Danger of electrical shock, burns or death.

Transcription

1 anger of electrical shock, burns or death. lways remove all power sources before a emp ng any repair, service or diagnos c work. Power can be present from shore power, generator, inverter or ba ery. ll power sources must be disabled and secured before performing any service. If you lack the skills, tools or equipment to perform diagnos c or repair work leave such work to an authorized Winnebago Industries dealer or other qualified shop. opyright 0 Winnebago Industries, Inc.

2 VIEO 8 TE WG RELESE 900 ZONE ISION RE TE FTR-IG PNEL-SERVIE 8-0-HT G-0-0U () INPUT ONNETIONS PTLE STELLITE LE ISH OX GL PLTE-WLL,TELEPHONE/OX 9-0-HT G U () WIRE SM-OH HNNEL-WIRE PTH,TOP 0-0-HT () G U (8) WIRE SM-HSSIS TO SLIE RM SEE 8 PIN HOUSING TO WIRE SM- OMPRTMENT LMPS (IN FLO) OX RE VIEW FFZ GG XXZ YYF Switch attery Ground Load WTER PUMP ONTROL ETIL PIN HOUSING TO WIRE SM-MIN HOLING PIN HOUSING () ETIL E PIN HOUSING TO WIRE SM- OMPRTMENT LMPS W,WE TO OMPRTMENT LMP PIN HOUSING TO WIRE SM-UX HOLING TNK VIEO-R VIEO- UIO-L UIO-R VIEO-G PNEL-REEPTLE -0-HT G-0- () PNEL-REEPTLE -0-HT LEL-OX 8-0-HT PLTE-R 90-0-HT PTER NUT G-0- () G-0-08U () WIRE SM TV-EXTENSION TO PNEL-REEPTLE FROM WIRE SM OH YEL-OX TO PNEL-REEPTLE 00 ROP LE SM-MOULR FROM MONIT PNEL TO INVERTER 0 NW,WE TO OMPRTMENT LMP TELEPHONE WIRE TO PLTE-WLL,PHONE OX (RE) OX (GL) TO PLTE-WLL,PHONE GROMMET-FRONT FLO- IN PIN HOUSINGS () ETIL E PIN HOUSING TO WTER HETER PIN HOUSING TO FURNE PIN HOUSING TO WIRE SM-WTER TNK PIN HSG TO WTER PUMP MOULE-WTER PUMP ETIL ENTERTIN ENTR/EXT TV-V 0 INVERTER-/, 000 WTT OES/STNRS-S/MVSS WIRE SM-WTER TNK OES/STNRS US PIN HOUSING TO SLIE RM MOT (SEE 8) R OPYRIGHT 0 WINNEGO INUSTRIES, IN. FTR IG. TE WIRE PSSES THROUGH FLO T THIS POINT. HKR P.E. LL IMENSIONS RE IN MILLIMETERS. WITH RE TNK SENS WIRES SO THEY O T PSS OVER SENSS. USE WIRE TIE MOUNT N WIRE M.E. SNR UNSPEIFIE TOLERNES RE: WHOLE IM (X) MTERIL: FIRST USE JH TIE S NEEE. TNK SURFE MUST E LENE ONE-PLE (X.X). USING ISOPROPYL LOHOL N PRIME WITH PRIMER 9. TWO-PLE (X.XX) 0.0 NGLE. SEE WIRING IGRM-OY,V F ITIONL INFMTION. THIR NGLE PROJETION. LL WIRES TO E LMPE WITH LMP WIRE TIE EVERY OOMM UNLESS OTHERWISE SPEIFIE. F ELETRIL TQUE SPEIFITIONS F ELETRIL LLS O T SLE RWING REFER TO ES008 F FSTENER TIGHTENING GUIELINES WIRING INSTL-OY,V TES: OF8 PRT REF: /0/0

