Measuring Circumferential Metal Loss Rates in Subsea Pipelines

Size: px
Start display at page:

Download "Measuring Circumferential Metal Loss Rates in Subsea Pipelines"

Transcription

1 Measuring Circumferential Metal Loss Rates in Subsea Pipelines Presented by Dan Clarke 7 December

2 Contents Introduction to Corrosion Monitoring RPCM Technology Overview Measurement Performance Case Studies 2

3 Introduction to Corrosion Monitoring Integrity Management Inspection Monitoring Data Analysis Mitigation 3 Integrity Monitoring forms an essential part of any Integrity Management Strategy

4 Introduction to Corrosion Monitoring Corrosion Modelling? 4

5 RPCM Technology Overview Electrical Resistance Measurement Principle Exposed Protected S R x 0 x S b l V S V R Cumulative Corrosion (x 0 x) = f(v S / V R ) Corrosion rate = -dx/ dt I 5

6 RPCM Technology Overview Subsea Corrosion Probe Basic implementation of high resolution ER measurement. 6

7 RPCM Technology Overview Key Attributes Full circumference corrosion and temperature measurement (8 sectors) CEION technology sub-micron measurement Welded or flanged into pipe Designed for life of field (>25 years) No diameter transition / piggable Typical applications: flowline spools, export pipelines, onshore Online device (Modbus, Canbus) 18-30VDC continuous, <10W Qualified for subsea HTHP applications 15kpsi, 350F, 3000m water depth 7 S1 S2 S8 S3 S7 S6 S4 S5

8 RPCM Technology Overview Components Recoverable Electronics Drop Protection Frame PUP Piece HPHT Customer supplied Material (High pressure High Temperature) PUP Piece Customer supplied Material Inner spool 8 Forged Reducers

9 RPCM Technology Overview Ring Pair Sensor Operation Pipe rings CRA flange Ceramic coated rings machined from free-issue pipe (usually carbon steel) are retained between 2 CRA flanges. Sample rings inner surfaces are left uncoated. Ceramic provides isolation and corrosion resistance. Wires attached on outside of sensor rings are fed out to a non-retrievable pod via 9 primary and secondary HTHP penetrators.

10 I 1,IN 10 RPCM Technology Overview Measurement Operation 7 8 I IN,0 1 Sample 2 3 Reference Ring Pair Data Sector Metal Loss 3 (nm) I OUT,0 I 1,OUT Sample and Reference Rings are in series with one another and a controlled current source. Each Ring Pair operates independently from other Ring Pairs (allows redundancy). For each measurement cycle, current is injected in Mode 0 (4sec), then switched to Mode 1 (4 sec). Total measurement cycle is approximately 10 seconds. Real time calculation of Metal Loss per sector Average Ref Temp (degc)

11 RPCM Technology Overview Ring Pair Configurations Ring Pair Type Corrosion Type General Welded Uniform, TOL, Mesa, Pitting Preferential Weld CRA (e.g. Duplex) Pre-Pitted High Sensitivity Redundant Pitting Pitting / Crevice All All Corrosion mechanisms measured by changing geometry and ring material 2-4 RPsis the standard configuration but more possible. Typical Config: 4 RPs, 2 General, 2 Welded 11

12 Measurement Performance The Importance of Resolution Corrosion Rate 1 micron resolution Time to Detection 0.1 mm / yr <4 days 1 yr 100 microns resolution 0.5 mm / yr <18 hours 73 days 1.0 mm / yr <9 hours 37 days 12 Resolution is defined as the smallest change that can be detected High resolution enables changes in corrosion rate to be identified quickly. An amount of metal equivalent to the resolution is lost before the operator has a chance to respond.

13 Measurement Performance The Importance of Resolution Resolu ution (microns) RPCM Metal Loss Resolution vs Pipe Diameter Filter Time Constant ~ 3 hours Pipe Diameter (inches) 300 bar 600 bar 13 Low pass 1 st order filter with TC ~ 3 hours Resolution determined by magnitude of resistance Relatively insensitive for large pipe diameters

14 Measurement Performance Top-of-Line Corrosion Case Study RPCM Sector Data Metal Loss (Microns) Sector 1 Sector 2 Sector 3 Sector 4 Sector 5 Sector 6 Sector 7 Stratifiedflow / high temp Dissolved CO2 / H2S Cold spots are vulnerable Organic acids (acetic, HCl) BOL protected by inhibitor Days 14

15 Case Study CoPJudy Jade North Sea x 16 Spool flanged into SSV

16 Case Study CoPJudy Jade North Sea Performance of subsea spool after 5 years continuous operation

17 Conclusions RPCMs have extensive field history Widely accepted technology for subsea pipeline corrosion monitoring Full circumferential view Versatile configuration allows monitoring of: PWC, other alloys, pitting etc Flexible platform for other measurements PT Conductivity (EIS) Single Phase Flow Resolution circa 1 micron (near real17 time)

18 18 Thank you for your attention!

