Proportional Directional Control Valves Series D*FH and D*FM General Description Operation Features Series D*FH Series D*FM

Size: px
Start display at page:

Download "Proportional Directional Control Valves Series D*FH and D*FM General Description Operation Features Series D*FH Series D*FM"

Transcription

1 Catalog HY14-255/ echnical Information General Description eries D*FH is a high response, proportional servovalve with an on-board drive amplifier. he D*FM is a high response, direct actuated servovalve with high resolution around low command inputs. he D*FM is designed for more precise control of position loops, force loops, and machine tool feed rates. incorporate the use of state-ofthe-art drive electronics with an LVD for continuous monitoring of the spool position. Zero lap spools are standard for closed loop applications with two different power down configurations. he valves feature frequency response levels greater than 1 Hz for D1FH and D1FM, and 45 Hz for D3FH and D3FM, along with low hysteresis and excellent repeatability. Operation eries D*FH eries D*FH valve uses a precision lapped spool and sleeve configured with four control positions. During normal operation, the valve will shift from the center position to either side providing flow out the or port. When the drive amplifier is disabled by either removing the enable or loss of electrical power, the valve will shift through in less than 1ms to a fourth position. he fourth position will block all four ports in one version. second version that is available will block the port and allow the and ports to bleed to the (tank line). (Refer to the With No Enable in roubleshooting section) eries D*FM he high resolution eries D*FM adds hydraulic and electronic control compensation to the standard D*FH valve. his feature enhances the tuning and accuracy of systems utilizing high resolution feedback transducers and control compensation available in high performance motion controllers. he D*FM valve uses a precision lapped spool and sleeve configured with four control positions. he fourth position (disabled) is available in an all ports blocked configuration or and ports bleed to tank configuration. Features On-oard Electronic Drive mplifier he unit is shipped as a factory preset and tested unit. (No adjustment is necessary) High Frequency Response he valve has a very high frequency response which is necessary for many closed loop applications. Four osition pool Capability he four position spool provides predictable flow in the event of a power failure to the drive electronics, within the limits of the power curve. 315 ar ressure Capability he maximum operating pressure rating for the D*FH and D*FM is 315 ar or 45 I (ort,, ). pool osition Feedback he LVD continuous feedback monitoring circuit provides low hysteresis and excellent repeatability. Drive Enable Feature Output to the coil is shut down when the enable signal (1 to 3 VDC) is not present. he valve will then shift to the fourth position flow path selected by the user. (E5 or E8 spool) High Resolution round Null For precise control of critical position, force, or feed rates (D*FM Version only) Cylinder Ratio djust o match following error on extend and retract. (D*FM Version only) Note: he tank line of either style valve must have a minimum pressure of 1.4 ar (2 I). Maximum tank line pressure is 35 ar (5 I). 98 Elyria, Ohio,

2 Catalog HY14-255/ Ordering Information D Directional Control Valve ize 1 NG6/CEO 3 3 NG1/CEO 5 tyle H High Response M High Response, Dual Gain pool ype Q equal to flow Q Code ymbol E5 1) E8 1) E53 2) (6/4) E83 2) (6/4) E84 2,3) (4/6) F Control 1) D1FH and D3FH only 2) D1FM only 3) D1FM*M flow code only D3FM*Y flow code only pool ype Code C tyle eal Electronic Variation C i-directional, 4 way, with 4 th position on power down J upply Voltage Electric ccessories J 24 VDC Valve ccessories Voltage Input... ±1 V (user configurable to... ± 2 m) N Nitrile V Fluorocarbon at p 35 ar (5 I) per metering edge Weight: D1F D3F Design eries NOE: Not required when ordering. roduct Variation Omit tandard (with enable) X6262 in C is V reference instead of an enable (for competitive interchange only). Valve enables with power. (note 4) Note 4: D1FH D1FM D3FH D3FM LM (GM) LM (GM) LM (GM) LM (GM) 5 (1.3) D 1 (2.6) F 12 (3.2) H 2 (5.3) M 4 (1.6) 4 (1.6) 5 (13.2) Y 1 (26.5) 1 (26.5) Maximum supply pressure is 315 ar (45 I). his is the pressure drop across the load and the valve. For maximum pressure drop per land, refer to the table on page 47. Do NO apply an enable signal to in C. nlike many other valves with the same 7-pin connector, in C is not for an enable signal. in C is a V reference used for DMMs or scopes to monitor pin F. It is not a power supply common. sing it as a power supply common will damage the C board. 3.7 kg (8.2 lbs.) 7.7 kg (17. lbs.) Mounting Interface Refer to the Mounting Interface Dimensions in the roportional Directional Valve section of this catalog. ccessories Refer to the ccessories section for bolt kits, subplates, connectors and pre-assembled cable assemblies. 99 Elyria, Ohio,

3 Catalog HY14-255/ echnical Information pecifications D1FH, D1FM D3FH, D3FM Interface NF D3, CEO 3, NG6 NF D5, CEO 5, NG1 1) 1) Rating spool 5 LM (1.3 GM) spool 5 LM (13.2 GM) 1) 1,2) t 35 ar D (5 I) D spool 1 LM (2.6 GM) Y spool 1 LM (26.4 GM) 1) per metering edge H spool 2 LM (5.3 GM) 1,2) M spool 4 LM (1.6 GM) 2) F spool 12 LM (3.2 GM) Frequency Response > 1 Hz (-3 d at 5% signal) > 45Hz (-3 d at 5% signal) tep Response < 12 ms at 1% signal < 25 ms at 1% signal ower Consumption 4 V max (ee voltage supply) 6 V max (ee voltage supply) Max. Operating ress. ort,, ort Min. ank Line ress. 315 ar (45 I) 35 ar (5 I) 1.4 ar (2 I) ypical pool Overlap Zero Lap ressure Gain 1) ypical 4% % of Change/1% 1) Minimum 25% Change in Command 2) ypical 9% Hysteresis <.5% Repeatability <.5% Viscosity Range Fluids Note: 1) D*FH only 17 to 65 ct / mm 2 /s (79 to 31 ) Mineral base hydraulic fluid 2) D*FM only D1FH, D1FM, D3FH, D3FM Operating emp. to 6 C Range (mbient) (32 to 14 F) Fluid Cleanliness Level Voltage upply Command ignals IO Class 15/12/1 (For longer life) IO Class 16/14/11 (For normal operation) 24 VDC (21 VDC Min., 3 VDC Max.) eak Current 4 (D24 power supply recommended) ± 1 VDC at 1 K ohm input impedance ± 2 m at 499 ohm input impedance rotection Class I65, NEM 4 (s factory sealed) Maximum and ressure Differential pool Code Code D F H M Y Max 1 ar 1 ar 6 ar 7 ar 52 ar 7 ar 5 ar E5 er Land (15 I) (15 I) (85 I) (1 I) (75 I) (1 I) (725 I) Max 8.3 LM 16.3 LM 9.7 LM 26.9 LM 46.2 LM 69.6 LM 121 LM (2.2 GM) (4.3 GM) (5.2 GM) (7.1 GM) (12.2 GM) (18.4 GM) (32 GM) Max 1 ar 1 ar 6 ar 7 ar 52 ar 7 ar 5 ar E8 er Land (15 I) (15 I) (85 I) (1 I) (75 I) (1 I) (725 I) Max 8.3 LM 16.3 LM 9.7 LM 26.9 LM 46.2 LM 69.6 LM 121 LM (2.2 GM) (4.3 GM) (5.2 GM) (7.1 GM) (12.2 GM) (18.4 GM) (32 GM) 1 Elyria, Ohio,

