Electronic Air / Fuel Ratio Control System

Size: px
Start display at page:

Download "Electronic Air / Fuel Ratio Control System"

Transcription

1 7 871 ISO 9001 Electronic Air / Fuel Ratio Control System RVW20... Electronic control unit - for use with modulating single- and dual-fuel burners - with extended functionality for mechanical air / fuel ratio control The RVW20... and this Data Sheet are intended for use by OEs which integrate the control system in their products! Use -dependent control of the burner s air damper the fuel valves an additional actuator Suited for use in connection with O2 trim control RPO25... Optimum and efficient burner operation HVAC Products

2 Warning notes To avoid injury to persons, damage to property or the environment, the following warning notes should be observed! Do not open, interfere with or modify the unit! Before performing any wiring changes in the connection area of the RVW20, completely isolate the unit from the mains supply (all-polar disconnection) Ensure protection against electric shock hazard by providing adequate protection for the terminals Check wiring and all safety functions To warrant protection against electric shock hazard, ensure that AC 230 V mains voltage is strictly separated from extra low voltage Engineering notes For additional information, especially on commissioning, refer to Basic Documentation P The following types of burner controls can be used in connection with the RVW20...: LAL..., LFL..., LEC..., LGK16... and LOK16... ounting notes Ensure that the relevant national safety regulations are complied with After commissioning, check the flue gas values The RVW20... is designed for flush panel mounting with housing ARG wall mounting with housing ARG61.040: fitting the screw terminal base to the subassembly terminal 32 at the top terminal 2 at the bottom wiring to be made according to the plant connection diagram Installation notes Installation work must be carried out by qualified staff Prior to startup, check wiring and parameter settings carefully Commissioning notes Commissioning and maintenance work must be carried out by qualified staff After commissioning, check the flue gas values Disposal notes The unit contains electrical and electronic components and may not be disposed of together with household garbage. Local and currently valid legislation must be observed. 2/10

3 echanical design RVW20... Insert of plug-in design with European standard printed circuit boards 2 x 32-pin DIN connectors exchangeable relay board for controlling the actuators Supplied without housing Located on the front of the unit are: - LED 1 for fuel 1 - LED 2 for fuel 2-7-segment display (3 digits) for operating phases, burner output and fault indication Housing ARG61.0X0 ade of impact-proof plastic With a transparent cover To be ordered as a separate item (refer to «Ordering») Ordering Air / fuel ratio control unit - With data storage module RZD20 plugged in RVW20.000E27 Air / fuel ratio control unit RVW20.001E27 - For fuel changeover in operation and correcting variable authority of 50 % - With data storage module RZD20 plugged in Housings - For flush panel mounting, complete with ARG connection terminals and cover - For wall mounting, complete with ARG connection terminals and cover Accessories Handheld terminal - Complete with cable KF8859 (2 m) - For setting the parameters - For fault detection - For troubleshooting Separate cable for handheld terminal (20 m) AZW20.20 KF8860 Data storage module (2 pieces in one package (backup data carrier)) RZD20 Relay board Exchangeable - Plug-in design Conductive plastic potentiometers for actuators refer to Data Sheet /10

4 Technical data ains voltage AC 230 V ±15 % ains frequency 50 Hz ±6 % Power consumption 25 VA Plug-in system design D to DIN Dimensions of RVW20... board 100 x 160 mm Connection terminals for 2 x 1.5 mm ² or 1 x 2.5 mm ² ounting position optional Safety class II to IEC Degree of protection of housing - Front - Base Weight - With housing - Without housing IP 42 to IEC 529 IP 10 to IEC 529 approx. 1.4 kg approx kg Switching capacity of terminals L-Q1 - Current Switching capacity of terminals Q4-Q5 / H - Current at AC 230 V - Current at AC 24 V Extra low voltage inputs Hum voltage Terminals B1...B4 - Impedance Conductive plastic potentiometers - Resistance - Angular rotation - Refer to Data Sheet 7921 ing signal X3 - Internal resistance Switching capacity of control outputs Y1...Y6 - Current - Number of switching cycles at AC 230 V ±15 % A AC V A A max. AC 50 mv (50 Hz) 100 kω 1 kω Ω Terminals +5 V - Amperage 1 ma Extra low voltage outputs terminal U10 - Current (all terminals) Terminals X2, U1 - Impedance AC 230 V ±15 % max ma eff. cos ϕ = 0.6: 13 x 10 6 cos ϕ = 0.8: 18.8 x 10 6 cos ϕ = 1: 20 x 10 6 DC 10 V max. 50 ma 25 kω 4/10

5 Control outputs Q2, Q3, Y10, Y20, F1, F2 on off - Current on signal X1 - Internal resistance AC V < AC 50 V < 1 ma 100 Ω Environmental conditions Transport Climatic conditions echanical conditions Temperature range Humidity Operation Climatic conditions echanical conditions Temperature range Humidity IEC class 2K2 class C < 95 % r.h. IEC class 3K5 class C < 95 % r.h. Condensation, formation of ice and ingress of water are not permitted! CE conformity According to the directives of the European Union Electromagnetic compatibility EC 89 / 336 EEC incl. 92 / 31 EEC Directive for gas appliances 90 / 396 EEC (level to EN 298) 5/10