Ring Pair Corrosion Monitor : RPCM

Ring Pair Corrosion Monitor : RPCM Ring Pair Corrosion Monitor : RPCM RPCM is an in-line, piggable, monitor for pipelines, flow lines and process pipework giving true corrosion rate measurement in all service conditions due to full inner

More information

A NOVEL APPROACH TO NON-PIGGABLE SUBSEA PIPELINE INSPECTION

A NOVEL APPROACH TO NON-PIGGABLE SUBSEA PIPELINE INSPECTION A NOVEL APPROACH TO NON-PIGGABLE SUBSEA PIPELINE INSPECTION S. Hartmann, Innospection Ltd., Aberdeen Dr. K. Reber, Innospection Germany GmbH, Stutensee, Germany A. Boenisch, Innospection Ltd., Aberdeen

More information

Edd Tveit Director Business Development Hanne Martinussen COO

Edd Tveit Director Business Development Hanne Martinussen COO Online and Real-Time Corrosion and Erosion Monitoring of Subsea Pipework and Pipelines using Permanently Installed or Retrofitted Ultrasonic Sensor Arrays Edd Tveit Director Business Development edd@sensorlink.no

More information

Pipeline Design & Installation Systems

Pipeline Design & Installation Systems Pipeline Design & Installation Systems Rigid pipeline subsea tie-backs new operational challenges Paul Georgeson Operations Support Manager Wood Group Kenny Agenda - Overview - Materials - Inspection -

More information

Subsea Pipeline IMR. PT Hallin Marine June 18 th, 2014!

Subsea Pipeline IMR. PT Hallin Marine June 18 th, 2014! PT Hallin Marine June 18 th, 2014! Introduction Issues and Risks Inspection, Maintenance & Repair Case Study Conclusions and Recommendations 2 Introduction Subsea Pipeline IMR q Obtain data to assess the

More information

Heat Exchanger & Boiler Tube Inspection Techniques

Heat Exchanger & Boiler Tube Inspection Techniques Overview For the in-service inspection of ferromagnetic, non-ferromagnetic and fin-fan tubes, the following advanced techniques offer high defect detection capabilities and accurate defect analysis: Multiple

More information

ICCP Retrofit Challenges for an Offshore Jacket Complex

ICCP Retrofit Challenges for an Offshore Jacket Complex Paper No. 6012 ICCP Retrofit Challenges for an Offshore Jacket Complex Christophe Baeté, CP Manager Elsyca n.v. Vaartdijk 3/603, 3018 Wijgmaal, Belgium christophe.baete@elsyca.com ABSTRACT An offshore

More information

PRE-INSPECTION CLEANING OF UNPIGGABLE SUBSEA OPERATIONAL PIPELINES

PRE-INSPECTION CLEANING OF UNPIGGABLE SUBSEA OPERATIONAL PIPELINES PRE-INSPECTION CLEANING OF UNPIGGABLE SUBSEA OPERATIONAL PIPELINES By: Jakub Budzowski and Robert Davidson, Halliburton Pipeline and Process Services Europe Abstract Subsequent to risk based inspection

More information

Developments and presence in Oil and Gas industries

Developments and presence in Oil and Gas industries Developments and presence in Oil and Gas industries Daniel Reuithe, Market Development Engineer Francois Weisang-Hoinard, Senior Product Manager May 27, 2015 Content Overview of Outokumpu s offering to

More information

Inspection Approaches & Experience. for Inspecting Challenging Subsea Assets

Inspection Approaches & Experience. for Inspecting Challenging Subsea Assets Subsea Malaysia 2015 Inspection Approaches & Experience for Inspecting Challenging Subsea Assets Jason Tong Regional Sales Engineer, Innospection j.tong@innospection.com Subsea Malaysia 2015 CONTENT -

More information

SiRCoS Submarine pipeline repair system. Carlo Maria Spinelli - Bratislava, September 2008

SiRCoS Submarine pipeline repair system. Carlo Maria Spinelli - Bratislava, September 2008 SiRCoS Submarine pipeline repair system Carlo Maria Spinelli - Bratislava, 18-19 September 2008 Outline 1 Introduction to subsea pipelines 2 Deep water projects 3 Pipeline damage & scenarios 4 SiRCoS Repair

More information

By: Derek Watson and Lee Robins, Tracerco, UK

By: Derek Watson and Lee Robins, Tracerco, UK TRACERCO DISCOVERY SUBSEA CT (COMPUTED TOMOGRAPHY) HELPS TO OPTIMISE YOUR OPERATIONAL PIGGING CAMPAIGN AND VERIFY ILI RESULTS: TECHNOLOGY FOR PIPELINE INTEGRITY AND FLOW ASSURANCE VISUALISATION By: Derek

More information

EMAT Application on Incoloy furnace Tubing Ramamohan Reddy M (ASNT Level III UT, PCN Level III UT,PAUT&TOFD)

EMAT Application on Incoloy furnace Tubing Ramamohan Reddy M (ASNT Level III UT, PCN Level III UT,PAUT&TOFD) EMAT Application on Incoloy furnace Tubing By Ramamohan Reddy M (ASNT Level III UT, PCN Level III UT,PAUT&TOFD) Outlines 1. Introduction EMAT 2. EMAT- Ultrasound waves 3. EMAT-Surface waves 4. EMAT-Guided

More information

The use of Mechanical Connectors throughout Life of Field

The use of Mechanical Connectors throughout Life of Field The use of Mechanical Connectors throughout Life of Field Andrew Woodward Subsea Sales Engineer andrew.woodward@hydratight.com 1 What I will cover Safety Moment Introduction to Hydratight What are Mechanical

More information

Abstract. 1. Introduction

Abstract. 1. Introduction IBP1572_09 REMOTE EROSION AND CORROSION MONITORING OF SUBSEA PIPELINES USING ACOUSTIC TELEMETRY AND WET-MATE CONNECTOR TECHNOLOGY Howard Painter 1, Stewart Barlow 2, Daniel Clarke 3, Dale Green 4 Copyright