4 Catalog HY14-255/ echnical Information Wiring Diagnosis (pool osition) upply Voltage 24 V V- Reference otential rotective Earth Installation Guidelines Refer to the Installation Guide for set-up, configuration, and application guidelines (packaged with each valve). D*FH and D*FM: ul. HY M1/ - Command + Command Enable or V Reference (x6262 option) lock Diagram Note 1: Install jumper J1 for current command input. Refer to installation guide ul. HY M1/. Note 2: Valves can be ordered with pin C internally grounded to be interchangeable with some competitor products. Refer to Ordering Information page. erformance Curves D1FM series proportional valves are electronically compensated dual flow-gain valves. he command voltage/flow transfer function is linear while the actual spool stroke/flow gain is designed to provide very high resolution at low flows. he D1FM series proportional valves are particularly well suited for machine tool feed applications, or where very fine flow resolution is required while maintaining a rapid advance function in a single valve. he D1FM frequency response is the same as the D1FH; refer to the next page. GM LM D1FM Operating Limits at 1% Command : ; or : F pool ar I ressure Drop Elyria, Ohio,

5 Catalog HY14-255/ erformance Curves GM 33.1 LM D3FM Operating Limits at 1% Command : ; or : Code Y ar I ressure Drop GM LM D1FH Operating Limits at 1% Command : ; or : Code M Code H ar I ressure Drop Elyria, Ohio,

6 Catalog HY14-255/ erformance Curves GM 33.1 LM D3FH Operating Limits at 1% Command : ; or : Code Y Code ar I ressure Drop mplitude Ratio (d) D1FH and D1FM Frequency Response at ±5%, ±5% Cmd, p= 7 ar (1 I) ± 5% ± 5% mplitude Ratio (d) D3FH and D3FM Frequency Response at ±5%, ±5% Cmd, p= 7 ar (1 I) ± 5% ± 5% -18 hase hift (degrees) ± 5% ± 5% Frequency (Hz) hase hift (degrees) ± 5% ± 5% 1 1 Frequency (Hz) 13 Elyria, Ohio,

7 M1 M1 M1 M1 M1 M1 Catalog HY14-255/ Dimensions D1FH and D1FM Inch equivalents for millimeter dimensions are shown in (**) (5.96) 51.5 (2.3) 146. (5.75) D3FH and D3FM Inch equivalents for millimeter dimensions are shown in (**) (8.56) 257. (1.12) 17. (6.69) 155. (3.94) 1. (2.76) 7. (2.76) 14 Elyria, Ohio,

DIN (NFPA/ISO/CETOP) NG6 (03) NG10

DIN (NFPA/ISO/CETOP) NG6 (03) NG10 Catalog HY14-255/ echnical Information eries D*FH and D1FM General Description he D*FH series high response proportional servovalves are direct solenoid operated, with electronic spool position feedback

More information

Proportional Directional Control Valves Series D1FB. General Description. Features. D1FB*3 OBE Spool/Body Design. D1FB*0 OBE Spool/Sleeve Design

Proportional Directional Control Valves Series D1FB. General Description. Features. D1FB*3 OBE Spool/Body Design. D1FB*0 OBE Spool/Sleeve Design echnical Information roportional Directional Control Valves Series D1FB General Series D1FB (NG6) proportional directional valves are available with and without onboard electronics (OBE). D1FB OBE: he

More information

DIN (NFPA/ISO/CETOP) NG6 (3) NG10

DIN (NFPA/ISO/CETOP) NG6 (3) NG10 13169 : Mutter R.S R.S Mutter : 13169 Calog HY14-255/US Technical Informion General direct opered proportional directional control solenoid valves are available with or without integred control electronics.

More information

DIN (NFPA/ISO/CETOP) NG6 (3) NG10

DIN (NFPA/ISO/CETOP) NG6 (3) NG10 Technical nformation General escription proportional directional control valves are direct operated solenoid valves with electronic spool position feedback, and on-board integrated control electronics.

More information

4-Way Servo Valve Model 4 WS. 2 E , (Series 2X) with Mounting Pattern to DIN or CETOP RP 115 H PSI (315 bar) H/A 3012 H/A 3013

4-Way Servo Valve Model 4 WS. 2 E , (Series 2X) with Mounting Pattern to DIN or CETOP RP 115 H PSI (315 bar) H/A 3012 H/A 3013 4-Way Servo Valve Model 4 WS. 2 E. 16..., (Series 2X) with Mounting attern to DIN 24 3 or CETO R 11 H Size 16... 40 SI (31 bar)... 3 GM (0 L/min) R 29 91/06.98 R 29 91/06.98 Replaces: 0.94 2 stage servo

More information

DIN NG10 NG25 NG32 ISO/CETOP

DIN NG10 NG25 NG32 ISO/CETOP atalog H14-255/US echnical Information eneral proportional pressure reducing valves have a proportional solenoid operated pilot stage and sliding spool main stage. he power supply voltage and input command