6 Function General Parameter settings Supervision and display Startup Controlled operation Shutdown Correcting signal Compensation of hysteresis The RVW20... controls the actuators depending on the positioning signals delivered by the load controller according to curves whose parameters can be set for each type of fuel synchronously With the help of the handheld terminal AZW20.20 (to be ordered as a separate item) Setting the parameters of the setpoint curves Setting other plant parameters 3 channels For 2, 3 or 4 actuators Each with 2 setpoint curves, with a maximum of 17 breakpoints Can be parameterized and stored in nonvolatile memory: Ignition position -specific operating positions Other parameters Using the data storage module RZD20, the values can be transferred to other RVW20... If inadmissible operating states or system faults occur, the burner will be shut down During startup and shutdown, the RVW20... shows operating phases on the display (during operation, the burner s output is displayed as a percentage) Faults are indicated by a flashing 2-digit code Burner startup is controlled by the burner control The RVW20... identifies the startup sequence during the startup phase, based on valve and fan control; the actuators are controlled accordingly checks the correct functioning of the connected components during the startup sequence runs to the parameterized ignition position to enable startup runs to the parameterized low-fire position after ignition After reaching the operating position, the burner control will enable the load controller The load controller controls the burner s output via the RVW20... The positions of the actuators will be reached based on the required burner output based on the selected type of fuel with the help of the parameterized setpoint curves The RVW20... drives the actuators to the calculated target positions The RVW20... drives the actuators to their start positions after burner shutdown on completion of the postpurge time, if scheduled Changes to the combustion parameters (e.g. density of air or quality of fuel) can be offset by connecting O2 trim control RPO25... to the input for the correcting signal the authority of the correcting variable can be parameterized The RVW20... offsets mechanical play between actuator and controlling element The authority of compensation of the hysteresis can be parameterized 6/10

7 Basic diagram RVW20 AIR1 Y1 X2 X2' ' AIR2 Y2 P AIR B1 FUEL1 B2 FUEL1 X1 FUEL2 Y3 Y4 P P B3 Fuel 1 FUEL2 U1 AUX1 FS Fuel 2 LR Y10 Y20 Integrator AUX2 Y5 Y6 P AUX B4 Programming Fuel select F1 F2 Q3 Q2 Control Q1 Q4 Q5 H 7871a06/0801 AZW20.20 FS FA Legend AIR Setpoint curves of the air damper actuators FUEL Setpoint curves of the fuel actuator AUX Setpoint curves of the auxiliary actuators H... Terminal markings (refer to «Connection diagram») B... Terminal markings (refer to «Connection diagram») LR controller F... Terminal markings (refer to «Connection diagram») Fan motor FA Burner control P Potentiometer FS Fuel selector Q...Y Terminal markings (refer to «Connection diagram») 7/10

8 Sequence diagram Phase R BETRIEB lim1 lim5 t4 SERVICE lim8 STOP STOP OPERATION Q3 G Q2 Y10 1) 5) 7) R Y20 1) 5) 5) 7) R Q1 Quit Q4-Q5 Ready Y1,Y3,Y5 Y2,Y4,Y6 SA SA X1 ( V) 2) 4) 5) Burner 3) 2) Output A ax IgnPos 6) SA1 (AIR) in IgnitLo Z SA4 (AUX) A ax in IgnitLo 6) SA2 (FUEL1) SA3 (FUEL2) Z 7871d02/0801 Legend Signal must be present or output is under voltage 1) Signals at«y10» or «Y20» only act on output «X1» Signal may not be present or output is dead 2) Output «X1» gives the current air damper position 3) Output «X1» gives the current burner output Signal can be present 4) Output «X1» changes according to signals «Y10» Controlled output and «Y20» Prerequisite for changing to the next phase 5) Signals at «Y10» or «Y20» have no impact Phase Parameter setting phase 6) If ignition load «IgnitLo» is set to a level above the minimum burner output, the ignition load will be AIR Setpoint curves of the air damper actuators approached in phase 7 AUX Setpoint curves of the auxiliary actuators 7) Optionally «Y10 / Y20» or analog signal at «U1» for AZW... Handheld terminal controlled operation FA Burner control FS Fuel selector lim... Duration of phase is limited. If the sequence does not FUEL Setpoint curves of the fuel actuator change by the time the set period has elapsed, the unit will LR controller initiate lockout Fan motor lim1 = 30 s P Potentiometer lim5 = 75 s Q...Y Terminal markings (refer to «Connection diagram») lim8 = 30 s SA Actuators t4 Interval 8/10

9 Connection terminals ains voltage side Extra low voltage side Q5 Q4 +5 V H Y6 Q3 Y5 Y10 Y20 N Q2 Q1 Y4 Y3 F1 Y2 F2 Y1 N N L L X1 U1 U10 B4 U10 B2 X2 U10 B3 U10 B1 7871a03/0901 Legend Terminal Input / Voltage Description output B1 I Feedback signal air damper actuator B2 I Potentiometer (wiper) fuel actuator (Fuel 1) B3 I Potentiometer (wiper) second fuel actuator (Fuel 2) B4 I Potentiometer (wiper) auxiliary actuator (AUX) F1 I AC 230 V Selection of fuel: fuel 1 F2 I AC 230 V Selection of fuel: fuel 2 L I AC 230 V Live for internal power supply, actuator outputs and «Q1» Reference potential for all low voltage inputs / outputs and for screening (all -terminals are internally interconnected) N I --- Neutral conductor for internal power supply, reference potential for the mains voltage inputs (all N-terminals are internally interconnected) Q1 O AC 230 V Acknowledge signal: indicates when certain actuator positions are reached Q2 I AC 230 V Signal from the burner control: first fuel valve on / off Q3 I AC 230 V Signal from the burner control: fan on / off Q4-Q5 / H O Potentialfree Readiness contact or nonreadiness / control loop: indicates when the RVW20... is ready to operate U1 I Signal input for analog burner output control U10 O DC 10 V Power supply for the potentiometers (all «U10» terminals are internally interconnected) X1 O Burner load signal X2 I Correcting signal of O2 trim control RPO25... Y1 O AC 230 V ing signal (open) (3-position control of actuators) Y2 O AC 230 V ing signal (closed) (3-position control of actuators) Y3 O AC 230 V ing signal (open) (3-position control of actuators) Y4 O AC 230 V ing signal (closed) (3-position control of actuators) Y5 O AC 230 V ing signal (open) (3-position control of actuators) Y6 O AC 230 V ing signal (closed) (3-position control of actuators) Y10 I AC 230 V Signal for increasing the burner s output (from the 3-position controller) Y20 I AC 230 V Signal for decreasing the burner s output (from the 3-position controller) +5 V O DC 5 V Auxiliary voltage, max. 1 ma 9/10

10 Dimensions Dimensions in mm Housing ARG for wall mounting Housing ARG for flush panel mounting 7871m03/ / AG Subject to change