More information

BRENT BYPASS & FRAM Subsea Projects

BRENT BYPASS & FRAM Subsea Projects BRENT BYPASS & FRAM Subsea Projects James Woods Team Lead Subsea Execution 06 April 2012 1 NGTS Overview 06 April 2012 2 Brent Bypass The opportunity exists to put in place effective means to provide the

More information

DIFFICULT TO PIG AND TO INSPECT OFFSHORE PIPES

DIFFICULT TO PIG AND TO INSPECT OFFSHORE PIPES DIFFICULT TO PIG AND TO INSPECT OFFSHORE PIPES K. Reber, Innospection Germany GmbH, Stutensee, Germany S. Hartmann, Innospection Ltd., UK A. Boenisch, Innospection Ltd., UK Introduction When it comes to

More information

spy pig Tracking systems

spy pig Tracking systems spy pig Tracking systems Spy pig Transmitters For the most reliable signal available, the SPY Pig Transmitter uses low frequency signals to effectively and consistently penetrate a steel pipe wall. We

More information

Application of FRP Pipes & Other Composites in Oil & Gas Sector: Opportunities and Challenges

Application of FRP Pipes & Other Composites in Oil & Gas Sector: Opportunities and Challenges PRESENTATION ON Application of FRP Pipes & Other Composites in Oil & Gas Sector: Opportunities and Challenges NCRAC 2012, Hyderabad 15.06.2012 S.K. Dewri, Chief Engineer, ONGC, Institute of Engineering

More information

Sensorlink Corrosion monitoring on welds. Subsea Controls Down Under ISO 9001:2008 certified IECEx certified

Sensorlink Corrosion monitoring on welds. Subsea Controls Down Under ISO 9001:2008 certified IECEx certified Sensorlink Corrosion monitoring on welds Subsea Controls Down Under 2018 Jan-Tore Ervik, CMO Jan-tore.ervik@sensorlink.no ISO 9001:2008 certified IECEx certified 2 Outline Sensorlink Motivations and applications

More information

spy pig Tracking systems

spy pig Tracking systems spy pig Tracking systems PIPELINE INSPECTION COMPANY Spy pig Transmitters For the most reliable signal available, the SPY Pig Transmitter uses low frequency signals to effectively and consistently penetrate

More information

TOP OF THE LINE CORROSION COMPARISON OF MODEL PREDICTIONS WITH FIELD DATA

TOP OF THE LINE CORROSION COMPARISON OF MODEL PREDICTIONS WITH FIELD DATA C2012-0001449 TOP OF THE LINE CORROSION COMPARISON OF MODEL PREDICTIONS WITH FIELD DATA Ussama Kaewpradap (1), Marc Singer, Srdjan Nesic Institute for Corrosion and Multiphase Technology Ohio University

More information

Jim Britton Deepwater Corrosion Services Inc. Houston, TX. UTC 2008 Bergen

Jim Britton Deepwater Corrosion Services Inc. Houston, TX. UTC 2008 Bergen Smart Cathodic Protection Retrofit Methods for ROV Installation Jim Britton Deepwater Corrosion Services Inc. Houston, TX. Presentation Outline Introduction Key Factors to Consider Anode System Tie-Back

More information

ECDA to assess possibility of AC Corrosion. Mark Yunovich Honeywell Corrosion Solutions January 27 th, 2009

ECDA to assess possibility of AC Corrosion. Mark Yunovich Honeywell Corrosion Solutions January 27 th, 2009 ECDA to assess possibility of AC Corrosion Mark Yunovich Honeywell Corrosion Solutions January 27 th, 2009 What are we talking about today? Assessing the degree of AC interference at the pipeline level

More information

Standard Horizontal Subsea Trees. Integrated offshore offering for reliable, high-quality, and capitalefficient

Standard Horizontal Subsea Trees. Integrated offshore offering for reliable, high-quality, and capitalefficient Standard Horizontal Subsea Trees Integrated offshore offering for reliable, high-quality, and capitalefficient performance Standard Horizontal Subsea Trees Through standardized processes, common core components,

More information

Offshore Pipelines. Capability & Experience

Offshore Pipelines. Capability & Experience Offshore Pipelines Capability & Experience Capability Overview INTECSEA is a leading engineering and project delivery company in the offshore oil and gas sector. It operates across the full project cycle

More information

TABLE OF CONTENTS Page

TABLE OF CONTENTS Page 2 American Petroleum Institute TABLE OF CONTENTS Page POLICY................t... 8 FOREWORD......................................................................................................................f...