More information

Electro-Hydraulic 4-Way Directional Servo Valve Model 4 WS 2 E.10 and 4 WSE 2 E. 10 (Series 4X) PSI (315 bar) K K

Electro-Hydraulic 4-Way Directional Servo Valve Model 4 WS 2 E.10 and 4 WSE 2 E. 10 (Series 4X) PSI (315 bar) K K Electro-Hydraulic -Way Directional Servo Valve Model WS 2 E. and WSE 2 E. (Series X) Size (D 5)... 6 PSI (5 bar)... 2 GPM (75 L/min) R 29 586/6.98 R 29 586/6.98 Replaces: 5.9 Features: Servo valve for

More information

4/3-way fast response valve Type 4WRGE

4/3-way fast response valve Type 4WRGE RE 9 7/.3 Replaces:.98 4/3-way fast response valve ype 4WRGE Nom. size max. operating pressure 35 ar Nom. sizes 6, 5 max. operating pressure 35 ar Series X Maximum flow 87 L/min H/ 568/95 ype 4WRGE L-X/35G4..K3...

More information

Proportional directional valves

Proportional directional valves 01/10 Proportional directional valves 6.12 Type 4WRPEH6...L2X NG 6 Up to 315 bar Up to 40L /min Contents Function and configuration 02 Ordering code 03 Symbols 03 Technical data 04 Electrical connection

More information

2-Way Proportional Logic Cartridge Valve Model FE.. (Series 1X and 2X) PSI (315 bar) F with electrical connection 12 X Y

2-Way Proportional Logic Cartridge Valve Model FE.. (Series 1X and 2X) PSI (315 bar) F with electrical connection 12 X Y RA 9 /6.98 -Way Proportional Logic Cartridge Valve Model FE.. (Series X and X) Size 6... 6... 6 PSI (5 bar)... 75 GPM (8 L/min) RA 9 /6.98 Replaces: 5.9 Characteristics: Single land throttle valve (main

More information

Direct Operated Proportional DC Valve Series D1FP

Direct Operated Proportional DC Valve Series D1FP Catalogue HY11-500/UK Characteristics The direct operated control valve D1FP of the nominal size NG0 (CETOP 0) shows extremly high dynamics combined with maximum flow. It is the preferred choice for highest

More information

Directional control valves, direct operated, with electrical position feedback and integrated electronics (OBE)

Directional control valves, direct operated, with electrical position feedback and integrated electronics (OBE) Directional control valves, direct operated, with electrical position feedback and integrated electronics (OBE) Type 4WRPEH RE 29035 Edition: 2017-04 Replaces: 2015-02 Size 6 Component series 2X Maximum

More information

SERVO VALVES. Maximum Flow. Maximum Operating Pressure MPa (PSI) U.S.GPM Page. Graphic Symbols.

SERVO VALVES. Maximum Flow. Maximum Operating Pressure MPa (PSI) U.S.GPM Page. Graphic Symbols. I SERVO VALVES Valve Graphic Symbols Maximum Operating Pressure MPa (PSI) Maximum Flow U.S.GPM.5 1 2 5 50 0 0 500 1 2 3 5 30 50 0 0 300 500 00 00 L/min Page Direct High Speed Linear Servo Valves LSVG-03

More information

Electronic Amplifier Model VT 3017 and VT 3018 (Series 3X) for the control of proportional directional valves, without positional feedback

Electronic Amplifier Model VT 3017 and VT 3018 (Series 3X) for the control of proportional directional valves, without positional feedback RA 29 939/06.98 Electronic Amplifier Model T 301 and T 3018 (Series 3X) for the control of proportional directional valves, without positional feedback RA 29 939/06.98 Replaces: 09.94 Electronic amplifier

More information

PROPORTIONAL PRESSURE CONTROLS TECNORD

PROPORTIONAL PRESSURE CONTROLS TECNORD Proportional Pressure Reducing / Relieving Valves Direct acting GPM PSI LPM BAR MODEL PAGE 0,8 5000 3 345 IP-DAR-43-H 8 0,8 700 3 50 IP-DAR-43-L 8 2 500 8 35 EC PRV 10 Pilot operated GPM PSI LPM BAR MODEL

More information

Eaton Servo-Performance Proportional Directional Valve AxisPro. KBH*-8 10 Series

Eaton Servo-Performance Proportional Directional Valve AxisPro. KBH*-8 10 Series Eaton Servo-Performance Proportional Directional Valve AxisPro KBH*-8 10 Series Contents Introduction General Description... 3 Typical Section View... 3 Model Code... 4 Spool Data... 6 Operating Data...

More information

Proportional Directional Control Valves Size 6

Proportional Directional Control Valves Size 6 Proportional Directional Control Valves Size 6 Direct operated, positioncontrolled Interface to DIN 2 30 and ISO 0 PN [p max. ] = 35 bar 75079.06.03.06 Description (standard units) Design The proportional

More information

4/3 Proportional Directional Valve, Size SAE 10

4/3 Proportional Directional Valve, Size SAE 10 / Proportional Directional Valve, Size SAE Q max =. gpm [ l/min], p max = psi [ bar] Direct acting, sliding-spool design, with solenoid operation Series PDFC- Description Series PDFC proportional directional

More information

RT-5005/5006/5007/5008

RT-5005/5006/5007/5008 Replaces: 09.12 Electro-hydraulic Control Digital Proportional Amplifier Type: RT-5005/5006/5007/5008 Series: 3X Table of contents Contents Page Features 1 Ordering code 2 Functional description 2 Block

More information

LSV(H)G Series High-speed Linear Servo Valves

LSV(H)G Series High-speed Linear Servo Valves LSV(H)G Series High-speed Linear Servo Valves LSVG-03 (3/8) & LSVHG-04/06/10 (1/2,3/4,1) Sub-plate Mounting LSVG/LSVHG Series High-Speed Linear Servo Valves offer extremely high response and excellent

More information

DENISON HYDRAULICS Proportional Pressure Control Valves

DENISON HYDRAULICS Proportional Pressure Control Valves DENISON HYDRAULICS Proportional Pressure Control Valves Series 4VP01 Cetop 03 Publ. 3-EN 2200-B, replaces 3-EN 2200-A FEATURES, SYMBOLS x FEATURES Direct operated pressure relief valve for flow up-to max.