Universal Controller

Universal Controller 7 863 Universal Controller POLYGYR RWF32... ISO 9001 RWF32... with casing ARG61.01 The RWF32... is a universal digital boiler temperature / pressure controller designed for use in oil- and / or gas-fired

More information

ASZ... Potentiometers. Siemens Building Technologies HVAC Products. ASZxx.7xx or ASZxx.8xx

ASZ... Potentiometers. Siemens Building Technologies HVAC Products. ASZxx.7xx or ASZxx.8xx 7 921 ISO 9001 ASZxx.7xx or ASZxx.8xx ASZxx.3x Single potentiometer Double potentiometer Single or double potentiometer Potentiometers ASZ... For integration into actuators type SQM... and SQN... to indicate

More information

ASZ... Potentiometers. Building Technologies HVAC Products. ASZxx.3x

ASZ... Potentiometers. Building Technologies HVAC Products. ASZxx.3x 7 921 ASZxx.7xx / ASZxx.8xx ASZxx.7xx / ASZxx.8xx ASZxx.9xx Potentiometers ASZ... For integration into SQM... and SQN... actuators to indicate the position of the actuator s drive shaft. Single and double

More information

SQN7... Actuators. Building Technologies HVAC Products

SQN7... Actuators. Building Technologies HVAC Products 7 84 ctuators SQN7... / SQN7... SQN74... / SQN75... SQN7... eversible electromotoric actuators for air dampers and valves of oil or gas burners of small to medium capacity. The SQN7... and this Data Sheet

More information

Actuators SQN7... Siemens Building Technologies HVAC Products. for air dampers and control valves of oil or gas burners

Actuators SQN7... Siemens Building Technologies HVAC Products. for air dampers and control valves of oil or gas burners 7 804 SO 900 Actuators SQN70... / SQN7... for air dampers and control valves of oil or gas burners SQN74... / SQN75... SQN7... eversible electromotoric actuators with torques up to 2.5 Nm un times: - SQN70...

More information

Room Temperature Controllers. for heating and cooling systems

Room Temperature Controllers. for heating and cooling systems 3 041 RCU10 RCU101 Room Temperature Controllers for heating and cooling systems RCU10 Choice of two-position or modulating PI control ON / OFF or PWM outputs for heating and cooling Operating modes: normal

More information

Technical data. Safety notes. T3-LR24A-SR en v Subject to changes 1 / 2

Technical data. Safety notes.  T3-LR24A-SR en v Subject to changes 1 / 2 echnical data sheet LR4A-SR Modulating rotary actuator for and -way control ball valves orque Nm Nominal voltage AC/DC 4 V Control: Modulating DC... V Position feedback: DC... V echnical data Safety notes

More information

Room Temperature Controllers. for heating and cooling systems

Room Temperature Controllers. for heating and cooling systems 3 048 RCU15 Room Temperature Controllers for heating and cooling systems RCU15 Choice of two-position or modulating PI control ON / OFF or PWM outputs for heating and cooling Control depending on room-

More information

Room Temperature Controllers. for heating and cooling systems

Room Temperature Controllers. for heating and cooling systems 3 041 RCU10 RCU10.1 Room Temperature Controllers for heating and cooling systems RCU10... Choice of two-position or modulating PI control ON / OFF or PWM outputs for heating and cooling Operating modes:

More information

Servomotor for butterfly valves VF, VFH. delta-elektrogas.com EE157-01/16

Servomotor for butterfly valves VF, VFH. delta-elektrogas.com EE157-01/16 MZ Servomotor for butterfly valves VF, VFH delta-elektrogas.com EE157-01/16 MZ Servomotor Contents Description.... 2 Features........ 2 Functioning and application..... 3 Technical specifications......

More information

Air damper actuators. OpenAir GDB..1E. Electronic motor driven actuators for open-close, three-position and modulating control

Air damper actuators. OpenAir GDB..1E. Electronic motor driven actuators for open-close, three-position and modulating control s OpenAir Air damper actuators GDB..1E Electronic motor driven actuators for open-close, three-position and modulating control Nominal torque 5 Nm Operating voltage AC 24 V ~ / DC 24 48 V or AC 100 240

More information

Electrical data Nominal voltage AC 24 V, 50/60 Hz DC 24 V. Power consumption In operation At rest For wire sizing

Electrical data Nominal voltage AC 24 V, 50/60 Hz DC 24 V. Power consumption In operation At rest For wire sizing echnical data sheet Rotary actuator LR4A Rotary actuator for and -way (control) ball valves orque 5 Nm Nominal voltage AC/DC 4 V Control: Open/close or -point echnical data Electrical data Nominal voltage

More information

Room Temperature Controllers. for heating and cooling systems

Room Temperature Controllers. for heating and cooling systems 3 048 RCU15 Room Temperature Controllers for heating and cooling systems RCU15 Choice of two-position or modulating PI control ON / OFF or PWM outputs for heating and cooling Control depending on room-

More information

Air damper actuators Rotary version with spring return, AC 24 V / DC V / AC 230 V

Air damper actuators Rotary version with spring return, AC 24 V / DC V / AC 230 V 4 614 OpenAir T Air damper actuators Rotary version with spring return, / DC 24 48 V / AC 230 V GA..1 Electronic motor driven actuators for two-position, three-position, and modulating control, nominal

More information

FA-3300 Heavy Duty Electric Actuator. Features and Benefits. FA-3300 Actuator with VG8000 valve. Constant running time. Fixed close-off force.