More information

Inspection Approaches & Experience. for Inspecting Challenging Subsea Assets

Inspection Approaches & Experience. for Inspecting Challenging Subsea Assets Inspection Approaches & Experience for Inspecting Challenging Subsea Assets Inspection Approaches & Experience for Inspecting Challenging Subsea Assets Andreas Boenisch Group Managing Director Innospection

More information

OPTIFLUX 5000 Technical Datasheet

OPTIFLUX 5000 Technical Datasheet OPTIFLUX 5000 Technical Datasheet Electromagnetic flowmeter in flanged version Exceptional long-term stability and accuracy For highly aggressive and abrasive fluids Fully vacuum-resistant with high-tech

More information

Non-Intrusive Ultrasonic Corrosion-Rate Measurements in Lieu of Manual and Intrusive Methods

Non-Intrusive Ultrasonic Corrosion-Rate Measurements in Lieu of Manual and Intrusive Methods Non-Intrusive Ultrasonic Corrosion-Rate Measurements in Lieu of Manual and Intrusive Methods Mark Feydo, Steve Strachan, Bruce Pellegrino Sensor Networks, Inc. 176-500 Technology Drive Boalsburg, PA, 16827,

More information

OPTIFLUX 5000 Technical Datasheet

OPTIFLUX 5000 Technical Datasheet OPTIFLUX 5000 Technical Datasheet Electromagnetic flowmeter in flanged version Exceptional long-term stability and accuracy For highly aggressive and abrasive fluids Fully vacuum-resistant with high-tech

More information

Optimizing MEG Systems on Long Subsea Tiebacks. Patrick Wan DOT PERTH, Wednesday 28 Nov 2012

Optimizing MEG Systems on Long Subsea Tiebacks. Patrick Wan DOT PERTH, Wednesday 28 Nov 2012 Optimizing MEG Systems on Long Subsea Tiebacks Patrick Wan DOT PERTH, Wednesday 28 Nov 2012 Presentation Outline Overview Hydrates MEG Management Summary 2 Overview Various flow assurance challenges associated

More information

Subsea Integrity and Efficiency Conference

Subsea Integrity and Efficiency Conference SUBSEA INTEGRITY & EFFICIENCY CONFERENCE 2015 Subsea Integrity and Efficiency Conference - 2015 Flexible Riser Integrity Assessment with Advanced MEC-FIT Technique Andreas Boenisch a.boenisch@innospection.com

More information

Evolution of Deepwater Subsea / Offshore Market

Evolution of Deepwater Subsea / Offshore Market Evolution of Deepwater Subsea / Offshore Market Amar UMAP Vice President, Technip COOEC Alliance DMFT 2014 Zhu Hai, China 18 October 2014 Table of contents 1. Evolution of Offshore/ Subsea Oil & Gas Industry

More information

Tony Owen, Subsea and Pipelines Decommissioning Delivery Manager AOG February 2017

Tony Owen, Subsea and Pipelines Decommissioning Delivery Manager AOG February 2017 Decommissioning in Practice Tony Owen, Subsea and Pipelines Decommissioning Delivery Manager AOG February 2017 Disclaimer and important notice This presentation contains forward looking statements that

More information

Flexible Pipe Solutions a competitive approach for Shallow water development. Sylvain Cabalery

Flexible Pipe Solutions a competitive approach for Shallow water development. Sylvain Cabalery Flexible Pipe Solutions a competitive approach for Shallow water development Sylvain Cabalery Agenda 1. Subsea at Technip in Brief and Asia Pacific presence 2. Flexible Pipes Solutions a. Main differences

More information

Airborne Oil & Gas. An introduction to TCP

Airborne Oil & Gas. An introduction to TCP Airborne Oil & Gas An introduction to TCP 20-09-2017 Thermoplastic Composite Pipe (TCP): Concept Coating Weight coating (optional) Laminate Liner Solid pipe structure: bonded Fit for purpose polymer: liner,

More information

2009 S. Kenny, Ph.D., P.Eng. Lecture Goals. Historical Overview. Students will be able to: Lecture 18 Pipeline Installation

2009 S. Kenny, Ph.D., P.Eng. Lecture Goals. Historical Overview. Students will be able to: Lecture 18 Pipeline Installation Lecture 18 Pipeline Installation Shawn Kenny, Ph.D., P.Eng. Assistant Professor Faculty of Engineering and Applied Science Memorial University of Newfoundland spkenny@mun.ca Lecture Goals Students will

More information

OG21 TTA4: Barents Sea Gas Condensate Field Development business case. Espen Hauge

OG21 TTA4: Barents Sea Gas Condensate Field Development business case. Espen Hauge OG21 TTA4: Barents Sea Gas Condensate Field Development business case Espen Hauge (espen.hauge@ge.com) Presentation at OG21 conference Kjeller 19.04.2012 How to select business cases? Support the vision

More information

ClampOn, Inc. Ultrasonic Intelligent Sensors. Presented by Hans A. Wagner

ClampOn, Inc. Ultrasonic Intelligent Sensors. Presented by Hans A. Wagner ClampOn, Inc. Ultrasonic Intelligent Sensors Presented by Hans A. Wagner Bergen, Norway Locations Project Management Engineering and Manufacturing Research and Development Sales and Service for Eastern

More information

Standard Subsea Wellheads. Integrated offshore offering for reliable, high-quality, and capital-efficient performance

Standard Subsea Wellheads. Integrated offshore offering for reliable, high-quality, and capital-efficient performance Standard Subsea Wellheads Integrated offshore offering for reliable, high-quality, and capital-efficient performance Standard Subsea Wellheads Through standardized processes, common core components, and

More information

Deepwater Subsea Tie-Back Flow Assurance Overview M U R P H Y S A B A H O I L C O M P A N Y L T D.