More information

Eaton Servo-Performance Proportional Directional Valve AxisPro. KBH Series

Eaton Servo-Performance Proportional Directional Valve AxisPro. KBH Series Eaton Servo-Performance Proportional Directional Valve AxisPro KBH-7 1 Series Contents Introduction General Description Typical Section View 3 Model Code 4 Spool Sleeve Details 5 Spool Data 6 Performance

More information

Servo-Performance Proportional Directional Valves with Feedback. K(B)SDG4V-3 1* Series Pressures to 350 bar (5075 psi)

Servo-Performance Proportional Directional Valves with Feedback. K(B)SDG4V-3 1* Series Pressures to 350 bar (5075 psi) Servo-Performance Proportional Directional Valves with Feedback K(B)SDG4V-3 1* Series Pressures to 350 bar (5075 psi) Contents INTRODUCTION General description.... 03 Features and benefits.... 03 Typical

More information

Eaton Servo-Performance Proportional Directional Valve AxisPro. KBH Series

Eaton Servo-Performance Proportional Directional Valve AxisPro. KBH Series Eaton Servo-Performance Proportional Directional Valve AxisPro KBH-5 1 Series Contents Introduction General Description Typical Section View 3 Model Code 4 5 Spool Sleeve Details 6 Spool Data 7 Pressure

More information

Electro-hydraulic Servo Valve Systems

Electro-hydraulic Servo Valve Systems Fluidsys Training Centre, Bangalore offers an extensive range of skill-based and industry-relevant courses in the field of Pneumatics and Hydraulics. For more details, please visit the website: https://fluidsys.org

More information

Proportional Directional Control Valves Size 6

Proportional Directional Control Valves Size 6 Proportional Directional Control Valves Size 6 Direct controlled, electrically adjustable Interface to DIN 2 30 and ISO 0 PN [p max. ] = 35 bar 750055.06.02.06 Description (standard units) Design The proportional

More information

MDSD (Series 2X) Mobile Dual Solenoid Driver

MDSD (Series 2X) Mobile Dual Solenoid Driver R 64/. MDSD (Series X) Mobile Dual Solenoid Driver R 64/.5 Replaces: 6.4 The MDSD amplifier provides control of components that use proportional solenoids without LVDTs for actuation. The MDSD orporates

More information

Proportional pressure controller

Proportional pressure controller Proportional pressure controller Introduction I. Introducing : Proportional Pressure Controller Input signal I or E Output pressure The MAC Proportional Pressure Controller, (PPC) is an innovative product

More information

Accessories Power Amplifiers

Accessories Power Amplifiers Front Panel Vickers Models with Command Logic Module and Ramps EEA-PAM-5**-B- Series General Description Features and Benefits The EEA-PAM-5**-B- Eurocards are power amplifiers with a four-input (demand

More information

Digital Proportional Amplifier. Type: RT-VSPA2-50. Series: 3X. Table of contents. Features. RD13763/11.07 Replaces:

Digital Proportional Amplifier. Type: RT-VSPA2-50. Series: 3X. Table of contents. Features. RD13763/11.07 Replaces: Replaces: 09.12 Electro-hydraulic Control Digital Proportional Amplifier Type: RT-VSPA2-50 Series: 3X Table of contents Contents Page Features 1 Ordering code 2 Functional description 2 Block circuit diagram

More information

4/3 proportional directional valve direct operated, with integrated electronics

4/3 proportional directional valve direct operated, with integrated electronics 4/ proptional directional valve direct operated, with integrated electronics RE 2964/. Replaces: 2.2 /6 Type 4WREEM Sizes 6 and Component series 2X Maximum operating pressure 5 bar Maximum flow: 9 l/min

More information

Proportional Directional Control Valves Nominal sizes 16 and 25

Proportional Directional Control Valves Nominal sizes 16 and 25 Proportional Directional Control Valves Nominal sizes 16 and 25 Pilot operated, electrically adjustable Interface acc. to DIN 24 340 and ISO 4401 PN [p max. ] = 315 bar 7502968.06.01.06 Description Design

More information

Electronic amplifier for the control of proportional valves without position control Model VT 3006, Series 3X H/A 4240/94 VT X

Electronic amplifier for the control of proportional valves without position control Model VT 3006, Series 3X H/A 4240/94 VT X Electronic amplifier for the control of proportional valves without position control Model T 3006, Series 3X RA 29 926/06.98 Replaces: 02.96 The amplifier T 3006-3X is suitable for the control of pilot

More information

PROPORTIONAL PRESSURE CONTROLS TECNORD

PROPORTIONAL PRESSURE CONTROLS TECNORD Proportional Pressure Relief Valves Normally closed GPM PSI LPM BAR MODEL PAGE 0,8 430 3 30 EB-PRL 18 12 3000 45 207 EE-PRB 20 30 3000 114 207 ET-PRB 22 Normally open GPM PSI LPM BAR MODEL PAGE 12 3000

More information

Proportional pressure controller

Proportional pressure controller Proportional pressure controller Introduction I. Introducing : Proportional Pressure Controller Input signal I or E Output pressure The MAC Proportional Pressure Controller, (PPC) is an innovative product

More information

INTERNATIONAL STANDARD

INTERNATIONAL STANDARD INTERNATIONAL STANDARD ISO 10770-2 Second edition 2012-12-01 Hydraulic fluid power Electrically modulated hydraulic control valves Part 2: Test methods for three-port directional flow-control valves Transmissions

More information

Box chopper amplifier BOE

Box chopper amplifier BOE Box chopper amplifier BOE Description The box chopper amplifier is an always energised Pulse-Wide-Modulated (PWM) H-Bridge for to drive inductive loads with bipolar current in according to an analogue

More information

MM1/MM2 CONTROL VALVES CLOSED LOOP PROPORTIONAL PRESSURE CONTROLS THE FUTURE OF CONTROL TM

MM1/MM2 CONTROL VALVES CLOSED LOOP PROPORTIONAL PRESSURE CONTROLS THE FUTURE OF CONTROL TM THE FUTURE OF CONTROL TM MM1/MM CONTROL VALVES CLOSED LOOP PROPORTIONAL PRESSURE CONTROLS 317-335-60 P.O. Box 18 McCordsville, Indiana 46055 www.proportionair.com FEATURES Universal Mounting Din Rail,

More information

THE FUTURE OF CONTROLTM MM1/MM2 CONTROL VALVES CLOSED LOOP PROPORTIONAL PRESSURE CONTROLS

THE FUTURE OF CONTROLTM MM1/MM2 CONTROL VALVES CLOSED LOOP PROPORTIONAL PRESSURE CONTROLS THE FUTURE OF CONTROLTM MM1/MM CONTROL VALVES CLOSED LOOP PROPORTIONAL PRESSURE CONTROLS 317-335-60 P.O. Box 18 McCordsville, Indiana 46055 www.proportionair.com FEATURES Universal Mounting Din Rail, Panel

More information

Disc Gap Control DGC-2. Technical Manual

Disc Gap Control DGC-2. Technical Manual GB Disc Gap Control DGC-2 Technical Manual Contents Introduction Electronic unit... 1 Tracer valve... 1 Technical data... 2 Component layout... 4 Functions, electronic unit Stepper motor operation...