FA-3300 Heavy Duty Electric Actuator. Features and Benefits. FA-3300 Actuator with VG8000 valve. Constant running time. Fixed close-off force. European Electronic Controls Catalogue Section E Product Bulletin FA-3300 Issue Date 0998 FA-3300 Heavy Duty Electric Actuator I ntroduction The FA-3300 series synchronous motor-driven, reversible, heavy

More information

GLB...9. Ball Valve actuators. Building Technologies HVAC Products. for valves VAI61... AC 24 V / AC 230 V

GLB...9. Ball Valve actuators. Building Technologies HVAC Products. for valves VAI61... AC 24 V / AC 230 V 4 657 Ball Valve actuators GLB...9 for valves VAI61... / Electronic motor driven actuators for three-position and modulating control, pre-wired with 0.9 m long connection cables. Remarks This data sheet

More information

Room Temperature Controllers. for heating and cooling systems

Room Temperature Controllers. for heating and cooling systems 3 041 RCU10 RCU10.1 Room Temperature Controllers for heating and cooling systems RCU10... Choice of two-position or modulating PI control ON / OFF or PWM outputs for heating and cooling Operating modes:

More information

Configured air damper actuators 6FU11xx-xDxxx-xxxx

Configured air damper actuators 6FU11xx-xDxxx-xxxx s OpenAir Configured air damper actuators 6FU11xx-xDxxx-xxxx Electronic motor driven actuators for open-close, three-position and modulating control Nominal torque 5 Nm Operating voltage AC 24 V ~ / DC

More information

RS /M MZ SERIES

RS /M MZ SERIES The RS 310-410-510-610/M MZ burners series covers a firing range from 1300 to 6300 kw, and it has been designed for use in low or medium temperature hot water boilers, hot air or steam boilers, diathermic

More information

EY-EM 527: Remote I/O module, ecolink527

EY-EM 527: Remote I/O module, ecolink527 Product data sheet 94.078 EY-EM 527: Remote I/O module, ecolink527 How energy efficiency is improved Regulation, control, monitoring and optimisation of operational systems, e.g. room automation or HVAC

More information

Operating Instruction

Operating Instruction Level and Pressure Operating Instruction VEGASEL 643 6 5 + + 3 5 + + max. min. on VEGASEL 643 5 6 7 8 9 10 11 12 13 14 in out Contents Contents Safety information... 2 1 Product description 1.1 Function

More information

Functional data Factory settings Variable Settings

Functional data Factory settings Variable Settings echnical data sheet Rotary actuator RF-MF(-O) Multifunctional rotary actuator with emergency control for and 3 way control ball valve orque Nm Nominal voltage AC/DC V Control: Modulating DC... V or variable

More information

Manual triggering of the adaption by pressing the «Adaption» button or with the PC-Tool

Manual triggering of the adaption by pressing the «Adaption» button or with the PC-Tool echnical data sheet LMA-MF-P Multifunctional damper actuator for operating air control dampers in ventilation and air-conditioning systems for building services installations For air dampers up to approx.

More information

Power consumption In operation At rest For wire sizing. 1.5 W at nominal torque 0.4 W 4 VA Connection Cable 1 m, 3 x 0.75 mm 2

Power consumption In operation At rest For wire sizing. 1.5 W at nominal torque 0.4 W 4 VA Connection Cable 1 m, 3 x 0.75 mm 2 echnical data sheet Rotary actuator LRA Rotary actuator for and -way (control) ball valves orque 5 Nm Nominal voltage AC... 4 V Control: Open/close or -point echnical data Electrical data Nominal voltage

More information

QFM21... Duct sensors. Symaro. for relative humidity and temperature

QFM21... Duct sensors. Symaro. for relative humidity and temperature 1 864 1864P01 Symaro Duct sensors for relative humidity and temperature QFM21... Operating voltage AC 24 V / DC 13.5...35 V Signal output DC 0...10 V / 4 20 ma for relative humidity Signal output DC 0...10

More information

Power consumption Operation At rest Wire sizing

Power consumption Operation At rest Wire sizing echnical data sheet NM24P-SR Modulating Robustline damper actuator for operating air dampers in industrial plants and in the technical building installations For air dampers up to approx..6 m 2 orque 8

More information

Electromotoric actuators

Electromotoric actuators s 4 540 ACVATIX Electromotoric actuators for Combi valves VPI45.., DN40/50 SQD65 operating voltage AC 230 V, 3-position control signal operating voltage AC 24 V, 3-position control signal SQD65 operating

More information

XR1 Rotor Earth Fault Relay. (May 2007) Manual XR1 (Revision New)

XR1 Rotor Earth Fault Relay. (May 2007) Manual XR1 (Revision New) XR1 Rotor Earth Fault Relay (May 2007) Manual XR1 (Revision New) Woodward Manual XR1 GB Woodward Governor Company reserves the right to update any portion of this publication at any time. Information provided

More information

SAX..P. Electromotoric actuators for valves ACVATIX. with a 20 mm stroke

SAX..P. Electromotoric actuators for valves ACVATIX. with a 20 mm stroke s 4 509 ACVATIX Electromotoric actuators for valves SAX..P with a 20 mm stroke SAX31P.. Operating voltage AC 230 V, 3-position control signal SAX61P.. Operating voltage AC/DC 24 V, control signal DC 0

More information

Overcurrent Protection / 7SJ45

Overcurrent Protection / 7SJ45 Overcurrent Protection / SJ SIPROTEC easy SJ numerical overcurrent protection relay powered by CTs Fig. / Description SIPROTEC easy SJ numerical overcurrent protection relay powered by current transformers

More information

XUA1 - AC Voltage and phase balance relay

XUA1 - AC Voltage and phase balance relay XUA1 - AC Voltage and phase balance relay Contents 1. Applications and features 2. Design 3. Function 3.1 Voltage supervision 3.2 Unbalanced voltage supervision 4. Operation and settings 4.1 Setting of

More information

Room Sensors. for relative humidity and temperature

Room Sensors. for relative humidity and temperature 1 857 1857P01 Room Sensors for relative humidity and temperature QFA20 Operating voltage AC 24 V or DC 13535 V Signal output DC 010 V for relative humidity Signal output DC 010 V or LG-Ni 1000 or T1 for

More information

Room Sensors. In ventilating and air conditioning plants to acquire relative humidity and temperature in rooms. Humidity measuring range

Room Sensors. In ventilating and air conditioning plants to acquire relative humidity and temperature in rooms. Humidity measuring range 1 857 1857P01 Room Sensors for relative humidity and temperature QFA20 Use Operating voltage AC 24 V or DC 13535 V Signal output DC 010 V for relative humidity Signal output DC 010 V or LG-Ni 1000 or T1