3 8 V IN IR V V L R V L R SERVIE VG VG UIO V IN Y Pb Pr S-VIEO V L R HE PHONE RF IN TV PIN HOUSING FROM WIRE SM-SIEWLL WG 900 V IN HMI IN H L RE- POWER (TV) -WY R LE TV GRN OX FROM WIRE SM- SLIE H L WIRE SM-OVH ETIL SLIE LOK ETIL J LE-OMPONENT/OMPOSITE FROM WIRE SM-SLIE LMP 98--HT () G-0-0J () ONNET () F REEPTLE-V STELLITE REEIVER ONNETION OX-G/G/G (FROM WIRE SM-ROOF) LIGHT-WRROE G-0-U () ETIL E HL- SWITH ETIL ET FROM FRONT STELLITE PREP PLTE* * ONNETION REQUIRE T FRONT STELLITE PREP PLTE. ETIL PLTE-WLL 9--HT G-0-08U SLIE LOK ETIL H SWITH G-0- () WIRE SM-EXTENSION -0-0 LMP SM-INETTE 9-8-HT G-0-0J () ONNET () F F REMOTE SENS 8-0-HT G-0-0T () PIN HOUSING TO WIRE SM-SOF H L LO- REMOTE SENS 8-0-HT G-0-0T () PIN HOUSING TO SLIE ROOF SPEKER GRILL 8-0-HT () OX TO STELLITE PREP PLTE & TV ETIL OX & R ONNETIONS ETIL L LOTION WITH SOF,, PIN HOUSINGS TO SIEWLL FROM WIRE SM-OH MM,MS TO SIEMRKER LMP WIRE SM-OH RE WITH WTER LINES & 0V WIRING ET,EU TO REFRIGERT L RESTESY UL TL ULTRLE LH ONUIT 9-0 TO OVER EXPOSE WIRES. MOUNT EVIE S LOSE TO WIRE ROP FROM INET S POSSILE. SWITH ETIL EL WIRE SM-SLIE H REST ESY, ULTRLETHER F INETTE, U-SHPE ULTRLETH INETTE - U-SHPE 0 INVERTER-/, 000 WTT ONNETS TO RER OF STELLITE PREP PLTE. SWITH ETIL ES OES/STNRS-S/MVSS. SEE WIRING INSTL-OY,V F ITIONL INFMTION. WIRE PSSES THROUGH FLO T THIS POINT. SEE WIRING IGRM-OY,V F ITIONL INFMTION. -WY R & OX TO TV ETIL FIRST USE OES/STNRS US JH. LL WIRES TO E LMPE WITH LMP WIRE TIE EVERY 00MM UNLESS OTHERWISE SPEIFIE. F ELETRIL TQUE SPEIFITIONS F ELETRIL LLS O T SLE RWING WIRING INSTL-OY,V TES: PRT /0/0

4 ! This switch must be on and park brake applied to operate any slide room. We recommend runnin the engine to insure adequate battery power. Slide room will not operate until slide room locks are retracted. 8 J,K FROM WIRE SM ROOF TO FRONT SPEKERS N T RE- LMP-INETTE 9--HT G-0-0J () ONNET () W WG 900 L,M FROM WIRE SM ROOF TO RER SPEKERS SPEKERS (SEE WIRING INSTL-TV/V SIE F ITIONL INFO) SWITHES ETIL EJ RIVER'S SIE FRONT WIRE SM-OVH N T MIS HOUSINGS TO WIRE SM-SIEWLL PSSENGER'S SIE RER RIO-SPEKER () G (8) WIRE SM-EXTENSION -0-0 W PIN HOUSING TO WIRE SM-SIEWLL SWITH ETIL EG LMP-MKEUP 9-0-HT ONNET () W UTO GEN STRT TIE MSTER SLIE ROOM ONTROL SWITH OFF ON RUSH HZR. Keep people and objects clear of the inside WRNING and the outside of the slideout room when operating. Failure to comply could result in death or serious injury. 