More information

Proportional Directional Valves with Feedback KBFDG4V-5-2C75N45-Z-M1-PC7-H7-12-EN123/EN150. Pressures to 315 bar (4500 psi)

Proportional Directional Valves with Feedback KBFDG4V-5-2C75N45-Z-M1-PC7-H7-12-EN123/EN150. Pressures to 315 bar (4500 psi) Proportional Directional Valves with Feedback KBFDG4V-5-2C75N45-Z-M1-PC7-H7-12-EN123/EN150 Pressures to 315 bar (4500 psi) Contents GENERAL DESCRIPTION... 03 SPOOL DATA... 03 FUNCTIONAL SYMBOL.... 03 MODEL

More information

Analog amplifier. RE 29926/10.06 Replaces: Type VT Component Series 3X

Analog amplifier. RE 29926/10.06 Replaces: Type VT Component Series 3X Analog amplifier RE 29926/10.06 Replaces: 0.03 /8 Type VT 3006 Component Series 3X H4240_d Table of contents Contents Page eatures 1 Ordering code 2 unctional Description 2 and 3 Block circuit / pin allocation

More information

Proportional flow valves digital, pressure compensated, direct operated, with position transducer

Proportional flow valves digital, pressure compensated, direct operated, with position transducer Table FS4-/E Proportional flow valves digital, pressure compensated, direct operated, with position transducer Valve body Throttle Compensator Proportional solenoid Position transducer Integral electronics

More information

GM24-MFT US. Proportional damper actuator, non-spring return, Multi-Function Technology

GM24-MFT US. Proportional damper actuator, non-spring return, Multi-Function Technology GM-MFT US Proportional damper actuator, non-spring return, Multi-Function Technology GM-MFT US Torque min. 0 in-lb Control to 0 VDC (DEFULT) Feedback to 0 VDC (DEFULT) pplication For proportional modulation

More information

Fuse, external A 6A, medium time lag. Power consumption W min 20 - max 60 (see paragraph 5.2) Output current A maximum 4.5 (see paragraph 5.

Fuse, external A 6A, medium time lag. Power consumption W min 20 - max 60 (see paragraph 5.2) Output current A maximum 4.5 (see paragraph 5. 89 251/217 ED EDM-M* DIGITAL AMPLIFIER FOR OPEN LOOP PROPORTIONAL VALVES EDM-M1 single solenoid EDM-M2 double solenoid EDM-M3 two single solenoids independent channels RAIL MOUNTING TYPE: DIN EN 50022

More information

Proportional pressure controller. Pressure range PSI/BAR. D Differential pressure G Gage pressure X X X - X X. Cover options

Proportional pressure controller. Pressure range PSI/BAR. D Differential pressure G Gage pressure X X X - X X. Cover options Proportional pressure controller Series PPC9A Port size Flow (Max) (Cv/Nl/min) Individual mounting Series 1/ /4 OPERATIONAL BENEFITS 6./600 covered analog base mount 1. Reliable operation, using two MAC

More information

Mobile dual solenoid driver

Mobile dual solenoid driver Electric Drives and Controls Hydraulics Linear Motion and ssembly Technologies Pneumatics Service Mobile dual solenoid driver R 864/0.0 Replaces: 06.8 /6 Model MDSD Component series X Table of contents

More information

RA / /6. Replaces: Table of contents RA /06.98

RA / /6. Replaces: Table of contents RA /06.98 Electronic amplifier for the control of proportional directional ales with electrical position feedback Models VT 5024 and VT 5025, Series 1X RA 29 958/06.98 Replaces: 11.97 The amplifiers VT 5024 and

More information

LA-5000 SERIES LINEAR VALVE ACTUATORS

LA-5000 SERIES LINEAR VALVE ACTUATORS LA-5000 SERIES LINEAR VALVE ACTUATORS GENERAL DESCRIPTION The LA-5000 Series are bi-directional, linear actuators internally geared to produce up to 6,500 lbs. (28,913 N) of thrust, and offer continuous

More information

Compact Hydraulic System for Energy Savings and High Precision. POWER Meister

Compact Hydraulic System for Energy Savings and High Precision. POWER Meister Compact Hydraulic System for Energy Savings and High Precision POWER Meister POWER Meister Compact Hydraulic System Superior Energy Savings High Precision AC servo motor controls rotational speed and direction

More information

/2 way motorised valves

/2 way motorised valves 8880 / way motorised valves >> ort size: G/... >> Low power consumption >> Wearresistant ceramic rotary action sliding plate >> Valve remains on last setting if power lost >> Will handle contaminated fluids

More information

Directional control valves, direct operated, with electrical position feedback and integrated electronics (OBE)

Directional control valves, direct operated, with electrical position feedback and integrated electronics (OBE) Directional control valves, direct operated, with electrical position feedback and integrated electronics (OBE) Type WRPEH RE 9 Edition: 8- Replaces: 7-5 Size 6 Component series 3X Maximum operating pressure

More information

Valve amplifier for proportional directional valves. Type VT-VRPA2. Features. Contents. RE Edition: Replaces: 07.05

Valve amplifier for proportional directional valves. Type VT-VRPA2. Features. Contents. RE Edition: Replaces: 07.05 Valve amplifier for proportional directional valves Type VT-VRPA RE 0119 Edition: 01-0 Replaces: 07.05 Component series 1X Analog, Euro-card format Suitable for controlling / proportional directional valves