More information

Analog amplifier RA. RE Edition: Replaces:

Analog amplifier RA. RE Edition: Replaces: Analog amplifier RA RE 950 Edition: 08.05 Replaces: 0.006 For control of simple functions of electrohydraulic components Two power outputs (PWM) and one switching output Each output has a separately adjustable

More information

Analog Amplifier RA. RE / /12 replaces: RE RE RE RE Technical Data Sheet

Analog Amplifier RA. RE / /12 replaces: RE RE RE RE Technical Data Sheet Electric Drives and Controls Hydraulics Linear Motion and Assembly Technologies Pneumatics Service Analog Amplifier RA RE 95 230/03.06 1/12 replaces: RE 95 022 RE 95 023 RE 29 874 RE 29 875 Technical Data

More information

KS 40-1 burner Universal Burner Controller

KS 40-1 burner Universal Burner Controller Universal Burner Controller BluePort interface and BlueControl software aintenance anager and error list odulating, two or three stage regulation Automatic/manual and function key External setpoint and

More information

Power consumption In operation At rest For wire sizing. Auxiliary switch NRF24A-SR-S2 NRF24A-SR-S2-O

Power consumption In operation At rest For wire sizing. Auxiliary switch NRF24A-SR-S2 NRF24A-SR-S2-O echnical data sheet NRF24A-SR-S2(-O) Modulating rotary actuator with emergency function for 2- and 3-way ball valves orque or ue 10 Nm Nominal voltage AC/DC 24 V Control: modulating DC 0... 10 V Position

More information

SAT.. Electromotoric actuators for valves ACVATIX. with a 5.5 mm stroke and 300 N positioning force

SAT.. Electromotoric actuators for valves ACVATIX. with a 5.5 mm stroke and 300 N positioning force 4 584 ACVATIX Electromotoric actuators for valves SAT.. with a 5.5 mm stroke and 300 N positioning force SAT31.. Operating voltage AC 230 V, 3-position control signal SAT61.. Operating voltage AC/DC 24

More information

Rotary actuators for ball valves

Rotary actuators for ball valves 4 658 Rotary actuators for ball valves for ball valves VAI61.. / VBI61.. and VAI60.. / VBI60.. / DC 24 48 V / AC 230 V Electromotive rotary actuators with spring return for emergency position For 2-position,

More information

EY-EM 522, 523: Remote I/O module, ecolink522, 523

EY-EM 522, 523: Remote I/O module, ecolink522, 523 Product data sheet 94.077 EY-EM 522, 523: Remote I/O module, ecolink522, 523 How energy efficiency is improved Regulation, control, monitoring and optimisation of operational systems, e.g. room automation

More information

SAY..P.. A6V ACVATIX Electromotoric actuators for valves. with a 15 mm stroke

SAY..P.. A6V ACVATIX Electromotoric actuators for valves. with a 15 mm stroke s A6V10628469 ACVATIX Electromotoric actuators for valves SAY..P.. with a 15 mm stroke SAY31P03 Operating voltage AC 230 V, 3-position control signal Operating voltage AC/DC 24 V, control signal DC 0 10

More information

AC 01.2 HART Technical data Actuator controls

AC 01.2 HART Technical data Actuator controls General information AC 01.2 actuator controls for controlling multi-turn actuators of the SA/SAR.2 type range and part-turn actuators of the SQ/SQR type range with interface. Power supply Standard voltages

More information

XR1 Rotor Earth Fault Relay. Manual XR1 (Revision C)

XR1 Rotor Earth Fault Relay. Manual XR1 (Revision C) XR1 Rotor Earth Fault Relay Manual XR1 (Revision C) Woodward Manual XR1 (EN) Woodward Governor Company reserves the right to update any portion of this publication at any time. Information provided by

More information

Technical data. Safety notes. Power consumption In operation At rest For wire sizing

Technical data. Safety notes. Power consumption In operation At rest For wire sizing echnical data sheet Damper actuator NM4A-SR-P Damper actuator for operating air control dampers in ventilation and air-conditioning systems for building services installations For air control dampers up

More information

Rotary actuators for ball valves

Rotary actuators for ball valves s ACVATIX Rotary actuators for ball valves GLB..9E Electromotoric rotary actuators for open-close, three-position or modulating control. Used in heating, ventilation and air conditioning plants. For 2-port

More information

Power consumption In operation At rest For wire sizing. 150 s / C Sound power level Motor. Emergency setting function 61 db (A)

Power consumption In operation At rest For wire sizing. 150 s / C Sound power level Motor. Emergency setting function 61 db (A) echnical Data sheets GRK4A-SR-5 Modulating SuperCap rotary actuator with emergency setting function and extended functionalities for butterfly valves and ball valves with mounting flange ISO 511-F05 orque

More information

Self-learning Room Temperature Controller Receiver

Self-learning Room Temperature Controller Receiver 2 265 REV23RF REV-R.02/1 REV23RF/SE Self-learning Room emperature Controller Receiver Consisting of controller (with integrated radio transmitter) and receiver (switching unit with relay outputs) REV23RF

More information

Technical data V phase cut, input impedance 8.2 k Position feedback (measuring voltage U) DC V, max. 0.5 ma Start point DC

Technical data V phase cut, input impedance 8.2 k Position feedback (measuring voltage U) DC V, max. 0.5 ma Start point DC echnical data sheet SMA-PC Parameterisable damper actuator for adjusting air dampers in ventilation and air-conditioning systems in buildings Air damper size up to approx. m orque 0 Nm Nominal voltage

More information

SIPROTEC easy 7SJ46 Numerical Overcurrent Protection Relay

SIPROTEC easy 7SJ46 Numerical Overcurrent Protection Relay Overcurrent Protection / 7SJ46 SIPROTEC easy 7SJ46 Numerical Overcurrent Protection Relay Function overview Fig. /11 Description The SIPROTEC easy 7SJ46 is a numerical overcurrent protection relay which