9-0F T N LMP-WLL 98--HT G-0-0J () ONNET () SWITH ETIL EE SWITHES ETIL EN ONVERTER ETIL V W MONIT PNEL G-08-08U () PNEL-MONIT,PS G-08-08U () Pump Water Heater Heater Electric L.P. Tank Levels attery Meter GenSet Start Stop T N PIN HSG TO SOF V LIGHTING IRUITS TO WIRE SM-ROOF ENTERTINMENT ENTER EXTERI WIRE SM TV EXTENSION 0-0-XXX G-0-08U (9) MOUNTE TO SIEWLL ENTERE OVER OPENING 0 THERMOSTT 8-0-HT G-0- () RELY () REMOTE PNEL INVERTER MOULR-V ISONNET SWITHES EILING ISLE HLL ONNET LL GROUNS TO GROUN R OX & UIO ONNETIONS TO WIRE SM-ROOF ETIL V REKER PNEL PIN HOUSING TO WIRE SM-SIEWLL RE- ETIL E SWITHES ETIL ER MONIT VIEW ETIL NEGTIVE R 00-0-HT OLT -0- () NUT () STU-ISOLTE () NUT () G-0- () ETIL G SWITHES ETIL EF SWITH ETIL SWITH ETIL EP LS-,8 PIN HOUSINGS TO LO SHEER ONTROL WIRE SM-OVH RIO SPEKER () GRILLE 8-0-HT () G-08- (8) PIN HOUSING TO SIEWLL V GENERT-STRT, WITH SPLITTER-OX ETIL K ISOLTE STU ETIL W ENTERTIN ENTR/EXT TV-V GENERT-STRT,UTO SYSTEM MIN WIRE SM-OH TO WIRE SM-HSSIS ONNETION LOTE HERE LPG 0 INVERTER-/, 000 WTT STEREO SYSTEM/W//V RER ETIL SWITH ETIL EM W T N INETTE SOF/E RH SOF/E ULTRLETHER. SET 'GEN TYPE' TO MTH GENERT MOEL INSTLLE IN OH. SET 'SFE TYPE' TO 'IGNITION'. SEE OPERTS MNUL F SETUP PROEURE. ONNETS INLINE OF THE YELLOW VIEO LE. WRP OTH ENS OF FILTER ONNETIONS WITH TPE TO SEURE FILTER. WIRE PSSES THROUGH FLO T THIS POINT. SEE WIRING IGRM-OY,V F ITIONL INFMTION. SWITH ETIL EH LR- WIRE SM-OH RE WITH 0V WIRES (SEE WIRING INSTL-OY F ITIONL INFO) RIO-WLL MT, V//W LRM 9-0-HT () FILTER-VIEO ISE RIO SPEKERS JM HOME THETER SOUN SYSTEM OES/STNRS-S/MVSS OES/STNRS US FIRST USE JH. LL WIRES TO E LMPE WITH LMP WIRE TIE EVERY 00MM UNLESS OTHERWISE SPEIFIE. F ELETRIL TQUE SPEIFITIONS F ELETRIL LLS O T SLE RWING WIRING INSTL-OY,V TES: PRT /0/0

5 G-0-U () 8 W J J JE NM JG FROM SIEWLL FROM SIEWLL WG 900 G-0-0 () M LK W J ET JF J PRE-WIRE IN LTH SM SSP SLIE LOK MOT PRE-WIRE IN LTH SM S SLIE LOK MOT ONVERTER- MP G-0-U () PLTE 90-0-HT EE USS R () TO WIRE SM-OH TO WIRE SM-HSSIS J G () IRUIT REKER M 8 LK ETIL G (K VIEW) HOUSING V IRUIT REKERS (PUSH TO RESET) LMPS LMPS LMPS LMPS MONIT/ TV OMPT LMPS G-0-0 WSHER OEM0-0-0 IRUIT