More information

Omar E ROOD 1, Han-Sheng CHEN 2, Rodney L LARSON 3 And Richard F NOWAK 4 SUMMARY

Omar E ROOD 1, Han-Sheng CHEN 2, Rodney L LARSON 3 And Richard F NOWAK 4 SUMMARY DEVELOPMENT OF HIGH FLOW, HIGH PERFORMANCE HYDRAULIC SERVO VALVES AND CONTROL METHODOLOGIES IN SUPPORT OF FUTURE SUPER LARGE SCALE SHAKING TABLE FACILITIES Omar E ROOD 1, Han-Sheng CHEN 2, Rodney L LARSON

More information

High-response valve with integrated digital axis controller (IAC-R) and field bus interface

High-response valve with integrated digital axis controller (IAC-R) and field bus interface High-response valve with integrated digital axis controller (IAC-R) and field bus interface RE 99/09.0 Replaces: 06.05 / Type 4WRPNH.../4C... Type 4WRPNH.../4P... Size 6 and 0 Component series X Maximum

More information

TECHNICAL DATASHEET #TDAX CAN SAE J1939, Dual Output Valve Controller

TECHNICAL DATASHEET #TDAX CAN SAE J1939, Dual Output Valve Controller TECHNICAL DATASHEET #TDAX020200 CAN SAE J1939, Dual Output Valve Controller Features: Two independent, software controlled outputs selectable as: Proportional Current (up to 2.5A); Hotshot Digital; PWM

More information

Valve amplifier for proportional valves with electrical position feedback

Valve amplifier for proportional valves with electrical position feedback Valve amplifier for proportional valves with electrical position feedback Type VT-MRPA1-... RE 30221 Edition: 2015-02 Replaces: 2013-08 Component series 1X Analog, modular design Intended for controlling

More information

Generator Speed Controller Model GSC 1

Generator Speed Controller Model GSC 1 enerator Speed Controller odel SC 1 RA 29 977/09.95 Replaces: 4.92 Self contained controller for driving electrical power generators with a hydrostatic transmission 16 Bit microprocessor based controller

More information

R30D RVDTs DC-Operated Rotary Variable Differential Transformers

R30D RVDTs DC-Operated Rotary Variable Differential Transformers R30D RVDTs DC-Operated Rotary Variable Differential Transformers RVDTs incorporate a proprietary noncontact design that dramatically improves long term reliability when compared to other traditional rotary

More information

3300/20 Dual Thrust Position Monitor

3300/20 Dual Thrust Position Monitor 3300/ Dual hrust osition onitor DG K DG BY G B BUFF D D UC 3300/ DU HU I 25 vdc 24 25 I 16 I 5 5 / / D D I 0 12 0 I 5 5 C C 8 C C U U 4 25 0 25 B Description he 3300/ Dual hrust osition onitor provides

More information

ELECTRONIC REGULATOR FOR OPEN LOOP

ELECTRONIC REGULATOR FOR OPEN LOOP Characteristics SINGLE CHANNEL DUAL CHANNEL 12 VDC / 24 VDC ± 10% Feeding voltage (stabilized) 12 VDC / 24 VDC ± 10% 10 30 VDC Feeding voltage (max) 10 30 VDC 40 W Max power absorption 40 W 2.8 A Output

More information

Electronic amplifier for the control of proportional valves without position control Model VT 3024, Series 3X H/A 4149/94 VT X

Electronic amplifier for the control of proportional valves without position control Model VT 3024, Series 3X H/A 4149/94 VT X RA 29 934/0.98 Electronic amplifier for the control of proportional valves without position control Model T 3024, Series 3X RA 29 934/2.9 The amplifier T 3024-3X is suitable for the control of pilot operated

More information

Proportional pressure controller

Proportional pressure controller Proportional pressure controller Introduction I. Introducing : Proportional Pressure Controller Input signal I or E Output pressure The MAC Proportional Pressure Controller, (PPC) is an innovative product

More information

Paddle wheel flow controller for On/Off control

Paddle wheel flow controller for On/Off control addle wheel flow controller for On/Off control Type 8032 compact Type 8032 can be combined with... Type 8032 remote Indication, monitoring, transmitting and On/Off control in one device. rogrammable outputs

More information

Temposonics. E-Series Model ER. Magnetostrictive, Absolute, Non-contact Linear-Position Sensors. Analog and Start/Stop Outputs.

Temposonics. E-Series Model ER. Magnetostrictive, Absolute, Non-contact Linear-Position Sensors. Analog and Start/Stop Outputs. Temposonics Magnetostrictive, Absolute, Non-contact Linear-Position Sensors Analog and Start/Stop Outputs SENSORS Document Part Number: 550996 Revision E Data Sheet FEATURES Linear, Absolute Measurement

More information

Valve amplifier for proportional valves. Type VT-SSPA1-1 (5, 50, 100, 150) Features. Contents. RE Edition: Replaces:

Valve amplifier for proportional valves. Type VT-SSPA1-1 (5, 50, 100, 150) Features. Contents. RE Edition: Replaces: Valve amplifier for proportional valves Type VT-SSPA- (5, 50, 00, 50) RE 306 Edition: 05-03 Replaces: 04-07 Component series X Analog, connector design Suitable for controlling solenoid-actuated pressure

More information

Valve amplifier for proportional pressure valves

Valve amplifier for proportional pressure valves Valve amplifier for proportional pressure valves Type VT-MRMA1-1 RE 30214 Edition: 2017-03 Replaces: 04.13 Component series 1X Analog, modular design Suitable for controlling a direct current motor-operated

More information

VP60. 5/3 Way proportional directional control valves Nominal diameter 8 direct operated sliding valves with µp-driven position control

VP60. 5/3 Way proportional directional control valves Nominal diameter 8 direct operated sliding valves with µp-driven position control / Way proportional directional control valves Nominal diameter 8 direct operated sliding valves with µp-driven position control Adjusted, linear flow characteristic Zero-overlap-characteristic High flow

More information

Continental Hydraulics Installation Manual CEM-PA-A

Continental Hydraulics Installation Manual CEM-PA-A CEMPAA Description: This closed loop PID amplifier drives a single solenoid proportional pressure or flow control valve coil up to 2.6A. It is suitable to provide precise closed loop control in pressure,