More information

Outside Temperature Sensors

Outside Temperature Sensors 1 814 1814P01 Symaro Outside Temperature Sensors QAC31 Active sensors for acquiring the outside temperature Operating voltage AC 24 V or DC 13535 V Signal output DC 010 V or 420 ma Use The QAC31 outside

More information

Spring Return DuraDrive Proportional Actuator

Spring Return DuraDrive Proportional Actuator MS40-7043, MS4-7073, MS4-753 Spring Return DuraDrive Proportional Actuator For spring return applications that require proportional modulation control of dampers and valves in HVAC systems. Features: Proportional

More information

3B SCIENTIFIC PHYSICS

3B SCIENTIFIC PHYSICS 3B SCIENTIFIC PHYSICS Digital Multimeter E 1018832 Instruction sheet 12/16 SD/UD 1 probe 1a Finger guards 2 Measurement socket 10 A for current measurement in 10-A (positive) 3 Measurement socket COM (negative)

More information

XF2 Frequency Relay. Manual XF2 (Revision A)

XF2 Frequency Relay. Manual XF2 (Revision A) XF2 Frequency Relay Manual XF2 (Revision A) Woodward Manual XF2 GB Woodward Governor Company reserves the right to update any portion of this publication at any time. Information provided by Woodward Governor

More information

Phase sequence and phase failure monitor

Phase sequence and phase failure monitor Measuring and monitoring relay Measuring and monitoring relay Current and voltage monitor Detection of falling below and exceeding a set threshold value of voltages and currents Phase sequence and phase

More information

XUA1 AC Voltage and phase balance relay. (August 1996) Manual XUA1 (Revision New)

XUA1 AC Voltage and phase balance relay. (August 1996) Manual XUA1 (Revision New) XUA1 AC Voltage and phase balance relay (August 1996) Manual XUA1 (Revision New) Woodward Manual XUA1 GB Woodward Governor Company reserves the right to update any portion of this publication at any time.

More information

Electronic Thermostat TE-1 Version according to EN

Electronic Thermostat TE-1 Version according to EN JUMO GmbH & Co. KG Delivery address:mackenrodtstraße 14, 3639 Fulda, Germany Postal address: 3635 Fulda, Germany Phone: +49 661 63- Fax: +49 661 63-67 e-mail: mail@jumo.net Internet: www.jumo.net JUMO

More information

XU2-AC AC voltage relay. (Februar 1997) Manual XU2-AC (Revision New)

XU2-AC AC voltage relay. (Februar 1997) Manual XU2-AC (Revision New) XU2-AC AC voltage relay (Februar 1997) Manual XU2-AC (Revision New) Woodward Manual XU2-AC GB Woodward Governor Company reserves the right to update any portion of this publication at any time. Information

More information

Drive Electronics pq11

Drive Electronics pq11 Drive Electronics Plug-in type amplifier with constant current controller for proportional valves Control of one solenoid Easy mounting directly on valve body Standard voltage and current signals for setpoint

More information

SAL.. ACVATIX Electromotoric rotary actuators for butterfly or slipper valves. with 90 rotary angle

SAL.. ACVATIX Electromotoric rotary actuators for butterfly or slipper valves. with 90 rotary angle s 4 502 ACVATIX Electromotoric rotary actuators for butterfly or slipper valves SAL.. with 90 rotary angle SAL31.. Operating voltage AC 230 V, 3-position control signal SAL61.. Operating voltage AC/DC

More information

Electromotoric actuators for stroke valves

Electromotoric actuators for stroke valves s ACVATIX Electromotoric actuators for stroke valves SAS.. Electromotoric actuators with 5.5 mm stroke and 400 N positioning force SAS31.. Operating voltage AC 230 V, 3-position control signal Operating

More information

Rotary actuators for ball valves

Rotary actuators for ball valves 4 658 Rotary actuators for ball valves for ball valves VA..61.. / VB..61.. and VA..60.. / VB..60.. / DC 24 48 V / AC 230 V GA..9E Electromotive rotary actuators with spring return for emergency position

More information

IDEAL INDUSTRIES, INC. TECHNICAL MANUAL MODEL:

IDEAL INDUSTRIES, INC. TECHNICAL MANUAL MODEL: IDEAL INDUSTRIES, INC. TECHNICAL MANUAL MODEL: 61-352 The Service Information provides the following information: Precautions and safety information Specifications Basic maintenance (cleaning, replacing

More information

21 VA (l max 20 5 ms) Connection Cable 1 m, 4 x 0.75 mm 2 Functional data Factory settings Variable Setting Torque Inhibiting torque

21 VA (l max 20 5 ms) Connection Cable 1 m, 4 x 0.75 mm 2 Functional data Factory settings Variable Setting Torque Inhibiting torque echnical data sheet GK4A- Communicative SuperCap rotary actuator with emergency setting function and extended functionalities for adjusting air dampers in ventilation and air-conditioning systems for building

More information

Power consumption In operation At rest For wire sizing

Power consumption In operation At rest For wire sizing echnical data sheet GM4A-SR-P Modulating damper actuator for operating air control dampers in ventilation and airconditioning systems for building services installations For air dampers up to approx. 8

More information

658 Current to Position Converters

658 Current to Position Converters 658 Current to Position Converters Current to Position Converters for Solid State Switching Output Adjustable Zero, Span and Deadband Two Wire Input from Controller Operates with 90 to 1000 Ω Feedback

More information

XP2-R Power and Reverse Power Relay

XP2-R Power and Reverse Power Relay XP2-R Power and Reverse Power Relay Manual XP2-R (Revision C) Woodward Manual XP2-RE Woodward reserves the right to update any portion of this publication at any time. Information provided by Woodward

More information

Overview of types. Technical data. T5-NRDVX24-SR-T-.. en v Subject to changes 1 / 3

Overview of types. Technical data.   T5-NRDVX24-SR-T-.. en v Subject to changes 1 / 3 echnical data sheet NRDVX4-SR--.. Modulating short stroke actuator for the motorisation of Cazzaniga and Siemens short stroke valves in HVAC systems Nominal stroke max. 5.5 mm Actuation force 500 Nm Nominal

