted

More information

Clopay Models 835/837 Sliding Door System Installation Guide

Clopay Models 835/837 Sliding Door System Installation Guide Clopay Models 835/837 Sliding Door System Installation Guide The aim of this instruction is to guide you through the process of construction and fitting of Sliding Doors. Due to the number of sizes available

More information

Best Barns USA Assembly Book

Best Barns USA Assembly Book Best Barns USA Assembly Book Revised August 15, 2017 the Richmond 16'x24' Building w/ Full Loft Manufactured by Reynolds Building Systems, Inc 205 Arlington Drive Greenville, PA 16125 This manual is copyrighted

More information

Best Barns USA Assembly Book

Best Barns USA Assembly Book Best Barns USA Assembly Book Revised August 15, 2017 the Richmond 16'x28' Building w/ full loft Manufactured by Reynolds Building Systems, Inc 205 Arlington Drive Greenville, PA 16125 This manual is copyrighted

More information

EASY-IN POOL STEP SYSTEM NE132

EASY-IN POOL STEP SYSTEM NE132 EASY-IN POOL STEP SYSTEM NE132 This instruction manual features multiple guides for the step unit components. 7939 EASY POOL STEP (NE113) FOR USE WITH: EASY-IN POOL STEP (NE126) 6492 PARTS & HARDWARE FOR

More information

MEADOWVALE II PLAY SYSTEM F24035

MEADOWVALE II PLAY SYSTEM F24035 MEADOWVALE II PLAY SYSTEM F24035 INSTALLATION AND OPERATING INSTRUCTIONS 14 5 (4.4 m) 24 10 / 7.9m 12 10 / 3.9m 18 8 (5.7 m) 10 6 / 3.2m 28 / 8.5m WARNING To reduce the risk of serious injury or death,

More information

Therma-Tru Door Gallery Setup Instructions Swing Unit with Hardware Kit - Hardware Part # MADGSWU15 (Swing Unit) Part # MADGHKSU10 (Hardware Kit)

Therma-Tru Door Gallery Setup Instructions Swing Unit with Hardware Kit - Hardware Part # MADGSWU15 (Swing Unit) Part # MADGHKSU10 (Hardware Kit) Swing Unit with Hardware Kit - Hardware Tools Included: 4mm Allen Wrench, 6mm Allen Wrench, 8mm T-Handle Allen Wrench (1) 3/4" Drill Bit, (1) 7/32" Drill Bit and Hole Template Guide Tools Required: Phillips

More information

LOWLINE SINGLE FOLD DOWN WALL BEDS

LOWLINE SINGLE FOLD DOWN WALL BEDS ASSEMBLY INSTRUCTIONS LOWLINE SINGLE FOLD DOWN WALL BEDS Tools Required For Assembly No 2 & No 4 Phillips Head Screwdrivers No 2 Slot Head Screwdriver Hammer Electric Drill (Hammer Drill for Masonry) 6.5mm

More information

PRO CYCTM PRO CYC, INC. SYSTEM 1.5 FS

PRO CYCTM PRO CYC, INC. SYSTEM 1.5 FS ASSEMBLY INSTRUCTIONS Congratulations on your decision to use the world s most advanced and user-friendly cyclorama system. We have taken a great deal of care to create and ship your cyc, so please take

More information

Lab Style Table Frame Part No Assembly Guide Automation Technology

Lab Style Table Frame Part No Assembly Guide Automation Technology Ergonomic Workstations Lab Style Table Frame Part No. 8 0 Assembly Guide 7 90 70 Automation Technology SPECIFICATIONS Lab style frame part number... 80 Height... 70 mm (8.") Width... 90 mm (.7") Depth...

More information

English/French 06/04

English/French 06/04 E000 PLEASE READ ASSEMBLY INSTRUCTIONS COMPLETELY BEFORE ASSEMBLING YOUR BUILDING CAUTION: Some parts have sharp edges. Care must be taken when handling the various pieces to avoid a mishap. For safety

More information

Installation and Assembly - Universal Articulating Swivel Double-Arm for 42" - 60" Plasma Screens

Installation and Assembly - Universal Articulating Swivel Double-Arm for 42 - 60 Plasma Screens Installation and Assembly - Universal Articulating Swivel Double-Arm for 42" - 60" Plasma Screens Models: PLAV 70-UNL, PLAV 70-UNL-S PLAV 70-UNLP, PLAV 70-UNLP-S R This product is UL Listed. It must be

More information

Oakland II POCKET BILLIARD TABLE INSTALLATION MANUAL

Oakland II POCKET BILLIARD TABLE INSTALLATION MANUAL TM Oakland II POCKET BILLIARD TABLE INSTALLATION MANUAL www.brunswickbilliards.com SERVICE DEPARTMENT P.O. BOX 68 BRISTOL, WI 53104 EMAIL: BRUNSWICKSERVICE@BRUNSWICKBILLIADS.COM 51-906253-000 OCTOBER 2016

More information

INSTALLATION INSTRUCTIONS

INSTALLATION INSTRUCTIONS INSTALLATION INSTRUCTIONS For Wallbed models: Do-It-Yourself BOOKLET #C90 WARNING! ALL MURPY/WALLBED SYSTEMS CONTAIN STORED ENERGY. FAILURE TO USE AND FOLLOW THESE INSTRUCTIONS DURING THE INSTALLATION

More information