REKER (9) ETIL J (FRONT) RRS ETIL H (FRONT) RRS K FROM OH L FROM OH U FROM WIRE SM HSSIS ETIL M TO GROUN R STU-ISOLTE NUT G-0- () OOT IRUIT REKER () ONNET (9) PTER () LEL FRONT FURNE/ EXH FN SOF LMPS REFRIG ETIL G (FRONT VIEW) LMPS LP ETET G WIRE SM-ROOF G/G WIRE SM-ROOF G G/G WIRE SM-OH WIRE SM-OH LE- OMPONENT/ OMPOSITE (TV ) LE- OMPONENT/ OMPOSITE (TV ).0 LU LU PLTE REEPTLE-V WIRE SM-ROOF ETIL WIRE SM-OH WIRE SM- SLIE -WY R -WY R OH USS R HEX NUT-PLNUT (SUPPLIE WITH IRUIT REKER) PM KNURLE NUT (SUPPLIE WITH IRUIT REKER) ETIL F NM FROM TV OOSTER SPLITTER G-08- () LE SM-OX (GRN) IN LE SM-OX (GRN/GRN) LE SM-OX (UNMRKE) TO WIRE SM-OH TO MIN TV TO EXTERI TV GRN G/G/G PTER () GRN G/G/G ETIL - ETIL K LE SM-OX (UNMRKE) ETIL L ENTERTIN ENTR/EXT TV-V EXT FULL OY PINT PKG # G EXTERI GRPHIS PKGE # 9K EXTERI GRPHIS PKGE # JM-O 9 EXT FULL OY PINT PKG # EXT FULL OY PINT PKG # RE WIRES THRU HOLE EXT FULL OY PINT PKG # WRP OTH ENS WITH TPE TO SEURE ONNETION. F POSITIONING IMENSIONS SEE WIRING INSTL-OY,0V. MOUNT SWITH N SPER TO LOK ON JM JG JN PG GROMMET SWITH/MGNET- STEP, ELETRI G-0-08 () G 9K 9 OES/STNRS-S/MVSS OES/STNRS US FIRST USE JH JUST HEIGHT TO MTH MGNET. MOUNT MGNET USING PILOT HOLES IN SREEN O FRME. MOUNT WITH MGNET TOWR SWITH. ETIL E F ELETRIL TQUE SPEIFITIONS F ELETRIL LLS O T SLE RWING WIRING INSTL-OY,V TES: ETIL PRT /0/0

6 8 SWITH-WNING TUT 08--HT (IRUITS FFR,FFP,FFN) SWITH-UTO LEVEL TUT-SWITH 08--HT IRUITS SS,SSE, SS,SSE,SSF SWITH-OMPT LIGHTS TUT-SWITH 08--HT IRUITS W,W TOP 8 LEL-SLIE,RIVERS,FRT 99-0-HT SLIE-ELE,FRONT () RIVER'S SIE FRONT WG 900 WNING IN LEVEL UTO LEVEL STE ON OMPT LIGHTS OFF PLTE-SWITH 8-0-HT G-0-0U () TOP 8 ETIL EK ONNET TO -PIN HOUSING WITH IRUITS WJ,GGE,GGF,GG, R,U,WP,WN. LEL-SLIE,PSS,RER 99-0-HT SWITH TUT 08--HT (IRUITS PPM,PPN,PPS,PPT) SWITH-STEP IRUITS ER,ES SWITH TUT 08--HT (IRUITS MM,PPW,MM) PSSENGER'S SIE RER MONIT-SOLR HRGER SWITH-OH TT TUT-SWITH 08-9-HT IRUITS KF,LG, LJ,LJ,LH,KF,KF,LK ETIL E SWITH-HSSIS TT TUT-SWITH 08-0-HT IRUITS UU,TTY,UU, UU,TTZ,UU,UU,UU MKEUP JF P SWITH-ROKER 0-0-HT SWITH-SE -0-HT SWITH-EZEL -08-HT G-08-08U () EILING YK J YL SWITH-ROKER 0-0-HT SWITH-SE -0-HT SWITH-EZEL -0-HT G-08-08U () MSTER SLIE ROOM ONTROL SWITH PLTE-KEY, SLIE ROOM 98-0-HT () ETIL EE ETIL EL This switch must be on and park brake applied to operate any