Deepwater Subsea Tie-Back Flow Assurance Overview M U R P H Y S A B A H O I L C O M P A N Y L T D. Deepwater Subsea Tie-Back Flow Assurance Overview 1 Contents Case Study Overview Flow Assurance Basis/Data Results Pre-FEED/FEED Considerations Flow Assurance Field Architecture Technologies 2 Preliminary

More information

New generation of welding and inspection systems

New generation of welding and inspection systems New generation of welding and inspection systems Throughout the pipeline industry, and particularly in offshore and spool base production, welding requirements are shifting toward higher quality, greater

More information

Controls and Communications Connectors Diamould electrical connectors

Controls and Communications Connectors Diamould electrical connectors Controls and Communications Connectors Diamould electrical connectors APPLICATIONS Subsea production systems controls Connectivity to tree, manifold, choke, and chemical injection metering valve (CIMV)

More information

REDUCING DEEPWATER PIPELINE INSPECTION COSTS

REDUCING DEEPWATER PIPELINE INSPECTION COSTS REDUCING DEEPWATER PIPELINE INSPECTION COSTS WHITE PAPER INTRODUCTION Inspecting a deepwater pipeline is extremely challenging. One problem might be that it lies more than 2,000 m (6,500 ft.) subsea, giving

More information

Ultramonit sensorbelt; a system for wall thickness monitoring. Håvard Sletvold Axess Orkla Inspection AS, Orkanger, Norway

Ultramonit sensorbelt; a system for wall thickness monitoring. Håvard Sletvold Axess Orkla Inspection AS, Orkanger, Norway Ultramonit sensorbelt; a system for wall thickness monitoring Håvard Sletvold Axess Orkla Inspection AS, Orkanger, Norway Email: hsl@axess.no Permanent monitoring - Agenda Technology background Overview

More information

NDT KONFERANSEN ZENOVIEA VOROSCIUC

NDT KONFERANSEN ZENOVIEA VOROSCIUC NDT KONFERANSEN 2011 ZENOVIEA VOROSCIUC Short about FMC Expectations Requirements New Challenges. New Solutions. 2 FMC Technologies Subsea Eastern ~ 150% growth from 2004-2010 MUSD Revenue Employees ER

More information

Jørn Scharling Holm DONG Energy

Jørn Scharling Holm DONG Energy Jørn Scharling Holm DONG Energy 3 rd June 2016 Offshore BoP - Sub-topics and timelines Delivery by Delivery by Table Priority Table 2020-2025 Table 2025-2030 Delivery post 2030 Industrialized transport

More information

DXe SUBSEA WELLHEAD CONNECTORS

DXe SUBSEA WELLHEAD CONNECTORS DXe SUBSEA WELLHEAD CONNECTORS Illustration shown: DXe-3 Connector with DXe latching segment Upper Body Indicator Rod Ring Gasket Retainer Latch Segment Spreader Upper Split Ring Retractor Latch Port Ring

More information

Integrating & Operating A New Salinity Measurement System As Part of A Wet Gas Meter. Svein Eirik Monge Product Manager, Emerson Subsea Flow Metering

Integrating & Operating A New Salinity Measurement System As Part of A Wet Gas Meter. Svein Eirik Monge Product Manager, Emerson Subsea Flow Metering Integrating & Operating A New Salinity Measurement System As Part of A Wet Gas Meter Svein Eirik Monge Product Manager, Emerson Subsea Flow Metering Outline Operator Challenges - Flow Assurance and Integrity

More information

ENGINEERING REPORT PHASES I & II MITIGATOR PERFORMANCE TESTS

ENGINEERING REPORT PHASES I & II MITIGATOR PERFORMANCE TESTS ENGINEERING REPORT PHASES I & II MITIGATOR PERFORMANCE TESTS INDUCED AC MITIGATION PERFORMANCE ON A STEEL GAS TRANSMISSION PIPELINE REPORT OF JANUARY 29, 2014 Copyright MATCOR, Inc. 2014 MITIGATOR TM VS.

More information

FAILURES TO MONITOR AND PREDICT. Detect early warning signs Automate monitoring of critical systems Give critical data to key decision makers

FAILURES TO MONITOR AND PREDICT. Detect early warning signs Automate monitoring of critical systems Give critical data to key decision makers FAILURES TO MONITOR AND PREDICT Detect early warning signs Automate monitoring of critical systems Give critical data to key decision makers ABOUT ASTRO TECHNOLOGY ADVANCED INSTRUMENTATION FOR: Subsea

More information

Table Of Contents Casing Head 02 Christmas Tree & Tubing Head Tubing Spool 04 Contact Us

Table Of Contents Casing Head 02 Christmas Tree & Tubing Head Tubing Spool 04 Contact Us Table Of Contents Casing Head 02 Christmas Tree & Tubing Head 03 Tubing Spool 04 Contact Us 05 1 www.sapwellsglobal.com Casing Head Specialized large-diameter pipe lowered into an open hole and cemented

More information

The Next Generation of Reeled Pipe Lay Vessels: for Ultra Deep Water Field Developments in Remote Locations

The Next Generation of Reeled Pipe Lay Vessels: for Ultra Deep Water Field Developments in Remote Locations The Next Generation of Reeled Pipe Lay Vessels: for Ultra Deep Water Field Developments in Remote Locations SUBSEA ASIA 2012 Kuala Lumpur Convention Centre, Malaysia Conference 03 October 2012 By John

More information

The Deepwater Horizon

The Deepwater Horizon Managing Deepwater Corrosion Challenges Face the Oil and Gas Industry as Offshore Assets Move into Deeper Water Kathy Riggs Larsen, Associate Editor The Deepwater Horizon offshore drilling unit explosion

More information

Pipeline Technology Conference 2010

Pipeline Technology Conference 2010 THRESHOLDS, ACCURACIES AND RESOLUTION: QUANTITATIVE MEASUREMENT AND ITS ADVANTAGES FOR METAL LOSS INSPECTION A. Barbian, M. Beller, A. Hugger, C. Jäger, A. Pfanger NDT Systems & Services Stutensee, Germany

More information

RISK & RELIABILITY BASED FITNESS FOR SERVICE (FFS) ASSESSMENT FOR SUBSEA PIPELINES By. Ir. Muhd Ashri Mustapha & Dr. Yong BaI.