More information

Digital Interface Card DEC005000

Digital Interface Card DEC005000 Engineering & Manufacturing Solutions Digital Interface Card DEC005000 APPLICATION: The DEC005000 conveniently interfaces industry standard signals 4-20mA, 0-5V or 0-10V with a proportional solenoid valve

More information

815-BR SERVO AMPLIFIER FOR BRUSH SERVOMOTORS

815-BR SERVO AMPLIFIER FOR BRUSH SERVOMOTORS 815-BR SERVO AMPLIFIER FOR BRUSH SERVOMOTORS USER GUIDE September 2004 Important Notice This document is subject to the following conditions and restrictions: This document contains proprietary information

More information

ValveExpert. Check / Adjust / Repair Servo- and Proportional Valves

ValveExpert. Check / Adjust / Repair Servo- and Proportional Valves ValveExpert Check / Adjust / Repair Servo- and Proportional Valves Automatic Test Stand Contents INTRODUCTION... 4 REVIEW OF SPECIFICATIONS... 5 APPLICATIONS... 5 CONTROL SIGNALS... 5 AMPLIFIER FOR PROPORTIONAL

More information

APPLICATION NOTES G GENERAL PURPOSE P I D SERVOAMPLIFIER

APPLICATION NOTES G GENERAL PURPOSE P I D SERVOAMPLIFIER C31015 Rev 2.2.2001 APPLICATION NOTES G122-202 GENERAL PURPOSE P I D SERVOAMPLIFIER INDEX INTRODUCTION Page 1. BROCHURE ( supplied separately ) 2 2. A TYPICAL CLOSED LOOP 4 COMPONENT SELECTION 3. CHECK-LIST

More information

Potentiometer Control EC20200

Potentiometer Control EC20200 Engineering & Manufacturing Solutions Potentiometer Control EC20200 APPLICATION: Proportionally control the speed of hydraulic motors and cylinders. ISO 9001:2008 WITH DESIGN Certificate #02.002.1 Features

More information

EPA-M*** POWER AMPLIFIER FOR OPEN LOOP PROPORTIONAL VALVES SERIES 20

EPA-M*** POWER AMPLIFIER FOR OPEN LOOP PROPORTIONAL VALVES SERIES 20 89 220/101 ED EPA-M*** POWER AMPLIFIER FOR OPEN LOOP PROPORTIONAL VALVES EPA-M1** single solenoid EPA-M2** double solenoid EPA-M3** 2 independent channels single solenoid valves RAIL MOUNTING TYPES: DIN

More information

Multi-function 11 pin Plug-in for use with 90 series sockets

Multi-function 11 pin Plug-in for use with 90 series sockets 88 eries - lug-in timers 5-8 A Features 88.02 88.12 Multi-voltage and multi-function timer range Front panel or socket mount 8-11 pin plug-in version available ime scales from 0.05s to 100h 1 delayed contact

More information

Single Ended Linear DC Servo Amplifier

Single Ended Linear DC Servo Amplifier Service Data Vickers Servo Valves Single Ended Linear DC Servo Amplifier EM-A-0 Revised 09/0/ I-0-S General This manual is written primarily to establish a logical troubleshooting procedure for the solid

More information

82880 series 2/2-way motorised valves

82880 series 2/2-way motorised valves > > ort size: G1/2... 1 > > Low power consumption > > Wear-resistant ceramic rotary action sliding plate > > Valve remains on last setting if power lost > > Will handle contaminated fluids Technical features

More information

Electrohydraulic Actuators PVEA/H/S

Electrohydraulic Actuators PVEA/H/S MAKING MODERN LIVING POSSIBLE Electrical Installation Electrohydraulic Actuators PVEA/H/S powersolutions.danfoss.com Revision history Table of revisions Date Changed Rev September 2015 Minor layout revision

More information

How to Order Manifold. Manifold mounting. DIN rail mounting style Direct mounting style

How to Order Manifold. Manifold mounting. DIN rail mounting style Direct mounting style Plug Lead Unit Series 000 [Option] How to Order Manifold S 0 FD D Electrical entry F kit D-sub connector kit P kit Kit type Flat ribbon cable connector kit J kit Flat ribbon cable (0P) (PC Wiring System

More information

P/N: AX TECHNICAL DATASHEET #TDAX Single Input, Dual Output Valve Controller 1 Universal Input, +5V reference CAN (SAE J1939)

P/N: AX TECHNICAL DATASHEET #TDAX Single Input, Dual Output Valve Controller 1 Universal Input, +5V reference CAN (SAE J1939) TECHNICAL DATASHEET #TDAX022000 Single Input, Dual Output Valve Controller 1 Universal Input, +5V reference (SAE J1939) Features: 1 universal signal input 2 proportional or on/off outputs up to 3 A User

More information

4/3 proportional directional valve with integrated digital electronics and field bus interface (IFB-P) Type 4WREF. Features.

4/3 proportional directional valve with integrated digital electronics and field bus interface (IFB-P) Type 4WREF. Features. 4/ proportional directional valve with integrated digital electronics and field bus interface (IFB-P) Type 4WREF RE 9048 Edition: 0-0 Replaces:. Sizes 6 and 0 Component series X Maximum operating pressure

More information

M-66. Operating Manual FISHER RESEARCH LABORATORY. Valve and Box Locator (Metal Detector)

M-66. Operating Manual FISHER RESEARCH LABORATORY. Valve and Box Locator (Metal Detector) M-66 Valve and Box Locator (Metal Detector) Operating Manual FISHER RESEARCH LABORATORY CONTENTS Description... pg. 3 Control Panel... pg. 4 Setting Up... pg. 5 Tuning... pg. 5 Searching... pg. 6 Specifications...