slide room. We recommend runnin the engine to insure adequate battery power. OFF ON LEL-SLIROOM ONTROL, MN HT TIE Slide room will not operate until slide room locks are retracted. SWITH-KEY,SPST-ILLIIS LK (ONNETS TO IRUITS Y & J)! WRNING RUSH HZR. Keep people and objects clear of the inside and the outside of the slideout room when operating. Failure SWITH-PUMP TUT 08-0-HT (J,JY,XXZ,YYF) SWITH-SERVIE LMP TUT 08-0-HT W,W SWITH-UTO LEVEL TUT-SWITH 08-0-HT SS,SSE,SS,SSF,SSE EILING JE YM WX YN HLL SWITH-ROKER 0-0-HT 0-0-HT SWITH-SE -0-HT SWITH-EZEL --HT G-08-08U () J KJ FN UP KH KG J JM KG KH OWN SWITH-ROKER 0-0-HT 0-0-HT SWITH-SE -0-HT SWITH-EZEL --HT G-08-08U () to comply could result in death or serious injury. 9-0F ETIL EJ LEL-WRNING, SLIE ETIL EF ETIL EN MONIT J JJV SWITH-ROKER 0-0-HT SWITH-SE -0-HT SWITH-EZEL -0-HT G-08-08U () JE L SWITH-ROKER 0-0-HT SWITH-SE -0-HT SWITH-EZEL -0-HT G-08-08U (). YM J YN ETIL E HLL F SWITH IENTTION SEE ETIL EK. ONNET WIRE SM-RESISTER FN TO -PIN HOUSING J PH ON WIRE SM LOTE Y SWITHES. SWITHES RE TO E INSTLLE S SHOWN ON THIS RWING. ISLE ETIL E EILING YK P YL SWITH-ROKER 0-0-HT 0-0-HT () SWITH-SE -0-HT SWITH-EZEL --HT G-08-08U () EILING JE PL W PJ PH ETIL EG WTER PUMP ETIL EH SWITH-ROKER 0-0-HT () SWITH-SE -0-HT SWITH-EZEL -9-HT G-08-08U () SWITH-PUMP TUT 08--HT G-0-0U () F ELETRIL TQUE SPEIFITIONS TES: EILING JF PE ETIL EM GS GR FN ETIL EP M SWITH-ROKER 0-0-HT SWITH-SE -0-HT SWITH-EZEL -0-HT G-08-08U () SWITH-ROKER 0-0-HT SWITH-SE -0-HT SWITH-EZEL --HT G-0-U () ETIL ER GGX J FFY FN ETIL ES SWITH-ROKER 0-0-HT SWITH-SE -0-HT SWITH-EZEL --HT G-08-08U () WIRE SM-RESIST Y F ELETRIL LLS Y M N FIRST USE ETIL ET FN - EILING_EROOM VENT-POWER VENTILT WNING - PTIO, ELETRI OES/STNRS-S/MVSS OES/STNRS US JH O T SLE RWING WIRING INSTL-OY,V PRT /0/0

7 G GN V R W 8 WG 900 LOSN LSH- LIGHT-HLOGEN SUPPLIE WITH LIGHT HL- STELLITE ELEVTION SENS ETIL G FN-EILING 9-0-HT G-0- () ONNET () ETIL H Y SPEKER-ROUN,EILING 08-0-HT () G08--0 (8) LO- 8 WSHER-PLSTI 80-0-HT () G-08-08U (0) Y FN - EILING_EROOM OES/STNRS-S/MVSS OES/STNRS US ENTER FN OVER MM HOLE IN ROOF. TES: PPLY LOTITE P/N TO FN LE MOUNTING NUT THRES. LMP LOTE IN SERVIE OMPRTMENT. LMP LOTE IN POWER OMPRTMENT. F ELETRIL TQUE SPEIFITIONS F ELETRIL LLS FIRST USE JH O T SLE RWING WIRING INSTL-OY,V 8 PRT 900 /0/0