More information

Miniature resistance thermometer Explosion-protected version Model TR34, thread-mounted

Miniature resistance thermometer Explosion-protected version Model TR34, thread-mounted Electrical temperature measurement Miniature resistance thermometer Explosion-protected version Model TR34, thread-mounted WIKA data sheet TE 60.34 Applications Machine building, plant and vessel construction

More information

Valve amplifier for proportional pressure valves

Valve amplifier for proportional pressure valves Valve amplifier for proportional pressure valves Type VT-MRMA1-1 RE 30214 Edition: 2017-03 Replaces: 04.13 Component series 1X Analog, modular design Suitable for controlling a direct current motor-operated

More information

Inductive sensor slot-type SI2-K08-AP7

Inductive sensor slot-type SI2-K08-AP7 SI2-K08-AP7 Slot sensor, height 8 mm Plastic, polypropylene Mechanical end stop, removable, for analog pointer instruments 3-wire DC, 10 30 VDC NO contact, PNP output Cable connection Wiring diagram Type

More information

NEXUS NX50-1, -2 Servo Motor Installation. Fireye DESCRIPTION SAFETY INFORMATION

NEXUS NX50-1, -2 Servo Motor Installation. Fireye DESCRIPTION SAFETY INFORMATION NEX-050 APRIL 8, 0 Fireye NEXUS NX50 -, - Servo Motor Installation DESCRIPTION This Manual describes the installation and operating instructions for the NX50 50Nm / 7 lb.-ft. servo motor. Other servo motor

More information

EMD-FL-3V-400. Electronic monitoring relay for voltage monitoring in three-phase networks. INTERFACE Data sheet _en_03. 1 Description.

EMD-FL-3V-400. Electronic monitoring relay for voltage monitoring in three-phase networks. INTERFACE Data sheet _en_03. 1 Description. Electronic monitoring relay for voltage monitoring in three-phase networks INTERFACE Data sheet 102110_en_03 1 Description PHOENIX CONTACT - 09/2009 Features Increasingly higher demands are being placed

More information

Manual triggering of the adaption by pressing the «Adaption» button or with the PC-Tool

Manual triggering of the adaption by pressing the «Adaption» button or with the PC-Tool echnical data sheet SMA--P Multifunctional damper actuator for adjusting air dampers in ventilation and air-conditioning systems for building services installations For air dampers up to approx. m orque

More information

Technical data sheet. Technical data. Safety notes

Technical data sheet. Technical data. Safety notes echnical data sheet LM4A-F Damper actuator for operating air control dampers in ventilation and air-conditioning systems for building services installations For air dampers up to approx. m orque 5 Nm Nominal

More information

Instruction Manual for Digital Grounding Resistance Meter

Instruction Manual for Digital Grounding Resistance Meter Instruction Manual for Digital Grounding Resistance Meter Instruction Manual for Digital Grounding Resistance Meter Table of Contents I. Overview...2 II. Open-case Inspection...3 III. Safety Precautions...4

More information

SAX.. ACVATIX Electromotoric actuators for valves. with a 20 mm stroke

SAX.. ACVATIX Electromotoric actuators for valves. with a 20 mm stroke s 4 501 ACVATIX Electromotoric actuators for valves SAX.. with a 20 mm stroke SAX31.. Operating voltage AC 230 V, 3-position control signal Operating voltage AC/DC 24 V, control signal DC 0 10 V, 4 20

More information

s Climatix extension module 26 I/Os POL985.00/XXX

s Climatix extension module 26 I/Os POL985.00/XXX s 3 921 Climatix TM Climatix extension module 26 I/Os POL985.00/XXX The POL985.00/XXX extension module extends the number of I/Os of Climatix 600 controllers. It is a product of the Climatix range. The

More information

High-quality digital indicator for panel mounting Model DI35-M, with multi-function input Model DI35-D, with two inputs for standard signals

High-quality digital indicator for panel mounting Model DI35-M, with multi-function input Model DI35-D, with two inputs for standard signals Accessories High-quality digital indicator for panel mounting Model DI35-M, with multi-function input Model DI35-D, with two inputs for standard signals WIKA data sheet AC 80.03 Applications Machine building

More information

11 VA Connection Cable 1 m, 4 x 0.75 mm 2 Functional data Factory settings Variable Setting Torque (nominal torque) Motor Spring return

11 VA Connection Cable 1 m, 4 x 0.75 mm 2 Functional data Factory settings Variable Setting Torque (nominal torque) Motor Spring return echnical data sheet SF24A- Communicative spring return actuator with emergency function for adjusting air dampers in ventilation and air conditioning systems in buildings For air dampers up to approx.

More information

Differential pressure sensors

Differential pressure sensors 1 912 1912P02 QBM64/ 1912P01 QBM63/ Differential pressure sensors for air and non-aggressive gases, with a diaphragm sensing element QBM63/ QBM64/ With choice of pressure-linear or extracting-the-root

More information

Operator Manual. Transmitters Series KAT-... Analog transmitters in 2-wire technique

Operator Manual. Transmitters Series KAT-... Analog transmitters in 2-wire technique Operator Manual Transmitters Series KAT-... Analog transmitters in 2-wire technique Important Safety Notes! In the case of non-observance of the installation and safety notes or improper use of the transmitter

More information

PHOENIX CONTACT - 09/2009

PHOENIX CONTACT - 09/2009 Electronic miniature circuit-breaker CLIPLINE Data sheet 03906_en_0 PHOENIX CONTACT - 09/2009 Description The EC-E... electronic miniature circuit-breaker selectively protects all 24 V DC load circuits

More information

AC/DC 24 V, 50/60 Hz. Functional data Variable Settings. DC V, max. 0.5 ma. End point DC V... 4 ma ma Non-variable