RISK & RELIABILITY BASED FITNESS FOR SERVICE (FFS) ASSESSMENT FOR SUBSEA PIPELINES By. Ir. Muhd Ashri Mustapha & Dr. Yong BaI. RISK & RELIABILITY BASED FITNESS FOR SERVICE (FFS) ASSESSMENT FOR SUBSEA PIPELINES By Ir. Muhd Ashri Mustapha & Dr. Yong BaI. June 2011 Hannover All rights reserved. No part of this document may be reproduced,

More information

High-Resolution Corrosion Monitoring for Reliable Assessment of Infrastructure

High-Resolution Corrosion Monitoring for Reliable Assessment of Infrastructure 19 th World Conference on Non-Destructive Testing 2016 High-Resolution Corrosion Monitoring for Reliable Assessment of Infrastructure André Lamarre 1 1 Olympus Scientific Solutions Americas, Quebec City,

More information

Location. Established in 2015 Office location: Klepp Næringspark, Norway.

Location. Established in 2015 Office location: Klepp Næringspark, Norway. Location Established in 2015 Office location: Klepp Næringspark, Norway. Vision to be leader within On-Site machining & Decommissioning segment with a main focus on mature plants, offshore installations,

More information

FOSTEN AUTOMATION SÉRIE F500-RD

FOSTEN AUTOMATION SÉRIE F500-RD FOSTEN AUTOMATION SÉRIE Guided Wave Radar Level Transmitter Guided wave radar level transmitter. Low maintenance, auto calibrated references. Easy installation, directly in tanks or auxiliary vessels.

More information

Basic Measurements for Pipe Inspections

Basic Measurements for Pipe Inspections Basic Measurements for Pipe Inspections Period 7 Basic Corrosion Course 2017 February 21-23, 2017 Mark Anderson-MTS 1 DOT 192.459 External corrosion control: Examination of buried pipeline when exposed.

More information

DACON INSPECTION SERVICES I MFL INSPECTION OF PIPELINES

DACON INSPECTION SERVICES I MFL INSPECTION OF PIPELINES I MFL INSPECTION OF PIPELINES DACON AND INLINE INSPECTION Dacon well-known for pipeline inspection solutions using UT, MFL and LRUT UT tools provide unrivaled inspection accuracy compared to MFL Wide variety

More information

LEADING THE WAY IN WELLHEAD AND PIPELINE TECHNOLOGY. Wellheads Christmas Trees Gate Valves Surface Safety Valves Frac Trees Check Valves

LEADING THE WAY IN WELLHEAD AND PIPELINE TECHNOLOGY. Wellheads Christmas Trees Gate Valves Surface Safety Valves Frac Trees Check Valves LEADING THE WAY IN WELLHEAD AND PIPELINE TECHNOLOGY Wellheads Christmas Trees Gate Valves Surface Safety Valves Frac Trees Check Valves OUR Stream-Flo Industries Ltd. is committed to provide premium quality

More information

CHINA ZHEJIANG ZHONGGONG VALVE GROUP CO,.LTD FORMEN VALVE

CHINA ZHEJIANG ZHONGGONG VALVE GROUP CO,.LTD FORMEN VALVE INTERNATIONAL SALES: FORMEN VALVE ADD: OUBEI TOWN, YONGJIA COUNTY, WENZHOU, ZHEJIANG, CHINA HEADQUARTER: ZHEJIANG ZHONGGONG VALVE GROUP ADD: WUXING INDUSTRY ZONE, OUBEI TOWN, WENZHOU, CHINA ABOUT US Formen

More information

Title of Innovation: In-Line Inspection for Water Pipelines

Title of Innovation: In-Line Inspection for Water Pipelines Title of Innovation: In-Line Inspection for Water Pipelines Nominee(s) Margaret Hannaford, P.E., Division Manager, Hetch-Hetchy Water and Power Division of the San Francisco Public Utilities Commission

More information

Emergency Pipeline Repair Systems; A Global Overview of Best Practice

Emergency Pipeline Repair Systems; A Global Overview of Best Practice Emergency Pipeline Repair Systems; A Global Overview of Best Practice Brief Introduction to EPRS EPRS: Key Challenges Worldwide EPRS: Global Approaches to These Challenges Best Practice Comparison James

More information

RELIABILITY OF GUIDED WAVE ULTRASONIC TESTING. Dr. Mark EVANS and Dr. Thomas VOGT Guided Ultrasonics Ltd. Nottingham, UK

RELIABILITY OF GUIDED WAVE ULTRASONIC TESTING. Dr. Mark EVANS and Dr. Thomas VOGT Guided Ultrasonics Ltd. Nottingham, UK RELIABILITY OF GUIDED WAVE ULTRASONIC TESTING Dr. Mark EVANS and Dr. Thomas VOGT Guided Ultrasonics Ltd. Nottingham, UK The Guided wave testing method (GW) is increasingly being used worldwide to test