More information

Analogue amplifier. Features. Table of contents. RE 29980/09.05 Replaces: Type VT-SR2. Series 1X 1/6

Analogue amplifier. Features. Table of contents. RE 29980/09.05 Replaces: Type VT-SR2. Series 1X 1/6 Analogue amplifier RE 29980/09.05 Replaces: 02.03 1/6 Type VT-SR2 Series 1X H5658 Table of contents Contents Page eatures 1 Ordering code 2 unctional description 2 Technical data 3 Block circuit diagram

More information

Output Current Efficiency (1)

Output Current Efficiency (1) HD5 eries C-DC ower upplies 5 Watts xxx eries High fficiency up to 9% High ower Density rogrammable Output oltage (-5%) rogrammable Output Current (-5%) arallel Operation Fully Featured ignals & Controls

More information

MAXTUNE. DIGITAL SERVO CONTROL servo & stepper INTELLIGENT SERVO DRIVE

MAXTUNE. DIGITAL SERVO CONTROL servo & stepper INTELLIGENT SERVO DRIVE DIGITAL ERVO CONTROL servo & stepper MAXTUNE INTELLIGENT ERVO DRIVE 5 01 85 3 8 1 5 01 83 5 0 1 BA ystems introduces MaxTune, the next-generation high performance servo drive. MaxTune features hardware

More information

TECHNICAL DOCUMENT EPC SERVO AMPLIFIER MODULE Part Number L xx EPC. 100 Series (1xx) User Manual

TECHNICAL DOCUMENT EPC SERVO AMPLIFIER MODULE Part Number L xx EPC. 100 Series (1xx) User Manual ELECTRONIC 1 100 Series (1xx) User Manual ELECTRONIC 2 Table of Contents 1 Introduction... 4 2 Basic System Overview... 4 3 General Instructions... 5 3.1 Password Protection... 5 3.2 PC Interface Groupings...

More information

Position control unit

Position control unit Ver. HGE 3 EVOPK POE Ver. HGE 3 EVOPK POE Ver. HGE 3 EVOPK POE Ver. HGE 3 EVOPK POE J-F7 - MEHTOLIK-II Multi-axes position controller via high-speed MEHTOLIK-II Up to 6 axes controlled with minimum wiring.

More information

Microbridge Mass Airflow/Amplified

Microbridge Mass Airflow/Amplified Figure 1 Heater control circuit FEATURES Laser trimmed for improved sensor interchangeability Flow sensing up to 1.0 SLPM Low differential pressure sensing Like the AWM2000 Series, the dual Wheatstone

More information

PRECISION ELECTRONICALLY COMPENSATED CURRENT TRANSFORMER

PRECISION ELECTRONICALLY COMPENSATED CURRENT TRANSFORMER RECIIO ELECTROICALLY COMEATED CURRET TRAFORMER Common Mode Rejecter for Testing Meters with Interconnected Current and Voltage Circuits * Models CMR-I 2130 CMR-I 2230 CMR-I 2330 Version 3.2b * ATETED Content

More information

DCS-62 Series Spring Return Electronic Actuator Product Bulletin

DCS-62 Series Spring Return Electronic Actuator Product Bulletin Delta Control Products, Inc. 0 West Rose Garden Lane Phoenix, Z 807 6-780-08 DCS-6 Series Spring Return Electronic ctuator Product ulletin Description The Delta DCS-6 direct-coupled spring return electronic

More information

Sealed Interface Control: EC20300

Sealed Interface Control: EC20300 ISO 9001:2000 WITH DESIGN Certificate #02.002.1 Sealed Interface Control: EC20300 FEATURES: Weather tight control package Pulse Width Modulated output Waterproof altitude pressure and vapor release vent

More information

Analog Servo Drive 20A20

Analog Servo Drive 20A20 Description Power Range NOTE: This product has been replaced by the AxCent family of servo drives. Please visit our website at www.a-m-c.com or contact us for replacement model information and retrofit

More information

Digital amplifier for proportional valves PEM XD

Digital amplifier for proportional valves PEM XD Digital amplifier for proportional valves PEM XD FEATURES - Amplifier for cap rail mounting according to DIN EN 50022 - Control of 2 coils in open loop, or 2 proportional valves with 1 coil in open loop

More information

The T6000 Series Electro-Pneumatic Transducer converts a DC current or voltage input signal to a directly proportional pneumatic output.

The T6000 Series Electro-Pneumatic Transducer converts a DC current or voltage input signal to a directly proportional pneumatic output. GENERAL INFORMATION T6000 SERIES TRANSDUCER Electro-Pneumatic (I/P, E/P) APPLICATIONS The T6000 Series Electro-Pneumatic Transducer converts a DC current or voltage input signal to a directly proportional

More information

Vickers. Servo Valves. Servo Electronics. Amplifiers, Power Supplies, Function Modules, and Controllers. Rev. 11/97

Vickers. Servo Valves. Servo Electronics. Amplifiers, Power Supplies, Function Modules, and Controllers. Rev. 11/97 Vickers Servo Valves Servo Electronics Amplifiers, Power Supplies, Function Modules, and Controllers Rev. 11/97 656 Introduction Vickers amplifiers, power supplies, and function modules provide a convenient

More information

Ametek, Inc. Rotron Technical Products Division. 100 East Erie St., Suite 200 Kent, Ohio User's Guide. Number Revision F

Ametek, Inc. Rotron Technical Products Division. 100 East Erie St., Suite 200 Kent, Ohio User's Guide. Number Revision F Ametek, Inc. Rotron Technical Products Division 100 East Erie St., Suite 200 Kent, Ohio 44240 User's 120 Volt, 800 Watt and 240 Volt, 1200 Watt Brushless Motor Drive Electronics 5.7" (145 mm) and 7.2"

More information

Valve amplifier for proportional directional valves and proportional pressure valves. Type VT-VSPA2-1. Features. Contents

Valve amplifier for proportional directional valves and proportional pressure valves. Type VT-VSPA2-1. Features. Contents Valve amplifier for proportional directional valves and proportional pressure valves Type VT-VSPA2-1 RE 30110 Edition: 2013-04 Replaces: 05.12 Component series 2X Analog, euro-card format Suitable for

More information

1.8MN ServoSled. Hyge Upgrade with Flush Rail

1.8MN ServoSled. Hyge Upgrade with Flush Rail SERVOSLED SERVO-ACCELERATOR SLED SYSTEMS 1.8MN ServoSled Hyge Upgrade with Flush Rail Seattle Safety ServoSled System ServoSled servo-accelerator sled systems give full computer pulse control and high

More information

Power Supplies. SHP Series: Heavy Duty Modular Power Supplies

Power Supplies. SHP Series: Heavy Duty Modular Power Supplies Power upplies HP eries: Heavy Duty Modular Power upplies his new generation of high power, intelligent modular power supplies, range from 500 through 4920 watts and were designed for optimum flexibility.

More information