AC/DC 24 V, 50/60 Hz. Functional data Variable Settings. DC V, max. 0.5 ma. End point DC V... 4 ma ma Non-variable echnical data sheet S--MF- Multifunctional rotary actuator for butterfly valves orque 00 Nm Nominal volta e V Control: ontrol configurable confi urable Position feedback: configurable Auxiliary u iliary

More information

Power consumption In operation At rest For wire sizing

Power consumption In operation At rest For wire sizing echnical data sheet SM4A-SR-P Modulating damper actuator for adjusting air dampers in ventilation and air-conditioning systems for building services installations For air dampers up to approx. 4 m orque

More information

Overview of types. Technical data

Overview of types. Technical data echnical data sheet SHA-.. Multifunctional linear actuators for adjusting air dampers and slide valves in ventilation and air-conditioning systems for building services installations For air control dampers

More information

SAV.. ACVATIX Electromotoric actuators for valves. with a 20/40 mm stroke

SAV.. ACVATIX Electromotoric actuators for valves. with a 20/40 mm stroke s 4 503 ACVATIX Electromotoric actuators for valves SAV.. with a 20/40 mm stroke SAV31.. Operating voltage AC 230 V, 3-position control signal Operating voltage AC/DC 24 V, control signal DC 0 10 V, 4

More information

Technical data. Parameterisable damper actuator in the

Technical data. Parameterisable damper actuator in the echnical data sheet Parameterisable damper actuator in the IP66 protective housing for or adjusting ad usting air dampers in industrial plants and in technical building installations For air dampers up

More information

Assembly. Front view. HiC2441. SL2 1b. Termination Board

Assembly. Front view. HiC2441. SL2 1b. Termination Board SMART Universal Barrier HiC Features Assembly channel isolated barrier V DC supply (bus powered) Analog input, digital input, analog output, digital output No configuration required, device is selfadapting

More information

Process displays For standard signals, temperature, resistance measurement

Process displays For standard signals, temperature, resistance measurement Features Inputs: Voltage ±10 V, ±200 V / Current ±20 ma / thermocouples J,K,T,N,Pt100,Pt1000 / resistance measurement / potentiometer Display range can be linearised Two limits output Min, Max functions

More information

HAWK5000 Operators Manual

HAWK5000 Operators Manual HAWK5000 Operators Manual Keison Products P.O. Box 2124, Chelmsford CM1 3UP, England Tel: +44 (0) 1245 600560 Fax: +44 (0) 1245 600030 Email: sales@keison.co.uk www.keison.co.uk KANE INTERNATIONAL LIMITED

More information

Power consumption In operation At rest For wire sizing

Power consumption In operation At rest For wire sizing echnical data sheet MC4A-SR-F Modulating damper actuator for adjusting air dampers in ventilation and air-conditioning systems for building services installations For air dampers up to approx..4 m orque

More information

Miniature resistance thermometer Model TR33, thread-mounted

Miniature resistance thermometer Model TR33, thread-mounted Electrical temperature measurement Miniature resistance thermometer Model TR33, thread-mounted WIKA data sheet TE 60.33 Applications Machine building, plant and vessel construction Propulsion technology,

More information

Technical data. Safety notes

Technical data. Safety notes echnical data sheet M3A-F Damper actuator for operating air control dampers in ventilation and air-conditioning systems for building services installations For air dampers up to approx. m orque 5 m ominal

More information

Impulse system MPT 700. Manual Edition GB

Impulse system MPT 700. Manual Edition GB Impulse system MPT 700 Manual 6.2.2.2 Edition 10.10 GB 1 Introduction... 4 1.1 Version and model... 5 1.2 CE Mark... 7 2 Operation... 8 2.1 Controls... 8 2.1.1 Front panel... 8 2.1.2 Parameter display...

More information

SAX.. ACVATIX Electromotoric actuators for valves. with a 20 mm stroke

SAX.. ACVATIX Electromotoric actuators for valves. with a 20 mm stroke s 4 501 ACVATIX Electromotoric actuators for valves SAX.. with a 20 mm stroke SAX31.. Operating voltage AC 230 V, 3-position control signal SAX61.. Operating voltage AC/DC 24 V, control signal DC 0 10

More information

3B SCIENTIFIC PHYSICS

3B SCIENTIFIC PHYSICS 3B SCIENTIFIC PHYSICS Analogue Multimeter Escola 100 1013527 Instruction sheet 12/15 SD/JS 1 Display with mirror scale 2 Slotted screw for zero calibration 3 Calibration trimmer for setting centre zero

More information

SAY..P.. A6V ACVATIX Electromotoric actuators for VPI46. with a 15 mm stroke

SAY..P.. A6V ACVATIX Electromotoric actuators for VPI46. with a 15 mm stroke s A6V10628469 ACVATIX Electromotoric actuators for VPI46 SAY..P.. with a 15 mm stroke Operating voltage AC 230 V, 3-position control signal Operating voltage AC/DC 24 V, control signal DC 0 10 V, 4 20

More information

Radio Touch Order no.: 2880 xx. Operation and installation instructions. 1 Safety instructions. 2 Structure of the device (Figure 1) Radio Touch

Radio Touch Order no.: 2880 xx. Operation and installation instructions. 1 Safety instructions. 2 Structure of the device (Figure 1) Radio Touch Radio Touch Order no.: 2880 xx Operation and installation instructions 1 Safety instructions Electrical equipment must only be installed and assembled by a qualified electrician in accordance with the

More information

Operating instructions Fail-safe delay timer AZS About this document. Content

Operating instructions Fail-safe delay timer AZS About this document. Content 8 Appendix 8.1 Wiring example...4 8.2 Integral System Diagnostics (ISD)....5 9 EU Declaration of conformity Operating instructions.............pages 1 to 6 Original x.000 / 11.2017 / v.a. - 101126753-

More information

Original operating instructions Fail-safe inductive sensor GM504S / / 2010

Original operating instructions Fail-safe inductive sensor GM504S / / 2010 Original operating instructions Fail-safe inductive sensor GM504S 704070 / 01 06 / 2010 Contents 1 Preliminary note 3 1.1 Explanation of symbols 3 2 Safety instructions 4 2.1 Safety-related requirements

More information