More information

Raising Performance Together In the Oil & Gas Industry

Raising Performance Together In the Oil & Gas Industry Raising Performance Together In the Oil & Gas Industry Flanges, Bw Fittings, Valves, Pipes, Gaskets, Studbolts, Isolation Joints, Pig Launcher Receivers. C O M P A N Y P R O F I L E HISTORY NECO GOLD GROUP

More information

Mineral-insulated resistance thermometers to EN

Mineral-insulated resistance thermometers to EN Data Sheet 90.2221 Page 1/6 Mineral-insulated resistance thermometers to EN 60 751 for temperatures from -50 (-200) to +600 C flexible sheath with shock-protected sensor as single or twin resistance thermometer

More information

Diverse Capabilities Targeted Solutions

Diverse Capabilities Targeted Solutions Diverse Capabilities Targeted Solutions Today s Leader, Tomorrow s Innovation As a vertically integrated manufacturer with direct control over the entire supply chain from raw materials to finished product,

More information

Summary of Changes and Current Document Status

Summary of Changes and Current Document Status DNV SERVICE DOCUMENTS Summary of Changes and Current Document Status FEBRUARY 2012 FOREWORD DET NORSKE VERITAS (DNV) is an autonomous and independent foundation with the objectives of safeguarding life,

More information

Certifications and Licenses

Certifications and Licenses Company OMPA is a qualified Oilfield Machine Shop with over 40 years experience in Manufacturing of Custom Designed Equipment, Threading Service and Precision Machining Service. It operates on a total

More information

Working for the future POSGRIP Technology

Working for the future POSGRIP Technology Working for the future POSGRIP Technology A Request for Joint Industry Support to enable roll-out of a new method of wellhead design October 2008 Page 1 1.1 - The Principals of POS-GRIP A New Method for

More information

Subsea Integrity Practices in GoM A Case Study

Subsea Integrity Practices in GoM A Case Study Subsea Integrity Practices in GoM A Case Study Session 9: HSE SPE Workshop 21 st October 2011 Objectives Integrity Management Philosophy Performance Assessment Methods Integrity Issues and Mitigation Strategy

More information

TIDALFLUX 2300 F Technical Datasheet

TIDALFLUX 2300 F Technical Datasheet Technical Datasheet Electromagnetic flow sensor for partially filled pipes Measurement in partially filled pipes up to DN1600 / 64" Patented, non-contact level measurement Measurement possible down to

More information

Particulate Control O&M Training. APC/PCUG Conference July 12-16, 2009 The Woodlands, TX

Particulate Control O&M Training. APC/PCUG Conference July 12-16, 2009 The Woodlands, TX Particulate Control O&M Training APC/PCUG Conference July 12-16, 2009 The Woodlands, TX WPCA Particulate Training Seminar July 11, 2009 ESP Power Supply Choices Slide No 1 Precipitator Power Supplies Conventional

More information

WATERFLUX 3000 Quick Start

WATERFLUX 3000 Quick Start WATERFLUX 3000 Quick Start Electromagnetic flowmeter The documentation is only complete when used in combination with the relevant documentation for the signal converter. KROHNE CONTENTS WATERFLUX 3000

More information

Evaluation of In-Pavement Light Fixture Designs and Performance

Evaluation of In-Pavement Light Fixture Designs and Performance Evaluation of In-Pavement Light Fixture Designs and Performance Presented to: IES ALC Fall Technology Meeting By: Joseph Breen Date: Background In-Pavement Light Fixture Assemblies Utilize a Circle of

More information

The HOIS recommended practice for in-service computed radiography of pipes

The HOIS recommended practice for in-service computed radiography of pipes 18th World Conference on Nondestructive Testing, 16-20 April 2012, Durban, South Africa The HOIS recommended practice for in-service computed radiography of pipes Stephen F. BURCH, ESR Technology Ltd 16

More information

SSPC-PA 2 Procedure for Determining Conformance to Dry Coating Thickness Requirements

SSPC-PA 2 Procedure for Determining Conformance to Dry Coating Thickness Requirements SSPC-PA 2 Procedure for Determining Conformance to Dry Coating Thickness Requirements William D. Corbett, KTA-Tator, Inc. Chair SSPC Committee C.3.2 on Dry Film Thickness Measurement SSPC-PA 2 Procedure

More information

Riser Installation in Deep & Ultra Deep Water

Riser Installation in Deep & Ultra Deep Water Riser Installation in Deep & Ultra Deep Water Frank Lim 38 th Annual Offshore Pipeline Technology Conference Amsterdam, February 2015 Outline Introduction Overview of current deepwater riser systems and

More information

Tailor Made. Create your unique subsea valve

Tailor Made. Create your unique subsea valve Tailor Made Create your unique subsea valve Our engineers have developed a comprehensive range of subsea valves, operators and hydraulic actuators to deliver complete tailor made packages meeting the highest

More information

This specification describes the minimum requirements for service water piping systems (ie: cooling water, process water, etc.), located on surface.