8 8 WG 900 THE STELLITE ISH WIRE ONNETIONS RE TO E PLE ON THE ENTERLINE OF THE MOTHOME FING FWR 0 9Q SOLR 8P I- 00 ETIL GE 98 GE GE 8K ETIL GE - PLTE G-0- (0) 8Q M- ONNET LE SM STELLITE ONTROL FROM ROOF SM TO STELLITE ISH HERE ETIL G HOLE IN ROOF ONNET 9" LE SM OX (RER TV G/G) FROM ROOF SM TO UX INPUT ON STELLITE ISH ETIL GE ONNET 8' LE SM OX (FRONT TV G) FROM ROOF SM TO MIN INPUT ON STELLITE ISH VIEW GF-GF GLLEY VENT ETIL G VIEW G SIEWLL NT- GR G GS WIRE SM-ROOF G J NT- LK NT- KG RE JM WHT TH VENT ETIL GG KH LU ETIL G M WIRE SM-ROOF KJ 8P ST TV SYSTEM IN-MOTION LK M VENT-POWER VENTILT JM WHT STEREO SYSTEM/W//V RER ETIL GG 8K 8Q STELLITE ISH-UTOMTI STELLITE ISH & ELEV.SENS 9Q SOLR PNEL-0 WTT ENTERTIN ENTR/EXT TV-V OES/STNRS-S/MVSS OES/STNRS US SENS SUPPLIE WITH STELLITE SSEMLY. REMOVE LL SHIPPING RESTRINTS N FIRMLY INSERT THE SUPPLIE PLUGS INTO THE PPROPRITE SIZE HOLES FIRST USE JH S SPEIFIE IN THE INSTLLTION PROESS. SEE NTENN INSTLLTION MNUL F RET INSTLLTION PROEURE. TES: PIN HOUSING FROM WIRE SM- ELEVTION SENS ETIL G 8Q PIN HOUSING FROM WIRE SM-ROOF F ELETRIL TQUE SPEIFITIONS F ELETRIL LLS O T SLE RWING WIRING INSTL-OY,V PRT /0/0

9 8 FRONT LEFT SLIE MOULE ONTROL-IGISYN,HIGH SPEE WG 900 RIGHT RER SLIE RELYS () G9-08- () SWITH-FN, ERSING WIRE SM-ROOF RE-FFY LK-KKZ WNING ONTROL RELY G9-08- ONNET MOT LU TO SWITH LU N MOT LK TO SWITH LK FROM WIRE SM-HSSIS PIN HSG IRUITS GGH,GGG,GGJ GGL,GGK,GGM ETIL H FROM WIRE SM-OH 0 PIN HSG IRUITS U,GG,GGE,GGF,R, VVP,J,VVN,VVR FROM WIRE SM- SLIE POWER PIN HSG IRUITS LLK,LLL,LLN,LLM SETION H-H WIRE SM-SLIE RM PIN HSG IRUITS LLS,LLT,LLW,LLU H RER RM RM PIN HSG TO SLIE RM MOT FROM WIRE SM-SLIE RM IRUITS LLV,LLX H WIRE SM-HSSIS WIRE SM-HSSIS FRONT LEFT RER RM PIN HSG TO SLIE RM MOT FROM WIRE SM-SLIE RM IRUITS LLU,LLW PIN HSG TO SLIE RM EER FROM WIRE SM-HSSIS IRUITS GGK,GGM,GGL OES/STNRS-S/MVSS SEE WIRING INSTL-HSSIS F ITIONL INFMTION. OES/STNRS US SEE HSSIS ELETRIL OX SM F ITIONL INFMTION.. SEE WIRING IGRM-OY,V F ITIONL INFMTION.. LL WIRES TO E LMPE WITH LMP WIRE TIE EVERY 00MM, UNLESS OTHERWISE SPEIFIE. FRONT LEFT FRONT RM PIN HSG TO SLIE RM MOT FROM WIRE SM-SLIE RM IRUITS LLS,LLT PIN HSG TO SLIE RM EER FROM WIRE SM-HSSIS IRUITS GGG,GGJ,GGH F ELETRIL TQUE SPEIFITIONS F ELETRIL LLS FIRST USE JH O T SLE RWING WIRING INSTL-OY,V TES: 8 PRT /0/0