This specification describes the minimum requirements for service water piping systems (ie: cooling water, process water, etc.), located on surface. SPEC-3500 1/9 1.0 PURPOSE This specification describes the minimum requirements for service water piping systems (ie: cooling water, process water, etc.), located on surface. Note: This specification does

More information

Liquid Ultrasonic Flow Meters

Liquid Ultrasonic Flow Meters Liquid Ultrasonic Flow Meters Acadiana Flow Measurement School Lafayette, LA April 17-18, 2007 Liquid Ultrasonic Meter with Integral Transmitter Trans-Alaska Pipeline First Multi-path Ultrasonic Flow Meters

More information

Long Range Ultrasonic Testing - Case Studies

Long Range Ultrasonic Testing - Case Studies More info about this article: http://www.ndt.net/?id=21145 Prawin Kumar Sharan 1, Sheethal S 1, Sri Krishna Chaitanya 1, Hari Kishore Maddi 1 1 Sievert India Pvt. Ltd. (A Bureau Veritas Company), 16 &

More information

DOLPHIN SHELL & TUBE MARINE CONDENSERS (DSTMC)

DOLPHIN SHELL & TUBE MARINE CONDENSERS (DSTMC) PIOEER I HEAT TRASFER TECHOLOGY DOLPHI SHELL & TUBE MARIE CODESERS (DSTMC) Dolphin Shell & Tube Marine Condenser (DSTMC) General Information Dolphin carries out Thermal Design, Mechanical Design & detailed

More information

Pipeline & Specialty Services (P&SS)

Pipeline & Specialty Services (P&SS) Pipeline & Specialty Services (P&SS) A Pipeline Inspection Case Study: Design Improvements on a New Generation UT In-line Inspection Crack Tool Mark Slaughter Global Product Line Manager Pipeline & Specialty

More information

Learn more at

Learn more at Deepwater Riser System Challenges and Issues David Walters 2H Offshore Presentation Objectives Review riser system options Update on current industry status Highlight key issues Discuss current industry

More information

Integrity Management of Offshore Assets

Integrity Management of Offshore Assets OIL & GAS Integrity Management of Offshore Assets Opening session Leif Collberg 05 May 2017 1 DNV GL 2015 05 May 2017 SAFER, SMARTER, GREENER How regulations can solve the challenge of being performance

More information

Managing Metallic Pipe

Managing Metallic Pipe Managing Metallic Pipe Metallic Pipe Overview Buried infrastructure is the backbone of our modern society. It connects communities, empowers our economy and enables everyday life. While there are many

More information

Latest Developments for Pipeline Girth Welds using 3D Imaging Techniques. Novel Construction Meeting Jan van der Ent March 2016, Geneva

Latest Developments for Pipeline Girth Welds using 3D Imaging Techniques. Novel Construction Meeting Jan van der Ent March 2016, Geneva Latest Developments for Pipeline Girth Welds using 3D Imaging Techniques Novel Construction Meeting Jan van der Ent March 2016, Geneva 1 Content of presentation Standard A(UT) inspection What do we expect

More information

National Subsea Research Initiative

National Subsea Research Initiative National Subsea Research Initiative Coiled line pipe as a potential solution to all pipelines, WI & production risers for small pools, with a focus on installation methods from low cost vessels of convenience.

More information

The Battle of Carbon Steel

The Battle of Carbon Steel More info ab The Battle of Carbon Steel Advantages of Eddy Current Array over Magnetic Particle and Penetrant Testing for Inspecting the Surface of Carbon Steel Welds Terence Burke Product Application

More information

18th World Conference on Non-destructive Testing, April 2012, Durban, South Africa

18th World Conference on Non-destructive Testing, April 2012, Durban, South Africa 18th World Conference on Non-destructive Testing, 16-20 April 20, Durban, South Africa Guided Wave Testing for touch point corrosion David ALLEYNE Guided Ultrasonics Ltd, London, UK; Phone: +44 2082329102;

More information

This specification describes the minimum requirements for piping systems for the following service:

This specification describes the minimum requirements for piping systems for the following service: 201/11/2 1/9 1.0 APPLICATION This specification describes the minimum requirements for piping systems for the following service: Underground Service Water Note: This specification does not apply to piping

More information

Dust Test Surface Cleanliness

Dust Test Surface Cleanliness Paint Test Equipment Dust Test Surface Cleanliness Dust Test Information ISO 8502-3: Preparation of steel substrates before application of paints and related products. Tests for the assessment of surface

More information

SPOOLBASE & MULTIJOINT SERVICES

SPOOLBASE & MULTIJOINT SERVICES SPOOLBASE & MULTIJOINT SERVICES PIPELINE FABRICATION COMPANY PROFILE Pipeline Technique is a world leading provider of solutions to the oil and gas industry for the most demanding challenges in Welding,

More information

Section COUPLINGS AND COUPLING ADAPTERS. This Section covers couplings and coupling adapters for ductile iron and steel pipe.

Section COUPLINGS AND COUPLING ADAPTERS. This Section covers couplings and coupling adapters for ductile iron and steel pipe. PART 1 GENERAL 1.01 SUMMARY Section 15155 This Section covers couplings and coupling adapters for ductile iron and steel pipe. 1.02 MEASUREMENT AND PAYMENT A. No separate payment for Work performed under

More information

Wellhead equipment CATALOG

Wellhead equipment CATALOG equipment CATALOG Wellhead & Christmas tree Fixed the drilled wellhead.connect wellhead casing ring,seal and control the annular of casing. suspend tubing,control wellhead pressure and adjust flow rate,also

More information

The Essentials of Pipeline Integrity Management

The Essentials of Pipeline Integrity Management TRAINING METHODOLOGY This interactive training workshop includes the following training methodologies : Lectures Video Discussion of case histories and hands on calculations WHO SHOULD ATTEND The course

More information